Ford Edge Service Bulletins (2015)
182 manufacturer communications on file.
- September 22, 2016•Document ID: 10109046Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- TSB 16-0128
- Date Added:
- August 1, 2017
- Manufacturer:
- FORD
SummarySome 2015 Edge vehicles equipped with a 2.0L GTDI engine may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0054, P0137 and/or P0141 stored in the powertrain control module (PCM) memory. Follow the Service Procedure steps to correct the condition.
Associated Products (1)Associated Documents - September 21, 2016•Document ID: 10109070Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE); ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER; ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN; ENGINE AND ENGINE COOLING:COOLING SYSTEM; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR; ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY; ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM; ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS; ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS; ENGINE AND ENGINE COOLING; ENGINE AND ENGINE COOLING:ENGINE:GASOLINE; ENGINE AND ENGINE COOLING:ENGINE:DIESEL; ENGINE AND ENGINE COOLING:ENGINE; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV); ENGINE
- Mfr Comm. #:
- SSM 46085
- Date Added:
- August 1, 2017
- Manufacturer:
- LINCOLN
SummaryThe Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
Associated Products (297)2017 Ford C-Max2017 Ford Edge2017 Ford Escape2017 Ford Expedition2017 Ford Explorer2017 Ford F-1502017 Ford F-6502017 Ford F-7502017 Ford Fiesta2017 Ford Flex2017 Ford Focus2017 Ford Fusion2017 Ford Mustang2017 Ford Taurus2017 Ford Transit2017 Ford Transit Connect2017 Lincoln Continental2017 Lincoln MKC2017 Lincoln MKT2017 Lincoln MKX+ 277 moreAssociated Documents - September 16, 2016•Document ID: 10109065Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL
- Mfr Comm. #:
- SSM 46071
- Date Added:
- August 1, 2017
- Manufacturer:
- FORD
SummaryFor 2015-2016 Edge vehicles, update the Integrated Diagnostic Software (IDS) to version 102.02 or higher prior to reprogramming or installing an anti-lock brake system (ABS) module.
Associated Products (2)Associated Documents - September 16, 2016•Document ID: 10109063Service Bulletin/Repair InstructionsPOWER TRAIN:AUTOMATIC TRANSMISSION; POWER TRAIN
- Mfr Comm. #:
- SSM 46069
- Date Added:
- August 1, 2017
- Manufacturer:
- LINCOLN
SummarySome 2015-2016 vehicles equipped with 6F50/6F55 transmission Built On 11/2/2015 And Through 2/1/2016 may exhibit no reverse, 3rd and 5th gear and/or DTCs P0715, P0717, P0756 and/or P2701. This may be caused by the direct clutch snap ring out of position and/or damage to the direct clutch hub. The cause of the failure is the Tone Wheel surface putting uneven load on the snap ring. To repair this condition the Tone Wheel (7F283) must be replaced,(also referred to as Direct Clutch Cylinder/Tone wheel) in addition to the Tone Wheel, replace Direct Clutch Hub (7G384), Direct Clutch Return Spring (7F235), Direct Clutch Snap Ring (7C122), TSS Sensor (7M101), Seal Kit (7153) and filter in the kit. Disassemble, clean the transmission and main control to remove metal particles. Refer to WSM, Section 307-01. Use causal part 7F283 and applicable Labor ops from SLTS section 7.
Associated Products (16)Associated Documents - September 14, 2016•Document ID: 10109085Service Bulletin/Repair InstructionsVEHICLE SPEED CONTROL
- Mfr Comm. #:
- 16B32
- Date Added:
- August 1, 2017
- Manufacturer:
- LINCOLN
SummaryCertain 2015 Model Year Edge, 2015-2016 Model Year F-150, MKT, and Police Interceptor Sedan, and 2016 Model Year Escape, Explorer, Flex, Fusion, MKX, Mustang, Police Interceptor Utility, Taurus, and Transit Vehicles - Electronic Throttle Body Repair
Associated Products (13)Associated Documents - September 1, 2016•Document ID: 10109029Service Bulletin/Repair InstructionsPOWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); POWER TRAIN:AUTOMATIC TRANSMISSION
- Mfr Comm. #:
- TSB 16-0111
- Date Added:
- August 1, 2017
- Manufacturer:
- FORD
SummarySome 2014-2016 Fusion and 2015-2016 Edge vehicles equipped with a 6F35 transmission and active start/stop feature may exhibit an illuminated malfunction indicator lamp (MIL) with a harsh transmission engagement after an active stop/start event. Diagnostic trouble code (DTC) P0C27 will be stored in the powertrain control module (PCM) memory. This condition may be caused by air entering the transmission fluid auxiliary pump supply tube. Follow the Service Procedure steps to correct the concern.
Associated Products (5)Associated Documents - August 23, 2016•Document ID: 10092567Service Bulletin/Repair InstructionsEQUIPMENT; STRUCTURE:BODY:ROOF AND PILLARS
- Mfr Comm. #:
- SSM 46025
- Date Added:
- February 23, 2017
- Manufacturer:
- FORD
SummarySOME 2015-2016 EDGE VEHICLE MAY EXHIBIT A ROOF OPENING PANEL THAT IS SLOW TO CLOSE. THIS MAY BE CAUSED BY DIRT OR DEBRIS IN THE ROOF OPENING PANEL MAIN AND/OR IDLER TRACKS OR AN ISSUE WITH THE ROOF OPENING PANEL MAIN TRACK ASSEMBLY OR IDLER TRACK ASSEMBLY. ENGINEERING IS CURRENTLY INVESTIGATING THIS CONCERN. CONTINUE TO MONITOR OASIS FOR UPDATES.
Associated Products (2)Associated Documents - August 22, 2016•Document ID: 10092562Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; STEERING
- Mfr Comm. #:
- SSM 46022
- Date Added:
- February 23, 2017
- Manufacturer:
- FORD
SummaryWHEN HOOKING UP THE VEHICLE COMMUNICATION MODULE (VCM) AND INTEGRATED DIAGNOSTIC SYSTEM (IDS) TO THE DLC LOCATED ON THE DRIVER SIDE UNDER THE STEERING COLUMN AT THE GWM, MAKE SURE THAT THE IGNITION IS OFF BEFORE CONNECTING TO IDS. IF THE IGNITION IS ON OR THE ENGINE IS RUNNING DURING THE HOOK UP, IT CAN RESULT IN VARIOUS WARNING LIGHTS BEING ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS), NO START OR NO CRANK CONDITIONS OR THE CLUSTER INOPERATIVE. FOR LINCOLN VEHICLES, THIS INFORMATION IS NOW LISTED IN THE TECHNICAL INSPECTION AND POST ROAD TEST SECTIONS OF EPDI ON THE PTS WEBSITE. IF A VEHICLE DISPLAYS THESE ISSUES, DISCONNECT THE EQUIPMENT FROM THE DLC AND REINSTALL WITH THE IGNITION OFF. CLEAR ANY DTCS PRESENT AND RETEST.
Associated Products (29)2017 Ford Explorer2017 Ford F-2502017 Ford F-3502017 Ford F-4502017 Ford F-5502017 Ford F-6502017 Ford F-7502017 Ford Fusion2017 Ford Mustang2017 Lincoln MKC2017 Lincoln MKZ2016 Ford Edge2016 Ford Explorer2016 Ford F-1502016 Ford Fusion2016 Ford Mustang2016 Lincoln MKC2016 Lincoln MKX2016 Lincoln MKZ2015 Ford Edge+ 9 moreAssociated Documents - July 15, 2016•Document ID: 10091422Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING; ELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 45936
- Date Added:
- February 13, 2017
- Manufacturer:
- FORD
SummarySOME 2015-2016 EDGE AND 2016 MKX VEHICLES BUILT ON OR BEFORE 6/11/2016 MAY EXHIBIT A NOISE FROM THE ELECTRIC COOLING FANS, MOST NOTICEABLE RIGHT AFTER THE ENGINE IS TURNED OFF AS THEY SPIN DOWN TO A STOP. IF THE NOISE CAN BE PINPOINTED TO THE COOLING FAN MOTOR, INSTALL A NEW COOLING FAN MOTOR AND SHROUD F2GZ-8C607-E WHICH WAS RELEASED FOR SERVICE TO RESOLVE THIS CONCERN.
Associated Products (4)Associated Documents - July 13, 2016•Document ID: 10091272Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 45926
- Date Added:
- February 11, 2017
- Manufacturer:
- LINCOLN
Summary2013-2017 FUSION/ESCAPE/MKZ (EXCLUDING 3.7L), 2015-2016 EDGE/EXPLORER (EXCLUDING 3.5L/3.7L), 2015-2016 MKC, AND 2016 MKX VEHICLES (EXCLUDING 3.7L) EQUIPPED WITH ALL WHEEL DRIVE (AWD) MAY EXHIBIT A LEAKING PASSENGER SIDE POWER TRANSFER UNIT (PTU) HALFSHAFT/LINKSHAFT SEAL. THIS MAY BE DUE TO A WORN PTU BUSHING. THE PTU BUSHING CAN NOW BE REPAIRED WITHOUT PTU REPLACEMENT. THE ONLINE WSM IS BEING UPDATED FOR ALL LISTED VEHICLES.REFER TO THE INTERMEDIATE SHAFT BUSHING REMOVAL AND INSTALLATION IN WORKSHOP MANUAL (WSM), SECTION 308-07. THE PROCEDURE IS THE SAME FOR ALL VEHICLES. IF THE PROCEDURE IS NOT PUBLISHED FOR THE VEHICLE BEING SERVICED CHECK THE WSM OF ANOTHER LISTED VEHICLE. BUSHING PART NUMBER IS F2GZ-63600A58A. THE PARTS CATALOG IS BEING UPDATED TO INCLUDE THIS BUSHING.
Associated Products (22)2017 Ford Escape2017 Ford Fusion2017 Lincoln MKZ2016 Ford Edge2016 Ford Escape2016 Ford Explorer2016 Ford Fusion2016 Lincoln MKC2016 Lincoln MKX2016 Lincoln MKZ2015 Ford Edge2015 Ford Escape2015 Ford Explorer2015 Ford Fusion2015 Lincoln MKC2015 Lincoln MKZ2014 Ford Escape2014 Ford Fusion2014 Lincoln MKZ2013 Ford Escape+ 2 moreAssociated Documents - July 7, 2016•Document ID: 10091201Service Bulletin/Repair InstructionsENGINE; FUEL/PROPULSION SYSTEM
- Mfr Comm. #:
- TSB16-0094
- Date Added:
- February 10, 2017
- Manufacturer:
- LINCOLN
SummarySOME 2015-2016 EDGE AND 2016 MKX VEHICLES EQUIPPED WITH A 2.7L ECOBOOST ENGINE AND BUILT ON 10/29/2015 AND THROUGH 4/1/2016 MAY EXHIBIT A KNOCKING/TAPPING NOISE THAT CAN BE HEARD IN THE FUEL FEED TUBE THAT ATTACHES TO THE HIGH PRESSURE FUEL PUMP ON THE ENGINE. THIS MAY BE DUE TO A LOOSE CHECK VALVE LOCATED IN THE FUEL FEED TUBE. FOLLOW THE TSB SERVICE PROCEDURE STEPS TO CORRECT THE CONDITION.
Associated Products (4)Associated Documents - June 1, 2016•Document ID: 10081005Service Bulletin/Repair InstructionsEQUIPMENT; SERVICE BRAKES; EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
- Mfr Comm. #:
- SSM-45857
- Date Added:
- September 24, 2016
- Manufacturer:
- LINCOLN
Summary2015-2016 EDGE AND 2016 LINCOLN MKX - OVERLY SENSITIVE BRAKE APPLICATION AT LOWSPEED AND/OR IN COLD/WET CONDITIONS - BUILT ON OR BEFORE 3/23/2016
Associated Products (3)Associated Documents - May 13, 2016•Document ID: 10078990Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:SOFTWARE
- Mfr Comm. #:
- SSM-45821
- Date Added:
- August 30, 2016
- Manufacturer:
- FORD
SummarySIRI EYES FREE FUNCTIONAL ISSUES USING BLUETOOTH AND APPLE IOS 9.2 AND 9.2.1
Associated Products (78)2016 Ford C-Max2016 Ford Edge2016 Ford Escape2016 Ford Expedition2016 Ford F-1502016 Ford Flex2016 Ford Focus2016 Lincoln MKC2016 Lincoln MKS2016 Lincoln MKT2016 Lincoln MKX2016 Lincoln MKZ2016 Lincoln Navigator2015 Ford C-Max2015 Ford Edge2015 Ford Escape2015 Ford Expedition2015 Ford F-1502015 Ford F-2502015 Ford F-350+ 58 moreAssociated Documents - May 6, 2016•Document ID: 10078982Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; ELECTRICAL SYSTEM:SOFTWARE
- Mfr Comm. #:
- SSM-45804
- Date Added:
- August 30, 2016
- Manufacturer:
- FORD
Summary24 HOUR CLOCK DISPLAY RESETS TO 12 HOUR DISPLAY
Associated Products (3)Associated Documents - May 4, 2016•Document ID: 10078962Service Bulletin/Repair InstructionsSEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
- Mfr Comm. #:
- TSB-16-0080
- Date Added:
- August 29, 2016
- Manufacturer:
- FORD
SummarySOME 2015-2016 EDGE AND 2016 EXPLORER VEHICLES BUILT ON OR BEFORE 2/12/2016 EQUIPPED WITH CLIMATE CONTROLLED SEATS MAY EXHIBIT A LACK OF COOLING PERFORMACE FROM THE FRONT SEAT BACKRESTS.
Associated Products (3)Associated Documents - May 4, 2016•Document ID: 10078961Service Bulletin/Repair InstructionsSTRUCTURE:BODY:ROOF AND PILLARS
- Mfr Comm. #:
- TSB-16-0079
- Date Added:
- August 29, 2016
- Manufacturer:
- FORD
SummarySOME 2015 EDGE VEHICLES EQUIPPED WITH A ROOF OPENING PANEL AND BUILT ON OR BEFORE 8/10/2015 MAY EXHIBIT A RATTLE, POP, TAP AND/OR TICK NOISE COMING FROM THE ROOF AT THE TOP OF THE B-PILLAR. NOISE CAN BE HEARD ABOVE AND BEHIND THE DRIVER AND/OR PASSENGER FRONT SEATS.
Associated Products (1)Associated Documents - April 20, 2016•Document ID: 10205031Service Bulletin/Repair InstructionsEQUIPMENT; EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
- Mfr Comm. #:
- TSB160066
- Date Added:
- December 20, 2021
- Manufacturer:
- FORD
SummaryTouchscreen navigation system - arabic language - blank screen
Associated Products (88)2016 Ford Edge2016 Ford Escape2016 Ford Expedition2016 Ford Explorer2016 Ford F-1502016 Ford F-4502016 Ford Fusion2016 Ford Mustang2016 Ford Taurus2016 Ford Transit2016 Lincoln MKC2016 Lincoln MKS2016 Lincoln MKT2016 Lincoln MKX2016 Lincoln MKZ2016 Lincoln Navigator2015 Ford Edge2015 Ford Escape2015 Ford Expedition2015 Ford Explorer+ 68 moreAssociated Documents - April 20, 2016•Document ID: 10183767Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- 16-0066
- Date Added:
- December 7, 2020
- Manufacturer:
- FORD
SummarySome 2012-2016 vehicles equipped with a touchscreen navigation system and the language set to Arabic may exhibit a blank screen. This may be the result of the ribbon cables not being fully seated inside the front display interface module (FDIM) or an improper software configuration of the FDIM.
Associated Products (75)2016 Ford Transit2016 Lincoln MKC2016 Lincoln MKS2016 Lincoln MKT2016 Lincoln MKX2016 Lincoln MKZ2016 Lincoln Navigator2015 Ford Edge2015 Ford Escape2015 Ford Expedition2015 Ford Explorer2015 Ford F-1502015 Ford F-4502015 Ford F-5502015 Ford Fusion2015 Ford Mustang2015 Ford Taurus2015 Ford Transit2015 Lincoln MKC2015 Lincoln MKS+ 55 moreAssociated Documents - April 5, 2016•Document ID: 10183749Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- 16B10
- Date Added:
- December 7, 2020
- Manufacturer:
- FORD
SummaryIn some of the affected vehicles, the front control/display interface module (FCDIM) may have been unintentionally programmed for the European market instead of the North American market
Associated Products (49)2016 Ford C-Max2016 Ford E-1502016 Ford E-2502016 Ford E-3502016 Ford E-4502016 Ford Edge2016 Ford Escape2016 Ford Expedition2016 Ford Explorer2016 Ford F-1502016 Ford F-2502016 Ford F-3502016 Ford F-4502016 Ford F-5502016 Ford F-6502016 Ford F-7502016 Ford Fiesta2016 Ford Flex2016 Ford Focus2016 Ford Fusion+ 29 moreAssociated Documents - March 24, 2016•Document ID: 10075283Service Bulletin/Repair InstructionsSTRUCTURE:BODY:ROOF AND PILLARS
- Mfr Comm. #:
- 16-0053
- Date Added:
- June 22, 2016
- Manufacturer:
- FORD
SummaryISSUE Some 2015 Edge vehicles equipped with a roof opening panel and built on or before 11/16/2015 may exhibit a body creak-type noise in the area above the driver and/or passenger rear doors when driving over bumps. This may be due to the C-pillar body sheet metal rubbing on an interior panel and/or a metal tab on the roof opening frame in the grab handle area rubbing on the C-pillar body panel.
Associated Products (1)Associated Documents