Ford Edge Service Bulletins (2020)
162 manufacturer communications on file.
- November 18, 2020•Document ID: 10183392Service Bulletin/Repair InstructionsEQUIPMENT; POWER TRAIN; EQUIPMENT ADAPTIVE/MOBILITY
- Mfr Comm. #:
- SSM 49345
- Date Added:
- December 4, 2020
- Manufacturer:
- LINCOLN
SummarySome 2020 Edge/Nautilus/Escape/Corsair/Transit Connect vehicles with and 8F35/8F40 transmission built on or before 30-Sep-2020 may exhibit an illuminated powertrain malfunction (wrench) indicator with diagnostic trouble codes (DTCs) P0741 and/or P1744 present or stored in the powertrain control module (PCM). This may be due to the torque converter and a pump stator bushing leak. Replacement of only the torque converter and/or the main control may not resolve the concern. To correct the condition, replace the following components: the torque converter, fluid pump assembly, both fluid filters, main control, input shaft, and flush the transmission cooling system.
Associated Products (6)Associated Documents - November 11, 2020•Document ID: 10183569Service Bulletin/Repair InstructionsFUEL SYSTEM, OTHER:DELIVERY:FUEL PUMP; ENGINE AND ENGINE COOLING; EQUIPMENT
- Mfr Comm. #:
- SSM 49328
- Date Added:
- December 4, 2020
- Manufacturer:
- FORD
SummarySome 2019 MKC, 2019-2020 Edge/Nautilus/Escape/Ranger, 2020 Corsair, 2019-2021 Explorer vehicles equipped with 2.0L and 2.3L EcoBoost engines may exhibit a light to moderate ticking type noise at idle (600-700 RPM). The noise is usually more prominent in the area of the high-pressure fuel pump, located on the top of the engine just behind the number 4 ignition coil. This noise is not detrimental to engine function and has no short or long-term effects on engine durability. This an operating characteristic of these engines and no repairs should be attempted.
Associated Products (15)Associated Documents - November 6, 2020•Document ID: 10183405Service Bulletin/Repair InstructionsEQUIPMENT; ELECTRICAL SYSTEM; ELECTRICAL SYSTEM:ADAS:HUD:CAMERA/SENSOR
- Mfr Comm. #:
- 20B39
- Date Added:
- December 5, 2020
- Manufacturer:
- FORD
SummaryCertain 2020 Model Year Multiple Vehicle Lines Front View and Center High Mount Stop Lamp Camera Improper Function In some of the affected vehicles, insufficient electrical conductivity within the Printed Circuit Board (PCB) internal to the camera may lead to intermittent front view or Center High Mount Stop Lamp (CHMSL) camera operation. This could result in a blank or distorted image from the front of the vehicle or of the truck bed Dealers are to replace the front view camera or the CHMSL camera following the dealer bulletin technical information. This service must be performed on all affected vehicles at no charge to the vehicle owner.
Associated Products (9)Associated Documents - October 29, 2020•Document ID: 10181931Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:SOFTWARE; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
- Mfr Comm. #:
- SSM 49292
- Date Added:
- November 4, 2020
- Manufacturer:
- FORD
SummarySome 2018-2020 Ford and Lincoln vehicles may exhibit inoperative remote features via the Ford Pass/Lincoln Way mobile app, incomplete user authorization, no modem electronic serial number (ESN) displayed or DTCs U2100 and/or B156D in the telematics control unit (TCU). These symptoms may persist even after performing a TCU software update and/or replacement. To correct this condition, start a new session with the latest version of the appropriate diagnostic scan tool and perform a PMI on the TCU. If issues persist, open a hotline assistance request and include the IDS version (if applicable) used to perform the PMI and the Authorization Status PID value in the TCU datalogger. For claiming use causal part 14H092 and applicable labor times in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (49)2020 Ford Edge2020 Ford Expedition2020 Ford F-1502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford Fusion2020 Ford Mustang2020 Ford Ranger2020 Lincoln Aviator2020 Lincoln Continental2020 Lincoln Corsair2020 Lincoln MKX2020 Lincoln MKZ2020 Lincoln Nautilus2020 Lincoln Navigator2019 Ford Edge2019 Ford Escape2019 Ford Expedition+ 29 moreAssociated Documents - October 26, 2020•Document ID: 10181913Service Bulletin/Repair InstructionsEQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL; ELECTRICAL SYSTEM:SOFTWARE
- Mfr Comm. #:
- SSM 49284
- Date Added:
- November 4, 2020
- Manufacturer:
- FORD
SummarySome 2018-2020 Ford and Lincoln vehicles equipped with TCU and WiFi Hotspot, May display Vehicle Hotspot feature not enabled on this vehicle when attempting to enter the Hotspot menu. When using the FordPass/Lincoln Way application, the customer may receive a message saying Wi-Fi has been disabled from this vehicle. Check the vehicle specifications or vehicle build information for the mfal code. If mfal = WAFAC or WAFAB do not replace the TCU, engineering is currently investigating this condition. Inform customers Ford is developing a software fix that is expected in early January. In the interim, let the customer know they can continue to drive the vehicle and schedule a follow-up appointment with the customer for early January. Once the update becomes available, contact the customer and confirm the service appointment is going forward. Monitor OASIS for updates.
Associated Products (71)2020 Ford Ecosport2020 Ford Edge2020 Ford Escape2020 Ford Expedition2020 Ford Explorer2020 Ford F-1502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford Fusion2020 Ford Mustang2020 Ford Ranger2020 Ford Transit2020 Ford Transit Connect2020 Lincoln Aviator2020 Lincoln Continental2020 Lincoln Corsair2020 Lincoln MKX2020 Lincoln MKZ+ 51 moreAssociated Documents - October 26, 2020•Document ID: 10181912Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:SOFTWARE; EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
- Mfr Comm. #:
- SSM 49283
- Date Added:
- November 4, 2020
- Manufacturer:
- LINCOLN
SummarySome 2017-2020 Ford and Lincoln vehicles equipped with a telematics control unit (TCU) may exhibit incomplete user authorization, inoperative remote features and/or a message stating the system cannot access the Lincoln/FordPass Connect feature in the application due to being a fleet vehicle. Replacing the TCU will not resolve this condition. Engineering is currently investigating this condition. Inform customers Ford is developing a software fix that is expected in early January. In the interim, let the customer know they can continue to drive the vehicle and schedule a follow-up appointment with the customer for early January. Once the update becomes available, contact the customer and confirm the service appointment is going forward. Monitor OASIS for updates.
Associated Products (19)2020 Ford Ecosport2020 Ford Edge2020 Ford Escape2020 Ford Expedition2020 Ford Explorer2020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford Fusion2020 Ford Mustang2020 Ford Ranger2020 Ford Transit2020 Lincoln Aviator2020 Lincoln Corsair2020 Lincoln MKX2020 Lincoln MKZ2020 Lincoln Nautilus2020 Lincoln NavigatorAssociated Documents - October 20, 2020•Document ID: 10181924Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- TSB 20-2363
- Date Added:
- November 5, 2020
- Manufacturer:
- FORD
SummarySome 2019 MKZ, 2019-2020 EcoSport/Mustang/Continental/Fusion/F-150/Transit Connect/Ranger/Edge/Nautilus and 2020 Escape/Corsair/Aviator/Explorer/Expedition/Navigator/F-Super Duty vehicles with SYNC 3 may experience various SYNC performance related concerns. To correct the condition, follow the Service Procedure.
Associated Products (37)2020 Ford Ecosport2020 Ford Edge2020 Ford Escape2020 Ford Expedition2020 Ford Explorer2020 Ford F-1502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford F-6502020 Ford F-7502020 Ford Fusion2020 Ford Mustang2020 Ford Ranger2020 Ford Transit Connect2020 Lincoln Aviator2020 Lincoln Continental2020 Lincoln Corsair2020 Lincoln Nautilus+ 17 moreAssociated Documents - October 16, 2020•Document ID: 10181909Service Bulletin/Repair InstructionsSTRUCTURE:BODY:HATCHBACK/LIFTGATE; ELECTRICAL SYSTEM:SOFTWARE
- Mfr Comm. #:
- SSM 49267
- Date Added:
- November 4, 2020
- Manufacturer:
- FORD
SummarySome 2019-2020 Edge/Nautilus vehicles may exhibit an inoperative power liftgate with diagnostic trouble code (DTC) B144F:79 stored in the rear gate trunk module (RGTM). This may be due to the calibration of the RGTM. To resolve the concern, reprogram the RGTM using the latest software level of the appropriate Ford diagnostic scan tool. For claiming use causal part number 14B291 and Section 10 of the Service Labor Time Standards (SLTS) Manual. Do not replace the power strut unless DTC B144F remains after reprograming the RGTM.
Associated Products (4)Associated Documents - October 16, 2020•Document ID: 10181908Service Bulletin/Repair InstructionsEQUIPMENT ADAPTIVE/MOBILITY; EQUIPMENT; ELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 49266
- Date Added:
- November 4, 2020
- Manufacturer:
- LINCOLN
SummarySome 2020 Edge/Nautilus vehicles built on 12-Aug-2020 and through 22-Aug-2020 may exhibit a customer concern of the FordPass or Lincoln Way mobile apps unable to connect to the vehicle. The customer may state that there is no activate button on the FordPass or Lincoln Way mobile app. This may be due to the telematics control unit (TCU) module. To correct the condition, reprogram the TCU using As-Built data. For claiming use causal component 14G087 and labor operations from Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (4)Associated Documents - September 29, 2020•Document ID: 10180674Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:ADAS:BLINDSPOT:SOFTWARE; EQUIPMENT ADAPTIVE/MOBILITY
- Mfr Comm. #:
- SSM 49217
- Date Added:
- October 6, 2020
- Manufacturer:
- FORD
SummarySome 2015-2020 F-150/Mustang, 2016-2020 Edge, 2016-2018 MKX and 2019-2020 Nautilus vehicles built on or before 18-Jan-2020 may exhibit a mirror click and/or ratcheting noise when using memory functions or easy entry/exit function. This may be due to the software in the driver door module (DDM) and passenger door module (PDM). To correct the condition, reprogram the DDM and PDM with the latest software level of the appropriate Ford diagnostic scan tool. For claiming use causal part 14B291 and applicable labor times in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (24)2020 Ford Edge2020 Ford F-1502020 Ford Mustang2020 Lincoln MKX2020 Lincoln Nautilus2019 Ford Edge2019 Ford F-1502019 Ford Mustang2019 Lincoln MKX2019 Lincoln Nautilus2018 Ford Edge2018 Ford F-1502018 Ford Mustang2018 Lincoln MKX2017 Ford Edge2017 Ford F-1502017 Ford Mustang2017 Lincoln MKX2016 Ford Edge2016 Ford F-150+ 4 moreAssociated Documents - September 25, 2020•Document ID: 10180428Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- SSM 49210
- Date Added:
- October 6, 2020
- Manufacturer:
- FORD
SummarySome 2009-2020 Ford and Lincoln vehicles equipped with turbochargers may exhibit an oil leak from the turbocharger oil supply or return tubes, O-rings or 6.7L pedestal gasket. Although oil may collect on the turbocharger, it is very rare for a turbocharger to leak oil. To isolate the source of the leak, refer to Workshop Manual (WSM), Section 303-00 General Information > Diagnosis and Testing > Engine > Engine Oil Leaks - Fluorescent Oil Additive Method procedure. When an oil leak is present at a turbocharger oil supply or drain tube, remove the affected oil tube and inspect for damage, and replace the O-ring seals, pedestal gasket or oil tube as required. Refer to WSM, Section 303-04. For claiming, use the affected oil tube or pedestal gasket as the causal part and applicable labor operations in Sections 6 and 9 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (150)2020 Ford Edge2020 Ford Expedition2020 Ford Explorer2020 Ford F-1502020 Ford Fusion2020 Ford Mustang2020 Ford Ranger2020 Ford Transit2020 Ford Transit Connect2020 Lincoln Aviator2020 Lincoln Continental2020 Lincoln Corsair2020 Lincoln MKX2020 Lincoln MKZ2020 Lincoln Navigator2019 Ford Edge2019 Ford Escape2019 Ford Expedition2019 Ford Explorer2019 Ford F-150+ 130 moreAssociated Documents - September 14, 2020•Document ID: 10180392Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 49179
- Date Added:
- October 6, 2020
- Manufacturer:
- LINCOLN
SummarySome 2015-2020 Edge, 2016-2018 MKX, and 2019-2020 Nautilus vehicles may exhibit the parking lamps stay on and/or the trailer lights flicker with vehicle turned off when a trailer is connected to the vehicle. This may be due to the software in the trailer module (TRM). To correct the condition, reprogram the TRM with the latest software of the appropriate Ford diagnostic scan tool. Use causal part 19H332 and applicable labor times from Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (13)Associated Documents - September 9, 2020•Document ID: 10180340Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:SOFTWARE; BACK OVER PREVENTION: CAMERA SYSTEM; ELECTRICAL SYSTEM
- Mfr Comm. #:
- TSB 20-2301
- Date Added:
- October 1, 2020
- Manufacturer:
- FORD
SummarySome 2019 MKZ, 2019-2020 Mustang/Continental/Fusion/F-150/Transit Connect/ Ranger/Edge/Nautilus and 2020 Escape/Corsair/Aviator/Explorer/Expedition/ Navigator/F-Super Duty vehicles with SYNC 3 may experience various SYNC performance related concerns. To correct the condition, follow the Service Procedure.
Associated Products (26)2020 Ford Edge2020 Ford Escape2020 Ford Expedition2020 Ford Explorer2020 Ford F-1502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford Fusion2020 Ford Mustang2020 Ford Ranger2020 Ford Transit Connect2020 Lincoln Aviator2020 Lincoln Continental2020 Lincoln Corsair2020 Lincoln Nautilus2020 Lincoln Navigator2019 Ford Edge2019 Ford F-150+ 6 moreAssociated Documents - August 21, 2020•Document ID: 10179183Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION; EQUIPMENT
- Mfr Comm. #:
- SSM 49122
- Date Added:
- September 2, 2020
- Manufacturer:
- LINCOLN
SummarySome 2015-2020 F-150, 2016-2018 MKX, 2019-2020 Nautilus, 2015-2020 Edge, 2017-2019 Fusion, 2017-2020 MKZ And 2017-2020 Continental vehicles equipped with a 2.7L/3.0L EcoBoost engine may appear to have a low engine oil level if the proper procedures are not followed. Refer to the Owner's Manual > Maintenance > Engine oil check section. When checking the engine oil level after shutting off the engine wait at least 15 minutes prior to checking in order to allow the oil to drain back to the oil pan. The engine oil level can be checked immediately if the engine has not been started. When changing the engine oil the engine needs to be at normal operating temperature and the oil filter removed before draining the oil. Allow the oil pan to drain completely for up to 5 minutes. Check oil level after filling by following the oil level check procedure.
Associated Products (28)2020 Ford Edge2020 Ford F-1502020 Lincoln Continental2020 Lincoln MKZ2020 Lincoln Nautilus2019 Ford Edge2019 Ford F-1502019 Ford Fusion2019 Lincoln Continental2019 Lincoln MKZ2019 Lincoln Nautilus2018 Ford Edge2018 Ford F-1502018 Ford Fusion2018 Lincoln Continental2018 Lincoln MKX2018 Lincoln MKZ2017 Ford Edge2017 Ford F-1502017 Ford Fusion+ 8 moreAssociated Documents - August 13, 2020•Document ID: 10179367Service Bulletin/Repair InstructionsTRACTION CONTROL SYSTEM; SERVICE BRAKES, AIR:ANTILOCK; ELECTRICAL SYSTEM:SOFTWARE
- Mfr Comm. #:
- SSM 49091
- Date Added:
- September 4, 2020
- Manufacturer:
- LINCOLN
SummarySome 2019-2020 Edge/Nautilus vehicles may exhibit a false traction control or yaw control event. This may be due to software in the anti-lock braking system (ABS) module. To correct the condition, reprogram the ABS module using the latest software level of the appropriate Ford diagnostic scan tool. For claiming, use causal part 2B373 and labor times in Section 02 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (6)Associated Documents - August 13, 2020•Document ID: 10179362Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
- Mfr Comm. #:
- SSM 49088
- Date Added:
- September 4, 2020
- Manufacturer:
- FORD
SummarySome 2019-2020 Edge vehicles may exhibit an Overspeed Warning message displayed in the IPC. The warning may display at 118 km/h (73 mph). To correct the condition, perform an as-built configuration of the IPC using the appropriate Ford diagnostic scan tool. For claiming, use causal part 10849 and applicable labor times from Section 10 in the Service Labor Time Standards (SLTS) Manual.
Associated Products (2)Associated Documents - August 12, 2020•Document ID: 10179344Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; ENGINE; EQUIPMENT
- Mfr Comm. #:
- SSM 49085
- Date Added:
- September 4, 2020
- Manufacturer:
- FORD
SummarySome 2020 Ford and Lincoln vehicles equipped with a TCU may exhibit incomplete user authorization, no authorization pop-up on the SYNC infotainment system, vehicle connectivity concerns, vehicle location disabled message and/or various FordPass/LincolnWay App command/control concerns. To correct these conditions, ensure that customer connectivity settings (CCS) are turned on in the SYNC system. If the concerns persist after CCS is turned on, turn CCS OFF, perform an ignition cycle, and turn CCS settings back on. After any CCS changes, force-close and relaunch the FordPass/ LincolnWay app on the customers phone. Once CCS is turned on, program the TCU to the latest IDS/FDRS version level. If the concern is still present, follow normal diagnostics in Workshop Manual (WSM), Section 415-00. Refer to PTS OASIS home page for TCU version identification. For claiming, use causal part 14G229.
Associated Products (20)2020 Ford Ecosport2020 Ford Edge2020 Ford Escape2020 Ford Expedition2020 Ford Explorer2020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford Fusion2020 Ford Mustang2020 Ford Ranger2020 Ford Transit2020 Ford Transit Connect2020 Lincoln Aviator2020 Lincoln Corsair2020 Lincoln MKX2020 Lincoln MKZ2020 Lincoln Nautilus2020 Lincoln NavigatorAssociated Documents - August 12, 2020•Document ID: 10179121Service Bulletin/Repair InstructionsEQUIPMENT; ELECTRICAL SYSTEM
- Mfr Comm. #:
- TSB 20-2259
- Date Added:
- September 2, 2020
- Manufacturer:
- FORD
SummarySome 2019 MKZ, 2019-2020 Mustang/Continental/Fusion/F-150/Transit Connect/ Ranger/Edge/Nautilus and 2020 Escape/Corsair/Aviator/Explorer/Expedition/ Navigator/F-Super Duty vehicles with SYNC 3 may experience various SYNC performance related concerns. To correct the condition, follow the Service Procedure
Associated Products (29)2020 Ford Edge2020 Ford Escape2020 Ford Expedition2020 Ford Explorer2020 Ford F-1502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford F-6502020 Ford F-7502020 Ford Fusion2020 Ford Mustang2020 Ford Ranger2020 Ford Transit Connect2020 Lincoln Aviator2020 Lincoln Continental2020 Lincoln Corsair2020 Lincoln Nautilus2020 Lincoln Navigator+ 9 moreAssociated Documents - August 5, 2020•Document ID: 10179312Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; EQUIPMENT
- Mfr Comm. #:
- SSM 49046
- Date Added:
- September 4, 2020
- Manufacturer:
- FORD
SummarySome 2020 Edge vehicles may exhibit an Overspeed Warning message displayed in the IPC. The warning may display at 118 km/h (73 mph). To correct the condition, perform an as-built configuration of the IPC using the appropriate Ford diagnostic scan tool. For claiming, use causal part 10849 and applicable labor times from Section 10 in the Service Labor Time Standards (SLTS) Manual.
Associated Products (1)Associated Documents - July 29, 2020•Document ID: 10177878Service Bulletin/Repair InstructionsBACK OVER PREVENTION; ELECTRICAL SYSTEM; EQUIPMENT
- Mfr Comm. #:
- SSM 49033
- Date Added:
- August 4, 2020
- Manufacturer:
- FORD
SummarySome 2020 F150/Nautilus/Expedition/Transit/Edge/Escape/Mustang vehicles built on or before 21-Jun-2020 may exhibit various front and/or rear parking aid camera concerns such as poor image quality, flickering and/or completely inoperative. If a vehicle exhibits this condition, replace the affected camera(s). Refer to Workshop Manual (WSM), Section 41313. For claiming, use causal part 19G490 and any applicable labor operations in Section 11 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (7)Associated Documents