MINI Cooper Service Bulletins (2014)

462 manufacturer communications on file.

• December 1, 2015•Document ID: 10147907

  Service Bulletin/Repair Instructions
  ENGINE; ELECTRICAL SYSTEM

  Mfr Comm. #:

  M120415

  Date Added:

  November 13, 2018

  Manufacturer:

  MINI

  Summary

  "B38, B46, and B48 Engines: Engine Noise, Drivability Complaints, and Various DME Faults. The vehicle exhibits one the following complaints: z Noise from the lower engine area, described as a high-pitched whine z Loss of power when idling z At a higher engine speed (above 3,000 rpm), a brief decrease in the engine speed can be felt. z Extended cranking before the engine will start z The customer notices an increased level of ""free play"" in the clutch pedal when changing gears. z The clutch pedal remains depressed, and will not return to the disengaged position. z Emergency operation is active, with one or more of the faults listed below. One or more of the following faults may be stored in the vehicle: z 160020 Crankshaft sensor, signal: implausible z 180001 Catalytic converter: efficiency too low z 200D0C Powertrain, safety function: bus signal rpm reduction implausible z 11A002 Fuel high pressure, plausibility: Pressure too low z 1F054D Powertrain, safety function: powertrain reduced power, DSC-signal implausible Note: If additional faults are found in the DME memory (e.g., misfire, camshaft sensor, knock sensor, etc.), then those faults will be the primary focus of the diagnosis using the test plans provided for those faults. ""FC 120408 Boost pressure control: Shut-down as a consecutive reaction"" is only a result of the component fault and is not the primary reason for the complaint or https://www.minitis.net/tiscode/cgi-bin/bulletin.aspx?sie_path=/tsb/bulletins/htm_store/286...1/4/2016 Page 2 of 2 illumination of the engine malfunction warning."

  Associated Products (4)

  2016 MINI Cooper2016 MINI Cooper Convertible2015 MINI Cooper2014 MINI Cooper
  Associated Documents

  • DownloadMC-10147907-0001.pdf↗
• December 1, 2015•Document ID: 10147906

  Service Bulletin/Repair Instructions
  ENGINE

  Mfr Comm. #:

  M110815

  Date Added:

  November 13, 2018

  Manufacturer:

  MINI

  Summary

  Surface Cracks on the Water Pump Drive Pulley. During a repair, service or inspection, the drive pulley on the water pump shows signs of cracking. No part replacement is necessary unless there is another issue found that will be corrected by replacing the drive pulley.

  Associated Products (17)

  2016 MINI Cooper2016 MINI Cooper Convertible2016 MINI Countryman2015 MINI Cooper2015 MINI Countryman2014 MINI Cooper2014 MINI Countryman2013 MINI Clubman2013 MINI Cooper2013 MINI Cooper Coupe2013 MINI Cooper Roadster2012 MINI Cooper2012 MINI Cooper Coupe2012 MINI Cooper Roadster2011 MINI Cooper2010 MINI Cooper2009 MINI Cooper
  Associated Documents

  • DownloadMC-10147906-0001.pdf↗
• December 1, 2015•Document ID: 10147904

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM

  Mfr Comm. #:

  M090115

  Date Added:

  November 13, 2018

  Manufacturer:

  MINI

  Summary

  New programming feature: Exclusion of Infotainment Control Units from Programming.

  Associated Products (18)

  2016 MINI Cooper2016 MINI Cooper Convertible2016 MINI Countryman2015 MINI Cooper2015 MINI Countryman2014 MINI Cooper2014 MINI Countryman2013 MINI Clubman2013 MINI Cooper2013 MINI Cooper Coupe2013 MINI Cooper Roadster2012 MINI Cooper2011 MINI Cooper2010 MINI Cooper2009 MINI Cooper2009 MINI Cooper Convertible2008 MINI Cooper2007 MINI Cooper
  Associated Documents

  • DownloadMC-10147904-0001.pdf↗
• November 1, 2015•Document ID: 10216768

  Service Bulletin/Repair Instructions
  ENGINE AND ENGINE COOLING

  Mfr Comm. #:

  SIM120414

  Date Added:

  August 1, 2022

  Manufacturer:

  MINI

  Summary

  Turbocharger coolant pump: fault code 20a503. "drive faulty" message is displayed in the check control

  Associated Products (1)

  2014 MINI Cooper
  Associated Documents

  • DownloadMC-10216768-0001.pdf↗
• November 1, 2015•Document ID: 10147842

  Service Bulletin/Repair Instructions
  ENGINE AND ENGINE COOLING

  Mfr Comm. #:

  M120414

  Date Added:

  November 13, 2018

  Manufacturer:

  MINI

  Summary

  "Turbocharger Coolant Pump: Fault Code 20A503. ""Drive Faulty"" message is displayed in the Check Control. Fault code 20A503 ""Turbocharger coolant pump, self diagnosis: Signal implausible"" is stored in the DME. Unfavorable DME software application"

  Associated Products (2)

  2015 MINI Cooper2014 MINI Cooper
  Associated Documents

  • DownloadMC-10147842-0001.pdf↗
• October 1, 2015•Document ID: 10147801

  Service Bulletin/Repair Instructions
  ENGINE AND ENGINE COOLING; ELECTRICAL SYSTEM; VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR

  Mfr Comm. #:

  M640315

  Date Added:

  November 13, 2018

  Manufacturer:

  MINI

  Summary

  "Intermittent Failure of the Blower Motor. Intermittent failure of the blower motor at high vehicle speeds and/or strong headwinds. The fault code ""0x801204 - blower output stage: Short circuit or blocked"" is stored in IHX_I1 (Heater-air conditioning control unit) sets under the following conditions: High vehicle speeds. Or Driving into strong headwind. Sunroof in the open/tilt position and/or an open side window may cause situation to occur at lower speeds. The blower resumes operation again after 60 seconds. CAUSE High wind flow and wind force causes a current overload in the blower motor."

  Associated Products (4)

  2016 MINI Cooper2016 MINI Cooper Convertible2015 MINI Cooper2014 MINI Cooper
  Associated Documents

  • DownloadMC-10147801-0001.pdf↗
• October 1, 2015•Document ID: 10147800

  Service Bulletin/Repair Instructions
  ENGINE AND ENGINE COOLING; VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR

  Mfr Comm. #:

  M640215

  Date Added:

  November 13, 2018

  Manufacturer:

  MINI

  Summary

  The Blower Motor is Faulty. The blower motor does not operate at any fan speed. The blower motor may work intermittently with the blower fan speed operating only on FULL speed. CAUSE The blower motor is faulty and causes the blower resistor to fail.

  Associated Products (18)

  2016 MINI Cooper2016 MINI Cooper Convertible2016 MINI Countryman2015 MINI Cooper2014 MINI Cooper2013 MINI Clubman2013 MINI Cooper2013 MINI Cooper Coupe2013 MINI Cooper Roadster2012 MINI Cooper2012 MINI Cooper Coupe2012 MINI Cooper Roadster2011 MINI Cooper2010 MINI Cooper2009 MINI Cooper2009 MINI Cooper Convertible2008 MINI Cooper2007 MINI Cooper
  Associated Documents

  • DownloadMC-10147800-0001.pdf↗
• October 1, 2015•Document ID: 10147799

  Service Bulletin/Repair Instructions
  STRUCTURE

  Mfr Comm. #:

  M620115

  Date Added:

  November 13, 2018

  Manufacturer:

  MINI

  Summary

  Door Open Message Displayed, Even Though Door Is Closed. While driving, a CCM (Check Control Message) indicates the doors are open, even though they are closed. Also, sometimes the gong will sound and the interior lights will go on and off. The FRM (Footwell Module) sees an incorrect door lock status caused by voltage variations in the door locks.

  Associated Products (9)

  2016 MINI Cooper2016 MINI Cooper Convertible2016 MINI Countryman2015 MINI Cooper2014 MINI Cooper2013 MINI Cooper2013 MINI Cooper Coupe2012 MINI Cooper2011 MINI Cooper
  Associated Documents

  • DownloadMC-10147799-0001.pdf↗
• October 1, 2015•Document ID: 10147798

  Service Bulletin/Repair Instructions
  STRUCTURE; EQUIPMENT

  Mfr Comm. #:

  M510715

  Date Added:

  November 13, 2018

  Manufacturer:

  MINI

  Summary

  Paint on the B-Pillar is Scratched/Damaged. The paint finish on the B-pillar (above the door stricker) is scratched due to the inner door cavity window seal. The door window cavity seal rubber is too hard and scuffs the B-Pillar area when opening and closing door.

  Associated Products (4)

  2016 MINI Cooper2016 MINI Cooper Convertible2015 MINI Cooper2014 MINI Cooper
  Associated Documents

  • DownloadMC-10147798-0001.pdf↗
• October 1, 2015•Document ID: 10147797

  Service Bulletin/Repair Instructions
  SUSPENSION; SUSPENSION:REAR:SHOCK ABSORBER

  Mfr Comm. #:

  M330115

  Date Added:

  November 13, 2018

  Manufacturer:

  MINI

  Summary

  Noises from the Rear Axle Shock Absorber. The customer complains about a hammering noise from the rear axle area, when driving on rough road surfaces with low ambient temperatures. This noise will disappear with warmer ambient temperature. CAUSE Rear axle shock absorbers

  Associated Products (4)

  2016 MINI Cooper2016 MINI Cooper Convertible2015 MINI Cooper2014 MINI Cooper
  Associated Documents

  • DownloadMC-10147797-0001.pdf↗
• October 1, 2015•Document ID: 10147796

  Service Bulletin/Repair Instructions
  SUSPENSION

  Mfr Comm. #:

  M310115

  Date Added:

  November 13, 2018

  Manufacturer:

  MINI

  Summary

  Front Axle Noise when Turning at Low Ambient Temperatures. A groaning and/or squeaking noise from the front axle occurs when turning at low speeds or idle. The noise is most noticeable at low temperatures (approx. 32 degrees F), but not at higher temperatures and after driving.

  Associated Products (4)

  2016 MINI Cooper2016 MINI Cooper Convertible2015 MINI Cooper2014 MINI Cooper
  Associated Documents

  • DownloadMC-10147796-0001.pdf↗
• October 1, 2015•Document ID: 10147795

  Service Bulletin/Repair Instructions
  ENGINE

  Mfr Comm. #:

  M110715

  Date Added:

  November 13, 2018

  Manufacturer:

  MINI

  Summary

  "Excessive amount of water condensation may accumulate in the engine's crankcase. With prolonged vehicle storage, water condensation in engine's oil may cause oil pump malfunction. AFFECTED VEHICLES This Service Action involves F55 and F56 models (MINI Cooper with B38 engine) produced from 07/05/2014 to 02/24/2015 that are still ""new vehicles"" in dealer inventory, based on our analysis. Vehicles which require this Service Action to be completed will show it as ""Open"" when checked either in the ""Service Menu"" of DCSnet (Dealer Communication System) or with the Key Reader. Increased number of colds starts and stops during a vehicle's transportation and storage process (prior to customer delivery)."

  Associated Products (4)

  2016 MINI Cooper2016 MINI Cooper Convertible2015 MINI Cooper2014 MINI Cooper
  Associated Documents

  • DownloadMC-10147795-0001.pdf↗
• October 1, 2015•Document ID: 10147794

  Service Bulletin/Repair Instructions
  EQUIPMENT; EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

  Mfr Comm. #:

  M011014

  Date Added:

  November 13, 2018

  Manufacturer:

  MINI

  Summary

  "MINI Motorer-Focused Satisfaction (MFS) Program. Based on Motorer feedback, MINI has determined that during the first three years of service, some vehicles may require specific additional service work to be performed. To address this issue, MINI USA, a division of BMW of North America, LLC (""MINI USA"") is providing the following Motorer-Focused Satisfaction (MFS) Program. This program's procedures have been available to you to address specific Motorers' concerns since September 1, 2014. As part of our Motorer Pledge to deliver an incredible MINI motoring experience, for the abovereferenced MINI vehicles, we developed this program to increase our Motorers' satisfaction by helping to prevent unexpected dealer service repair visits."

  Associated Products (18)

  2016 MINI Cooper2016 MINI Cooper Convertible2016 MINI Countryman2015 MINI Cooper2014 MINI Cooper2013 MINI Clubman2013 MINI Cooper2013 MINI Cooper Coupe2013 MINI Cooper Roadster2012 MINI Cooper2012 MINI Cooper Coupe2012 MINI Cooper Roadster2011 MINI Cooper2010 MINI Cooper2009 MINI Cooper2009 MINI Cooper Convertible2008 MINI Cooper2007 MINI Cooper
  Associated Documents

  • DownloadMC-10147794-0001.pdf↗
• September 1, 2015•Document ID: 10147290

  Service Bulletin/Repair Instructions
  EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM); EQUIPMENT

  Mfr Comm. #:

  M651015

  Date Added:

  November 5, 2018

  Manufacturer:

  MINI

  Summary

  NAV Road Map Installation Using USB Stick. The Navigation road map can be installed onto the head unit in the vehicle using a USB stick connected to the USB connector in the center console in the vehicle. 32GB USB stick is necessary Desired NAV road map version can be retrieved from the HDD-Update console PROCEDURE 1. Copy the desired NAV road map from the HDD-Update console onto a 32GB USB stick. Refer to the Attachment. 2. To install the desired NAV road map version into the vehicle, connect the USB stick into the USB connector. The connector is located: On R-Series MINI vehicles in the glove box: https://www.minitis.net/tiscode/cgi-bin/bulletin.aspx?sie_path=/tsb/bulletins/htm_store/26...10/5/2015 Page 2 of 2 On F-Series MINI vehicles at the center instrument panel area 3. When prompted, enter the 20-digit enabling code. 4. Start the NAV road map installation and follow the on-screen instructions. WARRANTY INFORMATION Not applicable. ATTACHMENTS View PDF attachment M651015_Attachment.

  Associated Products (18)

  2016 MINI Cooper2016 MINI Cooper Convertible2016 MINI Countryman2015 MINI Cooper2014 MINI Cooper2013 MINI Clubman2013 MINI Cooper2013 MINI Cooper Coupe2013 MINI Cooper Roadster2012 MINI Cooper2012 MINI Cooper Coupe2012 MINI Cooper Roadster2011 MINI Cooper2010 MINI Cooper2009 MINI Cooper2009 MINI Cooper Convertible2008 MINI Cooper2007 MINI Cooper
  Associated Documents

  • DownloadMC-10147290-0001.pdf↗
• September 1, 2015•Document ID: 10147289

  Service Bulletin/Repair Instructions
  EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

  Mfr Comm. #:

  M650415

  Date Added:

  November 5, 2018

  Manufacturer:

  MINI

  Summary

  Business Navigation (HU Basic) - not possible to downgrade the navigation map. After replacing the HU Basic (Entry Navigation), the version of the navigation map cannot be downgraded to the version of the replaced HU Basic. This is caused by an error in the routing table which is stored in the Central Gateway Module. Therefore, no communication with the map server can be established.

  Associated Products (3)

  2016 MINI Cooper Convertible2015 MINI Cooper2014 MINI Cooper
  Associated Documents

  • DownloadMC-10147289-0001.pdf↗
• September 1, 2015•Document ID: 10147288

  Service Bulletin/Repair Instructions
  EQUIPMENT:APPLIANCE:AIR CONDITIONER; EQUIPMENT

  Mfr Comm. #:

  M640215

  Date Added:

  November 5, 2018

  Manufacturer:

  MINI

  Summary

  This Service Information bulletin supersedes SI M64 02 15 dated August 2015. SUBJECT The Blower Motor is Faulty. The blower motor does not operate at any fan speed. The blower motor may work intermittently with the blower fan speed operating only on FULL speed. CAUSE The blower motor is faulty and causes the blower resistor to fail.

  Associated Products (18)

  2016 MINI Cooper2016 MINI Cooper Convertible2016 MINI Countryman2015 MINI Cooper2014 MINI Cooper2013 MINI Clubman2013 MINI Cooper2013 MINI Cooper Coupe2013 MINI Cooper Roadster2012 MINI Cooper2012 MINI Cooper Coupe2012 MINI Cooper Roadster2011 MINI Cooper2010 MINI Cooper2009 MINI Cooper2009 MINI Cooper Convertible2008 MINI Cooper2007 MINI Cooper
  Associated Documents

  • DownloadMC-10147288-0001.pdf↗
• September 1, 2015•Document ID: 10147287

  Service Bulletin/Repair Instructions
  EQUIPMENT:APPLIANCE:AIR CONDITIONER

  Mfr Comm. #:

  M640115

  Date Added:

  November 5, 2018

  Manufacturer:

  MINI

  Summary

  Air Draft into Driver's Foot-well. With the blower motor on, a draft in to the driver's foot-well area can be felt. As shown in the picture, the plug is missing from the air conditioning housing near the driver's foot-well area. The missing plug may be found in the vehicle DO NOT reinstall since it fits too loose and may fall out again.

  Associated Products (2)

  2015 MINI Cooper2014 MINI Cooper
  Associated Documents

  • DownloadMC-10147287-0001.pdf↗
• September 1, 2015•Document ID: 10147285

  Service Bulletin/Repair Instructions
  SUSPENSION:REAR:SHOCK ABSORBER

  Mfr Comm. #:

  M330115

  Date Added:

  November 5, 2018

  Manufacturer:

  MINI

  Summary

  Noises from the Rear Axle Shock Absorber. The customer complains about a hammering noise from the rear axle area, when driving on rough road surfaces with low ambient temperatures. This noise will disappear with warmer ambient temperature. CAUSE Rear axle shock absorbers

  Associated Products (4)

  2016 MINI Cooper2016 MINI Cooper Convertible2015 MINI Cooper2014 MINI Cooper
  Associated Documents

  • DownloadMC-10147285-0001.pdf↗
• September 1, 2015•Document ID: 10147284

  Service Bulletin/Repair Instructions
  SUSPENSION:FRONT:MACPHERSON STRUT

  Mfr Comm. #:

  M310215

  Date Added:

  November 5, 2018

  Manufacturer:

  MINI

  Summary

  In isolated cases, during the vehicles assembly, it is possible that one of the front spring struts was not correctly positioned in the swivel bearing.

  Associated Products (4)

  2016 MINI Cooper2016 MINI Cooper Convertible2015 MINI Cooper2014 MINI Cooper
  Associated Documents

  • DownloadMC-10147284-0001.pdf↗
• September 1, 2015•Document ID: 10147283

  Service Bulletin/Repair Instructions
  FUEL SYSTEM, GASOLINE; FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP; FUEL SYSTEM, GASOLINE:STORAGE

  Mfr Comm. #:

  M160115

  Date Added:

  November 5, 2018

  Manufacturer:

  MINI

  Summary

  Fuel Filling Nozzle Shuts Off Repeatedly While Refueling. The fuel filling nozzle turns off repeatedly while filling the fuel tank, regardless of the pump being used. CAUSE Defective service valve located within the fuel tank assembly. The service valve mechanism can stick closed at times and restrict the vapor release to the carbon canister while filling with fuel.

  Associated Products (2)

  2015 MINI Cooper2014 MINI Cooper
  Associated Documents

  • DownloadMC-10147283-0001.pdf↗