Ford · Model Report
Showing safety data for the 1993 model year only.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1990-1993 FORD F-SERIES VEHICLES EQUIPPED WITH DUAL FUEL TANKS AND 4.9, 5.0,5.8, OR 7.5 LITER GASOLINE FUELED ENGINES. SOME VEHICLES CAN EXPERIENCE A CROSS TANK FUEL FLOW CONDITION DUE TO A DAMAGED CHECK VALVE IN THE FUEL PUMP/SENDER ASSEMBLY. FUEL MAY BE SUPPLIED FROM ONE TANK AND SOME OR ALL OF THE UNUSED FUEL MAY BE RETURNED TO THE OTHER TANK.
TL* THE CONTACT OWNS A 1993 FORD F-250. WHILE THE CONTACT WAS FUELING THE VEHICLE, THE FUEL CAP SHRANK AND FUEL SPEWED FROM THE FUEL TANK. THE FAILURE OCCURRED WHENEVER HE ATTEMPTED TO FUEL THE FRONT TANK FIRST. AS THE FUEL TRAVELED TO THE REAR TANK, IT SPEWED OUT. THE CONTACT STATED THAT THE FAILURE WAS A FIRE HAZARD. THE CONTACT DROVE THE VEHICLE TO FUTURE FORD OF ROSEVILLE (650 AUTOMALL DR, ROSEVILLE, CA 95661, (888) 656-7577), BUT THE MECHANICS REFUSED TO SERVICE THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 250,000.
No injuries · No fire · No crash
STARTED VEHICLE NORMALLY AND AS SOON AS THE BRAKE WAS APPLIED, A LOUD 'POP' SOUND WAS HEARD BEHIND THE DASH AND A LARGE AMOUNT OF SMOKE CAME INTO THE CAB FROM THE A/C VENTS. I CONTINUED FOR ABOUT ONE MINUTE. THE VEHICLE WAS SHUT OFF AND PARKED IN PLACE. THE SMOKE SUBSIDED. THIS IS CONSISTENT WITH THE PROBLEMS INDICATED IN THE SPEED CONTROL DEACTIVATION SWITCH RECALL AFFECTING 1993 FORD F-250 VEHICLES CAUSING UNDER HOOD FIRES. HOWEVER, AFTER CONTACTING FORD, THEY INDICATED THAT MY PARTICULAR VIN WAS NOT INCLUDED IN THE RECALL, AND I WOULD BE RESPONSIBLE FOR THE COST OF TOWING AND ANY REPAIRS.
TL* THE CONTACT OWNS A 1993 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, HE NOTICED THAT THE SPEEDOMETER AND CRUISE CONTROL FAILED TO OPERATE. IN ADDITION, THE ABS WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE WARNING LIGHT REMAINED ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER 8V051000 (VEHICLE SPEED CONTROL:CRUISE CONTROL) HOWEVER THE VIN WAS NOT INCLUDED. THE CONTACT EXPERIENCED THE SIMILAR DEFECT AS MENTIONED IN THE RECALL. THE VEHICLE WAS REPAIRED AT THE CONTACT'S EXPENSE. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 145,000. UPDATED 10/17/12*LJ THE CONSUMER VIN WAS NOT INCLUDED IN THE RECALL. UPDATED 10/18/12
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1993 FORD F-250 EQUIPPED WITH COOPER DEAN MUD TERRAIN RADIAL SXT TIRES, SIZE 285/75/16. THE CONTACT STATED THAT THERE WERE BLISTERS BETWEEN THE LUGS. THE FRONT PASSENGER TIRE HAD WIRES PROTRUDING, WHICH WAS CAUSING TREAD SEPARATION. THE MANUFACTURER ADVISED THE CONTACT THAT THE TIRES WERE NOT INCLUDED IN NHTSA RECALL NUMBER: 06T003000(TIRES:TREAD/BELT). THE CURRENT AND FAILURE MILEAGES WERE 234,242.
No injuries · No fire · No crash
THIS IS ABOUT A FUEL TANK DELIVERY AND AIR INDUCTION BULLETIN, CROSS TANK FUEL FLOW PROBLEM MY FORD F250 TRUCK IS HAVING. I HAVE NOTIFIED MY LOCAL DEALERSHIP AND FORD CUSTOMER SERVICE, THEY BOTH SAY THERE IS NO RECALL FOR THIS VEHICLE. BUT I FOUND A NHTSA CAMPAIGN # 93V12500 DESCRIBING EXACTLY WHAT HAS BEEN HAPPENING FOR THE LAST 6 MONTHS. IT NEEDS TO BE FIXED AND IS EXPENSIVE, BUT I CAN'T GET ANY SATISFACTION FROM FORD, I'M HOPING YOU CAN HELP. *TR UPDATED 04/15/10.*JB
No injuries · No fire · No crash