Ford Bronco Complaints (1990)

82 consumer complaints on file.

#10959185March 7, 2017
SEATS
THE SEAT PAN UNDER THE SEAT TRACKS HAS CRACKED IN MY 1990 BRONCO WITH CAPTAIN CHAIRS. THE VEHICLE WAS IN MOTION WHEN THIS HAPPENED ON A PUBLIC PAVED STREET, AND COMING TO A NORMAL STOP. BACK IN OCTOBER 1990, I RECEIVED SAFETY PROGRAM NUMBER (B(93) ABOUT THIS POTENTIAL PROBLEM. I IMMEDIATELY BROUGHT THE VEHICLE TO THE DEALERSHIP OF PURCHASE, JOHN FOSTER FORD, UPON RECEIPT OF THE NOTIFICATION. I DO NOT LET ANY SAFETY ISSUES GO. THEY LOOKED AT THE VEHICLE AND DID NOT MAKE THE REPAIR. BECAUSE THE VEHICLE IS SO KINDLY DRIVEN IT HAS TAKEN MANY YEARS FOR THE FLAW IN THE FORD SEAT PAN DESIGN TO DEVELOP. I SPOKE WITH FORD AT THE CUSTOMER SERVICE 800 NUMBER AGAIN TODAY AND HAVE BEEN IN TOUCH WITH THE REGIONAL SERVICE MANAGER AND THEY REFUSE TO PERFORM THE REPAIR OR ACKNOWLEDGE THAT THE VEHICLE WAS INVOLVED IN THE SAFETY PROGRAM. I STILL HAVE THE LETTER AND ORIGINAL ENVELOPE FOR WHICH IT CAME. THERE SHOULD BE A RECORD OF THE INITIAL INSPECTION CHARGE DONE BY THE DEALERSHIP IN SOME COMPUTER RECORD WHEN THEY TURNED IN THEIR INSPECTION CLAIM, BUT THEY DO NOT OR AT LEAST WILL NOT ADMIT TO IT. THERE APPEARS TO BE A COMPUTER ISSUE WITH MY VIN, BECAUSE OBVIOUSLY THE REPAIR WAS NOT PERFORMED AND I HAVE DEMONSTRATED WITH THE SECOND SAFETY NOTICE ON THE IGNITION SWITCH (FSA 95S28) THAT I IMMEDIATELY BROUGHT THE VEHICLE INTO THE DEALERSHIP FOR REPAIR AT WHICH TIME THEY ALSO DID NOT MAKE THE SEAT PAN REPAIR ON NOVEMBER 22, 1996. I HAVE COPIES OF THAT NOTICE AND THE BENSON FORD DEALERSHIP (SAME DEALERSHIP LOCATION, DIFFERENT OWNER) INVOICE TO PROVE I AM DILIGENT ABOUT SUCH MATTERS. ALL I AM LOOKING FOR IS TO FORD TO RECOGNIZE THAT THIS DESIGN FLAW WAS RELEVANT TO MY VEHICLE AND MAKE THE REPAIR, ESPECIALLY SINE NOW THE SEAT PAN HAS ABOUT AN 8 INCH CRACK.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10872802June 6, 2016
STRUCTURE:BODY, SEATS
CRACKED SEAT MOUNTS ON FLOOR BOARD. 1990 BRONCO, BUCKET SEATS, HAVE THE SAME PROBLEM AS THE 89-90 BRONCOS WITH CAPTIANS CHAIRS, THE FLOOR BOARD CRACKS AROUND THE BOLTS. THIS MAKES THE FRONT SEATS WOBBLE, BOUNCE, AND MOVE, INCREASING THE STRESS ON THE FLOOR PAN, UNTILL THE FLOOR PAN BREAKS AND THE BOLT NO LON GET HOLDS ANYTHING. EXISTING RECALL FOR MODELS WITH CAPTIANS CHAIR, DO NOT APPLY TO BUCKET SEATS, IT NEEDS TO BE EXPANDED OR A NEW RECALL PUT OUT. THIS IS VERY UNSAFE, AND IS CLEARLY A MANUFACTURING DEFECT, ATTACHED IMAGES SHOW NO RUST OR OTHER CORROSION THAT COULD HAVE CAUSED THIS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10621226August 10, 2014
STRUCTURE:BODY, VEHICLE SPEED CONTROL
I WAS HEADING TO THE STORE WHEN MY GAS PEDAL FOR STUCK. I PRESSED THE BRAKES AND HELD THEM DOWN TO NO AVAIL. I ENDED UP CRASHING THROUGH SOMEONES YARD AND HITTING THEIR PROPERTY. MY BRONCO FINALLY STOPPED ABOUT 15 SECONDS LATER. THE WHOLE INCIDENT WAS ABOUT TWO MINUTES LONG. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10291340November 7, 2009
STRUCTURE, SEATS
FLOOR PAN UNDER DRIVERS SEAT HAS CRACKED WHERE THE SEAT IS ATTACHED IN 1990 BRONCO. CAUSES SEAT TO SHIFT, SINK AND BOUNCE AND NOT FEEL SECURE TO VEHICLE. IDENTICAL PROBLEM IN MY 1989 FORD BRONCO AND WAS REPAIRED BY DEALER AS A RECALL DEFECT. CANNOT FIND ANY RECALL INFORMATION REGARDING THE 1990 BRONCO WITH THIS ISSUE OR FOR 1989 BRONCO DESPITE DEALERS REPAIR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10214482January 11, 2008
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
TL*THE CONTACT OWNS A 1990 FORD BRONCO II. WHILE DRIVING APPROXIMATELY 35 MPH IN DRY WEATHER, THE CONTACT HEARD A LOUD CLANK FROM THE REAR OF THE VEHICLE. HE NOTICED THAT THE BRAKE ROTOR FAILED. WHEN THE BRAKE WAS REMOVED FROM THE REAR PASSENGER SIDE, ALL OF THE COMPONENTS FELL OUT. NHTSA CAMPAIGN ID NUMBER 98E010000 (SERVICE BRAKES, AIR:DISC:ROTOR) WAS REFERENCED. THE VEHICLE WAS TAKEN TO THE DEALER TO BE REPAIRED. THE POWERTRAIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 164,058.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10155156April 4, 2006
ENGINE AND ENGINE COOLING:ENGINE
1990 BRONCO EQUIPMENT FAILED CAUSING AN ENGINE COMPARTMENT FIRE. *TS A NEW POWER STEERING PUMP HAD BEEN INSTALLED PRIOR TO THE FIRE. *NM
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10153747March 26, 2006
TIRES
A PATTERN OF SAME SIZE CHUNKS ON THE SAME CIRCULAR COLUMN OF THE TIRES ARE BREAKING OFF. TIRE PSI AND BALANCING ARE EXCELLENT. NO OFF ROAD OR AGGRESSIVE DRIVING. TIRE ONLY 6 MONTHS OLD. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10068083April 29, 2004
ELECTRICAL SYSTEM:IGNITION:SWITCH
1990 FORD BRONCO IGNITION SWITCH FAILED. (SAFETY RECALL #96V071000 OF NOV95) FORD DEALER SAID NO RECALLS ON THIS VEHICLE AND CHARGED ME $476.00. I CHECKED THE FORD WEBSITE AND THEY ONLY LIST RECALLS FROM JAN96, IS THERE A STAUTE OF LIMITATIONS ON SAFTEY RECALLS AND HOW LONG?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10066482April 19, 2004
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
MY LAST TWO ALTERNATORS BURST INTO FLAMES. THE MECHANIC WHO CHANGED THE LAST ONE SAID THAT HE "HAS REPLACED HUNDREDS" IN THE LAST TEN YEARS *AK
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10062645March 19, 2004
ENGINE AND ENGINE COOLING:COOLING SYSTEM
THERMOSTAT CAUSED ENGINE TO OVERHEAT. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10053151January 14, 2004
ELECTRICAL SYSTEM:IGNITION
1990 FORD BRONCO I BROUGHT THIS VEHICLE IN TO JIM DOYLE FORD ON DELAWARE AVENUE IN KENMORE N.Y, LAST WEEK. THE IGNITION SWITCH BROKE, AND WAS TO BE REPLACED VIA RECALL. THE IGNITION SWITCH MALFUNCTIONED, AND I SMELLED FIRE.SAW SMOKE. TURNED KEY OFF TO NO AVAIL, IMMEDIATELY RAN IN THE HOUSE, GRABBED FIRE EXTINGUISHER, CALLED FIRE DEPT (CAR WAS PARKED BETWEEN 2 HOUSES) AND RAN OUT AND CUT BATTERY CABLE. AFTER DETERMINING PROBLEM (DEFECTIVE IGNITION SWITCH) I HAD THE VEHICLE TOWED TO JIM DOYLE FORD. THEY OFFERED THE FREE REPAIR, AND CALLED ME STATING THAT SOMETHING INSIDE THE IGNITION COLUMN WAS BROKEN, AND THEY WOULD CHARGE ME 60 DOLLARS PLUS TAX JUST TO DIAGNOSE. I DECLINED, WENT TO THE DEALER, AND THE IGNITION SWITCH WAS JUST HANGING OUT FROM THE HARNESS UNDER THE DASH, THE MECHANIC USED A SCREWDRIVER TO PUSH THE SWITCH AND STARTED THE VEHICLE FOR ME. I THEN TOOK THE VEHICLE TO BUFFALO KEY AND LOCK, AND THE TECHNICIAN (RON CHASE) FOUND THAT THE INTERNAL MECHANISM IN THE STEERING COLUMN HAD BROKEN, AND HE STATED THAT IT IS A COMMON PROBLEM SINCE THE DEFECTIVE (RECALLED) IGNITIONS GENERALLY MELT AND WELD THEMSELVES IN THE "START" POSITION, WHEN THE DRIVER ATTEMPTS TO TURN IT OFF IT CAUSES THE RACK AND RODS INSIDE OF THE STEERING COLUMN TO BREAK, RENDERING THE IGNITION KEY ETC INOPERABLE. THIS IS DIRECTLY ATTRIBUTABLE TO THE DEFECTIVE IGNITION SWITCH THAT WAS RECALLED. FORD STATED THAT THEY WOULD NOT PAY FOR THIS SINCE THE ONLY THING COVERED WAS THE IGNITION SWITCH ITSELF. $295.00 LATER, MY IGNITION SWITCH AND INTERNAL WORKS ARE REPLACED, THEY BROKE DUE TO A RECALLED ITEM COVERED BY FORD, AND FORD WILL NOT RE-IMBURSE ME. THIS IS UNFAIR, MY TRUCK IS IN EXCELLENT CONDITION, EXTREMELY WELL MAINTAINED AND THE IGNITION SWITCH WAS DIRECTLY THE CAUSE OF THE OTHER DAMAGE. PLUS, MY VEHICLE WAS IN THE DEALER SHOP FOR 3-4 HOURS AND I GOT IT BACK IN DEPLORABLE CONDITION (OIL/GREASE ALL OVER IT, SEATS AND DASH COVERED WITH GREASE, STEERING WHEEL COVER TORN OFF.*AK
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10000930January 10, 2003
ELECTRICAL SYSTEM:IGNITION, ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS, ELECTRICAL SYSTEM
1990 FORD BRONCO DESTROYED IN FIRE. SPONTANEOUS FIRE ORGINATED IN ENGINE COMPARTMENT OR UNDER DASH INSIDE VEHICLE WHILE PARKED ON STREET. VEHICLE WAS NOT RUNNING AT THE TIME. VEHICLE IS A TOTAL LOSS.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10001784December 31, 2002
VEHICLE SPEED CONTROL
WHILE DRIVING THE VEHICLE AT 10MPH, THE VEHICLE SUFFERED SUDDEN ACCELERATION, AND HAD A FRONT COLLISION WITH A GARAGE DOOR. MR THE DEALER STATED THAT THIS WAS CAUSED BY THE THROTTLE BODY INJECTION BEING DIRTY. SCC
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#566622July 10, 2002
ELECTRICAL SYSTEM:IGNITION:MODULE
CONSUMER STATES THE THICK FILM IGNITION MODULE IS NOT USABLE UNLESS THE TEMPERATURE IS 70 DEGRESS OR COOLER, OTHERWISE THERE IS AN UNCONTROLLABLE STALL THAT OCCURS, CONSUMER HAS CONTACTED THE MANUFACTURER ON SEVERAL OCCASIONS TO TRY AND GET THE PART REPAIRED OR REPLACED.*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#8011624June 12, 2002
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE, ELECTRICAL SYSTEM:IGNITION:MODULE
VEHICLE STALLS INTERMITTENTLY AT ANY SPEED/IN WARM WEATHER/OR ON INCLINES, AND DOWN GRADES. DEALER REPLACED THE FUEL PUMP, WHICH DID NOT REMEDY THE PROBLEM. *AK THE CONSUMER STATES THAT FORD HAS NEVER PROVIDED ANY DATA OR SERVICE TO SOLVE THE PROBLEM-BY THEIR USE OF DISTRIBUTOR MOUNTED THICK FILM IGNITION MODULE. (TFI PROBLEM) THE VEHICLE WILL CRANK BUT WON'T START. *SCC
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#8011519June 11, 2002
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
A VEHICLE FIRE STARTED UNDER THE DASH WHILE DRIVING. DEALER AND MANUFACTURER WERE NOTIFIED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION, AND PLEASE FILL IN VEHICLE MILEAGE.*AK
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#891759June 29, 2001
SUSPENSION:FRONT:CONTROL ARM
CONSUMER WAS TRAVELING ABOUT 65MPH ON HIGHWAY AND HEARD A NOISE COMING FROM UNDERNEATH OF VEHICLE. ENTIRE FRONT OF CAR DROPPED DOWN/. IT WAS LEFT AXLE. DEALERSHIP WAS AWARE OF PROBLEM. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#737369December 6, 2000
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
I HAVE DONE RESEARCH ON THE PUMP. THERE IS A UPGRADE BUT THE PRICE IS NOT RIGHT. I BELIVE THE DEALER SHOULD REPLACE IT FREE OF CHARGE OR AT LEAST LOWER THE COST. IT HAS BEEN KNOWEN TO MELT THE PLUG ON TOP BUT SOMTIMES IT WELL SPARK AND START A FIRE. *AK
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#736917November 27, 2000
TIRES
DURING A CROSS COUNTRY TRIP WE EXPERIENCED SEVERE TIRE BLOW OUT ON OUR LEFT REAR TIRE AT 65 MPH ON GEORGIA HIGHWAY 70 OUTSIDE DALTON GA. THE BLOW OUR CAUSE OUR '90 FORD BRONCO II TO GO OFF THE HIGHWAY AND ROLL 8 TIMES TRAVELLING A TOTAL OF 250 FEET. MY HUSBAND WAS THE PASSENGER AND WAS HOSPITALIZED AFTER WE CAME TO A STOP AFTER COLLIDING WITH A LARGE PINE TREE. MY 3 YEAR OLD DAUGHTER AND I WERE NOT HOSPITALIZED. WE WERE ALL WEARING OUR SEAT BELTS. VISUAL INSPECTION OF THE TIRE SHOWS THE TREAD COMPLETELY SEPERATED FROM THE TIRE WHICH WAS STILL UNDER WARRANTY. CONTACT WITH THE SELLER OF THE TIRE GOT NO ANSWER EXCEPT TO SEND THE TIRE BACK TO COOPER TIRE. WE LIVE IN CHICAGO IL AND THE WRECKED CAR AND TIRE ARE IN DALTON GEORGIA SO THIS IS NOT FEASABLE. HOSPITAL BILLS AND THE LOSS OF OUR ONLY VEHICAL HAS PUT A TREMENDOUS STRAIN ON OUR FINANCES AND A TRIP TO GEORGIA TO RECLAIM THE TIRE AND VEHICLE ARE NOT POSSIBLE. (TIRESIZE: 215/70R15)( DOT NUMBER: TIRE SIZE: 215/70R15 )
Crash:
Yes
Fire:
No
Injuries:
3
Deaths:
0
#557294November 13, 2000
TIRES:TREAD/BELT
FIRESTONE TIRE EXPERIENCED TREAD SEPARATION CAUSING VEHICLE TO ROLLOVER, CONSUMER SUSTAINED INJURIES FROM ACCIDENT. *SLC
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0

← Back to Ford Bronco