Kia EV6 Complaints (2023)

135 consumer complaints on file.

#11715319February 3, 2026
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
ICCU blew along with the fuse
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11715058February 2, 2026
VISIBILITY/WIPER, ELECTRICAL SYSTEM
Heating system fails to generate sufficient heat to defrost windshield or prevent ice buildup in the winter, also impacts the temperature of the cabin. No error codes are generated but it appears the PTC heater is not functioning as expected.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11714142January 29, 2026
ELECTRICAL SYSTEM
10:00 am January 28th AFTER A DRIVE OF APPROXIMATELY 20 MILES TO THE GROCERY STORE, we parked the 2023 Kia EV6 Wind,in the parking area, then entered the store to shop. On returning, we placed the groceries in the trunk and proceeded to leave for home. The push button "START" provoked a notice on the dash that the 12 volt battery was "LOW". The drive circuits would not enable. Prior to going in the store the dash information reported the main battery was at 62%, all else is normal. We are now stuck 20 miles from home. We called KIA roadside assistance, via a cell phone. The Kia site told us it did not recognize the VIN number we had entered three separate times.. It would not proceed down the logic tree for us to be assisted by their service. We called :AAA"they sent a service truck with a jumper battery which allow us to get a small charge on the 12 volt system, enough to get us home. Immediately upon arriving I opened the hood, retrieved my "Fluke DVM" to measure battery voltage. 6.2 volts was the reading. The 12 volt battery was not charged by the voltage regulation system in our car. Fortunately, we were dressed well, being the temperature outdoors was 14*F at the time and we had access to the grocery store for safety. Yet still a major inconvenience due to breakdown. Later, I disconnected the negative battery terminal, then connected the 12 volt AGM battery charger I have purchased for home use. The battery was charged to full overnight to 13.2 volts. I removed the charger cables, then left the battery set for 12 hours disconnected from the vehicle. The voltage dropped to 12.6 volts dc, indicating a healthy battery. This morning January 29th, I called the Kia dealership to explain our problem, the scheduler has acknowledged a possible bad charge control unit, but told me if it was not a control unit problem, I would pay a fee of $135 dollars for the troubleshooting, even though the vehicle has approximately 33,000 miles. Schedule Feb 4th
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11714032January 28, 2026
UNKNOWN OR OTHER, ELECTRICAL SYSTEM
ICCU failure. Was confirmed by shop car was towed to over phone. But no mention of it on invoice as of yet. I was at traffic light when I heard a pop and when I tried to go, got the warning message to pullover and the turtle icon. I made it to a towable spot. Super fortunate all in all. Can’t imagine if on highway in weather. No hints of failure before. Car was recently purchased month prior. I took it in for recall within first week, was told all good, software was updated. I kept between 20%-80% at all times, charged lvl2 at work daily and lvl1 at home sometimes. Had cheap voltage meter in car and was reading fine. Hope to get my car back soon.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11714011January 28, 2026
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, POWER TRAIN
While driving my Kia EV6 in the middle of a snowstorm, the vehicle experienced a sudden and severe power failure. I heard a loud popping sound from the rear of the cabin, after which the vehicle immediately entered reduced-power (limp) mode. Within approximately one minute, the vehicle shut down entirely and lost all propulsion and mobility. I was able to move the vehicle to a safe location only because I was not in traffic or on the highway at the time of the failure. Had this occurred at highway speeds or in active traffic, it would likely have resulted in a dangerous situation with a high risk of collision, especially given the severe winter weather, low visibility, and slippery road conditions. The vehicle has approximately 21,000 miles. This is the second failure of the Integrated Charging Control Unit (ICCU) in this vehicle. The vehicle was inspected by an authorized Kia dealer, who has officially diagnosed the failure as a failed ICCU and associated fuse. There were no warning lights or messages prior to the failure. The first indication of a problem was the popping sound, immediately followed by limp mode and then a complete shutdown without further warning. The vehicle is available for inspection upon request. The repeat nature of this failure, lack of advance warning, and sudden loss of propulsion represent a serious safety defect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11713938January 28, 2026
FUEL/PROPULSION SYSTEM
While changing lanes on a freeway, the car passed through a narrow strip of slush from recent snowfall. The car immediately disabled the motors, preventing acceleration and regenerative braking for nearly 50 seconds. There were no warning lights, sounds, or messages displayed on the car's gauge cluster display, either for the initial loss of propulsion or for the restoration of propulsion. This caused a loss of traction when the car eventually passed through a patch of packed snow and ice.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11713663January 27, 2026
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
It seems as if the ICCU on my car failed. It will not charge and went into limp mode in order for me to drive it home a few blocks.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11713447January 26, 2026
VISIBILITY/WIPER
A small amount of snow / ice is sufficient to prevent the windshield wipers from returning all the way to the original starting position low on the windshield. For some reason this prevents them from functioning entirely - they just get stuck in a loop trying to go all the way down. I am able to lift them up manually but they won't do so under wiper motor power / while driving. I have a video that clearly shows the failure mechanics that this system won't allow me to upload.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11712811January 22, 2026
ELECTRICAL SYSTEM
The vehicle ICCU failed on 18 January 2026. It previously had the ICCU inspected and updated as part of #24V-867. Warnings on screen told me to stop driving and pull over. Had vehicle towed to Dealer where they confirmed ICCU failure and initially were going to charge nearly $4000 to repair. KIA Customer care spoke to dealership and ICCU repair is now being covered. It seems apparent that the earlier fix did not resolve the issue, and raises concerns over whether KIA truly understands the underlying cause. Will the replacement fail after 30k miles? Will I be stranded?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11711811January 19, 2026
FUEL/PROPULSION SYSTEM
Vehicle was normal and during the drive a warning light for "Check Electric Vehicle System" was shown, then a second warning light "Stop Vehicle and Check Power Supply" was shown, within 2 minutes the vehicle went into "turtle" or reduced speed mode and then finally the vehicle shut down completely. I was on city streets at the time and was able to park safely, but if this had happened on and interstate highway it would have been dangerous. This is a known issue with this vehicle as it ended up being an ICCU Assembly failure. There is also a safety recall for this, but Kia is not replacing the part and just doing a software update that is not fixing the root cause of the problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11711542January 16, 2026
ELECTRICAL SYSTEM
Without any warning the car dies on the interstate, it warns you once it fails. The ICCU fails. It left me stranded with my dog.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11711508January 16, 2026
FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM, POWER TRAIN
While driving at normal speed, my Kia EV6 experienced a sudden and complete failure of the ICCU system with zero warning. The vehicle instantly lost all propulsion power and all 12V electrical power, rendering the car uncontrollable and unsafe. I was unable to accelerate, unable to place the vehicle in gear, and unable to activate hazard lights. This occurred despite the vehicle being at approximately 99% battery charge. This failure created an immediate and severe safety hazard, as the vehicle effectively became a dead object in traffic without warning to surrounding drivers. There was no prior alert, no dashboard warning, and no indication of impending failure. This defect is well-documented and pervasive across the Hyundai–Kia–Genesis E-GMP electric vehicle platform and has persisted despite multiple recalls spanning several model years. Kia has acknowledged the issue through recalls but does not have a reliable or permanent fix. Even newer model year vehicles that are claimed to address the issue have experienced the same failure. If this defect occurred in an internal combustion engine vehicle — for example, a random, complete engine shutdown or fuel system failure while driving — it is highly unlikely that regulators would permit the issue to persist across multiple model years without resolution. The fact that this is occurring in an electric vehicle should not lower the safety standard. A sudden total loss of propulsion and electrical power is equally dangerous regardless of drivetrain. Critically, there is no assurance that this failure will not recur, even after replacement of the ICCU or related components. Owners are effectively being returned vehicles that can lose all power again at any time, without warning. It is deeply concerning that this issue remains unresolved after multiple recalls and multiple model years. Continued operation of these vehicles without a verified, permanent fix places the public at ongoing risk.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709625January 8, 2026
ELECTRICAL SYSTEM
Got a Check electrical system error, car reduced speed and 12v battery stopped charging. Car was towed to the dealership and they confirmed that the ICCU needed to be replaced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708371January 2, 2026
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
My Kia EV6’s ICCU failed while I was driving, leading the car to completely lose power while on a busy street.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708253January 1, 2026
SERVICE BRAKES
I was driving on a residential street at fairly slow speeds, like 25 mph. There was a stop sign so I engaged the brakes and the car did not smoothly slow down but instead it felt like the back tires locked up and a skid started and I actually went into the intersection before coming to a stop. There was no ice, no sand, just the road surface and the skid in the rear of the vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707268December 27, 2025
POWER TRAIN, ENGINE, FUEL/PROPULSION SYSTEM
I am submitting this as a supplemental statement to my existing NHTSA safety complaint regarding my electric vehicle, KIA EV6, 2023 model. Since my original filing, the vehicle has now experienced loss of power / loss of propulsion a total of three times. These incidents occur without warning, are unpredictable, and render the vehicle unsafe to operate. The vehicle can suddenly lose motive power, creating a serious risk of collision, particularly in traffic or at speed. The manufacturer and authorized dealership have been unable to identify the root cause or permanently repair the defect. Dealer documentation reflects that the issue “cannot be replicated,” and no corrective action beyond temporary battery charging or system reset has been performed. No explanation has been provided as to why the power loss occurred or how it will be prevented from recurring. Because the defect is intermittent and safety-critical, I no longer feel safe driving this vehicle and have stopped operating it entirely. A reasonable consumer would consider repeated, unexplained loss of propulsion to present an unreasonable risk to safety. I am submitting this update so NHTSA is aware that: The defect is recurrent (three incidents) The condition remains unresolved The vehicle is unsafe for continued use I respectfully request that NHTSA review this matter for potential investigation, as loss of propulsion in an electric vehicle poses a serious safety hazard to the driver and others on the road. Thank you for your attention to this safety concern. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706848December 23, 2025
ELECTRICAL SYSTEM
Car said there was a 12V low battery danger and said to pull over immediately while driving. After taking it to the dealership, they said my ICCU went out. So they had to replace it. I've read that the ICCU on these cars are notorious for failing and needing replacement.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706763December 23, 2025
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, POWER TRAIN
While driving, heard a pop and a check electric vehicle system error popped up on the dash. Car was not drivable except for very low speeds shortly after (impacted safety of the drive) until it eventually stopped being able to turn on at all.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706684December 22, 2025
ELECTRICAL SYSTEM
The ICCU that charges the 12V on board battery failed to keep the battery charged and it made my vehicle a paper weight. Had to have it towed to my local Kia dealership to wait 2 weeks for an appt. Hasn’t been repaired yet and I’m sure it won’t be a short wait after they schedule the repair
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706661December 22, 2025
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
ICCU FAILURE. Car would not drive
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia EV6