Ford · Model Report
Showing safety data for the 1997 model year only.
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, IF THE INTERMEDIATE SHAFT YOKE SEPARATES FROM THE STEERING GEAR INPUT SHAFT, THE STEERING SYSTEM BECOMES DISCONNECTED.
VEHICLE DESCRIPTION: MINI VANS, LIGHT PICKUP TRUCKS, AND SPORT UTILITY VEHICLES. OFF LEASE CANADIAN VEHICLES EQUIPPED WITH DAYTIME RUNNING LIGHTS WHICH MEET CANADIAN REQUIREMENTS AND NOT THE PHOTOMETRIC REQUIREMENTS OF FMVSS 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." ACCORDING TO FORD, THE VEHICLES WERE IMPORTED INTO THE U.S. ERRONEOUSLY.
The contact owns a 1997 Ford Expedition. The contact stated while driving 35 MPH, the steering wheel became loosened while making a left turn. The contact stated that the "Check Suspension" and "Check ABS" messages were displayed on the instrument panel along with the oil, brake, and battery warning lights being illuminated. The contact called a local dealer and was informed that the part needed to repair the steering wheel was no longer in stock. The manufacturer was also notified of the failure and the contact was provided the same information as from the dealer. The contact also stated that moisture had begun to leak from the sunroof. The vehicle was not repaired. The failure mileage was approximately 171,000.
No injuries · No fire · No crash
Vehicle will speed up or slow down in certain times for certain speeds without notice smell of smok and looked hurt wiring
No injuries · No fire · No crash
WHILE COMING TO A STOP AND THE INTERSECTION OF LONGSTREET AND HIGHWAY 82. I PRESSED ON THE BRAKE PEDDLE AND THE BRAKES LOCKED UP AND I SLED THROUGH THE INTERSECTION INTO A DITCH. I WAS TRAVELING THE SPEED LIMIT OF 50 MPH. THE PASSENGER AIR BAG DEPLOYED BUT THE DRIVERS DID NOT DEPLOY. I HAVE A BROKEN NOSE FROM HITTING STEERING WHEEL. SEAT BELTS WERE ON FRONT SEAT DRIVER AND PASSENGER.
MY 1997 FORD EXPEDITION XLT BEIGE IN COLOR SINCE I HAVE OWN THIS VEHICLE I HAVE HAD TO REPLACE FIVE (5) SPARK PLUGS AND COIL FOR THEY HAVE BLOWN OUT OF THE CYLINDER AND I HAVE HAD TO HAVE THE VEHICLE TOWED INTO A REPAIR FACILITY WHICH HAVE BEEN COSTLY TO ME. THE ENGINE ON THIS VEHICLE IS A 5.4. THE VEHICLE WAS IN MOTION AT THE TIME OF THE PROBLEM ON THE HIGHWAY
No injuries · No fire · No crash
STEERING IS EXTREMELY OVERACTIVE AND SEEMS TWITCHING, MEANING AT LOW SPEED OR AT HIGH RATE OF TRAVEL VERY SLIGHT MOVEMENTS OF THE STEERING WHEEL CAUSE THE VEHICLE TO MOVE SUDDENLY, AND UNCONTROLLABLY, PREVIOUS OWNER WENT OFF HIGHWAY AND FELT UNSAFE IN VEHICLE BECAUSE OF THIS ISSUE. I IMAGINE THIS HAS TO DO WITH THE VARIABLE ASSIST POWER STEERING BUT CANNOT FIND ANY DIAGNOSTIC AIDE IN RESOLUTION OF ISSUE.