Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford Fusion vehicles without a 3.5L engine and Lincoln MKZ hybrid electric vehicles, 2011 Mercury Milan vehicles, 2011-2012 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with a 3.5L GTDI engine and 2013 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with any available engine. The affected vehicles have electric power steering assist systems that may shut down as a result of a steering motor sensor fault.
Ford Motor Company (Ford) is recalling certain model year 2010-2013 Ford Taurus vehicles manufactured December 1, 2009, to July 31, 2010, and 2011-2013 Lincoln MKS vehicles manufactured June 1, 2011, to October 31, 2011. In the affected vehicles, the interior door handle return spring may unseat, resulting in interior door handle that does not return to the fully stowed position after actuation.
Ford is recalling certain model year 2012 Taurus, Lincoln MKS, and model year 2013 Explorer vehicles manufactured July 19, 2011, through March 15, 2012. In the affected vehicles, the fuel tanks may have a marginally sealed seam in the side of the tank. As a result, the fuel tanks may not provide the expected strength in the event of an impact. The tanks may also leak.
The contact owns a 2012 Lincoln MKS. The contact stated that while driving 40 MPH, there was an abnormal fuel odor coming from the vehicle. The contact pulled over the right side of the road and exited the vehicle and became aware of a leak underneath the vehicle. No warning light was illuminated. The vehicle was not taken to a dealer or an independent mechanic to be diagnosed. The vehicle was not repaired. The contact associated the failure with NHTSA Campaign Number: 13V109000 (FUEL SYSTEM, GASOLINE); however, the VIN was not included in the recall. The vehicle was repaired. The manufacturer was not notified of the failure The approximate failure mileage was 130,000.
No injuries · No fire · No crash
This is additional information related to my prior complaint 1167880 regarding the 2012 Lincoln MKS steering issue.
No injuries · No fire · No crash
I’ve owned my 2012 Lincoln MKS for 3 years. A warning recently appeared saying “Power Steering Assist Fault,” and now the steering is very hard to turn, especially at low speeds. I’ve already paid around $1,800 in the past to fix this issue once, but now I’m experiencing the same or similar problems again. I haven’t had it officially diagnosed this time because both Ford and the dealer told me it wouldn’t be covered, since the recall (15S18) is now expired. This is a serious safety issue. The car is difficult to control and unsafe to drive. I’m a full-time worker and a father of two toddlers, and I’m still making payments on this car that I now can’t safely use — or only for short trips while constantly worrying about steering failure. I just found out about this old recall, and the dealership never told me anything about it when I bought the car used. I strongly believe I’m experiencing the same issue Ford previously recalled these vehicles for, and I’m asking NHTSA to investigate or reopen the recall so it can be repaired before me or my family is seriously injured.
No injuries · No fire · No crash
After starting the vehicle on Thursday 6/26/2025, the Power Steering Assist Fault message appeared in the message center. The owner's manual was consulted and as recommended, the engine was turned off for over 10 seconds, turned back on, and the message returned. The Power Steering Assist Fault message has appeared each time upon starting the engine (both by remote and push-button) for 8 days and counting. In September of 2015, the recall associated with a fault in the electric power steering system (number 15S18) was completed at the dealership. The recommended maintenance scheduled has been followed since the vehicle was purchased in January 2012.
No injuries · No fire · No crash
The contact owns a 2012 Lincoln MKS. The contact stated while attempting to drive out of a parking space, the message "Power Assist Failure" was displayed, and the vehicle lost power steering functionality. The vehicle was towed to an independent mechanic, where it was determined that the Power Steering Control Module (PSCM) needed to be reprogrammed, and the steering rack needed to be replaced. The mechanic related the failure to Ford Campaign Number: 15N01. The vehicle was then taken to the dealer, where the same assessment was made. The dealer ordered the part for the repair; however, the manufacturer's warranty department denied the claim for the repair after several attempts. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 158,000.
No injuries · No fire · No crash