Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2004-2007 Touareg vehicles. These gasoline-powered vehicles have a fuel filter flange that may crack, allowing fuel to leak.
CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." ALL THREE REAR SEAT POSITIONS AND THE FRONT PASSENGER POSITION ARE EQUIPPED WITH SEAT BELT RETRACTORS THAT HAVE A LOCKING FEATURE WHICH CONVERTS THE RETRACTOR FROM AN EMERGENCY LOCKING RETRACTOR (ELR) MODE TO AN AUTOMATIC LOCKING RETRACTOR (ALR) MODE FOR THE PURPOSES OF CHILD RESTRAINT INSTALLATION. THE BELT MAY DEACTIVATE THE ALR MODE WITH CERTAIN CHILD RESTRAINTS.
ON CERTAIN SPORT UTILITY VEHICLES, THE REAR SEAT BELT LATCH ATTACHMENT BOLT MAY HAVE BEEN INSUFFICIENTLY RIVETED.
ON CERTAIN SPORT UTILITY VEHICLES, THE TIRE PRESSURE MONITORING SYSTEM (TPMS) WIRING HARNESS MAY HAVE BEEN IMPROPERLY ROUTED DURING ASSEMBLY. AN IMPROPERLY ROUTED TPMS WIRING HARNESS MAY CONTACT THE PARKING BRAKE CABLE SPRING.
I have contacted Volkswagen about my recall over a month ago the man claimed he ordered the parts and would be in contact but has never contacted me ever since and since then my vehicle has completely stopped working and the gas smell is at a very dangerous level
No injuries · No fire · No crash
The flange for the fuel does not leak from that i can see couse if it was leaking it would be on the ground.
No injuries · No fire · No crash
Hello: this is the 2nd VW TOUAREG this year to repair so far, this one is a 2004 model that I have had to replace complete left & right xenon headlamp assembly Very pricy. Wiring insulation turns brittle, cracks & falls off inside the headlamp assembly, This allows the bare wires to touch & short causing fuses to blow shutting off headlamps while driving at night. This I think should be recalled, I have fixed 5 of these TOUAREGs in 4 years for this same problem. THANK YOU 10/24/24
No injuries · No fire · No crash
My SUV was sitting for a few days at the airport and I when I got in the car, it started fine but the headlights, interior lights, power folding mirrors and the voltmeter were not working. I had to leave the car there since it was night time. The next day I drove it home in daylight and started checking fuses. I noticed two fuses (#2, #12) on the driver side fuse panel were failed. I replaced the #2, 5 amp, fuse and no changes were noticed. Then I replaced the #12, 25 amp, fuse and I heard a number of systems clicking and powering on; the lights flickered. Then I smelled burning and saw a puff of smoke come from under the dash. I immediately pulled the fuse . After troubleshooting, I found the body control module 7L6-937-049-K had caught fire internally and started to burn through the casing. Had I not pulled the fuse and disconnected the battery, this could have been catastrophic. Once I smelled the smoke, I realized it was like the acrid smell in the suv the night before. The fact the fuse blew the previous day saved the vehicle. It was parked on the fourth floor of parking garage at the airport so many vehicles could have been damaged and people endangered had it caught fire. Not to mention the disruption at an airport. There were no warning lamps. The only indication of a problem was the inoperable systems I mentioned. Also thinking back, the slight acrid smell was present the day I arrived at the airport, I had mistaken it for plane exhaust and car exhaust smells in the garage. The vehicle has not been inspected by any dealer, manufacturer or govermental agency. I have contacted the manufacturer for guidance and help with repairing. I am awaiting a response.
The contact owns a 2004 Volkswagen Touareg. The vehicle had previously been serviced at the dealer under NHTSA Campaign Number: 17V583000 (Fuel System, Gasoline) however, the fuel pump failed after the recall repair was performed. The vehicle was taken to the dealer and diagnosed with fuel pump failure. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 130,000.
No injuries · No fire · No crash