Kia · Model Report
Showing safety data for the 2020 model year only.
Kia Motors America (Kia) is recalling certain 2020-2021 Rio vehicles. The brake master cylinder may have been manufactured with sharp edges that can damage the inner oil seal, resulting in reduced braking performance.
My 2020 Kia Rio S caught fire spontaneously while parked and unattended for 5 hours at my work parking lot. The vehicle was turned off and had not been involved in a collision. I was notified of the fire after it had already started. The fire caused catastrophic damage to the passenger compartment and resulted in a total loss of the vehicle. Component/system suspected: The exact component that initiated the fire has not yet been determined. Based on the circumstances, I am concerned about a possible vehicle electrical or mechanical failure, but I do not want to speculate as to the cause without investigation reports. The vehicle was subsequently taken to a salvage/inspection facility. I am currently determining whether it remains available for inspection. Safety risk: The vehicle caught fire while parked without an apparent external cause. The fire became extensive enough to destroy the passenger compartment and vehicle. This created a significant fire hazard to nearby vehicles, property, and people. Had the vehicle been parked in a garage or other enclosed area, or had someone been inside or near the vehicle when the fire began, the potential consequences could have been severe. Reproduction/confirmation: The problem has not been reproduced by a Kia dealer or independent repair facility. The vehicle was destroyed by the fire and declared a total loss. Inspections: Boise Fire Department responded to the vehicle fire. Progressive Insurance subsequently inspected/handled the vehicle and classified the loss as a non-collision total burn/total loss. I have requested the complete Boise Fire Department records and additional records from Progressive concerning any investigation into the origin and cause of the fire. Kia has not yet inspected the vehicle to my knowledge. Warnings/symptoms before the fire: There were no warning lights, messages, smoke, unusual odors, electrical problems, noises or any other symptoms I was aware of. No after market electronics or anything.
No injuries · No fire · No crash
The contact owns a 2020 Kia Rio. The contact stated that while coming to a stoplight, the vehicle unexpectedly stalled. There was no warning light illuminated. The vehicle did not need to be restarted. The vehicle was taken to the dealer; however, the vehicle was not diagnosed or repaired. The contact was informed by the dealer that the failure could not be duplicated. The manufacturer was not made aware of the failure. The approximate failure mileage was 28,000.
No injuries · No fire · No crash
Upon stopping at a red light and or stop sign, when applying brakes, the car continues to move forward, even after pumping the brakes. Vehicle has been diagnosed by a certified auto mechanic. The findings and recommendation for the Brake Master Cylinder to be the reason the vehicle continues to creep forward, when brake are applied and held. This issue has on two separate occasions near collision, because the vehicle wouldn't stop.
No injuries · No fire · No crash
I was driving up a hill and it would not go past 20-30 mph, and the rpm will sometimes go up when not accelerating. The transmission does not shift when driving and will sometimes make the car stop and go stop and go continuously. Tried accelerating but the rpm would go up while the mph would not.
No injuries · No fire · No crash
I went into a rural King store to shop when I came back out my car was completely filled with smoke. I opened the front passengerdoor and the smoke hit me in the face it was so thick and green it was just it took my breath. It took me 10 minutes to locate what had happened and down on the door frame of the passenger side of the front seat where the wiring is there was a whole melted all the way through that panel and you could see the wiring was exposed so I assume that the wiring had caught on fire. I'm not sure about this it has been looked at and it is at Jeff Wilder Toyota in Clarksville Indiana. They want me to pay $1,000 deductible for this but I feel like if it was a wiring issue key is should be responsible. I am going through a flood right now in my home and now I have to deal with that and I don't think I'm even responsible for the payment I think he is at the cover it.