Toyota Tacoma Complaints (2025)

116 consumer complaints on file.

#11740765May 29, 2026
STRUCTURE:BODY:DOOR:HANDLE:INTERIOR
The interior driver side door handle on my 2025 Toyota Tacoma failed and wouldn't open the door from the inside. I had to roll down my window to open from the outside. The dealership replaced the handle assembly under warranty. This happened at around 9300 miles on the odometer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740284May 27, 2026
STRUCTURE:BODY:DOOR:HANDLE:INTERIOR
Interior drivers side door handle broken. I thought it was the locking mechanism having issues and i had to hold the locking plastic tab in the unlock position to open the door from the inside. After the 3rd time exiting my tacoma the door handle snapped. Now i how to open the door from the outside by rolling down the window, making it inconvenient in the rain.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738127May 15, 2026
POWER TRAIN
The contact owns a 2025 Toyota Tacoma. The contact stated that she received an email for NHTSA Campaign Number: 25V656000 (Power Train). The local dealer was contacted, but the vehicle was not diagnosed or repaired. The contact stated that the dealer failed to alert her of the recall prior to the sell. The manufacturer was contacted and referred her to the local dealer. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736190May 6, 2026
POWER TRAIN
In October of 2025 I was notified of a safety based recall for my 2025 Tacoma related to the front axle shafts possibly breaking which could cause loss of steering control should an incident occur. The recall is listed as 25TA11, (Interim notice 25TB11) and is attached to NHTSA ID 25V656. As of May 6th, Toyota lists this situation as still preparing the remedy. If the situation is truly a safety concern, I believe the length of time Toyota is taking to provide the remedy is unacceptable. I would like to politely suggest that Toyota have pressure put on them to provide the proper remedy in an actual timely manner for something that can cause loss of control or a rolling vehicle in the 'Limited' trim models.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11735950May 5, 2026
ELECTRICAL SYSTEM
The driver's side window switch panel failed and caught on fire. It is available for inspection.It will be towed to a toyota dealership tomorrow. Nobody was in the vehicle when the fire started. The problem has not been confirmed or reproduced by a dealer. The vehicle has not been inspected, is going in for inspection tomorrow. There was no warning or indication prior to the fire starting.
Crash:
No
Fire:
Yes
Injuries:
1
Deaths:
0
#11735371May 3, 2026
POWER TRAIN
Vehicle recalled, left at Dealership on October 10th 2025. Dealership and Toyota corporate have failed to rectify the recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11733479April 24, 2026
STEERING, SUSPENSION
*Steering system - tie rod / steering nut lock was loose and discover after alignment service * Loose tie rod nut created a potential safety risk because it involves a steering component related to vehicle control. This could have put me, my passengers, and others drivers at risk if the condition had worsened while driving. *No, the condition has not yet been confirmed by a dealer or independent service center. I noticed abnormal steering/handling, inspected the vehicle myself, and discovered a loose tie rod nut. The vehicle is available for inspection upon request. *No the vehicle I available upon request *No
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11733188April 23, 2026
STRUCTURE:BODY:DOOR:HANDLE:INTERIOR
Driver's side interior door handle mechanism broke during normal usage at 8 months/6,300 miles. Breakage occured within the door panel, leaving a non-functioning handle. After breakage, the door cannot be opened from the inside of the vehicle and the occupant cannot easily exit the vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732972April 22, 2026
SEATS
Less than 5000 miles - seat popping and cracking noise. If you look it up online, a lot of the 4th Gen Tacomas are doing this but when you take it to a dealership they say that is normal. It feels like the seat will break and moves around alot but Toyota will not acknowledge the issue at the dealership and has no fix. Seems unsafe.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732393April 20, 2026
POWER TRAIN
The contact owns a 2025 Toyota Tacoma. The contact received notification of NHTSA Campaign Number: 25V656000 (Power Train); however, the part to do the recall repair was not yet available. The vehicle was taken to the dealer, where it remained since October 2025, while the contact drove a rental vehicle. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11729275April 5, 2026
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
My 2025 Toyota Tacoma engaged the emergency braking/pre-collision system system while my vehicle was going under 10 mph on a steep road in winter conditions. My vehicle was completely under control before the system engaged and there was no risk of a collision with any vehicles in front of me. The emergency braking system engaged and rendered my vehicle completely out of control. I tried desperately to pump the brakes in hopes I could regain control of the vehicle, but the brakes were fully locked. Had the brakes dis-engaged, I could have easily avoided the collision. The car not only did not decelerate, it accelerated down the hill while the brakes were locked for several seconds. My vehicle eventually slid into another vehicle that had been parked on the side of the road. From doing extensive research I believe a perfect storm of events caused this malfunction. Previously on this day, several inches of snow had fallen. The road had not been plowed and cars were parked on the side of the road. There was also a curve in the road near my vehicle's collision where the other vehicle was parked. My windshield was also still defrosting in the uppermost section near the rear view mirror. It is also possible the radar block on the front of the vehicle had snow or ice on it. It was also actively snowing. From what I have read, any of the above factors can cause a malfunction in the emergency braking pre-collision system. I had never been in an accident in over 20 years of driving and my vehicle did the least safe maneuver it could have in the given situation. There is no circumstance where one would purposefully slam the brakes on a snowy/icy down hill road if they know how to drive in the snow (even if you were going under 10mph as I was). At the most basic level of failure, I can't imagine this system should ever engage if going as slow as I was. Also, the system is designed to decelerate (was accelerating) and I was pumping brakes in effort to disengage
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11729199April 4, 2026
POWER TRAIN, ENGINE
On Sunday March 22, 2025 at around 1340, I was leaving my house and driving on a small incline and noticed my vehicle had a jerk when down shifting. This happened four times while traveling up hill. I have not yet had any repeat issues since this date.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11728645April 1, 2026
POWER TRAIN
The contact owns a 2025 Toyota Tacoma. The contact received notification of NHTSA Campaign Number: 25V656000 (Power Train); however, the part to do the recall repair was not yet available. The local dealer was contacted but the vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11728582April 1, 2026
STRUCTURE:BODY:DOOR:HANDLE:INTERIOR
My rear backseat driver’s side door handle broke on March 16th, 2026. I either have to roll down the window and open the door from the outside or I have to let passengers out from exiting from the front seat. I took it in for inspection by the dealer, West Kendall Toyota on March 17th, 2026. They had to order a new part. They tried repairing it on March 31, 2026 but failed to do so and had to reorder the part. It is still broken as of today April 1st, 2026. My front seat driver’s side door handle also broke in August of 2025 and I could only get out through opening the window and unlatching the door from the outside door handle. This is a serious safety issue as passengers could become trapped should the car be hit on the other side and if even more so if the power goes out on the car. I feel Toyota is not doing enough to fix the issue and is not making a quick effort to repair this and is showing a lack of concern for consumer safety.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11728170March 31, 2026
POWER TRAIN
transmission is very rough, especially when going into a stop to where there is a loud clunk, and feels like a bowling ball falling out of the transmission. this happened from new until now.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726922March 25, 2026
POWER TRAIN
The contact owns a 2025 Toyota Tacoma. The contact received notification of NHTSA Campaign Number: 25V656000 (Power Train); however, the part to do the recall repair was not yet available. The local dealer was contacted, but the vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726844March 24, 2026
POWER TRAIN
Toyota issued this recall about six months ago, and they have been dragging their feet for something that should be rather simple. They have not handled this recall in a timely manner we were originally told it was gonna be corrected in November that obviously didn’t happen and now we were told first quarter of twenty six and obviously that hasn’t happened
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726018March 21, 2026
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, LANE DEPARTURE: WARNING, LANE DEPARTURE: ASSIST
Due to my husband driving the vehicle, ISP states it looks like he crossed into an oncoming semi-chip truck trailer, causing a fatal accident and killing him instantly. The 2025 Toyota Tacoma's Safety Sense obviously failed since my husband is now dead. We had the 2025 Tacoma in the prior week due to my complaints that the lane assist was not working properly and the screen did not respond to my touch to turn it on. After the fatal accident, ISP removed the black box to download information for the accident report. I am now waiting for isp report. No jaws of life was used to extract husband they didn't need it Tacoma metal already peeled back like a tuna can.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
1
#11725346March 18, 2026
ELECTRICAL SYSTEM
My 2025 Toyota Tacoma TRD Pro (VIN [XXX] , purchased from Delaney Toyota, DuBois PA) exhibited a recurring Smart Key and door lock malfunction beginning in late October/early November 2025 and continuing through the date the vehicle was traded in February 2026 with the defect unresolved. Symptoms observed: Doors locking autonomously on exit, sometimes before occupants could exit the vehicle System falsely detecting the key fob as being inside the vehicle when it was in the owner's pocket outside, causing the truck to refuse to lock Touch-lock refusal at the door handle Random unprompted beeps while parked and locked with no corresponding lock movement Key card unable to lock the vehicle Dealership witness: During a January 2026 service visit, Delaney Toyota Service Advisor Ricky Carlson was personally locked inside the vehicle by this malfunction before he could exit. This was witnessed firsthand by a trained Toyota service employee and is part of the service history, though it was not captured in the official repair order. Service history: December 22, 2025 — RO #XXXX, no codes found, TAS case opened January 21, 2026 — RO #XXX, TAS case XXX, technician unable to duplicate, no codes found February 9, 2026 — RO #XXX, TAS case XXX, dealership driver witnessed false key-in-vehicle behavior directly when owner demonstrated it on arrival, behavior self-resolved before service bay access, no codes found Additional facts This defect never generated a diagnostic trouble code across three service visits Toyota Corporate case XXX was opened and closed without resolution Toyota arbitration case XXX was also closed without resolution The identical defect has since appeared on a replacement 2026 Toyota Tacoma TRD Pro (VIN [XXX] ), currently under active Toyota Corporate case #XXX The vehicle was traded in February 2026 because Toyota Corporate failed to resolve the defect within the warranty window INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719623February 21, 2026
POWER TRAIN, STEERING
MY 2025 TACOMA is part of a recall by Toyota, I was notified of the potential issue on early November 2025 and told Toyota was working on a remedy. On December 3rd, 2025 while using 4-wheel drive during a snow storm the drive shaft (recall issue) broke. On December 4th, 2025, the local Toyota dealer checked my Tacoma and found it unsafe to drive - they kept my Tacoma and provided a loaner vehicle. Toyota reported at this time the remedy would be available by the end of 4th quarter (December). As of today, February 21, 2026 -- there is still no remedy for the issue, my Tacoma is still sitting at the dealer, and I do not have my truck. Toyota reports a remedy will be available during the 1st quarter of the year but nothing yet. I called brand engagement recently and asked them to extend my warranty, Toyota care, and other free trials that were included with my purchase. However, Toyota refuses to do anything further - as they said a loaner car is enough - to make the issue more acceptable even though my new vehicle is losing this coverage.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tacoma