Volvo · Model Report
Showing safety data for the 2004 model year only.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2001-2006 S80 and 2001-2009 S60 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
ON CERTAIN PASSENGER VEHICLES, THE FUEL PRESSURE SENSOR LOCATED ON THE LEFT END OF THE FUEL RAIL MAY, AT TIMES, TRANSMIT INCORRECT SIGNAL REGARDING THE FUEL PRESSURE TO THE ENGINE CONTROL MODULE. IF THE SIGNAL IS OUTSIDE OF THE PRE-PROGRAMMED ALLOWABLE LIMITS, A DIAGNOSTIC TROUBLE CODE MAY BE SET AND THE CHECK ENGINE LIGHT WILL COME ON. THE SOLDERED JOINTS ON THE CIRCUIT BOARD OF THE FUEL PRESSURE SENSOR MAY CRACK DUE TO TEMPERATURE CHANGES AND EXCESSIVE VIBRATIONS.
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
2004 VOLVO S60 PURCHASED THE CAR USED IN SEPT 04. On 7/8/24 STRANDED AT 7-11 CAR WOULDN'T START. ACTING AS IF THERE WAS POWER LOSS, AC WENT OFF, BRAKE FAILURE LIGHT ON PANEL, POWER WINDOWS AND LOCKS DID NOT WORK, TEMP 105 OUTSIDE , THEN DRIVER PANEL WENT BLACK., I WAS SCARED. ENGINE WOULDN'T START. FINALLY, AFTER WAITING 10 MINUTES...IT STARTED RUNNING BUT WAS SLUGGISH. RADIO WAS ON, POWER DOOR, LOCKS, AND WINDOWS, DID NOT WORK. CUT THE CAR OFF AND BACK ON, ALL POWER RETURNED, NOW CHECK ENGINE AND AIR BAG TROUBLE ON PANEL. CALLED VOLVO DEALER NEXT DAY NEAR MY HOME, THEY CAN NOT SEE MY CAR TIL NEXT WEEK TUESDAY. CAN NOT ACCESS ENGINE BOX, MUST GO TO DEALER.
No injuries · No fire · No crash
Starting Sunday November 27 my car started dripping gasoline on the floor, on the driver side near the rear wheel. Immediately I took it to Volvo dealer Wynne in Hampton, VA. The service specialist told me there was not any existing recall for that issue and let me go. That night I put under the leak a flat pan. That night I collected one gallon in about 8 hours. I called Volvo cars USA [XXX] explained me the car have been fixed for the campaign #09V483000 in September 14, 2010. I own the car since 2015. I asked her if the recall should be possible to do it again at no cost for me, because it falls under Safety due to the fact the car may get in fire due to the leak of gas. She asked me to go back again to Wynne Volvo dealer and tell to the service specialist that I talked to them and if they wouldn't repair my car I could open a case with Volvo Cars USA. The service specialist told me I could leave the car for inspection, but I would be responsible for at least $180 to get and estimate, but never said that they would fix it under the safety recall number 09V483000 for vehicles sold or registered in the states with hot climate like Virginia. The recall started in January 15, 2010. It covers the fuel pump that can develop cracks in the fuel pump flange. The technician said the repair they did under the recall was replacing an O-Ring gasket only not the fuel pump. The person I talked to in Service is [XXX] with Title Service Advisor. Phone number [XXX]. I called again today Wednesday November 30, 2022 to Volvo Cars USA they said they can not promise to wave the repair because they need first that I pay $180 for a car diagnostic of the issue. They would probably accept to pay part of the total charge but they would be doing it at good will. I don't have $180 to pay upfront for a safety recall that it didn't last but only 12 years. The Safety recall is valid as long as the car is in service, it doesn't matter if I am or not the first owner. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA)
No injuries · No fire · No crash
The contact owns a 2004 Volvo S60. The contact stated that while operating the vehicle, the instrument panel would not illuminate or operate. During the failure, the fuel gauge, speedometer, odometer, and other information was unavailable to the driver. The cause of the failure was not determined. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was 157,000.
No injuries · No fire · No crash
RECALL AIRBAGS- FUEL GAUGE GOES UP AND DOWN NEVER REGISTERS CORRECTLY
No injuries · No fire · No crash
DRIVING HOME FROM CHURCH,, SMOKE STARTED COMING FROM THE DRIVERS SEAT,FROM THE HEATED SEAT. BURNED A HOLE THRU THE LEATHER . WAS ABLE TO TURN OFF THE SWITCH AND PUT SOME SNOW INTO THE GOLF SIZE HOLE AND PULLED THE FUSE TO THE ELECT HEAT SWITCH. NO FURTHER DAMAGE WAS NOTICED .CITY STREET. THE HOLE IS ABOUT 11/2 IN BELOW LEFT SIDE BEADING AND CLOSER TO FRONT OF SEAT. LEATHER SEAT IN VERY GOOD CODITION AND NON SMOKER. GARAGE KEEP.