Was parking and when I hit the park button. A lot of error lights came on. After a reset, I have an Airbag needs service error.
No injuries · No fire · No crash
After gently removing the fabric cover of our Cybex Eternis S All-In-One car seat to wash it according to the manufacturer's care instructions, and then putting the cover back on, the car ride immediately following, the red plastic pieces designed to hold the cover in place completely snapped off. This structural failure exposed two sharp, unshielded metal screws directly in the child's seating area. Because these screws were left fully exposed by the broken plastic, they created an immediate laceration hazard. As a direct result of this defect, my young daughter's leg was cut by the exposed screws while using the seat.
No injuries · No fire · No crash
SYSTEMS AFFECTED: Electrical System (12V Power Supply / Low-Voltage), Climate Control (HVAC System / Thermal Management), Towing / Recovery DESCRIPTION OF SAFETY HAZARD & DEFECT: My 2022 Rivian R1T experienced a sudden, complete electrical failure due to a defective HVAC system, resulting in a dangerous hard-bricked state that rendered the vehicle totally inoperable. Approximately 30 days prior to the incident, the vehicle underwent a comprehensive inspection at a Rivian Service Center where both the HVAC system and 12-volt battery system were tested and cleared. Shortly after, a primary internal failure/glitch within the HVAC equipment created a high parasitic power draw on the vehicle's low-voltage circuit while parked. The HVAC module failed to enter sleep mode, continuously draining the dual 12-volt AGM battery array below critical operating thresholds. This rapid, deep-discharge condition completely disabled the vehicle's primary high-voltage contactors and low-voltage control modules, locking out all vehicle functions, electronic doors, and drive controls. The vehicle could not be restarted, jump-started normally, or safely shifted into neutral, necessitating an emergency flatbed tow to the service center. Technicians confirmed that the primary HVAC equipment failure directly caused the full depletion and destruction of the 12-volt electrical system. This defect presents an immediate safety risk. An uncommanded HVAC-induced power drain that completely depletes the 12-volt system can cause sudden electrical failure, vehicle bricking, loss of hazard lights, and lock-out conditions, potentially stranded occupants in dangerous environments or busy roadways. Rivian is treating this catastrophic multi-system failure as non-warranty maintenance, refusing to address a clear pre-existing latent defect in their low-voltage power management and thermal architecture. REQUESTED ACTION: Investigation into 2022 Rivian R1 HVAC power management defects causing severe 12V drain
No injuries · No fire · No crash
On February 15, 2025, Rivian performed Field Service Action FSAM-1507 on my 2024 Rivian R1T at 11,590 miles. Hub-to-knuckle fasteners were found loose in four structural locations. This was identified as a safety-related field service action. A second field service action, FSAM-1678 (front halfshaft NVH washers), was performed November 3–4, 2025. I am reporting both actions to create a federal record of the structural safety deficiencies in this vehicle.
No injuries · No fire · No crash
2024 Rivian R1T has a persistent pulling defect and safety hazard. Four repair attempts at Rivian Denver Service Center all failed: 1. Jul 16, 2025 - WO-1452784, 16,117 mi: Alignment performed. Defect continued. 2. Aug 11, 2025 - WO-1530133, 16,936 mi: Same-day return. Second alignment. Defect continued. 3. Nov 3-4, 2025 - WO-1745098, 20,520 mi: Rivian lead technician ride-along confirmed pull in writing: "After 2 alignments, vehicle is still pulling. Confirmed by lead technician." Tire rotation attempted. Defect continued. 4. Dec 22-23, 2025 - WO-1869730, 22,136 mi: Rivian documented "No Problem Found" after 2.5hr alignment + 20-min test drive, then waived $690 in labor. I have video of a Rivian advisor verbally confirming the pull in Nov 2025, directly contradicting this finding. Pulling caused premature wear on all 4 tires by 20,774 mi (Rivian confirmed, WO-1765303). Additional safety defects: - FSAM-1507: Hub-to-knuckle fasteners loose in 4 locations (Feb 2025, 11,590 mi) - FMVSS 108 headlamp federal violation corrected Jul 2025 - FSAM-1678: Front halfshaft washers replaced Nov 2025 - 12V battery failure limited vehicle to 61 MPH while driving (Oct 2024, 8,215 mi) Vehicle returned May 27, 2026 due to unresolved safety defect.Please investigate this defect on 2024 Rivian R1T vehicles.
No injuries · No fire · No crash