Mazda North American Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2004-2005 MPV, 2004 RX-8, and 2006-2007 Mazdaspeed6 vehicles. These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Mazda North America Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2006-2007 Mazdaspeed6 and 2004 MPV vehicles nationwide. Mazda is also recalling 2005-2006 MPV vehicles in Alabama, Arizona, Arkansas, California, Delaware, the District of Columbia, Florida, Georgia, Hawaii, Illinois, Indiana, Kansas, Kentucky, Louisiana, Maryland, Mississippi, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, South Carolina, Tennessee, Texas, Virginia, West Virginia, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. On July 9, 2019 this recall was expanded to include certain 2004-2011 RX-8 vehicles that were previously recalled under 16V-354 but have not yet been repaired. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Mazda North American Operations (Mazda) is recalling certain model year 2003-2008 Mazda6, 2004-2008 RX-8, and 2006-2007 Mazdaspeed6 vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion and other factors, including manufacturing variability that, over time, could cause the inflator to rupture.
Mazda North American Operations (Mazda) is recalling certain 2004 Mazda RX-8 vehicles. The ball joint socket on the front suspension lower control arm may crack and the ball joint may separate from the socket.
Mazda North America Operations (Mazda) is recalling certain model year 2004-2008 RX-8 vehicles. Heat from the engine and the exhaust may cause the main fuel pump pipe to crack.
The contact owns a 2004 Mazda RX-8. The contact stated that while the vehicle was being serviced at Valvoline for a scheduled oil change, the contact was informed that fuel was leaking. The contact was advised not to drive the vehicle. The dealer was contacted and notified of the failure. The vehicle was taken to the dealer, where a diagnostic evaluation revealed a fractured fuel system discharge pipe. The contact was informed that the fuel pump required replacement. The contact associated the failure with NHTSA Campaign Number: 17V354000 (Fuel System, Gasoline), which was completed on the VIN in 2009. The manufacturer was notified of the failure and informed the contact that the repair was not covered under warranty. The failure mileage was approximately 70,000.
No injuries · No fire · No crash
No worries — here it is trimmed to under 2,000 characters: I am reporting a recurring safety defect on my 2004 Mazda RX-8 (VIN: [XXX] a repair under NHTSA Recall 1017E (Fuel Pump Ring / Discharge Pipe). Recall 1017E was completed on my vehicle on September 19, 2017. The same fuel leak has since recurred, with fuel vapor now entering the passenger cabin. Only a few thousand miles have been driven since the recall repair. The vehicle is currently at Della Mazda, Queensbury, NY at approximately 72,000 miles. On May 8, 2026, I contacted Mazda Customer Experience Center. Mazda confirmed the dealer submitted a pre-authorization request for recall coverage, which Mazda corporate denied, stating the recall was previously completed and further repairs are my responsibility. I have a chat transcript documenting this. A recall remedy that fails to correct the covered defect should not be considered complete. I am requesting NHTSA review whether Recall 1017E has produced recurring failures, direct Mazda to honor the recall remedy, and advise on available consumer reimbursement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash
For a year I have responded to every notice for a recall repair (7 total) Mazda has not repaired my vehicle or scheduled its repair. My recall ID is 016742248 and my Campaign Number is 100409. My car has a DO NOT DRIVE status and Mazda tells me I MUST drive the car 2 hours to get it repaired each way. And they refuse to transport y vehicle even thought I have told them in phone conversations about my cars do not drive status. The latest attempt for filing for a repay was 7-21-25 at 9:40am central time.
No injuries · No fire · No crash
The contact owns a 2004 Mazda RX-8. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle failed to restart. The check engine warning light was illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the engine. The dealer determined that the engine had no compression. The vehicle was repaired, but the failure reoccurred. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 60,000.
No injuries · No fire · No crash
The electric power steering randomly pulls hard to one side while driving. There are brief spasms of forceful jerks each jerk is 1-2 seconds the series of jerks lasts 10-20 seconds and usually stops with power steering failure all while driving.
No injuries · No fire · No crash