Chevrolet Silverado Complaints (2025)

165 consumer complaints on file.

#11774264October 28, 2026
STEERING
The contact owns a 2025 Chevrolet Silverado 2500. The vehicle was previously taken to the dealer after the messages "Trailer Brake Disabled, Service Required" and "Hill Activated" were displayed, and the vehicle was pulling to the left while driving 45 MPH. The dealer performed a tire rotation and an oil change; however, the failure persisted with the vehicle pulling to the left side. The vehicle was returned to the dealer, who determined that no alignment was needed. The failure recurred, and the vehicle was taken back to the dealer a third time. The dealer informed the contact that the manufacturer was aware of the failure in 2021 - present Silverado; however, no repair was available at that time. The manufacturer was notified of the failure by phone and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 21,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11772980October 22, 2026
ENGINE
CHECK ENGINE LIGHT CAME TRUCK STARTED RUNNING ROUGH AND ON LOW POWER TOOK TO DEALER THE CODE WAS MISFIRE CYLINDER 5 THEY FOUND CYLINDER BADLEY SCORRED SO THE REPLACED THE MOTOR AT 27000 MILES A 6.2 IN A 2025 SILVARADO 1500 TRAIL BOSS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11773005October 22, 2026
STEERING
The contact owns a 2025 Chevrolet Silverado 2500. The contact stated that on several occasions, the electronic power steering failed to function as intended intermittently, and the steering wheel became very difficult to turn. The vehicle was taken to a dealer to be diagnosed, and the contact was advised that the battery needed to be replaced and a software update performed. The battery was replaced, and the software update was performed; however, the failure persisted. The manufacturer was notified of the failure. The failure mileage was 30,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11772813October 21, 2026
ENGINE
My Silverado is a 2025 with the 6.2 engine and recently the dealer found metal shavings in the oil which is premature engine failure. My truck is not part of the recall because it is a newer year but these engines keep blowing up theres alot of us please help with another recall for the newer years.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11770044October 9, 2026
ENGINE
The contact owns a 2025 Chevrolet Silverado 1500. The contact stated the engine was knocking at initial start-up. The contact informed the dealer and confirmed that the vehicle was not under recall. The contact decided not to take the vehicle to the dealer. The contact manufacturer was informed of the failure and confirmed that the vehicle was not under recall. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 9,952.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11770061October 9, 2026
ENGINE
On July 4, 2026 while driving with my family up a two lane state road headed to the lake cruising 55mph the engine blew and locked up with no warning, no check engine light or anything causing me to almost wreck and leaving me and my family stranded in a dangerous situation for a moment. I drive out of town just about everyday for work so my truck is set on cruise control most days through the week making multiple long distance trips a month so the mileage racked up fast for me causing me to go right over my warranty when this happened so I can’t get any help with it. Even knowing the issue right now with the 6.2 they will do nothing.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11769705October 7, 2026
ENGINE, ELECTRICAL SYSTEM
The contact owns a 2025 Chevrolet Silverado 1500. The contact stated that while driving 45 MPH, the vehicle lost automotive power. The vehicle was restarted within seconds and the message "Push to Start" was displayed. The vehicle was taken to the dealer to be diagnosed, and the contact was informed that the failure was not duplicated. The manufacturer was notified of the failure. The failure mileage was 30,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11767934September 30, 2026
VEHICLE SPEED CONTROL, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, FORWARD COLLISION AVOIDANCE: WARNINGS
On XXX at ~3:00 p.m., I was driving my 2025 Chevrolet Silverado 1500 High Country (VIN [XXX]) in stop-and-go highway traffic with Super Cruise engaged. The vehicle ahead was a truck towing a low, empty flatbed trailer. My truck came to a complete stop behind the trailer. While stopped, with no accelerator input from me, the vehicle accelerated forward on its own and struck the rear of the flatbed before I could intervene. My foot was not on the accelerator. It appears the forward sensors may not have detected the low, unloaded trailer as an obstacle, so when the system resumed from the stop it accelerated into it. No injuries. The other vehicle had a steel rear plate and was undamaged; damage to my truck is estimated at $3,549.68. A vehicle that accelerates on its own from a complete stop into a stationary object ahead is a serious hazard. This was low-speed property damage only, but the same failure at higher speed, or with a pedestrian, cyclist, or child ahead, could cause death. I have an infant, and the thought of this happening with my child aboard is alarming. I am concerned that low-profile or unloaded trailers may not be reliably detected by the forward sensing system — a systemic limitation, not a one-time glitch. I ask NHTSA to review whether other GM/Super Cruise vehicles have experienced unintended acceleration from a stop or failure to detect low trailers. I notified GM (Chevrolet claim #XXX) and requested the vehicle's Event Data Recorder and Super Cruise/OnStar telematics be preserved. I am filing this so there is an independent safety record. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11767268September 27, 2026
ELECTRICAL SYSTEM, POWER TRAIN, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
The specific cause has not been identified. On XXX6, my 2025 Chevrolet Silverado 1500 Custom LT Trail Boss unexpectedly rolled away while parked and unoccupied, striking another parked vehicle. The truck remains at Modern Chevrolet and is available for inspection. GM/ESIS opened a safety and product liability investigation and is arranging inspection/data retrieval. I parked at Walmart in [XXX], shut the truck off, exited, locked it, and walked away. Shortly afterward, I heard a sound resembling the key-fob-left-inside warning. My key fob was in my pocket, so I returned and saw the truck moving with no driver. Another person and I tried to stop it. I entered through the driver’s door and pressed Start/Stop several times, but it would not start while moving. It continued moving and struck another parked vehicle. Vehicle dropped off on XXX and Modern Chevrolet could not reproduce the incident or identify the cause. The service advisor stated it “came out of gear but don’t know why” and escalated it to GM. GM/ESIS plans to retrieve SDM/airbag data, and I requested any Tech II/MDI scan data. No warning lights, messages, or chimes were observed during the incident. I did not see/hear “SHIFT TO PARK,” and I was able to lock the truck with the key fob outside. In a later controlled test, I left the truck in Drive and shut it off. It displayed “SHIFT TO PARK” and sounded a warning chime. Opening the driver’s door also produced a key-fob-left-inside-type alert, which did not occur on XXX. The truck did not automatically shift to Park or engage the electronic parking brake and slight movement was felt during the test. No further testing occurred by me after XXX. I have also experienced infotainment freezing after software updates and random electronic parking brake application when shutting off, and remains engaged after restart. The truck received an oil change/tire rotation at Modern Chevrolet on XXX. Cause still remains UNKNOWN. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11767294September 27, 2026
SERVICE BRAKES
Brakes failed going into busy intersection with coming traffic. It can be available for inspection. Applied the brakes to stop at stop sign. Truck didn’t slow down - brakes went hard and my truck kept going. Escaped collision of oncoming vehicles going 55mph. Turned the truck a sharp left landing in first lane of traffic and quickly put into reverse. Going into the dealership Monday morning to have it checked. Happed too fast to notice any warning lamps etc..
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11766852September 25, 2026
POWER TRAIN, ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: WARNINGS
- Multiple system failure. Truck presented with oil or ATF leaking from the transmission bell housing and transmission inspection port cover. First detected by me at 30k mile oil change. Prior to this, my wife and I both complained that the truck was very slow to get into gear from a stop, especially while towing. Engine would rev and then finally dump power, spinning the rear tires. Additionally encountered hunting for gears on the highway. - Second failure. 24 AUG. Truck illuminated with Check engine light, Traction control light, forward collision light, service ECS, service trailer brake control, and ABS light. - Inconsistent power application and loss of safety features makes the truck unpredictable and unsafe to drive. - Truck is at the second dealer (first diagnosed issues as an oil drain plug). Has been at dealers for 32 days now. Problem is confirmed. - The suspected transmission issues have been noticed intermittently and getting progressively worse for about 6 months. Warning lights all appeared on the morning of 24 AUG. Truck was taken directly to the shop that morning.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11766797September 24, 2026
POWER TRAIN
I was traveling at 65 mph when my truck engine shut off, put itself in neutral, asked me to push the start button. And then the screen went black. Would not go into neutral for a tow. Taken to dealer where I purchased it from. Was told that the motor is seized.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11765726September 20, 2026
ENGINE
The engine started making a ticking noise and getting a little louder while driving to dealer where I had purchased the veichle and had it serviced as called for . They had me leave to check it out , they called me 2 hrs later and said it would need a new engine and it had a spun crankshaft bearing and would be 3 weeks to get the new engine . They said my warranty would cover the billing . I’m presently waiting to hear from them . They told me that the new engine would have a warranty but minus the 31615 miles that my odometer reads now ?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11764033September 14, 2026
ENGINE
While driving interstate speed pulling a trailer on 08/13/25 had a complete loss of power and truck died. Had to merge on-to the shoulder of the interstate with no power. Parked along side of interstate until towing arrived approx. 2 hours after loss of power event. Truck was towed to Husker Chevrolet where the truck was diagnosed with engine failure. There was no warning of this catastrophic event. On 09/11/26 dealership called stating that they replaced the engine, however the new engine expired while pulling it out of the shop. This would be this trucks 2nd engine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11763147September 9, 2026
ENGINE
The contact owns a 2025 Chevrolet Silverado 1500. The contact stated that while driving 60 MPH, the vehicle was losing power. The contact stated that several unknown warning lights and the engine warning light were flashing, and the message “Reduced Acceleration - Drive with Care” was displayed. The vehicle was operated at reduced power and driven to the dealer. The dealer diagnosed the vehicle as having engine failure; however, the part needed for the repair was not available. The failure mileage was approximately 46,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11761909September 3, 2026
ENGINE, FUEL/PROPULSION SYSTEM
cold starts sometime there is an audible tick, there is also occasional low oil pressure and the gauge drops and returns to the normal range
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11761507September 2, 2026
ELECTRICAL SYSTEM
The contact owns a 2025 Chevrolet Silverado 1500. The contact stated that while driving at various speeds, there was an abnormal odor inside the vehicle. The contact stated that water was coming from underneath the driver’s side dashboard. Additionally, the steering wheel was jerking while the lane assist feature was activated; however, the vehicle was not veering to the left or right side of the lane. No warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed, and several failure codes were retrieved, and a water test was performed; however, the failure could not be duplicated. The vehicle was repaired; however, while the contact's husband was driving at an undisclosed speed, there was an abnormal sound coming from the vehicle. The driver pulled over to the shoulder of the road, and after selecting the 2WD feature, the 4WD feature was disengaging, even though the 4WD warning light was not illuminated. The vehicle was taken to another local dealer, Chevrolet of Troy (1375 S Market St, Troy, OH 45373) for a second opinion. The contact was informed that DTC: U1611 was retrieved, and several unknown repairs were needed. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 23,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11761733September 2, 2026
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: WARNINGS
I was driving on the freeway and got a service trailer brake system and a brake system failure 62mph top speed. I exited the freeway and came to a stop sign and hit my brakes to stop but was unable to stop and blew through the stop sign. Luckily there were no cars at the intersection and I was by myself.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11761031August 31, 2026
ENGINE
Engine failure shut off on idle. Engine bay shakes. It unsafe to drive no indication of engine failure
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11761152August 31, 2026
ENGINE
The engine has been using atleast 1 quart of oil every 2000 miles. This is put my maintenance cost way above the estimated maintenance cost projected by the manufacturer This oil usage is also causing premature engine wear as it's a quart low every 2000 miles. Dealer responses was this is normal for this engine. I went back and forth with the about estimated maintenance cost and ofcourse there responses was it estimated, well that's a very inaccurate estimate or willful lie. Idk just not happy about it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Silverado