Mercury · Model Report
Showing safety data for the 1996 model year only.
VEHICLE DESCRIPTION: PASSENGER VEHICLES PREVIOUSLY SERVICED UNDER FORD SERVICE BULLETIN 97-17-9 FROM AUGUST 1997 THROUGH DECEMBER 1997. THESE VEHICLES WERE INADVERTENLY EQUIPPED WITH AN 18-GALLON FUEL TANK RATHER THAN THE 16-GALLON AS SPECIFIED. THE 18-GALLON TANK HAS A SECOND VALVE LOCATION WHERE A SHIPPING PLUG SHOULD BE INSTALLED.
THE AUTOMATIC TRANSMISSION PARK PAWL SHAFT MAY NOT BE FREE TO ROTATE AS INTENDED. IF THE PARK PAWL SHAFT DOES NOT ROTATE, IT WOULD PREVENT THE PARK PAWL FROM ENGAGING THE PARK GEAR WHEN THE SHIFT LEVER IS IN THE PARK POSITION.
THE PARK PAWL ABUTMENT BRACKET HAS A SHARP EDGE WHICH CAN CAUSE THE PARKING PAWL TO HANG UP AND NOT ENGAGE THE PARK GEAR. THIS WOULD ALLOW THE VEHICLE TO MOVE EVEN THOUGH THE GEAR SHIFT INDICATOR SHOWS THAT THE VEHICLE IS IN PARK.
THE PARK PAWL SHAFT WAS IMPROPERLY POSITIONED WHEN THE ROLL PIN THAT RETAINS IT WAS INSTALLED DURING TRANSMISSION ASSEMBLY. IF THE SHAFT WAS NOT PROPERLY POSITIONED, THE ROLL PIN MAY NOT HAVE LINED UP WITH THE GROOVE IN THE SHAFT AND HAVE BEEN CRUSHED AT ASSEMBLY. ALSO, A BURR COULD HAVE BEEN RAISED ON THE SHAFT.
THE BRAKE SYSTEM FLUID LEVEL INDICATOR LAMP SWITCH CAN MALFUNCTION. THIS DOES NOT COMPLY WITH FMVSS NO. 105, "HYDRAULIC BRAKE SYSTEMS."
JUST BOUGHT A MERCURY SABLE 1996. AFTER DRIVING THIS VEHICAL FOR ABOUT 10 MILES, THE TRANSMISSION BEGAN TO SLIP BADLY. IT BEGAN WITH HAVING TROUBLE ACCELERATING FROM A COMPLETE STOP. LUCKILY I WAS DRIVING IN A RURAL AREA WITH FEW STOPS AND LITTLE TRAFFIC. BY THE TIME I STOPPED AT THE 3 STOP SIGN. THE TRANSMISSION WOULD NO LONGER ENGAGE INTO 1ST OR 2ND GEAR. NEVER GOT INTO 4TH GEAR. BUT HAD TO GET PUSH THE VEHICAL FROM THE LAST STOP SIGN UNTIL I REACHED A SMALL HILL THAT ALLOWED ME TO REACH THE SPEED SO THAT 3RD WAS ABLE TO ENGAGE AND WAS ABLE TO MAKE IT TO MY HOUSE. THE CAR HASN'T MOVED SINCE THEN. WASTE OF $1,000!! TRANSMISSION IS FINISHED.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1996 MERCURY SABLE. WHILE DRIVING AT VARIOUS SPEEDS, A SQUEAKING NOISE WAS HEARD UNDER THE VEHICLE, ESPECIALLY WHEN SLOWING DOWN, MAKING TURNS, AND REVERSING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE CRADLE AND SUBFRAME BUSHING WERE CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. IN ADDITION, WHILE DRIVING AT CERTAIN SPEEDS AND MAKING RIGHT OR LEFT TURNS, THE STEERING WHEEL SEIZED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1996 MERCURY SABLE. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC FOR ROUTINE MAINTENANCE AND THE MECHANIC DISCOVERED THAT THE ENGINE CRADLE AND THE SUBFRAME WERE SEVERELY RUSTED AND CORRODED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 95,000.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1996 MERCURY SABLE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE SUDDENLY ACCELERATED AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE UNKNOWN REPAIRS WERE PERFORMED. THE FAILURE RECURRED HOWEVER AND THE VEHICLE WAS TAKEN TO THE DEALER FOR THE SAME FAILURE ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 6,000 AND THE CURRENT MILEAGE WAS 49,000. *TR
No injuries · No fire · No crash
RELEVANT INFORMATION---ENGINE WAS REPAIRED ON SEPT. 9/10, 2012 SAME MORNING AS THE ACCIDENT--CAR WAS DRIVEN TO BANK BUT AS I WAS LEAVING I COULD NOT PUT CAR INTO REVERSE. A GENTLEMAN PASSERBY WAS ABLE TO PUT IT INTO REVERSE WITH EFFORT AND A LOUD NOISE IN THE GEARS. I PROCEEDED TO MY EXERCISE CLASS WHICH LASTED ONE HOUR. HAD NO TROUBLE WITH REVERSE GEAR THIS TIME. ABOUT 1/2 HOUR LATER I WAS TURNING INTO A PARKING LOT AND IN A MATTER OF MINUTES THE ENGINE STARTED REVVING UP AND SHOT FORWARD ON ITS OWN, WENT OVER A CURB & SIDEWALK AND CRASHED INTO A BRICK WALL AT HIGH SPEED. THE AIR BAGS WENT OFF AND WITH EFFORT I WAS ABLE TO OPEN THE FRONT DOOR. I HAD MINOR INJURIES--NOSE, CUT ON ELBOW, BANGED UP KNEES. THE ENGINE OF THE CAR KEPT ROARING FOR POSSIBLY 15 MINUTES UNTIL SOMEONE CUT THE CABLE TO THE BATTERY. THE POLICE REPORTED THAT I HAD STEPPED ON THE GAS INSTEAD OF THE BRAKE WHICH WAS TOTALLY FALSE. I REMEMBER DISTINCTLY THINKING--THERE'S SOMETHING TERRIBLE WRONG WITH MY CAR. THE INSURANCE COMPANY WAS NOT INTERESTED IN PURSUING THE CAUSE WHICH MAY HAVE BEEN RELATED TO THE REPAIR DONE ON THE ENGINE. THEY CALLED THE CAR A TOTAL LOSS. *TR