On March 19, 2025 upon driving my car home from a 1 hour commute I sensed a unique, uncommon smell - like some sort of electrical component burning. I parked the car in my garage, turned it off and went inside my house. Within 5 minutes the engine was producing gray smoke followed by fire. The car went up in flames in less than 10 minutes. The fire spread to the attic and burned most of the house. I read recently that according to NHTSA, 292,000 ProMaster vans built between 2018 and 2026 are recalled due to a potential fire hazard linked to the cooling fan module. The ProMaster City has not been included in this recall. This seems like a mistake.
Cracked cylinder head requiring full engine replacement at ~80,000 miles. Out of warranty. This is one of two vehicles, purchased at the same time from same dealer in 6/2021 with the same engine failure at ~80,000. Second vehicle is [XXX] . It is likely that these two vehicles came off the assembly line fairly close to each other, during covid and all the issues that that brought to supply chains and manufacturing. One I could have chalked up to bad luck. Two is just too much of a coincidence to believe that there isn't something wrong with these engines. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash
Cracked cylinder head requiring full engine replacement at ~80,000 miles. Out of warranty. This is one of two vehicles, purchased at the same time from same dealer in 6/2021 with the same engine failure at ~80,000. Second vehicle is [XXX] . It is likely that these two vehicles came off the assembly line fairly close to each other, during covid and all the issues that that brought to supply chains and manufacturing. One I could have chalked up to bad luck. Two is just too much of a coincidence to believe that there isn't something wrong with these engines. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash
The contact owns a 2022 Ram Promaster City. The contact stated that occasionally while shifting into drive or reverse, the RPM increased to 4,000. On several occasions, the failure occurred while the brake pedal was depressed. The contact stated when the vehicle was shifted into neutral, the RPM decreased to normal between 750-800 RPM. No warning light was illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired due to the cost. The manufacturer was made aware of the failure. The failure mileage was approximately 5,500.
No injuries · No fire · No crash
Engine oil leak at the oil filter. The oil filter monting surface has a defect (not flat) allowing oil to push out. It is currently available for inspection, but it is scheduled to been seen by the dealer to be replaced under warranty. Safety - issue was noticed before enough damage was done to be unsafe. The leak was substantial, so I imagine it would lead to a safety issue due to abrupt engine failure. Oil filter was properly installed, verified by independent repair facility. Leak was reproduced / verified by independant repair facility. No warning indicators for the issue.
No injuries · No fire · No crash