Ford Escape Complaints (2005)

1,584 consumer complaints on file.

#10547178October 8, 2013
ENGINE AND ENGINE COOLING, VEHICLE SPEED CONTROL
I HAVE HAD PROBLEMS WITH MY FORD ESCAPE FOR A FEW MONTHS. GENERALLY WHEN AT A STOP MY ENGINE WOULD REV REALLY HIGH. AFTER THIS WENT ON FOR AWHILE NOW WHEN APPLYING THE BRAKE OR AT A STOP THE IDLING GOES SO LOW I'M AFRAID IT'S GOING TO STALL. I HAVE HAD A MECHANIC TEST IT AND PUT IT ON AN ANALYZER BUT THE ANALYZER DOESN'T SHOW A PROBLEM. I FINALLY HAD THE THROTTLE MOTOR REPLACED BUT IT IS STILL IDLING TOO LOW AT TIMES. THIS PROBLEM IS INTERMITTENT AND SEEMS TO BE NO RHYME OR REASON WHEN IT WILL START DOING IT. I'M AT A LOSS ON HOW TO FIX IT BUT IT'S PRETTY UNSAFE TO BE DRIVING AT TIMES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10547335October 8, 2013
SUSPENSION, STRUCTURE:BODY
THUMPING SOUND FROM RIGHT REAR OF CARGO DECK. UPON INTERIOR INSPECTION, NO LOOSE ITEMS IN CARGO AREA, NO LOOSE PANELS, AND JACK WAS NOT LOOSE. UPON EXTERIOR INSPECTION NOTICED RUSTED OUT PORTION OF WHEEL WELL. CAN SEE INTO INTERIOR (BACK OF INTERIOR PANEL, CARPETING, ETC.). SEEMS THAT THUMPING IS DUE TO WHEEL OR SUSPENSION PARTS BEING IMPROPERLY SUPPORTED DUE TO CORROSION OF/IN AREA OF WHEEL WELL. SPECIFICALLY, SHOCK AND/OR LARGE COIL SPRING ARE HITTING INTERIOR PANEL(S) OF VEHICLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10546307September 30, 2013
SUSPENSION, STRUCTURE:BODY
THE RIGHT REAR WHEEL WELL HAS RUSTED OUT. THIS MAKES IT A HUGE SAFETY FACTOR BECAUSE AT ANYTIME THE SHOCKS CAN BREAK FREE AND BUST UPWARD INTO MY TRUCK. I TOOK MY 2005 FORD ESCAPE TO MY MECHANIC AND HE SAID THAT IN THE LAST 2 MONTHS HE HAD SEEN 4-5 2005 FORD ESCAPES WITH THE SAME PROBLEM. IT IS ALL THE SAME RIGHT REAR WHEEL WELL. THERE IS A FACEBOOK PAGE WITH 195000 MEMBERS FOLLOWING IT SO I KNOW THAT I AM NOT ALONE. PROBLEM IS THAT HALF OF THE COUNTRY IS NOT IN AN AREA THAT HAS RUST. SO SOUTHERN FORD ESCAPE OWNERS ARE NOT GOING TO BE AFFECTED BY THIS. THIS CANNOT BE IGNORED BECAUSE NOT ALL 2005 FORD ESCAPE OWNERS HAVE THIS PROBLEM. ENVIRONMENTAL CONDITIONS WOULD SHOW YOU THAT ALL 2005 FORD ESCAPES WOULD HAVE THIS IF PUT TO THE SAME ENVIRONMENTAL FACTORS. THIS NEEDS A RECALL. IT IS AN EASY FIX. FORD ALREADY FIXED IT WITH THE NEWER MODELS. JUST WELD IN A NEW RIGHT REAR WHEEL WELL. THIS IS FRUSTRATING BECAUSE I KNOW IT IS A REAL PROBLEM WITH THIS MODEL, BUT THE ENVIRONMENT IS WHAT IS SAVING THIS FROM BEING A NATIONAL ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10546087September 29, 2013
STRUCTURE:BODY, WHEELS
THE RIGHT REAR INNER WHEEL WELL ROTTED LEAVING THE REAR SHOCK SUPPORT UNSECURED MAKING THE VEHICLE UNSAFE TO DRIVE. AFTER RESEARCHING ON THE INTERNET, FOUND THAT THIS WAS A COMMON ISSUE FOR THIS YEAR AND MAKE VEHICLE. DOES NOT APPEAR THAT FORD WANTS TO TAKE ANY RESPONSIBILITY FOR THE FAULTY MANUFACTURING AND/OR MATERIALS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10545579September 26, 2013
ELECTRICAL SYSTEM
WHILE DRIVING MY ESCAPE ON AN EXPRESSWAY IT SUDDENLY STARTED 'CHUGGING' AND DIED. I WAS LUCKY THERE WASN'T A LOT OF TRAFFIC - IT HAPPENED AT 11:30PM. I WAS ABLE TO COAST TO THE SIDE OF THE ROAD AND CALL A TOW TRUCK. THE VEHICLE IS IN A FORD SERVICE DEALER NOW BEING REPAIRED AT A COST OF $2564. THEY ARE REPLACING THE PCM, COILS AND PLUGS. APPARENTLY THIS IS A COMMON DEFECT THAT FORD DOES NOT COVER. THIS IS COULD HAVE TURNED INTO A VERY DANGEROUS SITUATION ON THE HIGHWAY. I FEEL FORTUNATE THAT IT DIDN'T HAPPEN DURING RUSH HOUR OR IN A REMOTE LOCATION. I AM VERY DISAPPOINTED IN FORD FOR NOT BACKING THEIR PRODUCT AND WILL NOT OWN ANOTHER ONE. *LN UPDATED 1/10/2013 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10545383September 25, 2013
SERVICE BRAKES
ABS LIGHT SUDDENLY CAME ON AND I HAD TO PRESS THE BRAKES ALMOST ALL THE WAY TO THE FLOOR TO STOP THE CAR. I PULLED OVER AND TURNED THE CAR OFF. WHEN I STARTED THE CAR BACK UP, THERE WAS NO ABS LIGHT OR SERVICE ENGINE INDICATOR. MECHANIC SAID THAT I NEED TO REPLACE THE MASTER CYLINDER AND POSSIBLY THE HCU. BUT THEY DON'T KNOW IF THAT WILL FIX IT. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10545054September 23, 2013
ENGINE
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE SUDDENLY STALLED. THE WAS ABLE TO RESTART THE VEHICLE, WHICH BEGAN DRIVING ROUGHLY. THE VEHICLE WAS TOWED TO A DEALER WHERE A DIAGNOSTIC WAS PERFORMED AND CONCLUDED THAT THE ENGINE CONTROL MODULE, COIL ASSEMBLY AND THE SPARK PLUG GASKET WOULD NEED REPLACING. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 170,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10544543September 20, 2013
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT THE VEHICLE MADE A RATTLING NOISE WHILE DRIVING. THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT THE REAR PASSENGER'S SIDE WHEEL WELL, STRUTS AND SHOCKS WERE SEPARATED DUE TO SEVERE CORROSION. THE VEHICLE WAS NOT TAKEN TO THE DEALER AND WAS NOT REPAIRED. THE MANUFACTURER WAS MADE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 115,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10544644September 20, 2013
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS, WHEELS
NOTICED A LOUD BANGING NOISE IN THE BACK PASSENGER SIDE. LOOKED IN WHEEL WELL AND IT IS COMPLETELY RUSTED OUT. YOU CAN SEE RIGHT THROUGH THE CAR. TOOK IT TO THE REPAIR SHOP AND THEY TOLD ME THEY HAVE SEEN MANY EXACT SCENARIOS. SHOCK IS ATTACHED IN A WAY THAT IT RUBS AGAINST THE WHEEL WELL CAUSING CORROSION.. NO OTHER RUST ON THE VEHICLE AND IT IS STORED IN THE GARAGE. I AM THE ORIGINAL OWNER AND HAVE GIVEN SCHEDULED MAINTENANCE AND REPAIR. IN LOOKING FURTHER IN TO THIS IT IS A COMMON COMPLAIN. CLEARLY A DESIGN FLAW. A RECALL IS NEEDED AS THIS IS A HUGE SAFETY ISSUE. THE WHEEL CAN FALL RIGHT OFF = AND THAT WILL CAUSE SERIOUS INJURY, PLEASE INVESTIGATE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10544438September 19, 2013
STRUCTURE:FRAME AND MEMBERS
TL* THE CONTACT OWNS A 2005 FORD ESCAPE XLT. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, SHE COULD HEAR A LOUD BANGING NOISE COMING FROM UNDER THE VEHICLE. THE CONTACT ALSO MENTIONED THAT UPON INSPECTION THE CAR WAS CORRODED UNDER THE PASSENGER'S SIDE REAR DOOR. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT THE UNDER BODY HAD TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE ON THE VEHICLE WAS 125,000. .... UPDATED 10-17-13 *BF UPDATED 10/24/2013 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10543596September 14, 2013
STRUCTURE:BODY, STEERING, SUSPENSION
THIS SAFETY ISSUE REQUIRES IMMEDIATE ATTENTION BY BOTH THE NHTSA AND FORD: 61 NHTSA COMPLAINTS FILED TO DATE: '04- 16; '05- 45. VEHICLE TAKEN TO FORD DEALERSHIP FOR SERVICE. SERVICE NOTIFIED THAT A FORWARD LOWER BALL JOINT WAS FAILING, NO OTHER DEFECTS WERE NOTED IN THE DETAILED VISUAL INSPECTION. IT WAS REPLACED TWO DAYS LATER. THE FOLLOWING DAY OF THE REPAIR, ON A DAILY COMMUTE BETWEEN TOL TO DTW, THE RIGHT REAR SHOCK TOWER SEPARATED WHILE DRIVING AT 70 MPH. VEHICLE BEGAN DOG-TRACKING. INITIAL INSPECTION DID NOT REVEAL THE HIDDEN DAMAGE CAUSED BY CORROSION AT THE WELDED SEAMS OF THE INNER WHEEL WELL DUE TO AN UNDERBODY COATING. UPON REMOVING THE UNDERCOATING, VERY EASILY BY HAND, TWO LARGE SECTIONS REMOVED, REVEALED THE SHOCK WAS PENETRATING THE INTERIOR OF THE VEHICLE AND WAS NO LONGER BEING STRUCTURALLY SUPPORTED BY THE VEHICLES UNI-BODY FRAME. THE LARGE SECTIONS REMOVED WOULD HAVE CAUSED TIRE FAILURE AT HIGHWAY SPEEDS BY PUNCTURE OR HAZARD TO OTHER FOLLOWING VEHICLES. THE SEPARATION OF THE SHOCK TOWER FROM THE BODY, DID CAUSE THE VEHICLE TO JERK AT THE TIME OF FAILURE, CREATING A LOUD POPPING SOUND AND CAUSING POTENTIAL HAZARD AS THE VEHICLE STEERED INTO OTHER LANES OF TRAFFIC AT HIGHWAY SPEEDS (70 MPH). THE VEHICLE IS RENDERED INOPERABLE DUE TO THE CATASTROPHIC NATURE OF THE FAILURE. LOCAL FORD DEALERSHIP STATES THEY ARE UNCOMFORTABLE REPAIRING THE STRUCTURE AND NOT AWARE OF ANY MANUFACTURE RECALLS. IN CONTACTING THEIR SISTER DEALERSHIP, THEY HAVE PREVIOUSLY REPAIRED THIS DEFECT, AND CONTINUED ON STATING THIS FAILURE IS A KNOWN ISSUE WITH 2004 - 2006 ESCAPES. THE FAILED PANEL IS AVAILABLE, P/N:PART 7L827827886A. A REINFORCEMENT PIECE IS ALSO AVAILABLE. SEE EXAMPLE PICTURE HERE: HTTP://IMAGESHACK.US/A/IMG854/6430/WHEELWELL2.JPG FACEBOOK SITE CONCERNING THIS SAFETY ISSUE: WWW.FACEBOOK.COM/PAGES/2005-FORD-ESCAPE-2004-2006/397923900236108. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10543430September 13, 2013
ENGINE
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, THE ENGINE WARNING LIGHT ILLUMINATED AS THE VEHICLE LOST ACCELERATION POWER. THE VEHICLE WAS TAKEN TO A REPAIR CENTER AND THE MECHANIC STATED THAT THE SPARK PLUGS, COILS, COMPUTER AND THE CATALYTIC CONVERTER HAD TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 147,000. THE VIN WAS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10543269September 12, 2013
ENGINE
THE CAR WOULD NOT RUN GOT IT TO THE REPAIR SHOP. TOLD ME IT WAS THE PCM, 6 COILS AND SPARK PLUGS ALL NEEDED TO BE REPLACE ($2K TO FIX). I CALLED FORD THEY SEEM TO KNOW ABOUT THIS ISSUE. TOLD ME EVEN THOUGH THE CAR IS AN 05 IT WAS MADE IN 04 SO THEY COULD NOT HELP. I WAS TOLD THERE WAS A PROGRAM TO FIX THIS ISSUE HAD TO BE WITHIN 8 YEARS AND 80K MILES. BAD SPARK PLUGS ARE TO BLAME. I DISAGREED 05 TO 2013 IS 8 YEARS, THEY SAY NO BECAUSE IT WAS MADE 10/14/04 SO IT WOULD PUT ME AT 9 YEARS 71K MILES. I ARGUED IT WAS SOLD IN 05 AND THAT IS WHAT THEY SHOULD GO BY, THEY DISAGREED. AFTER RESEARCHING THIS ONLINE SEVERAL PEOPLE HAVE HAD THIS SAME ISSUE WITH THE SAME YEAR MAKE AND VEHICLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10543360September 12, 2013
SUSPENSION
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED EXCESSIVE RUST ON THE SHOCK MOUNT ON THE REAR PASSENGER SIDE TIRE WAS CAUSING THE WHEEL TO KNOCK AGAINST THE FRAME. THE CONTACT TOOK THE VEHICLE TO A DEALER WHO STATED THE ENTIRE QUARTER PANEL AND INSIDE WHEEL WELL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 93,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10543050September 11, 2013
ENGINE, ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY, HYBRID PROPULSION SYSTEM: INVERTER
TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE LOST POWER AND STALLED. THE CONTACT ALSO MENTIONED THAT A RED TRIANGLE ILLUMINATED WITH A MESSAGE TO STOP SAFETY. THE VEHICLE WAS TAKEN TO THE DEALER AND THE MECHANIC DIAGNOSED THAT THE SERVICE HARNESS NEEDED TO BE INSTALLED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000. ACCORDING TO THE SERVICE BULLETIN, THE PROGRAM INVOLVED INSTALLING A SERVICE HARNESS IN THE HIGH-VOLTAGE TRACTION BATTERY AND REPROGRAMMING THE BATTERY CONTROL MODULE. UPDATED 11/06/13 UPDATED 11/29/13*LJ
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10543005September 10, 2013
ENGINE
DRIVING AT ANY SPEED, VEHICLE WILL SUDDENLY LOOSE ENGINE POWER AND ENGINE WILL STUTTER OR SHAKE AS SOMEONE PULLED OUT ONE SPARK PLUG AND VEHICLE IS TRYING TO COMPENSATE. ENGINE LIGHT WILL FLASH DURING THIS TIME APROX 40 SECONDS AND THEN ENGINE WILL CATCH AND RESUME NORMAL DRIVING. DOES NOT MATTER IF ENGINE IS HOT OR COLD, SHORT OR LONG DISTANCE THIS WILL HAPPEN RANDOMLY WITH OUT WARNING. AC OFF HEAT OFF AC ON HEAT ON DOES NOT MATTER. WE ARE NOW TRYING TO GOOGLE THE PROBLEM AND SEE WHAT OTHERS HAVE DONE WITH THE SAME PROBLEM. FORD HAS BEEN NO HELP AFTER READING THE CODES THEY TRY TO FIX WHAT MY PERSONAL MECHANIC HAS ALREADY REPLACED. CODES ALWAYS READ THE SAME THING COILS, FUEL INJECTION ALL HAVE ALREADY BEEN REPLACED AND PROBLEM PERSISTS. HAS BEEN IN TO REPAIR NUMEROUS TIMES AND SPENT 1,000'S OF DOLLARS ON VEHICLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10542038September 5, 2013
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT UPON INSPECTION IT WAS FOUND THAT THE DRIVER'S SIDE REAR SUSPENSION TOWER WAS COMPLETELY RUSTED AND RENDERED THE VEHICLE INOPERABLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE WAS CONFIRMED AND THE CONTACT WAS INFORMED THAT THE PART WAS NO LONGER MANUFACTURED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 80,000. THE VIN WAS UNAVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10542140September 5, 2013
POWER TRAIN
MY FORD ESCAPE 2005 WAS WORKING WELL WITHOUT ANY WARNING. SUDDENLY AFTER TURNING THE CAR SHUT DOWN. AFTER RESTARTING THERE WAS NOT ENOUGH POWER. WENT TO FORD AUTHORIZED REPAIR CENTER AND WAS TOLD THIS WAS A KNOWN PROBLEM WITH A TSB 10 -18-10, FAULTY SPARK PLUGS MAKE RADIO FREQUENCY INTERFERENCE WHICH MAKE COILS ON PLUGS AND POWER TRAIN CONTROL MODULE (PCM) TO MALFUNCTION. ALL SIX SPARK PLUGS AND COILS WERE REPLACED AND THE PROBLEM PERSISTS, ONLY SOLUTION IS TO CHANGE PCM. THIS PROBLEM CAN HAPPEN AT ANY TIME, AFTER ANY MILEAGE, WITHOUT ANY NOTICE, THESE VEHICLES SHOULD BE RE-CALLED AND FORD SHOULD PAY FOR THESE AS IT IS A DEFECT FROM FABRIC. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10538340September 2, 2013
ENGINE
AFTER DRIVING AT HIGH SPEEDS AND THEN SLOWING DOWN, (FOR EXAMPLE: GETTING OFF THE INTERSTATE ON THE OFFRAMP) THE ESCAPE WILL STALL OUT AND THE ENGINE WILL STOP. IT WILL START AGAIN, BUT WILL STALL OUT WHEN THE CAR IS PUT INTO GEAR. THIS HAS HAPPENED MULTIPLE TIMES TO ME. MECHANICS HAVE NOT BEEN ABLE TO REPEAT THE ISSUE. THERE IS A RECALL ON THE 2004 ESCAPE DUE TO THIS EXACT MISTAKE, BUT THE FORD DEALERSHIP WILL NOT FIX MINE BECAUSE THEY CANNOT REPEAT THE ISSUE. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10537868August 29, 2013
STRUCTURE:BODY, WHEELS, SUSPENSION
AS WE ARE DRIVING ALONG WE HEAR A VERY LOUD BANGING COMING FROM THE REAR OF THE VEHICLE.WHEN WE GET OUT TO INSPECT THE AREA WE FIND THE REAR PASENGER SIDE WHEEL WELL IS EXTREMELY RUSTED THRU AND CHUNKS OF THE WELL ARE ACTUALLY FALLING OUT. WE TOOK THE CAR TO THE FORD DEALER AND THEY SAID IT CANNOT BE REPAIRED!!!! BY THE FORD DEALER....THEN WE TOOK IT TO SEVERAL AUTO BODY SHOPS THAT SAID THEY CANNOT FIX THIS! SEVERAL PLACES SAID FORD USED FAULTY METAL OR UNDERCOATING AND THAT IS WHY IT RUSTED SO BADLY.THE CAR HAS ONLY 50000 MILES ON IT AND HAS BEEN HIGHLY MAINTAINED...I FINALLY FOUND AN AUTOBODY SHOP THAT WILL REPLACE THE ENTIRE WHEEL WELL AND THEER WILL BE NO GUARANTEE IT WONT HAPPEN AGAIN OR TO ANY OF THE OTHER WHEELS!!! I FEEL TOTALLY RIPPED OFF! I READ ONLINE THAT SEVERAL OTHER PEOPLE HAVE HAD THIS SAME PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Escape