Subaru Forester Complaints (2004)

219 consumer complaints on file.

#10561131January 23, 2014
FUEL SYSTEM, GASOLINE, ENGINE
TL* THE CONTACT OWNS A 2004 SUBARU FORESTER. THE CONTACT STATED WHEN THE TEMPERATURE DROPPED, FUEL FUMES WERE EMITTED IN AND AROUND THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 117,000. THE INTAKE MANIFOLD WAS REPLACED. UPDATED 03/12/14 UPDATED 3/12/14*CN THE FUEL LINES, CLAMPS AND UPPER INTAKE GASKETS WERE REPLACED. THE FUEL LINES WERE CRACKED. UPDATED 04/01/14
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10561154January 23, 2014
FUEL SYSTEM, GASOLINE
THIS 2004 SUBARU FORESTER 2.5 XT AWD 4-SPD AUTOMATIC TRANSMISSION WITH MULTI-PURPOSE FUEL INJECTION TURBO (FEEDBACK FUEL SYSTEM) HAS BEEN PRODUCING A STRONG FUEL SMELL THAT FILLS THE ENTIRE VEHICLE CABIN. I'VE BEEN TOLD BY THE DEALER THAT THIS IS TO BE EXPECTED FROM THIS TYPE OF ENGINE AND THAT THERE IS NOTHING MUCH THAT THEY CAN DO ABOUT IT AND TO LEARN TO LIVE WITH IT. THE DEALER ALSO INDICATES THAT THIS PROBLEM IS BASICALLY CAUSED BY EXTREME COLD WEATHER AND/OR TEMPERATURE CHANGE. I HAVE RESEARCHED THIS ISSUE AND FOUND THAT THERE WAS A SIMILAR PROBLEM WITH THE SUBARU IMPREZA AND THAT SUBARU ISSUED A RECALL. NO VEHICLE, SUBARU OR OTHERWISE, SHOULD PRODUCE A PROBLEM LIKE THIS ONE THAT IS "UNFIXABLE." THE CONSUMER SHOULD BE PROTECTED FROM THIS POTENTIALLY HAZARDOUS SITUATION. THIS CONSUMER IS PUTTING SUBARU ON NOTICE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10561032January 22, 2014
FUEL/PROPULSION SYSTEM, ENGINE
STRONG SMELL OF GASOLINE UPON STARTING THE CAR IN VERY COLD WEATHER. INSIDE AND OUTSIDE THE VEHICLE. ONLY HAPPENS WHEN IT IS COLD OUTSIDE. REALLY GIVES ME A HEADACHE AND MAKES ME NERVOUS ABOUT IGNITING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10561084January 22, 2014
FUEL SYSTEM, GASOLINE
SMELL OF RAW GAS INSIDE OF VEHICLE WHILE DRIVING. IT DOESN'T HAPPEN ALL THE TIME ONLY ON EXTREMELY COLD DAYS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10560830January 21, 2014
FUEL SYSTEM, GASOLINE
IMMEDIATELY UPON STARTING THE ENGINE A STRONG SMELL OF GASOLINE FILLED THE ENTIRE PASSENGER CABIN. COLD WEATHER TEMPERATURE WAS WELL BELOW FREEZING. HAS HAPPENED PREVIOUSLY, AND IS CORRECTED BY TIGHTENING THE FUEL LINE CONNECTIONS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10560643January 20, 2014
FUEL SYSTEM, GASOLINE
I STARTED THE CAR AFTER IT HAD SAT IN 10-15 DEGREE WEATHER AND THERE WAS A STRONG SMELL OF UNUSED GASOLINE IN THE CABIN. IT HAS STARTED HAPPENING ON START-UP FREQUENTLY SINCE THEN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10559512January 12, 2014
FUEL SYSTEM, GASOLINE
FUEL SMELL AT START UP IN TEMPS BELOW 35 DEGREES, DECREASES AFTER CAR WARMS UP. IF VERY COLD DOES NOT GO AWAY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10559347January 10, 2014
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
FUEL LEAK IN 2004 SUBARU FORESTER XT SIMILAR TO OTHER SAFETY COMPLAINTS ENTERED, NHTSA CAMPAIGN 09V468000 AND SUBARU RECALL WVK-21 FOR 2003 WRX. EVENING OF 7JAN2014 DRIVING HOME (IN UNCOMMONLY COOL WEATHER) THE VEHICLE BEGAN TO SMELL STRONGLY OF GASOLINE IN THE PASSENGER COMPARTMENT. UPON ARRIVING HOME, INSPECTED UNDER THE HOOD TO OBSERVE DRIPPING FUEL (APPROXIMATELY 1 DRIP PER SECOND) ABOVE THE ENGINE AT A METAL TO RUBBER FUEL LINE CONNECTION. LEAKED FUEL WAS POOLED ON THE TOP OF THE ENGINE. A PUDDLE OF WARM FUEL VAPORIZING NEAR ELECTRICAL EQUIPMENT (BATTERY, ALTERNATOR, RADIATOR FANS) IS A SERIOUS FIRE HAZARD. THE CAR HAS BEEN PARKED SINCE THE EVENT. I INVESTIGATED ON THE INTERNET AND HAVE FOUND NUMEROUS OTHER ACCOUNTS OF COLD WEATHER FUEL LEAKS IN MANY SUBARU MODELS NEARLY IDENTICAL TO MINE. MY LOCAL SUBARU DEALER APPEARED TO BE AWARE OF THE ISSUE WHEN I CALLED, BUT STATED THERE IS NO ACTIVE RECALL ON MY MODEL. THEY OFFERED THAT THEIR FIX IS TO TIGHTEN THE HOSE CLAMPS BUT I WOULD NEED TO COVER THE COST OF THE WORK. IF SUBARU HAS ACCEPTED RESPONSIBILITY FOR THIS ISSUE IN THE 2002-2003 IMPREZA AND WRX, WHY WOULD THEY NOT ADDRESS THE PROBLEM IN OTHER MODELS THAT SHOW THE SAME SYMPTOMS? *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10559009January 8, 2014
ENGINE, FUEL SYSTEM, GASOLINE
DURING THE RECENT COLD SNAP HERE IN TENNESSEE I GOT A REPORT FROM A FRIEND THAT HIS 2004 FORESTER XT WAS LEAKING FUEL INTO HIS ENGINE BAY. I WENT OUT TO START MY CAR THE NEXT DAY AND MINE IS DOING THE SAME THING. THE FUEL IS SLOWLY LEAKING ONTO THE ENGINE BLOCK. THIS IS AN EXTREMELY DANGEROUS SITUATION. I DID SOME RESEARCHING AND IT SEEMS THAT ALMOST ALL FORESTER MODELS FROM 2002-2006 HAVE THIS EXACT SAME ISSUE! SOME HAVE BEEN RECALLED, BUT THE FORESTER XT HASN'T. THE ENGINES ARE THE SAME...I DON'T UNDERSTAND WHY THIS DANGEROUS PROBLEM HASN'T BEEN RESOLVED BY SUBARU. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10558587January 6, 2014
FUEL SYSTEM, GASOLINE
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
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10556113December 15, 2013
FUEL SYSTEM, GASOLINE
STRONG SMELL OF FUEL WHEN OPERATING THE VEHICLE IN COLD WEATHER (AROUND 35 DEGREES OR COLDER). THE FUMES ARE SOMETIMES SO INTENSE THAT THEY CAUSE A HEADACHE AND CERTAINLY POSE A SIGNIFICANT FIRE RISK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10556013December 13, 2013
FUEL/PROPULSION SYSTEM
I'VE OWNED MY 2004 SUBARU FOR 5 YEARS WITHOUT INCIDENT, BUT AS OF DECEMBER 2013, I'VE EXPERIENCED A STRONG FUEL SMELL BOTH INSIDE AND OUTSIDE OF THE CAR. THE SMELL IS OVERPOWERING WHILE CAR IS PARKED, BUT LESSENS WHILE MOVING. IT BEGAN AFTER THE FIRST BIG DROP IN TEMPERATURE (40 DEGREES TO 10 DEGREES), AND HAS PERSISTED FOR OVER A WEEK NOW. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10555451December 10, 2013
FUEL SYSTEM, GASOLINE
I FIRST NOTICED A STRONG GAS SMELL IN THE VEHICLE ON THE COLDEST DAY OF THE YEAR, WHEN THE TEMPERATURE WAS BELOW 20 DEGREES. THE GAS SMELL ENTERS THE VEHICLE THROUGH THE VENTS WHEN THE HEATER IS TURNED ON AND THE CAR IS IDLING. WHILE THE VEHICLE IS TRAVELING AT A SPEED OF 10+ MPH, THE GAS SMELL IS NOT NOTICEABLE. WHEN THE HEATER IS TURNED OFF, THE GAS SMELL DOES NOT ENTER THE VEHICLE. WHEN I EXIT THE VEHICLE, I CAN SMELL GAS OUTSIDE OF THE VEHICLE ALSO. THE SMELL IS SO OVERWHELMING THAT I CANNOT RUN THE HEATER IN THE EXTREME COLD TEMPERATURES WHILE THE VEHICLE IS IDLING. I RAN THE VEHICLE THROUGHOUT THE SUMMER MONTHS AND THERE IS NO PROBLEM WITH THE GAS SMELL WHATSOEVER. I DO NOT TAKE MY CHILD IN THE VEHICLE WITH ME DURING THE WINTER MONTHS DUE TO THE STRONG GAS FUMES. I FEAR THAT I MAY BECOME STRANDED IN MY VEHICLE AND I WILL NOT BE ABLE TO IDLE MY CAR FOR HEAT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10555430December 10, 2013
FUEL/PROPULSION SYSTEM
DURING THE COLD WEATHER THERE IS AN VERY STRONG GAS SMELL IN THE CAR. I STARTED THE CAR AND LOOKED UNDER THE HOOD AND CAN SEE WHERE GAS IS LEAKING FROM THE FUEL SYSTEM. I BELIEVE IT LEAKS IN THE SAME SPOT THAT MANY OTHER PEOPLE HAVE REPORTED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10555020December 6, 2013
FUEL SYSTEM, GASOLINE
START VEHICLE IN THE MORNING AND CAN SMELL GAS FUMES OUTSIDE AND INSIDE EVEN WHEN DRIVING. THIS CAUSES BURNING OF NOSE AND THROAT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10551064November 6, 2013
FUEL/PROPULSION SYSTEM
IT WAS SUMMER WHEN I FIRST NOTICE THE SMELL OF FUEL THROUGH MY VENTS AND I WAS DRIVING PASS AN GAS STATION (SHELL) SO I DIDN'T THINK MUCH NOT TILL THE NEXT MORNING AS I WARMED UP THE CAR I SMELLED PURE GASOLINE NEXT TO THE PASSENGER FENDER I THEN POP THE HOOD AND TRACED IT AND I WAS LEAD TO THE TURBO SIDE OF THE ENGINE SEEMS TO BE COMING FROM THE FUEL RAIL AREA UNSURE AS THE ENGINE WARMED UP THE SMELL FADED AWAY BUT NOW IT'S WINTER AND IT'S BAD I CAN SEE A BIG LOST IN FUEL CONSUMPTION FULL TANK DOESN'T LAST A WEEK IT'S DRIVEN TO AND FROM WORK AROUND 4 TO 12 MILES A DAY NEED HELP! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10525878July 20, 2013
VEHICLE SPEED CONTROL
FLOOR MAT DETACHED FROM FLOOR; RIDES UP UNDER AND TRAPS ACCELERATOR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10511640May 13, 2013
FUEL/PROPULSION SYSTEM
FOR A PERIOD OF APPROXIMATELY THREE WEEKS IN EARLY JANUARY 2013 MY WIFE, DAUGHTER AND I COULD SMELL WHAT CAN ONLY BE DESCRIBED AS RAW GASOLINE WHEN WE DROVE OUR 2004 SUBARU FORESTER XT. IT WOULD TYPICALLY TAKE LESS THAN 5 MINUTES AFTER WE STARTED THE ENGINE FOR THE SMELL OF GAS TO BECOME VERY STRONG, EVEN OVERWHELMING. ALTHOUGH IT COULD STILL BE SICKENING, THE PROBLEM WOULD IMPROVE SOMEWHAT AFTER WE DROVE THE CAR FOR A FEW MINUTES. AFTER WE CAREFULLY REFUELED THE CAR ON TWO OR THREE OCCASIONS WE CONCLUDED THAT THE ISSUE DEFINITELY HAD NOTHING TO DO WITH SPILLED FUEL OR THE FUEL CAP. WE WERE VERY CONCERNED THAT WHETHER OR NOT THE SITUATION LED TO A FIRE, WE WERE ALL BEING MADE VERY SICK BY THE PROBLEM. WE CONTACTED THE SUBARU DEALER WHERE WE HAVE OUR FORESTER SERVICED AND DROPPED OFF THE CAR FOR THEM TO TROUBLESHOOT. WE WERE QUICKLY CONTACTED AND TOLD THAT THE ISSUE WAS WITH THE FUEL SYSTEM AND THAT BECAUSE THE FUEL LINES RAN UNDER THE TURBOCHARGER THE REPAIR WOULD BE VERY EXPENSIVE (AND IT WAS). AFTER RESEARCHING THE ISSUE IT QUICKLY BECAME APPARENT THAT THIS IS A COMMON PROBLEM WITH NOT ONLY FORESTERS, BUT FOR OTHER SUBARU MODELS AS WELL. BEING THAT THIS IS (BY ANY STANDARD) A COMMON PROBLEM ARISING FROM THE DESIGN OF THE VEHICLE, THAT THERE IS NO OPTION BUT TO REPAIR THESE VEHICLES ON THREAT OF FIRE OR ILLNESS, THAT THE PROBLEM DOES NOT OCCUR DUE TO ANY KIND OF MISUSE OR NEGLECT, THERE SHOULD BE A RECALL MADE FOR ALL SUBARUS THAT EXPERIENCE LEAKING FUEL SYSTEMS (NOT JUST THE WRX). BECAUSE THE REPAIR IS SO EXPENSIVE, AND SO MANY OF THE AFFECTED VEHICLES LACK ANY WARRANTY COVERAGE TO PAY FOR THE REPAIR, I AM CONCERNED THERE ARE MANY OWNERS WHO WILL ATTEMPT THE REPAIR THEMSELVES OR HAVE THE WORK DONE BY TECHNICIANS WHO ARE NOT FAMILIAR WITH THE PROBLEM. IT IS MY SINCERE HOPE THAT A SAFETY RECALL IS MADE AND OWNERS ARE NOTIFIED BEFORE ANYONE IS HARMED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10503109March 15, 2013
FUEL/PROPULSION SYSTEM
NOTICED A STRONG SMELL OF GAS WHILE DRIVING MY 2004 FORESTER XS, CAUSING HEADACHES TO MYSELF AND PASSENGERS. I BROUGHT IT TO MY MECHANIC WHO SAID THAT THERE WAS RAW GAS POOLING ON THE MANIFOLD. HE SAID THAT HE HAS SEEN THIS MANY TIMES BEFORE - LEAKING FUEL LINES DUE TO THE COLD (IT WAS 12 DEGREES WHEN I FIRST NOTICED IT). HE NOTED THAT THIS WAS THE WORST LEAK HE HAS SEEN. LOOKING AT A $700 BILL. I HAVE SINCE READ MANY OTHER COMPLAINTS ON THIS ISSUE. WONDERING WHY THERE HAS NOT BEEN A RECALL FOR THIS OBVIOUS SAFETY ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10499238February 19, 2013
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2004 SUBARU FORESTER. THE CONTACT STATED THAT THERE WAS AN OVERPOWERING GASOLINE FUEL SMELL INSIDE AND OUTSIDE OF THE VEHICLE. THE ODOR WOULD BECOME STRONGER WHEN THE CONTACT WAS OPERATING THE VEHICLE AT VARIOUS SPEEDS. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 116,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Subaru Forester