Toyota RAV4 Complaints (2021)

510 consumer complaints on file.

#11540459August 24, 2023
ELECTRICAL SYSTEM
Went to unplug my charger from 2021 RAV4 prime in May 2023 which was who installed this 220 outlet. He confirms the 220 outlet which was installed previous yr is safe, correcoutside in NH. I found handle of charger was extremely hot to touch and it would not release from car. Locked and unlocked vehicle again with key fob but still it would not release. Also attempted to lock /unlock using door switch with no success. Due to the extreme heat of charger at both ends I needed to get something to protect hand from heat. I unplugged charger from the 220 outlet installed by electrician for this car but the charger handle would not release from car until it cooled which took between 5- 10 minutes. Brought back electrician t for job and working but reported the charger was so hot the heat affected the plug.I am lucky the house and car did not ignite. I used my level 1 charger for next 2 months as I was still afraid of fire from the April hot level 2 charger on both ends incident. Eventually with electrician’s knowledge & comfort with this 220 outlet also knowing we have 2 electric boxes for load of house I purchased a new level 2 charging system in June. All has been working as expected. July I happened to see in my Toyota app a notice there is a safety recall for a potential fire risk. I was not sent any notice and lucky I saw this in the Toyota app. I called Toyota to report my incident there was no concern to make a report of my incident they only stated this fire risk is when charging below 41 degrees and they are hoping for Q4th 2023 fix. There was no concern for what if temps had dropped, financial burden it placed having to purchase new charging station, bringing out electrician again or that I live in North where temps are below 41 months at a time.I had this issue in May when temps were below 41 and haven’t charged below this temp since it’s summer. I do not dare charge overnight when electric supply is more economical as temps can drop.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11538176August 13, 2023
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING, LANE DEPARTURE: ASSIST
While waiting at a red light with my car stationary, the lane I occupied divided into two. I gently adjusted my steering wheel to the left, and in an unexpected turn of events, a dashboard indicator illuminated before my steering wheel rapidly veered to the right. This abrupt motion resulted in a collision with another vehicle, causing damage to both cars. Despite my attempts to avert the situation, my right thumb became trapped in the wheel, leading to a fracture. Shortly after the accident, the dashboard and multimedia system displayed multiple malfunctions: a VSC, TRAC, or Hill Start Assist Control system malfunction, a rear cross traffic alert malfunction, LTA malfunction, and a PKSB malfunction, all prompting a visit to the dealer. Upon contacting Toyota, they offered no assistance, asserting that the incident occurred at an approximate speed of 22 miles per hour due to data from the EDR. However, this contradicted the facts as my vehicle was stationary at a red light. The explanations provided by Toyota's representative, Alexis Turner, appeared inconsistent with the circumstances.
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#11537525August 9, 2023
UNKNOWN OR OTHER
My vehicle leaks water after it’s gone through the car wash or when there’s heavy rains.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11535677August 1, 2023
AIR BAGS, ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
I was in a bad car accident last Wednesday July 26, 2023 It was very scary and Bizarre; My car accelerated (started racing)and when I stepped on brake, it accelerated more. I saw a message flash up on my GPS screen but obviously couldn't read it as I was trying to stop my car. The Auto brakes didn’t work, I crashed into a tree; air bags didn’t deploy and I got this message ("CHECK ENGINE! A MALFUNCTION IN THE ELECTRONIC CONTROL OF THE ENGINE,THROTTLE, OR AUTOMATIC TRANSMISSION HAS BEEN DETECTED.CONTACT YOUR TOYOTA DEALER IN ORDER TO HAVE YOUR VEHICLE INSPECTED." (See attached). Luckily I was in an almost empty parking lot when this happened, if not i could have been killed or killed someone else. All the safety back ups failed. I took a picture of the message-will attach it to this report. I was taken to Huntington Hospital ER and had a cat scan to make Sure my sternum and ribs aren’t broken-showed Soft tissue abdominal swelling and bruised sternum and ribs from my seat belt. Pain to chest, ribs an right side. I believe my car is totaled Just had it inspected and serviced a few weeks ago at the Toyota dealership where I purchased it and it only has 10,000 miles on it! I am Fighting with insurance company to make sure the car's computer is interrogated before they do anything else.-The insurance company was pressuring me to release the car to Copart without this being done and I refused. My car was towed to and remains at Combined Auto Collision 4035 Jericho Tpk, East Northport, NY. This incident could have resulted in a catastrophic outcome and loss of life. Aa investigation needs to be taken to insure this does not happen to anyone else. Thank you for your kind assistance The consumer stated that the dealer identified the problem being that the water drainage pillars short out the electrical system.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11535304July 30, 2023
UNKNOWN OR OTHER
Roof leak causing water damage to headliner. Dealership won’t fix because they ran water on it and it didn’t leak but didn’t apply pressure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11534866July 27, 2023
VISIBILITY, ENGINE, ELECTRICAL SYSTEM
The contact rented a 2021 Toyota Rav4. The contact stated that while driving at an undisclosed speed, he heard a vibrating sound coming from the front driver’s side windshield. The vehicle was taken to an independent mechanic; however, the contact was informed that the vehicle was a rental and could not be diagnosed. The contact was informed to return the vehicle to Avis Car Rental. The contact stated that on a separate occasion, while driving at an undisclosed speed, the vehicle lost motive power and stalled. The contact stated that he was able to restart the vehicle after several minutes. The contact stated that due to the loss of motive power, the front driver’s and passenger’s side headlights failed to operate as needed. The vehicle was taken to the dealer however, the contact was informed that the vehicle could not be diagnosed since the vehicle was a rental. The vehicle was not diagnosed or repaired. The manufacture was not notified of the failure. The failure mileage was approximately 53,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11534494July 26, 2023
SERVICE BRAKES
When pulling into a parking spot at less than 5 mph the car accelerated violently and couldn't be stopped while braking. A marble or granite barrier stopped the my car preventing me from going into a shallow ravine and potential on coming traffic. There have been multiple safety recalls on the braking system on the car and each have been executed in a timely fashion. I cannot determine if warning lights went off at the time due to how quickly the issue happened
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11534181July 24, 2023
AIR BAGS
The contact owned a 2021 Toyota Rav 4. The contact stated that while sitting in traffic, the contact's vehicle was rear-ended at 45 MPH, and due to the impact, the contact rear-ended the vehicle in front. The "malfunction" warning message was displayed after the crash. The driver's side air bag did not deploy. The vehicle was declared a total loss by the insurance company. The contact stated that she suffered a concussion and memory loss due to the accident that required medical attention. The manufacturer was made aware of the failure but provided no assistance and did not confirm the status of the black box inspection. The failure mileage was approximately 10,100.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11531866July 12, 2023
UNKNOWN OR OTHER, VISIBILITY/WIPER, ELECTRICAL SYSTEM
We have water becoming stuck in our back passenger door due to a weather strip design flaw in Toyota Rav4 Hybrids. This will begin to happen to all weather strips and eventually destroy the interior and electrical if not repaired. This is a common design flaw in newer Toyota Rav4 Hybrids and we are lucky it's just our one door so far. I've been informed (by our Toyota Tech) that eventually all of the doors and the roof will leak due to this Toyota design flaw. When we took the car to get fixed at the dealership, they let us know it was an expensive repair, advised it was a design flaw, other customers are affected, and allowed us time to research before paying for the repair. We may attempt it ourselves since Toyota corporate has refused a reimbursement for the repair. This is a Toyota design flaw and requires a recall. They are charging hundreds to fix this. This will literally destroy the cars electrical.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11531296July 10, 2023
AIR BAGS
Airbags deployed without collision. Car went slightly off road, after attempted correction to get back onto the road the curtain airbags deployed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11530369July 5, 2023
WHEELS
there is no access to tpms data unless purchasing subscription from toyota to read the onboard computer where the data is readily available. this leaves a major safety feature is behind a paywall and should not be counted as installed as it does not work independantly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11529084June 27, 2023
FORWARD COLLISION AVOIDANCE: WARNINGS, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Driving with cruise control on, on a 2 lane road with a left turn lane. Approx 40MPH. Vehicle ahead of me by 4-5 car lengths got into left lane. When I has about 10 feet from him my brakes automatically slammed on, he was in his lane, I was in my lane. This has happened 4-5 times since I've had the veh. I now stay aware that this might happen and stay ready to cancel the cruise. This could be very dangerous if someone was right behind me. Dealer test drove and ran scan no problem found. Which as expected, if it doesn't happen when they test drive there's not a lot they can do. I understand this.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11525458June 5, 2023
STEERING, UNKNOWN OR OTHER
On April 29, 2023 I notice that there was a bad chemical smell in my car. I continued to try to find the issue and then I went to the back seat and discovered the floor of my 2021 RAV4 was completely flooded with water. I attempted to call Toyota but the service department was closed. I went to the local car wash to have them suck up the water in the meantime. I scheduled an appointment with Toyota on 5/1/2023 @3:45 to explain the issue that was going on. When I got there they serviced my vehicle and informed me that they weren’t able to find the source of a leak and they would need to keep my car. I asked would I be provided with a rental and the service advisor [XXX] told me no as this would need to be paid out of pocket. I didn’t agree and told them I’d have to bring it back. The following week I still noticed that there was water somewhere in my vehicle so I called to schedule another appointment on 5/10/2023 @3:45. This time I was connected with [XXX] who was very accommodating and set me up with a rental for one day. On 5/11/2023 I was contacted by [XXX] and he informed that they would need to keep my car for 3 weeks. He informed me that there was a lot of damage to the car and it would be fully covered. On 5/27/23 I was called and [XXX] told me I could pick up my vehicle. When I left on 5/27/23 I drove the car and when I put it in reverse my steering wheeled locked up and a message came across the screw saying “low voltage power steering.” I called the service department but they were closed until 5/30/23 for the holiday. I also contacted my service provider [XXX] and left a voicemail. He called me back 5/28/23 and informed me that he was out of town and to drop the car back of 5/30/23. I dropped the car off and they put me in another vehicle. 5/31/23 [XXX] called me back to inform me that the car was ready. I pick it up and it flooded in the inside again. I discovered there was a recall that it was never informed about and now they want me to pay. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMAT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11525040June 2, 2023
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
While traveling on highway with adaptive cruise control engaged and maximum following distance selected, adaptive cruise control applies excessive braking force than necessary when vehicle in front exits highway. Safety concern because following vehicles must abruptly apply brakes. Internet search reveals numerous, similar complaints. We were almost rear-ended on the highway. This feature is great, but needs attention for safety reasons.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11524971June 2, 2023
ENGINE
The hybrid system stopped working thus AWD, automatic emergency brake and other components stopped working as well. Message Hybrid System malfuction output power reduce visit your dealer AWD System malfuction 2wd mode engage visit dealer Engine light turn on
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11524413May 30, 2023
TIRES
The contact’s daughter owns a 2021 Toyota Rav4 equipped with Firestone Tires, Tire Line: Destination LE2, Tire Size: 225/65/R17, DOT Number: 8X2Y6 DE8. The contact stated that upon inspecting his daughter’s vehicle, he noticed that the tread all four tires was worn. The contact stated that he used a tire tread gauge identifier that confirmed that the front passenger’s and driver’s side tires had 6/32 tread, and the rear driver’s and passenger’s side tires had 7/32 tread remaining. The dealer was notified of the failure and confirmed that the normal tire replacement was at 40,000 miles, while the tire warranty was 60,000 miles. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and the contact was advised to contact Firestone. The contact notified the manufacturer however, no assistance was provided. The failure mileage was approximately 18,800.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11523383May 23, 2023
AIR BAGS
On May 20th, 2023 @ approximately 9:50 P.M. we struck a deer head on. Impact was severe enough that the passenger airbag should have deployed, but failed to deploy. I looked at the wiring guide for this vehicle after the incident, and I believe that in photo #4, it shows the path of the airbag wire and the airbag wire was cut at the time of impact.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11523298May 22, 2023
ELECTRICAL SYSTEM, ENGINE, UNKNOWN OR OTHER
We were on a drive back from Nashville like normal. My mom had picked me up from work at around 07:15. The car started making strange sounds as we were driving down the highway. It started yelling at us to pull over to a safe spot and slowing down. All of the lights had come on flashing at this time. It didn’t even make it to the shoulder; We made a stop on the triangle area for when cars come in from the exit. As soon as we stopped, smoke started engulfing us and 2 guys who saw this happening parked on the shoulder and came running out of their van with fire extinguishers and started telling us to get out. When we went around the car to check what was going on, we noticed the fire that had started from the bottom of it. They fired the extinguishers a couple of times to the bottom of it where we could see the fire but it didn’t help much so we had to retreat to a safer spot. We called 911 to ask them to send assistance. Not long after, the front half of the car was engulfed in flames. 10-20 minutes later, the fire department came to extinguish the flames. Once they got the fire under control, they towed the car to the shoulder of the road where we proceeded to salvage anything that was salvagable from the car. Where I got my hands cut up from broken shards that were littered all over the interior. We waited for awhile for another form of transportation to be able to make it home and it took a little bit due to the traffic that this incident had caused. We got the car towed back to Toyota for evaluation of the incident. It was supposed to be done within 2 months, but we still hadn’t heard anything about it going into 3. We called them to inquire about the car and the situation, and they said that they had closed the case and had to reopen it for further investigations. They had closed the case and not told us anything about it. We received an email on the 23rd of January that stated the vehicle was too far damaged for them to be able to evaluate anything.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11519151April 26, 2023
POWER TRAIN, FUEL/PROPULSION SYSTEM
Car won't accelerate for about 1 to 2 seconds from stopped. Didn't have the issue before the 23TA01 recall performed at the Dealership.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11518522April 23, 2023
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
I have a 2021 Rav4 gas LE. I bought it new in May 2021 and have 38,000 miles on it. I was casually driving the car going 30-40mph when the car dashboard lit up. The first notification I got was on the screen display saying a malfunction in the charging system was detected and to stop in a safe location. Next, all my dashboard lights turned on (tire pressure, traction control, check engine, ABS, brake, battery light, etc.) and got the following messages on the dashboard: - parking brake malfunction - pre collision malfunction - brake power low - stop in a safe place - secondary collision brake system malfunction - antilock brake system malfunction voltage ability - Voltage abnormality - steering power low And then finally, the “engine stopped” message when the emergency brakes engaged on their own while I was slowing down at a red light. Before this, I never got any warning lights or messages. I tried to get the car towed since jump starting the car didn’t work. The emergency brakes would not disengage in neutral. I had to call a tow truck. I took the car to the Toyota dealership. They said it was the battery and replaced it, but when I went to pick it up, the dashboard lights still wouldn’t go away even after resetting. The power locks still don’t work when the car is off and my key fob to unlock/lock also still doesn’t work. The display screen still isn’t turning on and the usb plugs in the car also aren’t drawing any power. The headlights and interior lights also don’t work. They said it’s an electrical problem but quoted me $520 to diagnose the problem ONLY since the car is now out of the 3 years/36k miles basic warranty. I have had this car less than two years and has 38k miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota RAV4