Ford Thunderbird Complaints

2,355 consumer complaints on file.

#11747063June 28, 2026
SUSPENSION, POWER TRAIN
Rattle in my front end E code for transmission
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11620384October 17, 2024
FUEL SYSTEM, GASOLINE
The contact owns a 2005 Ford Thunderbird. The contact stated that while driving at 30 MPH over a speed bump, the contact heard a loud grinding noise with no warning light illuminated. The contact stated while the vehicle was parked, the contact noticed fuel leaking from the fuel tank with no warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that the fuel pump failed and needed to be replaced. The vehicle was repaired. The contact stated while driving at an undisclosed speed, the vehicle stalled with no warning illuminated. The vehicle was towed to the dealer where it was diagnosed that the fuel tank failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 33,118.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11542638September 5, 2023
STEERING
The contact owns a 2002 Ford Thunderbird. The contact stated while driving 5 MPH and attempting to make a turn, the steering wheel seized. There was no warning light illuminated. The contact was able to turn the steering wheel while using excessive force and veered to the side of the roadway. The contact stated that he restarted the vehicle; however, the vehicle stalled after driving approximately 3-feet. The contact stated that he restarted the vehicle; however, the vehicle stalled while driving. The vehicle was towed to the residence. The contact stated that the vehicle was undrivable. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed nor repaired. The failure mileage was approximately 75,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11542652September 5, 2023
STEERING, ENGINE
The contact owns a 2002 Ford Thunderbird. The contact stated that while driving approximately 15 MPH and making a left turn, the power steering suddenly failed and the steering wheel would not turn in either direction, before the vehicle suddenly stalled. The vehicle was later towed to the residence. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure but no assistance was offered. The failure mileage was 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11534871July 27, 2023
TIRES
The contact owns a 1990 Ford Thunderbird equipped with Goodyear Tire, Tire Line: Viva 3 A/S, Tire Size: 250/70/R15, DOT Number: PJ34KB1R0219. The contact stated while driving 40 MPH, she became aware that the rear driver’s side tire was shaking abnormally. The contact took the vehicle to the Walmart where the tires were purchased and was informed that there were blisters on each tire and the tires needed to be replaced. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 151,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11466232May 26, 2022
STRUCTURE:INTERIOR PANELS:DASHBOARD
Dash board cracked few places by Windshield. It's really Between WINDSHIELD AND DASHBOARD. ANY RECALLS OR COMPLAINTS? [XXX] THANK YOU. [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11434577September 27, 2021
ENGINE
The contact owns a 2004 Ford Thunderbird. The contact stated while driving at an undisclosed speed, the contact approached a stop sign and the vehicle stopped as needed; however, after the contact depressed on the accelerator pedal, the vehicle began to misfire and shuddered for several minutes. The contact took the vehicle to the local dealer who inspected the vehicle and diagnosed that the failure was related to TSB 05-16-2 (moisture build up on the plugs and on the cylinder) that caused the vehicle to misfire. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 40,526.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11422055June 23, 2021
VEHICLE SPEED CONTROL
Sudden unintended acceleration on two occasions. Car only has 11,000 miles
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11415483May 6, 2021
AIR BAGS, SEATS, WHEELS
WHILE DRIVING MY CAR ON THE HIGHWAY LAST EVENING, THE LEFT SHOULDER AIRBAG WAS DEPLOYED. I IMMEDIATELY PULLED THE CAR TO THE SIDE OF THE ROAD. I NOTED THAT THE LEFT FRONT TIRE WAS FLAT. MY HUSBAND CHANGED THE TIRE. UPON REMOVING THE WHEEL WE NOTED THAT THE TIRE WAS COMPLETELY NORMAL, BUT THE RIM WAS FRACTURED ON THE INTERNAL ASPECT. THE SEAT WAS DAMAGED FROM THE DEPLOYED AIRBAG. IT APPEARS THAT THE RIM IMPLOSION SET OFF THE LEFT SHOULDER AIRBAG. HAD IT BEEN THE CHEST AIRBAG, I WOULD HAVE HAD AN ACCIDENT. I CALLED THE LOCAL DEALER AND THEY TOLD ME THAT THEY HAVE NEVER HEARD OF THIS. I HAD 4 NEW TIRES PLACED ABOUT 1 MONTH AGO AT COSTCO IN ALBUQUERQUE. THE CAR HAS ONLY 16,000 MILES ON IT. I HAVE OWNED IT FOR THEEE YEARS. PRIOR OWNER AN ELDERLY MAN- DRIVE IT 10,000 MILES OVER 13 YEARS. I AM NOT AWARE OF EVER ANY DAMAGE TO THE WHEEL OR HITTING ANYTHING WITH IT. I WAS DRIVING 60 MPH WHEN THIS OCCURRED.I HAVE INCLUDED A PICTURE OF THE INSIDE OF THE TIRE RIM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11364399October 14, 2020
VEHICLE SPEED CONTROL
HAVE REPLACED VIA FORD DEALER THROTTLE CONTROL SENSOR TWICE. FIRST REPAIR 2007. SECOND REPAIR 2014, AND NOW IN 2020. I AM FACING SAME PROBLEM AGAIN. OBVIOUSLY THE CONTROL SYSTEM IS DEFECTIVE. THE PROBLEM TRIGGERS VEHICLE LIMP MODE WHILE DRIVING AND IN PARK.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11351417August 26, 2020
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2004 FORD THUNDERBIRD. THE CONTACT STATED THAT WHILE INSIDE THE VEHICLE, AN ABNORMAL ODOR APPEARED AS THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO CHANGED THE OIL AND NOTICED FUEL LEAKING FROM THE FUEL TANK. THE CONTACT MENTIONED THAT THE FAILURE WAS CURRENTLY STILL BEING EXPERIENCED. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. A DEALER WAS NOT CONTACTED. THE CONTACT MENTIONED NHTSA CAMPAIGN NUMBER: 05V113000 (FUEL SYSTEM, GASOLINE) AS A POSSIBLE SOLUTION TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE HOWEVER NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 89,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11270335October 22, 2019
AIR BAGS
AIR BAG FLASHING CODE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11257357September 23, 2019
ENGINE
THROTTLE BODY SYSTEM FAILURE CAUSING INAPPROPRIATE VEHICLE DECELERATION WHILE DRIVING. THIS CONDITION HAPPENS WITHOUT WARNING AND CAN CAUSE ANOTHER VEHICLE TO REAR END YOU. I HAVE ALREADY HAD ONE THROTTLE BODY REPLACED DUE TO THIS CONDITION IN 2013 AND MY VEHICLE IS HAVING THE SAME PROBLEMS AGAIN. THE COMPUTER PROGRAM THAT CUTS THE ENGINE TO IDLE SPEED SHOULD BE DISABLED UNTIL A PERMANENT FIX TO THIS PROBLEM CAN BE CORRECTED. IN THE CURRENT MODE, THESE VEHICLES ARE UNSAFE TO DRIVE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11244929August 19, 2019
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
THE CLUSTER LIGHTS HAVE GONE OUT ON MY 2002 FORD THUNDERBIRD. WHEN THIS ACTUALLY HAPPENED I REALLY DON'T KNOW SINCE THE CAR IS MAINLY A SHOW CAR AND WHILE DRIVING THE CAR AT DUSK COMING BACK FROM A CAR SHOW THE CLUSTER LIGHTS DID NOT COME ON. WE PARKED THE CAR AND ONLY DROVE IT DURING DAYLIGHT HOURS. THEN THE FUEL SYSTEM QUIT WORKING SO WE HAD TO HAVE THE CAR TOWED TO A DEALER. AFTER DOING SOME RESEARCH I FOUND THAT THIS ISSUE COULD CAUSE HEADLIGHT FAILURE, TAILLIGHT FAILURE, TURN SIGNAL FAILURE, TILT STEERING WHEEL FAILURE, PARKING LIGHTS FAILURE, AND DRIVING LIGHTS FAILURE. WHEN DRIVING THE CAR AT NIGHT YOU CANNOT TELL HOW FAST YOU ARE GOING AND YOU ALSO HAVE THE RISK OF YOUR TURN SIGNALS, HEADLIGHTS AND TAIL LIGHTS GOING OUT. YOU CAN GOOGLE FORD THUNDERBIRD AND FIND INFORMATION WHERE OTHER OWNERS OF THIS CAR HAVE HAD SIMILAR EXPERIENCES. I BELIEVE THIS CAR NEEDS TO HAVE A RECALL SINCE THEY CANNOT BE DRIVEN AT NIGHT OR REALLY ANYTIME. WHICH IS A RISK NOT ONLY TO ME BUT ANY OTHER VEHICLE AROUND ME. I TOOK THE CAR TO A DEALER TO GET THE CAR LOOK AT AND FOR THEM TO RUN A DIAGNOSTIC TEST ON THE CAR AND THEY TOLD ME IT WAS A NETWORK PROBLEM AND IS VERY EXPENSIVE TO DIAGNOSE. HE SAID IT COULD TAKE HOURS TO DAYS TO FIGURE IT OUT CONSIDERING THE COMPUTER AND NETWORK SYSTEM ON THE CAR. THE SERVICE MAN ALSO TOLD ME THEY DID NOT LIKE TO WORK ON THIS CAR BECAUSE OF THIS ISSUE. HE ALSO STATED THAT WAS THE REASON FORD QUIT MAKING THIS VEHICLE. I HOPE YOU CAN SEE THE SAFETY ISSUES THIS VEHICLE CREATES. FROM SPEAKING WITH OTHER DEALERS FORD KNOWS ABOUT THIS ISSUE. THERE IS A WEBSITE ABOUT THE CLUSTER PROBLEMS IT IS : WWW.THUNDERBIRDSPECIALTIES.COM/2002-2005THUNDERBIRD-INSTRUMENT-CLUSTER-PROBLEMS/. THERE ARE SEVERAL OTHERS ON THE INTERNET ABOUT THIS ISSUE AND OTHER ISSUES WITH THE CAR.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11186764March 14, 2019
TIRES
TL* THE CONTACT OWNS A 2002 FORD THUNDERBIRD EQUIPPED WITH A FIRESTONE TEMPA SPARE TIRE, SIZE: T185-60-R17 (NA). WHILE CLEANING THE VEHICLE, THE CONTACT FOUND THAT THE SPARE TIRE THAT WAS STORED IN THE TRUNK WAS BLOWN OUT AND THE TIRE WIRES, RUBBER, AND CORDS WERE EXPOSED. THE MANUFACTURER WAS CONTACTED AND ADVISED THE CONTACT TO VISIT FIRESTONE TO HAVE THE TIRE REPLACED. THE CONTACT WAS INFORMED THAT THE TIRE WAS NO LONGER MANUFACTURED. THE CONTACT WAS CONCERNED THAT THERE WAS NO TIRE AVAILABLE TO REPLACE THE SPARE TIRE. THE VEHICLE FAILURE MILEAGE WAS 3,500 AND THE TIRE FAILURE MILEAGE WAS 2. *DT*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11182303February 25, 2019
AIR BAGS, STRUCTURE:BODY
MY DAUGHTER WAS IN A ROLLOVER ACCIDENT ON 09 -06 -2016 IN A 2002 FORD THUNDERBIRD CONVERTIBLE. THE AIR BAG DID NOT SUFFICIENTLY DEPLOY & SHE WAS SEVERELY INJURED AS A RESULT. SHE WAS ON INTERSTATE 95N NEAR MANNING, SC WHEN A SEMI TRUCK DID NOT SEE HER & CAME INTO HER LANE GRAZING THE CAR. SHE HAD TO GO OFF THE ROAD OR THE TRUCK WOULD HAVE CRUSHED HER. THE THUNDERBIRD ROLLED OVER & SHE WAS SEVERELY INJURED.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11144677November 1, 2018
AIR BAGS
MY AIRBAG LIGHT IS ON AND I WANT TO KNOW IF I HAVE A TAKATA AIRBAG. IF SO HOW TO I GET IT FIXED?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11119267August 10, 2018
SUSPENSION
BASICALLY, ALL SUSPENSION RUSTED OUT, INCLUDING BOTH FRONT SUSPENSIONS, SPINDLE RODS, SWAY BAR, OUTER TIE RODS, BOTH REAR TIE ROD LINKS, REAR LOWER AND UPPER CONTROL ARMS , FRONT UPPER CONTROL ARMS, REAR SHOCKS. ALL THE WORK WAS PERFORMED BY THE LOCAL FORD DEALER. I WAS TOLD THIS WAS NOT A UNIQUE PROBLEM TO THIS VEHICLE. DRIVING THE VEHICLE MADE SQUEEKY NOISES ALL THE TIME!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11097139May 21, 2018
AIR BAGS
AIR BAG NEEDS TO BE REPLACED AND FORD HAS NO REPAIR PARTS AVAILABLE TO PROVIDE OCCUPANT PROTECTION IN THE EVENT OF A CRASH. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11089780April 23, 2018
AIR BAGS
AIR BAG WARNING LIGHT APPEARED ON INSTRUMENT PANEL AND OWNER'S MANUAL INSTRUCTED TO RETURN TO DEALER. DEALER DIAGNOSED THE PROBLEM AS A FAULTY AIR BAG THAT SHOULD BE REPLACED. FORD MOTOR CO. SAID SERVICE PARTS ARE NOT AVAILABLE AND DEALER DID NOT REPAIR THE AIR BAG. I WAS ALLOWED TO LEAVE THE SERVICE DEPARTMENT WITH NO IDEA IF THE AIR BAG WOULD FUNCTION IN A CRASH. IS THE VEHICLE SAFE TO DRIVE AND SHOULD FORD MOTOR CO. HAVE DONE MORE TO ASSURE THE VEHICLE IS SAFE TO DRIVE?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Thunderbird