ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP RETAINING TABS HOLDING THE FUEL LINES WERE DAMAGED DURING PRODUCTION.
CERTAIN PASSENGER VEHICLES EQUIPPED WITH B205/B235 4-CYLINDER GASOLINE ENGINES AND B308 6-CYLINDER GASOLINE ENGINES MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IGNITION DISCHARGE MODULE (IDM) DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.
ON CERTAIN PASSENGER VEHICLES, IF AN OWNER CHANGES THEIR WHEELS/TIRES BETWEEN SUMMER AND WINTER USING A STEEL WHEEL IN THE WINTER AND AN ALLOY WHEEL IN THE SUMMER, IT IS POSSIBLE FOR RUST AND CONTAMINATION TO BUILD UP ON THE WHEEL HUB DURING THE STEEL WHEEL USAGE. IF THIS OCCURS AND THE CONTAMINATION IS NOT REMOVED, IT IS POSSIBLE THAT AFTER THE TIRE CHANGE SERVICE, SOME OF THIS CONTAMINATION COULD FLAKE OR GRIND AWAY RESULTING IN REDUCED CLAMPING FORCE OF THE WHEEL TO THE HUB. OVER SEVERAL SEASONS, IT IS POSSIBLE THAT THIS REDUCED FORCE COULD RESULT IN FRACTURES DEVELOPING IN THE WHEEL BOLTS DUE TO WHEEL TO HUB MOVEMENT.
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE AIR BAG ALERT LABELS MAY NOT BE PERMANENTLY AFFIXED AS REQUIRED BY THIS STANDARD.
With only 670 miles on a new set of tires, an inspection for a completely unrelated reason found that there was a bulge in 3 of the 4 NEW tires. Installed in Jun, issue found in Dec; car is driven very little. Tires were purchased from Tire Rack and installed by Discount Tire. Inspection by Discount tire found the 3 defective tires. They report bulges as "impact damage". I have had one other tire ever with impact damage in 180,000 miles on this 20+ year old car. On this set of tires, there were no incidents, such as hitting a curb or pothole. I have to believe that these tires have a manufacturing defect. For all I know, they had a sidewall bulge from day one. I am replacing all four tires. I have contacted Vredestein customer service, at both domestic and international email customer service contacts. They have not answered, even with an acknowledgement of receipt.
No injuries · No fire · No crash
TURBO MALFUNCTION AT A COST OF $455.00 AND ALSO ENGINE FILTER BOX.VEHICLE STILL NOT RUNNING CORRECTLY.WILL ONLY GO AT SPEED OF 25 MPH.REPAIRED ON 03/27/2018.STARTED OUT SMOKING ALL OVER THE PLACE FROM EXHAUST.WAS TOLD TURBO WENT BAD.I THINK A LOT OF THESE CARS HAVE THIS PROBLEM AS I READ ON FORUMS(SAAB,).THAT I HAVE SINCE JOINED.THE SAAB HAS 139,000 MILES..I WAS DRIVING ON A CITY STREET AT SPEED AROUND 35MPH.STARTED TO SMOKE HEAVY,BUT ONCE OUT OF CITY AS LONG AS I DROVE 50 MPH ON HIGHWAY SMOKE WAS DISPERSED FROM WIND AND MADE IT HOME BUT WHEN STOPPING FOR RED LIGHT WOULD BUCK AND TRY TO SHUT OFF.SMOKE NOT GOOD FOR ENVIRONMENT......
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2001 SAAB 9-5. WHILE DRIVING 15 MPH, THE FRONT DRIVER SIDE WHEEL DETACHED FROM THE VEHICLE WITHOUT WARNING. THE VEHICLE BECAME DIFFICULT TO CONTROL, SLAMMED TO THE GROUND, AND CAME TO A STOP. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHERE IT WAS DIAGNOSED THAT THE VEHICLE NEEDED A NEW ROTOR, HUB ASSEMBLY, AND FRONT RIM. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 194,000.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2001 SAAB 9-5. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE STALLED WITHOUT WARNING AND FAILED TO RESTART. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS EVENTUALLY ABLE TO RESTART. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V399000 (ELECTRICAL SYSTEM). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
No injuries · No fire · No crash
MY 2001 SAAB 9-5 HAS BEEN EXPERIENCING A CHECK ENGINE LIGHT FOR AWHILE ON AND OFF. THE VEHICLE WILL SOMETIMES STALL RANDOMLY AND NOT START UNTIL ENGINE COOLS DOWN. THE CODES FOR CEL LEAD TO DIRECT IGNITION. A PREVIOUS RECALL ON THESE VEHICLES, ONE MY VEHICLE RECEIVED. I CALLED DEALER AND THEY SAID SEEING AS IT WAS ALREADY TAKEN CARE OF ONCE NOTHING CAN BE DONE. I KNOW I WILL TO HAVE TO GET IT FIXED TO PASS EMISSIONS TESTING DUE TO FAULTY DIRECT IGNITION. NOT TO MENTION HOW UNSAFE IT IS IF IT STALLS. *TR
No injuries · No fire · No crash