GMC Sierra Complaints (2000)

698 consumer complaints on file.

#10438066December 2, 2011
SERVICE BRAKES, HYDRAULIC
TL* THE CONTACT OWNS A 2000 GMC SIERRA 2500. THE CONTACT STATED THAT THE BRAKE LINES WERE RUSTED, CAUSING A RESISTANCE IN BRAKING AND AN INCREASE IN STOPPING DISTANCE. THE VEHICLE WAS TOWED TO THE DEALER AND AFTER INSPECTION, BOTH BRAKE LINES AND CALIPERS WERE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 48,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10437624November 28, 2011
SERVICE BRAKES, HYDRAULIC, PARKING BRAKE:DRIVELINE:HYDRAULIC:HOSES, LINES/PIPING, AND FITTINGS
BADLY ROTTING/CORRODED BRAKE LINES. ONE HAS NOW BURST. BRAKE PEDAL GOES TO THE FLOOR. THERE WAS NO WARNING. NO WARNING LIGHT NOW OR PRIOR TO THE FAILURE. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10437267November 25, 2011
SERVICE BRAKES, HYDRAULIC
NHTSA SHOULD BE OPENING INVESTAGATIONS CONCERNING THE BRAKE LINE CORROSION INCIDENTS. WE JUST PURCHASED THIS TRUCK LESS THAN A YEAR AGO, AND BRAKE FAILURE CAUSED US TO HAVE THIS IN THE SHOP FOR OVER A MONTH AND STILL HAVE NO TRUCK YET. THERE ARE ENOUGH COMPLAINTS ON THE INTERNET FOR THE NHTSA TO HAVE A RECALL BEFORE SOMEONE GETS KILLED DUE TO THIS PROBLEM. THIS TRUCK ONLY COST US 6000.00. REPAIRS WILL PROBALLY BE HALF THAT PRICE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10435392November 13, 2011
SERVICE BRAKES, HYDRAULIC
THANK GOODNESS NO ONE WAS HURT, AND NO VEHICLE HIT WHEN MY BRAKE LINES BURST ON THIS VEHICLE. WHEN REPAIRED THE MECHANIC SAID THEY BASICALLY ROTTED OFF FROM RUST AND THAT THIS IS A VERY COMMON PROBLEM ON THESE VEHICLES. I UNDERSTAND SOME MAINTENANCE IS NORMAL ON ANY TRUCK, BUT BEING ABLE TO USE YOUR FINGERS TO CRUMBLE PARTS OF THE BRAKE LINE IS NOT. YOU NEED TO INVESTIGATE THIS BEFORE PEOPLE ARE HURT OR KILLED, IF SOME HAVEN'T BEEN ALREADY. YOU ALSO NEED TO REVISIT THE ABS SENSOR PROBLEM FROM THE PREVIOUS RECALL. THAT FIX DID NOT WORK, SO ALL I COULD DO IS DISCONNECT THEM OR CHANCE AN ACCIDENT!!!!!!!!!! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10435171November 10, 2011
SERVICE BRAKES, HYDRAULIC, SUSPENSION, STRUCTURE:BODY
RUST- HAD TO REPLACE ALL THE BRAKE LINES,ROCKER PANELS AND CAB CORNERS,GAS TANK STRAPS RUSTED OUT AND BROKE OFF .BOTH SPRING SHACKLES BROKE FROM RUST AND HAD TO BE REPLACED,THE FRAME HAD TO BE FIXED(CRACKED) AND NOW THE SHOCK MOUNTS HAVE RUSTED OFF AND HAVE TO BE FIXED AND ITS ONLY GOT 115,000 MILES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10435108November 9, 2011
SERVICE BRAKES, HYDRAULIC, STRUCTURE:BODY
MY 2000 GMC SIERRA'S FRAME IS EXTREMELY RUSTED. PARTS OF THE FRAME HAVE RUSTED COMPLETELY THROUGH. ALL THE BRAKES LINES HAVE BEEN REPLACED DUE TO RUST AS HAVE MANY OTHER BRAKE PARTS. I PURCHASED THE TRUCK USED BUT PREVIOUS OWNER STATED HE REPLACED THE BRAKE LINES DUE TO A LOW SPEED ACCIDENT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10433958November 2, 2011
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS, SERVICE BRAKES, HYDRAULIC
TL* THE CONTACT OWNS A 2000 GMC SIERRA 1500. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, HE APPLIED THE BRAKES AND THE PEDAL WAS DEPRESSED TO THE FLOORBOARD. THE VEHICLE COASTED TO A STOP AND WAS SAFELY DRIVEN HOME AND THE CONTACT NOTICED THAT THERE WAS A HOLE IN THE BRAKE LINES DUE TO CORROSION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 118,000. THE VIN WAS UNAVAILABLE. UPDATED 12/17/11 *BF UPDATED 01/18/12
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10433546October 29, 2011
SERVICE BRAKES, HYDRAULIC, SUSPENSION
I EXPERIENCED SUDDEN BRAKE FAILURE IN MY DRIVEWAY. THERE WAS NO WARNING LIGHT,JUST THE BRAKE PEDAL GOING TO THE FLOOR. MY MECHANIC LOOKED AT THE FAILED LINE AND SAID ALL MY LINES AND ABS UNIT WERE CORRODED AND NEEDED TO BE REPLACED. HE ALSO FOUND MY RIGHT REAR SPRING HANGER WAS RUSTED OFF AND THE SPRING WAS JUST RESTING ON THE BODY. THE REAR WHEEL BRAKE BACKERS PLATES ARE RUSTED OFF ALSO, AND THE ENTIRE FRAME IS VERY CORRODED. THIS IS A HUGE REPAIR BILL THAT MAY EXCEED THE VALUE OF THE TRUCK. THIS IS NOT NORMAL CORROSION. I HAVE LIVED IN NH 55 YRS AND HAVE NEVER HAD A VEHICLE ROT LIKE THIS. I HAVE A 2000 VOLVO V70 WITH 147,000 MILES ON IT WITH NO ISSUES. OBVIOUSLY GM CHEAPENED THIS TRUCK UP OR BOUGHT DEFECTIVE PARTS. I HAVE FOUND HUNDREDS OF ACCOUNTS ON THE INTERNET IDENTICAL TO MINE. THIS VEHICLE NEEDS TO BE RECALLED BEFORE PEOPLE ARE KILLED. I AM THANKFUL I WAS IN MY DRIVEWAY AND NOT HIGHWAY OR CITY DRIVING AT THE TIME OF THE FAILURE. DO THE RIGHT THING AND HOLD GM RESPONSIBLE. THERE WOULD BE NO GM WITHOUT OUR TAX DOLLARS AND THEY NEED TO MAKE THIS RIGHT. THANK YOU *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10433086October 27, 2011
SERVICE BRAKES, HYDRAULIC
TRUCK HAD FAILED TO STOP AT AN INTERSECTION AS WE APPROACHED RED LIGHT. UPON DEPRESSING THE PEDAL THE BRAKE PEDAL WENT TO THE FLOOR JUST ENOUGH TO GET TRUCK SLOWED BEFORE EMERGENCY PEDAL WAS DEPRESSED TO COME TO A COMPLETE STOP. WE WERE TRAVELING ABOUT 20 MILES AN HOUR BEFORE WE REACHED INTERSECTION ABOUT 75 YARDS AWAY. AS LIGHT TURNED GREEN, WE SLOWLY PULLED INTO A PARKING LOT AND PARKED TRUCK UNTIL A TOW TRUCK COULD GET VEHICLE BACK TO THE GARAGE FOR REPAIRS. UPON INSPECTION BY OUR MECHANIC, IT WAS FOUND THAT THE BRAKE LINE HAD RUPTURED NEAR THE ANTI-LOCK BRAKE HOUSING WHICH WAS CAUSED BY CORROSSION AND POOR BRAKE LINE TUBING MATERIAL. IT WAS NOTED THAT MATERIAL WAS NOT STAINLESS STEEL OR ANY NON-CORROSIVE MATERIAL SUPPLIED AND INSTALLED BY THE OEM. IT TOOK TWO WEEKS FOR OUR TRUCK TO BE REPAIRED AS THE MECHANIC HAD TO CUSTOMER BEND THE NEW BRAKE LINES BECAUSE OEM DOES NOT HAVE REPLACEMENT LINES WHICH CAME TO A FINAL COST OF CLOSE TO $1300. *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10432829October 26, 2011
SERVICE BRAKES, HYDRAULIC
1ST INCIDENT ON OR ABOUT NOVEMBER 2010 REAR BRAKE LINE FAILURE NO PREVIOUS WARNING LIGHT INDICATION - STEEL LINE BURST CAUSING BRAKE FAILURE ALONG WITH EMERGENCY BRAKE FAILED THIS HAPPENED AT ABOUT 10 MILES AN HOUR SO THE VEHICLE WAS ABLE TO BE STOPPED BY A CURB. TESTING THE BRAKES NONE WORKED EVEN THOUGH IT WAS A REAR LINE FAILURE. VEHICLE TOWED AND REPAIRED BY REPLACING THE LINE FROM ABSBOX TO REAR AND THE EMERGENCY BRAKE SHOES AND REAR DISC PADS WERE ALSO REPLACED. EVEN WITH THE EMERGENCY BRAKE SHOE REPLACEMENT ITS ABILITY TO STOP THE TRUCK WAS MINIMAL AT BEST 2ND INCIDENT ON OR ABOUT AUGUST 2011 THE TRUCK FAILED TO PASS NC STATE SAFETY INSPECTION AS EMERGENCY BRAKE WOULD NOT HOLD - THE EMERGENCY BRAKE SHOES AND REAR DISC PADS WERE REPLACED AGAIN WITH SIMILAR RESULTS WITH THE PREVIOUS REPLACEMENT - WITH MARGINAL EMERGENCY BRAKING OPERATION, BUT ENOUGH TO PASS THE NC STATE INSPECTION - ALSO THE BACKING PLATES OF THE REAR BRAKES HAD TO BE REPLACED AS THEY HAD RUSTED AWAY 3RD INCIDENT ON OR ABOUT OCTOBER 2011 FRONT BRAKE FAILURE NO PREVIOUS WARNING LIGHT INDICATION - STEEL LINE TO FRONT BRAKES BURST WHERE TWO OF THE LINES WERE RUBBING TOGETHER WHERE THEY CROSS OVER THE FRAME FROM THE ABS BOX. THIS OCCURRED AT A STOP SIGN. THE HYDRAULIC SYSTEM MAINTAINED SOME STOPPING ABILITY AND THAT COMBINED WITH THE RECENTLY REPLACED EMERGENCY BRAKE PADS DID STOP THE TRUCK JUST SLIGHTLY PAST THE STOP SIGN. TO MOVE THE VEHICLE TO A SAFE LOCATION IT HAD NO HYDRAULIC STOPPING ABILITY, BUT THE EMERGENCY BRAKE DID FUNCTION MARGINALLY AT THE VERY SLOW SPEED. THE VEHICLE AGAIN NEEDED TO BE TOWED. DUE TO THE WAY THE FRONT FOUR STEEL LINES ARE RUN AND BUNDLED TOGETHER WITH OBVIOUS OTHER POINTS WHERE THESE LINES RUB TOGETHER COMBINED WITH RUST WILL REQUIRE ALL THE FRONT STEEL LINES TO BE REPLACED INCLUDING THE STEEL LINES FROM THE MASTER CYLINDER TOO THE ABS BOX. *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10432663October 24, 2011
SERVICE BRAKES, HYDRAULIC
BRAKE FAILURE- SEVERELY RUSTED AND CORRODED BRAKE LINES. HAD TO HAVE EVERY BRAKE LINE CHANGED. THIS IS THE SECOND TIME THIS HAS HAPPENED TO THIS VEHICLE; THE FIRST TIME IN 2005 WITH 70,000 MILES AND THE SECOND TIME WAS ON 10/16/11 WITH 85,000 MILES. BRAKE LINES BROKE AND ALL FLUID CAME OUT, NO BRAKES AT ALL HAD TO TOW VEHICLE TO GARAGE. THIS LAST REPAIR COST ME $1200.00. MY TRUCK IS USED FOR PERSONAL USE, NORMAL OPERATION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10432503October 23, 2011
SERVICE BRAKES, HYDRAULIC
MULTIPLE BRAKE LINE FAILURE, AND FUEL LINE FAILURE DUE TO TO ROTTED LINES ALONG DRIVERS SIDE FRAME RAIL. DUE TO POOR QUALITY FACTORY INSTALLED COMPONENTS. THREE SEPARATE INCIDENTS, 2 WITH BRAKE LINES , 1 WITH FUEL LINES. APPROX. OUT OF POCKET EXPENSE SO FAR , (AND NOT COMPLETED YET), IS OVER $1,500.00 FOR PURCHASED AND INSTALLED REPLACEMENT PARTS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10432181October 20, 2011
SERVICE BRAKES, HYDRAULIC
BRAKES START ANTI LOCK FEATURE WHEN APPROACHING STOP, GREATLY LENGTHENING THE STOPPING DISTANCE.....THIS IS REPEAT OF SAME PROBLEM RECALLED IN OCT 2005, RESOLUTION OF WHICH WAS TO CLEAN THE COMPONENTS...WELL THEY GET RUSTY AGAIN AND THE SAME PROBLEM IS BACK....NOTE THAT BRAKES ARE TERRIBLE ON THIS VEHICLE, ALL COMPONENTS HAVE BEEN PREVIOUSLY REPLACED INCLUDING BOTH RUSTED OUT BRAKE LINES(JULY 2009, 55745 MILES, $1684.03). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10428631September 30, 2011
SERVICE BRAKES, HYDRAULIC
SEVERAL BRAKE LINES HAVE RUSTED THROUGH, THIS CAUSED LOSS OF BRAKE FLUID AND LOSS OF ANY BRAKING. THIS HAS CAUSED ME TO BE WITHOUT A TRUCK. DO TO THIS DEFECT GMC HAS CAUSED A VERY DANGEROUS VEHICLE TO BE ON THE ROAD. THIS WILL NOW COST ME TWO THOUSAND DOLLARS TO MAKE MY TRUCK SAFE TO DRIVE. GMC NEEDS TO BE HELD RESPONSIBLE FOR THIS POOR MATERIAL IN BRAKE LINE MATERIAL. PLEASE CORRECT THIS DEFECT BEFORE LIVES ARE LOST.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10427501September 26, 2011
SERVICE BRAKES, HYDRAULIC
EXITING THE HIGHWAY ON AN OFF RAMP, APPLIED THE BRAKES AND THE PEDDLE WENT TO THE FLOOR. FOUND A BRAKE LINE HAD CORRODED AND BURST. HAD TO REPAIR ALONG THE ROAD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10424271September 8, 2011
SERVICE BRAKES, HYDRAULIC
TL* THE CONTACT OWNS A 2000 GMC SIERRA 1500. WHILE DRIVING APPROXIMATELY 40 MPH THE CONTACT DEPRESSED THE BRAKE PEDAL AND IT DROPPED TO THE FLOORBOARD. THE CONTACT WAS ABLE TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THE BRAKE LINES CORRODED AND HAD TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10422466August 29, 2011
SERVICE BRAKES, HYDRAULIC
TL* THE CONTACT OWNS A 2000 GMC SIERRA 1500. THE CONTACT STATED THAT WHILE PULLING OUT OF THE DRIVEWAY AT A LOW SPEED, THE BRAKES WERE APPLIED AND THE BRAKE PEDAL DEPRESSED DOWN TO THE FLOOR. THE CONTACT HAD TO USE THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE VEHICLE WAS PARKED AND THE CONTACT NOTICED THAT THE BRAKE LINES WERE RUSTED OUT AND LEAKING BRAKE FLUID. THE VEHICLE WAS THEN TOWED TO AN INDEPENDENT MECHANIC, WHERE THE BRAKE LINES WERE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10419627August 16, 2011
SERVICE BRAKES, HYDRAULIC
COMPLETE BRAKE FAILURE DUE TO EXCESSIVE CORROSION. I GOT LUCKY THAT I HAD ROOM TO ROLL OUT. UPON INSPECTION I NOTICED THAT MANY COMPONENTS SHOW SIGNS OF EXCESSIVE RUST. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10419636August 16, 2011
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
BROKEN EXHAUST MANIFOLD BOLTS. DOING PREVENTATIVE MAINTENANCE AND AN INSPECTION I NOTICED FOUR BOLTS ON THE EXHAUST MANIFOLD BROKEN. THE FRONT AND REAR ON BOTH RIGHT AND LEFT SIDES ARE BROKEN OFF. I DID AN INTERNET SEARCH AND FOUND THIS VIDEO HTTP://WWW.YOUTUBE.COM/WATCH?V=0YG6WLBNZGI. I'M NOTICING THE TICKING SOUND OF EXHAUST LEAKS. LITTLE JETS OF FLAME IN THE ENGINE COMPARTMENT CAN'T BE A GOOD THING. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10419631August 16, 2011
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:WHEEL SPEED SENSOR/TONE RING, SERVICE BRAKES, HYDRAULIC
ANTI LOCK BRAKE SENSOR CORROSION CAUSES LOW SPEED BRAKING FAILURE. DRIVING AT LESS THAN 5 MPH WAS TERRIFYING. ALMOST HITTING PEDESTRIANS AT A CROSSWALK, ROLLING INTO AN INTERSECTION, AND ALMOST HITTING A STOPPED CAR IN FRONT OF ME. I TOOK THE TRUCK TO THE DEALER AND THEY VERIFIED THE CORRODED SENSORS. THIS WAS A RECALLED ISSUE ALREADY COMPLIED WITH. NO HELP FROM GM. THEY SAID THE BURDEN WAS MINE. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to GMC Sierra