Chevrolet Suburban Complaints (2022)

111 consumer complaints on file.

#11725419March 18, 2026
ENGINE
camshaft failure cylinder 7
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11724686March 16, 2026
POWER TRAIN
Check engine light with rough shifting and vehicle wouldn’t go in reverse. For safety reasons we had the vehicle towed to our local Chevy Dealership. Transmission needed a valve body rebuild. This is a known issue with this transmission but our VIN wasn’t under that recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722195March 5, 2026
ENGINE, ELECTRICAL SYSTEM, POWER TRAIN
In several separate unreplicable instances, the vehicle has turned off while driving, once on the highway, once on my street, once turning across heavy traffic, and others. I've almost died a couple times and I've taken it to the dealership several times, they have Not been able to find anything wrong with it and have been unable to replicate the issue. The engine has been replaced, and it was happening before and since. My 2023 is also doing the same thing.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721959March 4, 2026
SUSPENSION
Unmodified 2022 Chevrolet Suburban with 53K mi, driving 25 mph on paved county road. Without warning the upper ball joint on the right front side sheared off. There were no sounds, no bumps or grinding, truck is routinely maintained, cleaned and inspected - this was out of the blue. If we had been going faster it could have been a disaster. The dealer confirmed it is the upper ball joint. Significant mechanical damage has included the upper control arm and drive line (4wd). We are working with GM to get this repaired. It certainly seems like a Serious Safety issue. I have seen many reports of this problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721692March 3, 2026
POWER TRAIN
The contact owns a 2022 Chevrolet Suburban. The contact stated that while his wife was driving at an undisclosed speed, the rear wheels seized. There were several unknown warning lights illuminated. The message "Reduced Acceleration, Drive with Caution" was displayed. The contact's wife pulled into a parking lot, but the transmission failed to shift into reverse(R). The vehicle was towed to the dealer, where it was determined that the transmission control valve needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 26V085000 (Power Train); however, the VIN was not included in the recall. The manufacturer was made aware of the failure, and a case was opened. The failure mileage was approximately 86,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721068February 27, 2026
ENGINE, ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL
Vehicle accelerated while driving. The RPMs gage turned red; however, the vehicle stopped in the middle of the road with other cars coming. After the vehicle came to a full stop it would not move. Finally it started moving slowly and I was able to get off the road. When the tow truck arrived the vehicle would only go forward. No reverse. Error message on dashboard picture attached
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11720149February 24, 2026
ENGINE
Engine locked up going 75mph on highway. The vehicle's 6.2L V8 engine was recalled in 2025. Result of recall inspection was to change oil type to 0w-40. The vehicle is in the process of being inspected by dealer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719442February 20, 2026
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
My vehicle was subject to a GM recall involving inspection of the 6.2L engine. The recall inspection was completed by an authorized GM dealership at 58,581 miles. The vehicle was cleared as passing the recall criteria and returned to me. Within fewer than 10 miles after leaving the dealership following the recall inspection, at approximately 58,590 miles, the vehicle experienced a sudden loss of propulsion while traveling at highway speed (approximately 65 mph) on a divided U.S. highway while ascending an incline. The vehicle shifted into neutral and lost engine power without warning. Steering and braking remained functional, but the vehicle lost forward motive power in the left lane of traffic. Attempts to restart the engine resulted in a loud mechanical thud, and the engine would not restart. The vehicle was towed to the dealership. The engine is now being replaced. Prior to this incident, the vehicle had previously undergone an oil consumption test related to engine concerns before the recall campaign. This failure occurred shortly after the vehicle was inspected and cleared under the recall procedure. I am reporting this due to the sudden loss of propulsion at highway speed following recall inspection and the subsequent need for complete engine replacement.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11718467February 17, 2026
ENGINE, FUEL/PROPULSION SYSTEM
I own a 2022 Chevrolet Suburban RST that has experienced ongoing mechanical and safety issues over several years. I first began reporting drivability concerns to General Motors and the dealership in 2023 and continued contacting them throughout 2024 and 2025. During one dealership visit, a sales advisor rode in the vehicle with me and stated they did not observe any issues, despite my continued reports. The vehicle later suffered a loss of propulsion and required a full engine replacement. The radiator and cooling components were also replaced by a Chevrolet dealership. Due to ongoing concerns for my safety, I contacted General Motors multiple times, requested an executive buyback, and asked about Lemon Law options. GM advised that the engine had been replaced and that I needed to take ownership of the vehicle. After picking up the vehicle last Wednesday, I immediately noticed a persistent sweet coolant/radiator odor inside the cabin and outside the vehicle that continued for nearly a week. I also experienced engine hesitation/stuttering when stopped at traffic lights as the auto start/stop feature reengaged. I attempted to contact GM again regarding these concerns prior to today’s incident. Today, while driving, the vehicle displayed an engine overheating warning instructing me to turn the car off immediately. I safely pulled over and shut the vehicle down and am currently stranded roadside. Given the repeated failures, history of loss of propulsion, multiple repair attempts, denied buyback requests, persistent coolant odor, drivability issues, and now overheating shortly after engine and radiator replacement, I believe this vehicle presents an ongoing safety risk and request formal investigation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11718227February 16, 2026
ENGINE, UNKNOWN OR OTHER
My 2022 Chevrolet Suburban 6.2L, approximately 96,000 miles. Vehicle was taken to dealership for transmission warning message and returned as “repaired” with a software update. The following day, February 12th, while driving at highway speed on the expressway, the vehicle suddenly lost power without warning. A message appeared instructing me to press start, and the vehicle shifted into neutral and stalled. No warning lights were illuminated prior to the stall. This created a serious safety risk due to sudden loss of power at highway speed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11717004February 10, 2026
ENGINE
ON MY THIRD ENGINE 12626 MILES ON IT . HAD OIL CHANGED . OPENED OIL FILTER CANISTER FOUND METAL SHAVINGS BLACK SLUGE NEW ENGINE SERIAL N1251074N44X0872 THIS THE # FOR ENGINE 3
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11714022January 28, 2026
AIR BAGS, SEAT BELTS, UNKNOWN OR OTHER
“Service safety restraint system” light came on. I feel this is a defect and a serious concern. I’ve seen where others are experiencing the same issue. I bought this vehicle specifically because I wanted to a safe vehicle to drive my 4 children around in.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11713362January 26, 2026
FUEL/PROPULSION SYSTEM
On Saturday, 11/29/25 @ 3PM, while driving on I-75 from GA to MIA, our 2022 Suburban VIN: [XXX] sudden & unexpected had a mechanical failure. Without warning, vehicle stalled/ stop while traveling at highway speed, leaving us seconds to maneuver to the side. This failure created an extremely dangerous situation that could have resulted catastrophic or fatal accident for my family. Check engine light came on (code P102A). An officer stopped to assist & arranged car to be tow which we had to pay $135 to nearest Chevrolet dealership. Since the dealership was closed, I was forced to stay an additional night in a nearby hotel and paid $106.46. The vehicle was inspected by Countryside Chevrolet, who diagnosed the issue as a failure of the fuel pump control module however I was informed that this VIN was not covered under warranty or any special coverage, despite the fact that we experienced the exact same failure on our 2021 Chevrolet Tahoe, which was covered under warranty for this same defect. I was forced to pay $708.72 for the repair. This inconsistency is unacceptable—especially considering GMs extensive history of complaints, recalls, & class action litigation involving defective fuel pump & fuel system components, which present a well-documented safety risk. I filed a complaint with GM Customer Care (Case XXX). I submitted all required receipts for repairs, towing & hotel, however GM denied my claim without providing any explanation, only stating VIN was “not covered.” Also, GM refused to provide a written justification & my request for a manager callback was ignored. No consideration was given to the safety implications of this failure. This response is unacceptable & demonstrates a failure to take responsibility for a known safety defect. Demand: Given the seriousness of this incident, the documented defect, & GM’s prior knowledge of same failures, I demand full refund of $950.18 for expenses. This situation could have ended tragically. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709715January 8, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Chevrolet Suburban. The contact stated that while driving approximately 60 MPH, there was an abnormal scraping sound coming from under the vehicle. After stopping to inspect the vehicle, the contact discovered that the fuel tank had partially detached from the subframe and fuel was leaking from the fuel tank. The vehicle was towed to the local dealer, who replaced the fuel tank. No further information was available. The cause of the failure was unknown. The manufacturer was notified of the failure. The failure mileage was 40,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707940December 30, 2025
AIR BAGS, SEAT BELTS
Car says "service safety restraint system" and airbag light comes on intermittently. Dealer won't cover under safety restraint warranty. They site TSB about a wire that GM made too short but are not sure it will fix it. This car has 42,000. We are worried the safety restraint system won't work and we carry 4 children in our vehicle. This should be covered and a safety recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11704862December 13, 2025
ENGINE
I want to complain that my 6.2L V8 engine was “inspected” and they deemed it OK, then proceeded to make a requirement of thicker oil for its life. I was also given a long term warranty on the engine, however it is non-transferable, therefore the re-sale value of the vehicle is damaged beyond normal conditions. The engine is suspect, why else would it need thicker oil? The engine is all over the news with the recall, therefore why would anyone want to purchase my used vehicle based on that press and no further warranty? GM needs to make this right! That 10-year or 150,000 miles means nothing to re-sale value if is not transferable.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11701757November 26, 2025
ELECTRICAL SYSTEM
Onstar, my vehicle's core safety communication system, stopped working without notice, without an alert on the dash. Nothing. I press the onstar button and nothing happens. What if I was in trouble? Didn't have my phone? The issue was not communicated to me through the infotainment system. This seems like a serious issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11701730November 26, 2025
ENGINE
Car initially started stuttering on the high, check engine and traction control lights came on. I immediately went to the nearest Chevy dealership a mile away. Initially I had 20 error codes. The problem was the Left side lifters 4 of 8 stop working. Dealership recommended Replace Left lifters, 2 push rods, valve cove, head gasket. $5000. After starting the work. The technician could not repair the lifters because my camshaft is pitted and the RODS were rotating. Their recommendation is to replaced the whole engine to fully fix the problem. $12000 with 3 yr warranty. My SUV just 100kmiles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697700November 5, 2025
ENGINE
Engine failed while driving. Vehicle began making clicking noise less than one minute for engine shut off while driving. Check engine light came on after engine shut off. Car was stopped at a busy intersection and couldn’t move. Car is currently at Chevrolet dealership and is in need of a total engine replacement
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696772October 31, 2025
ENGINE
The contact owned a 2022 Chevrolet Suburban. The contact stated that while the vehicle was parked with the engine running, the front of the vehicle began to shake violently, with a knocking sound coming from the engine compartment. The check engine, traction control, and collision warning lights were illuminated. The contact called an independent mechanic; however, the vehicle was not diagnosed or repaired. The contact later visited the dealer and was informed that the vehicle needed to be brought in for diagnostic testing. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 97,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Suburban