GMC Sierra Complaints (2004)

582 consumer complaints on file.

#10536420August 20, 2013
SERVICE BRAKES
BRAKES FAILED DUE TO A SUDDEN BRAKE LINE FAILURE. THERE HAD BEEN NO PRIOR FLUID LEAKS. THE REAR METAL BRAKE LINE UNDER THE BED RUSTED AT A CLAMP IN FRONT OF THE FUEL TANK. AS I HAVE LOOKED FURTHER INTO THIS I HAVE SEVERAL FRIENDS THAT HAVE HAD THIS PROBLEM AND SEVERAL SHOPS SAID THAT THEY SAW THIS OFTEN WITH THESE VEHICLES ALL FAILING IN THE SAME AREA. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10534707August 11, 2013
SERVICE BRAKES
GOT IN VEHICLE, STARTED IT,PUT IN GEAR,APPLIED BRAKE AND PEDAL DEPRESSED FARTHER THAN USUAL, HIT AGAIN THEY WENT ALMOST TO FLOOR.GOT OUT AND SAW BRAKE FLUID ON FRAME WHERE LINE HAD RUSTED IN THROUGH.UPON INSPECTION ALL LINES ARE TERRIBLY RUSTED AND WILL NEED REPLACED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10534022August 7, 2013
SERVICE BRAKES
TL* THE CONTACT OWNS A 2004 GMC SIERRA DENALI. THE CONTACT STATED WHILE TRAVELING APPROXIMATELY 5 MPH, THE BRAKE PEDAL WAS ABLE TO BE FULLY DEPRESSED AND THE BRAKE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS FOUND THAT THE BRAKE LINES WERE CORRODED. THE CONTACT ALSO MENTIONED THAT THE FAILURE WAS EXPERIENCED TWICE. THE VEHICLE WAS BEING REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 86,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10532812July 31, 2013
STEERING
TL* THE CONTACT OWNS A 2004 GMC SIERRA. THE CONTACT STATED THAT WHILE ATTEMPTING TO PARK, THE VEHICLE EMITTED A LOUD EXPLOSIVE NOISE. THE CONTACT ATTEMPTED TO REVERSE HOWEVER, THE VEHICLE WOULD NOT RESPOND BECAUSE THE STEERING WHEEL WAS SEPARATED FROM THE ARM AND THE BOLT HAD BECOME SHREDDED. THE VEHICLE WAS TOWED TO A MECHANIC WHERE AN INSPECTION WAS PERFORMED. THE DEALER ADVISED THE CONTACT THAT THE STEERING BOX AND PITMAN ARM BOLT HAD SHREDDED FROM THE TIE ROD CENTER LINK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 79,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10532294July 29, 2013
SERVICE BRAKES
TL* THE CONTACT OWNS A 2004 GMC SIERRA 1500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH UPHILL, THE BRAKE PEDAL WAS DEPRESSED WITHOUT ANY RESPONSE FROM THE VEHICLE. THE EMERGENCY BRAKE WAS ENGAGED IN ORDER TO STOP THE VEHICLE FROM ACCELERATING ANY FARTHER. THE CONTACT PARKED THE VEHICLE AND NOTICED THAT THE BRAKES LINES WERE COMPLETELY CORRODED DUE TO EXCESSIVE RUST. IN ADDITION, BRAKE FLUID WAS LEAKING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC AND REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 60,600.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10531590July 24, 2013
SERVICE BRAKES
GOT IN MY CAR AND PROCEEDED TO GO DOWN THE ROAD I WAS DOING ABOUT 45 MILES AN HOUR I HIT THE BRAKES TO SLOW DOWN AND THE BRAKE PEDAL WENT THE WHOLE WAY TO THE FLOOR AFTER I GOT STOPPED AND CHECKED IT OUT THE BRAKE LINES ARE COMPLETELY RUSTED THROUGH. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10524720July 14, 2013
SERVICE BRAKES
INCIDENT #1 WHILE TRAVELING AT 50 MPH ON A COUNTRY ROAD I APPLIED BRAKES TO DECELERATE FOR A 75 DEGREE RIGHT HAND BEND IN THE ROAD. THE BRAKE PEDAL WENT TO THE FLOOR. I HAD TO COLUMN SHIFT DOWN THROUGH THIRD, SECOND, AND THEN TO FIRST GEAR, TO SLOW DOWN. I WAS UNABLE TO GET TO EMERGENCY BRAKE. FORTUNATELY IT WAS ON A LIGHTLY TRAVELED ROAD AND THERE WAS NO ON COMING TRAFFIC AS I HAD TO VEER INTO THAT LANE TO MAKE THE TURN. I WAS ABLE TO HOBBLE HOME, WITH HAZARDS ON, BY DOWNSHIFTING TO SLOW DOWN. THE TRUCK WAS TOWED TO LOCAL REPAIR SHOP. THE REAR BRAKE LINES HAD FAILED AND WERE REPLACED. INCIDENT #2 WHILE TRAVELING AT 30 MPH TRAVELING DOWN HILL A RACCOON RAN ACROSS THE ROAD. I APPLIED BRAKES IN A DEFENSIVE MANNER AND THE PEDAL WENT TO THE FLOOR. I AGAIN HAD TO COLUMN SHIFT THROUGH THIRD, SECOND, AND THEN HOBBLE DOWN HILL IN FIRST GEAR. I WAS UNABLE TO ENGAGE EMERGENCY BRAKE. I WAS ABLE TO HOBBLE HOME DOWN SHIFTING THROUGH THE GEARS. THE TRUCK WAS AGAIN TO SAME SHOP AND I HAD THEM REPLACE ALL BRAKE LINES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10524115July 10, 2013
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2004 GMC SIERRA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, ALL OF THE INSTRUMENT PANEL LIGHTS FAILED. THE CONTACT MENTIONED THAT THE FAILURE WOULD RECUR INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ENTIRE INSTRUMENT CLUSTER NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 84,000. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10524157July 10, 2013
SERVICE BRAKES, ELECTRICAL SYSTEM, EQUIPMENT ADAPTIVE/MOBILITY
I HAVE A 2004 GMC SIERRA THAT HAS AN ELECTRICAL ISSUE WITH THE ABS OR BRAKE SYSTEM. THE BRAKE LIGHT, ABS LIGHT AND SERVICE BRAKE SYSTEM LIGHT GOES OFF AT RANDOM TIMES. MIGHT HAVE SOMETHING TO DO WITH THE AIR CONDITIONING BECAUSE THE A/C DRAWS POWER FROM THE BATTERY AND I CAN SEE THAT A CERTAIN LEVEL THE INDICATORS GO OFF. MOST OF THE TIME THE LIGHTS CHIME AND BLINK WHEN I APPLY THE BRAKE BUT IT ALSO HAS HAPPENED WHEN JUST TURNED THE TRUCK ON. I'VE REPLACED THE ROTORS AND PADS TO STILL HAVE THE PROBLEM. I'M NOT SURE IF IT'S A GROUND OR SENSOR THAT IS FAILING. I'VE FOUND TSB FOR REGROUNDING, FAILING SENSORS, OR ECBM. STILL HAVEN'T FOUND THE CORRECT DIAGNOSIS. I JUST HOPE THE ABS FUNCTIONS WHEN I NEED IT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10523712July 8, 2013
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2004 GMC SIERRA. THE CONTACT STATED THAT THE INSTRUMENT PANEL FAILED AND ALL OF THE GAUGES STOPPED WORKING. THE DEALER INFORMED THE CONTACT THAT THE ENTIRE INSTRUMENT PANEL NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 83,000. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10521677June 25, 2013
SERVICE BRAKES
MY BRAKE LINES RUSTED AT THE REAR OF THE LT FRONT WHEEL SPLASH AREA. THIS VEHICLE HAS LOW MILES FOR THE YEAR AND WAS NOT DRIVEN IN SALT OR DEICE. THE BRAKE LINE SHOULD NOT NEED TO BE REPLACED AT THIS TIME WITH SO MUCH SERVICE LIFE LEFT. I WAS LUCKY, THE BRAKE LINE BURST IN MY DRIVEWAY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10515806June 8, 2013
ENGINE
VEHICLE HAS EXPERIENCED MULTIPLE INSTANCES OF EXHAUST MANIFOLD BOLT FAILURES AT THE CYLINDER HEAD ON BOTH BANKS OF THE ENGINE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10511935May 14, 2013
FUEL SYSTEM, DIESEL
DIESEL FUEL LEAKS FROM INJECTORS INTO ENGINE OIL PAN AND CONTAMINATES ENGINE OIL THEM LEAKS OIL FROM BREATHER & REAR MAIN OIL SEAL AND GM KNOWS THERE IS A PROBLEM BUT WONT DO ANY THING FOR THIS PROBLEM SAID ITS OUT WARRANTY ON TIME NOT MILES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10510663May 5, 2013
SERVICE BRAKES
I WAS BACKING OUT OF THE DRIVEWAY AND THE BRAKES WENT TO THE FLOOR. THE BRAKE LINES WERE SEVERELY RUSTED. THEY LOOK LIKE THE ARE 50 YEARS OLD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10508778April 19, 2013
SERVICE BRAKES
RUSTY BRAKE LINES ON 2004 GMC 2500HD SIERRA. ALMOST CAUSED ME TO HAVE AN ACCIDENT BECAUSE THE BRAKE PETAL WENT TO THE FLOOR IMMEDIATELY WHEN THE BRAKE LINE BURST. I HAVE PICTURES OF THE OLD RUSTED BRAKE LINES IF YOU WOULD LIKE TO SEE THE PICTURES. SINCE IT SEEMS TO BE A WIDE SPREAD PROBLEM ON GM PICKUP TRUCKS FROM RESEARCHING IT ON THE INTERNET, I'M CURIOUS TO KNOW WHEN THEY ARE GOING TO RECALL THEM? JUST SAW ON THE NEWS WHERE THERE IS A GOVERNMENT RECALL ON 2005-2009 SUBARU'S FOR THE SAME PROBLEM. IT COST $1290.00 TO REPAIR ALL THE BRAKE LINES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10508798April 19, 2013
SERVICE BRAKES
I WAS APPROACHING A STOP SIGN DRIVING APPROXIMATELY 45 MPH. WHEN I APPLIED THE BRAKES THE PEDAL WENT TO THE FLOOR, AND THE VEHICLE WOULDN'T STOP. I MANEUVERED PAST SEVERAL VEHICLES ALMOST STRIKING THEM. I WAS ABLE TO APPLY THE EMERGENCY BRAKE TO STOP THE VEHICLE AFTER SOME DISTANCE PAST THE INTERSECTION. I AM A POLICE OFFICER WITH 25 YEARS ON THE JOB. I HAVE ATTENDING VARIOUS DRIVING COURSES RELATED TO MY PROFESSION. IF A LAY PERSON WAS IN THIS SITUATION A SERIOUS ACCIDENT WOULD HAVE HAPPENED. I BARELY ESCAPED THE ACCIDENT DUE IN PART TO TRAINING AND A LARGE AMOUNT OF LUCK. ON THE DAY OF THE INCIDENT THE VEHICLE HAD STOPPED NORMAL AT THREE PRIOR INTERSECTIONS WITHOUT GIVING ANY WARNING OF A POTENTIAL PROBLEM. I HAVE READ ON LINE THE THEORY ABOUT THE SALT CAUSING THE DAMAGE TO THE BRAKE LINES. I HAVE NEVER DRIVEN THIS VEHICLE IN THE SNOW SINCE IT IS A SPARE VEHICLE. THE VEHICLE HAS 72000 MILES A LARGE MAJORITY OF THOSE MILES DRIVEN ON THE HIGHWAY (SUMMER AND FALL). I BOUGHT THIS VEHICLE NEW FROM THE DEALERSHIP IN 2004. THE COST TO REPAIR THE BRAKE LINES WAS $1,100 DOLLARS. A RECALL SHOULD BE MADE IN REGARDS TO THIS DEFECT BEFORE SOMEONE IS KILLED OR SERIOUSLY INJURED. I HAD A MECHANIC SHOP REPAIR THE VEHICLE SINCE THE DEALERSHIP CLAIMED THEY HAD NO OTHER REPORTED FAILURES ON THIS VEHICLE. A QUICK LOOK ON VARIOUS WEBSITES SHOWED THAT TO BE A FALSE CLAIM. ANYONE DRIVING THESE TYPES OF VEHICLES PLEASE HAVE YOUR BRAKE LINES INSPECTED BY A MECHANIC. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10507284April 5, 2013
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2004 GMC SIERRA 2500. THE CONTACT STATED THAT THE INSTRUMENT PANEL CHANGED THE DISPLAY AND LANGUAGE INDEPENDENTLY. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 63,000. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10504703March 27, 2013
SERVICE BRAKES
BRAKE LINE FAILURE AS AN EMERGENCY STOPPING PROCEDURE WAS IN PLACE. VEHICLE EVENTUALLY STOPPED, BUT REAR ENDED THE FORWARD VEHICLE. BRAKE LINE CORROSION IN HARD PIPING WAS DIAGNOSED AS THE PROBLEM AS THE HARD BRAKE LINE RUPTURED. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10500674February 27, 2013
SERVICE BRAKES
TL*THE CONTACT OWNS A 2004 GMC SIERRA 1500. THE CONTACT STATED THAT WHILE THE BRAKE PEDAL WAS DEPRESSED, THE ABS SYSTEM ACTIVATED WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO HAVE A DIAGNOSED PERFORMED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 97,000 AND THE CURRENT MILEAGE WAS 98,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10493612January 21, 2013
SERVICE BRAKES
WHEN COMING TO A RED LIGHT I TRIED TO STOP MY TRUCK. UPON PRESSING THE BRAKE PEDDLE THE FIRST TIME I STARTED TO SLOW DOWN. UPON PRESSING THE BRAKE PEDDLE THE SECOND TIME, THE PEDDLE WHEN TO THE FLOOR AND DID NOT SLOW ME DOWN. I HAD TO RUN THE RED LIGHT AND US MY E BRAKE TO SLOW DOWN AND FINALLY STOP AT A GAS STATION. WHILE WAITING FOR AAA TO PICK ME UP NOTICED BRAKE FLUID COMING OUT FROM UNDER DRIVERS SIDE. TRUCK WAS TOWED TO MY SON'S HOUSE. AFTER LOOKING UNDER THE TRUCK HE TOLD ME THE BRAKE LINES FROM THE FRONT OF THE TRUCK HAD BROKEN. HE SUGGESTED WE REPLACE ALL THE BRAKE LINES, WHICH WE DID. ALL THE ORIGINAL LINES WERE ROTTING AWAY. WHEN WE REMOVED THE BRAKE LINES THEY ALL BROKE INTO PIECES . WE REPLACED ALL THE ORIGINAL LINES WITH STAINLESS STEEL LINES AT COST OF $400.00 PLUS I FOUND A FRONT AND A REAR CALIPERS FROZEN, SO I REPLACED ALL THE BRAKES AND CALIPERS. THERE IS NO WAY THE BRAKE LINES ON A 8 YEAR OLD TRUCK SHOULD BE FOUND IN THIS SHAPE. THE ORIGINAL LINES LOOKED LIKE ALUMINUM COATED STEEL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to GMC Sierra