Chevrolet Silverado Complaints (2003)

2,092 consumer complaints on file.

#10490029December 25, 2012
SERVICE BRAKES
WHILE BACKING OUT OF DRIVEWAY THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. UPON INVESTIGATION A RUPTURED BRAKE LINE WAS FOUND. ALL THE LINES WERE VERY RUSTY. TWO SECTIONS WERE REPLACED TO GET THE VEHICLE ON THE ROAD AGAIN AND MOST OF THE REST WILL NEED REPLACED BEFORE THE VEHICLE CAN BE TRUST WORTHY. THE VEHICLE WAS INSPECTED BY THE DEALER HERE IN PA THIS PAST SUMMER AND NO MENTION WAS MADE OF THIS CONDITION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10488767December 14, 2012
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE BRAKE WAS DEPRESSED WHILE DRIVING 65 MPH AND THE BRAKES FAILED TO ENGAGE. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC. THE FAILURE WAS CONTRIBUTED TO THE BRAKE LINES, WHICH WERE FOUND TO BE CORRODED, AND CAUSED BRAKE FLUID TO LEAK. THE BRAKE LINES WERE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE FOR THE FAILURE. THE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 50,253. UPDATED 1/29/13 *CN UPDATED 02/06/13*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10488561December 13, 2012
POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
2003 CHEVROLET SILVERADO. CONSUMER WRITES IN REGARDS TO VEHICLE ENGINE MALFUNCTIONS. *SMD AN INSPECTION REVEALED THE DIFFERENTIAL FLUID HAD DROPPED FROM THE TRANSFER CASE, WHICH IN TURN SEIZED UP. THE TRANSFER CASE WAS REPLACED AT A COST OF $ 2,033.87. THE CONSUMER STATED THERE WAS A SLIGHT GRINDING NOISE WHILE DRIVING DOWN THE MOUNTAIN A FEW EARLIER. HOWEVER, HE INSPECTED THE VEHICLE, BUT FOUND NOTHING WRONG. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10488636December 12, 2012
SERVICE BRAKES
I MADE A PANIC STOP AND THEN LOST BRAKES ..LINES FROM MASTER CYLINDER TO BRAKE MODULE AND FROM MODULE TO FRONT AND REAR BRAKES BURST AT RUSTED AREA ........SEEMS TO BE LEAKING WHERE LINE MOUNTING CLIPS ARE LOCATED ... *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10487638December 7, 2012
SERVICE BRAKES
MOVING FROM PARKING SPACE, BRAKE PEDAL WENT TO FLOOR. NO STOPPING POWER AT ALL. CHECK BRAKE SYSTEM MESSAGE ILLUMINATED. BRAKE FLUID IS FULL. PEDAL MAKES SUCKING OR GURGLING SOUND WHEN DEPRESSED. PUMPING THE BRAKES DID NOT HELP. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10487589December 6, 2012
SERVICE BRAKES
ABOUT 2 WEEKS PRIOR TO MY INCIDENT MY FATHER HAD THE SAME ISSUE. WE BOTH OWN 2500 HD 2003 CHEVY TRUCKS BOUGHT ON SAME DAY. MY INCIDENT WAS I WAS LEAVING MY SISTERS HOUSE AND STARTED MY TRUCK BACKED UP THEN PUT TRUCK IN DRIVE STARTED FORWARD THERE IS A STOP SIGN CLOSE TO THE DRIVEWAY SO I STARTED BRAKING BUT PEDDLE WENT TO FLOOR SO I DID IT AGAIN SAME THING NO BRAKES. SO I USED E BRAKE TO STOP MYSELF GOT OUT AND SURE ENOUGH BUSTED BRAKE LINE UNDER CAB DRIVERS SIDE DOOR SAME PLACE MY FATHERS BUSTED A COUPLE WEEKS BE FOR MINE. HE LOCAL GARAGE WHERE MY DAD HAD HIS FIXED SAID HE HAVE CHANGED SEVERAL BRAKE LINES WITH SAME PROBLEM. ALSO NET AND FOUND THIS IS COMMON. WAY IS THERE NOT A RECALL ON THIS YET COULD BE A VERY SERIOUS ISSUE AND LIFE THREATENING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10486719December 2, 2012
SERVICE BRAKES
APPLICATION OF BRAKES UPON SLOW DOWN OF GETTING OFF OF EXIT RAMP WAS SOFT AND FARTHER THEN NORMAL. 3 OR 4 APPLICATIONS FOR TURNS SEEMED OK. FINAL APPLICATION TO TURN INTO PROPERTY HAD BRAKE FAIL APPEAR AND BRAKE GO TO FLOOR AND VEHICLE NOT SLOW QUICKLY ENOUGH AND TRUCK RUNNING INTO MY FENCE SCRAPPING THE SIDE OF MY TRUCK DOWN FENCE. UPON INSPECTION FOUND RESERVOIR EMPTY AND FLUID LEAKING FROM RUPTURED RUSTED LINE ON LEFT SIDE OF VEHICLE AT DRIVERS DOOR. INSPECTION FOUND MANY AREAS OF THE LINES BADLY RUSTED. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10486751December 2, 2012
SERVICE BRAKES
I WAS DRIVING MY 2003 CHEVY SILVERADO ON A RURAL BUT RESIDENTIAL ROAD WITH A STEEP DECLINE AT ABOUT 35 MPH. I ATTEMPTED TO SLOW DOWN BUT WHEN I STEPPED ON THE BRAKE PEDAL IT WENT TO THE FLOOR AND THE SERVICE BRAKES LIGHT CAME ON. IT FELT LIKE THERE WAS AIR IN THE BRAKE LINES SO I ATTEMPTED PUMPING THE BRAKES HOPING TO PREVENT ANY MORE ACCELERATION DOWN THE HILL AND THAT IS ABOUT ALL I GOT. I COULD NOT STOP AND HAD NO CHOICE BUT TO RIDE IT OUT UNTIL I CROSSED THE BRIDGE AT THE BOTTOM OF THE HILL AND STARTED UP THE OTHER SIDE.WHEN MY TRUCK FINALY CAME TO A STOP I QUIKLY PUT IT IN PARK TO PREVENT IT FROM ROLLING BACKWARDS DOWN THE HILL. I POPPED THE HOOD AND GOT OUT. I CHECKED THE BRAKE FLUID AND IT WAS ALMOST FULL SO I DIDN'T KNOW HOW AIR COULD GET IN THE BRAKE LINES.UNFORTUNATELY IT WAS SNOWING OUT SO I COULDN'T TELL IF I HAD A LEAK. I WAS ONLY A MILE FROM MY HOUSE SO I DECIDED I WOULD DRIVE IT HOME ON A DIFFERENT "FLAT" ROAD AT VERY LOW SPEED, ABOUT 10MPH. ONCE HOME I WAS ABLE TO HAVE MY WIFE PRESS ON THE BRAKES WHILE LYING UNDER THE TRUCK AND I FOUND THAT THE BRAKE LINE SUPPLYING THE REAR BRAKES WAS RUSTED OUT AND HAD A SEVERE LEAK. IF THIS HAD HAPPENED A FEW MINUTES LATER I WOULD HAVE BEEN ON A STATE HIGHWAY DOING 45 TO 50 MPH WITH OTHER VEHICLES. WHY ISN'T CHEVY/GM BEING MADE TO FIX THESE PROBLEMS ? *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10486646December 1, 2012
SERVICE BRAKES
CAME TO A STOP BUT THE PEDAL FELT SOFT, WENT TWO MORE MILES TO MY DESTINATION AND BRAKES FELT EVEN SOFTER. WHEN I WENT TO LEAVE I NOTICED A PUDDLE UNDER THE DRIVERS DOOR, I PUT SOME ON MY FINGER TO SMELL IT AND KNEW IT WAS BRAKE FLUID. I TOOK IT TO MY MECHANIC WHO SAID IT WAS A BLOWN BRAKE LINE CAUSED BY RUST, HE SAID HE HAS SEEN THIS ON ALOT OF SILVERADOS. I CALLED MY CHEVY DEALER AND THEY DIDN'T OFFER ANY RECALLS OR DISCOUNTS SO I HAD MY MECHANIC REPLACES ALL THE BRAKE LINES BECAUSE THEY WERE RUSTED AS BAD AS THE BLOWN LINE , ALSO HAD TO REPLACE TWO CALIPERS BECAUSE THE BLEEDERS WERE SO RUSTED THEY COULDN'T BE REMOVED. TOTAL COST 850.00 I'VE HAD ALOT OF TRUCKS WITH ALOT MORE MILES AND NEVER HAD PROBLEMS WITH THE BRAKE LINES. I THINK G.M. SHOULD REIMBURSE AT LEAST 50 % OF THE COST. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10486415November 29, 2012
SERVICE BRAKES
I OWN A 2003 CHEVY SILVERADO HD2500. THE TRUCK HAS LESS THAN 70 THOUSAND MILES ON IT AND I CAN'T BELIEVE THE ISSUES I HAVE HAD WITH IT. I'VE SPENT $1000'S FIXING THIS PIECE OF JUNK GM CALLS A TRUCK. I MUST HAVE REPLACED JUST ABOUT EVERYTHING ON THIS TRUCK, SOME THINGS TWO OR THREE TIMES. THE LATEST BEING THE BRAKE LINES, THE BRAKE LINES CORRODED THROUGH WITH NO WARNING. I WAS TOWING 4000 POUNDS OF WOOD WHEN I HIT MY BRAKES AND THE PEDDLE DROPPED TO THE FLOOR ? I ALMOST GOT KILLED! THIS TRUCK WAS MAINTAINED BY THE DEALER FOR THE 1ST 7 YEARS, UNTIL I FELT LIKE I WAS GETTING SCREWED BY GM AND USING THERE JUNK PARTS. IT IS A[XXX] SHAME WHEN AFTERMARKET PARTS ARE MUCH BETTER QUALITY THAN GM OEM PARTS ? I WILL NEVER USE GM PARTS AGAIN. I HAD THE SAME PROBLEM WITH THE ROTORS UNTIL I REPLACED THEM FOR THE THIRD TIME WITH AFTERMARKET ROTORS AND NOW THEY SEEM TO BE FINE NOW. GM MUST BE GETTING THEIR JUNK OEM PARTS FROM CHINA!! THIS IS RIDICULOUS AND GM SHOULD BE ASHAMED AND HELD ACCOUNTABLE FOR THEIR VEHICLES BEING UNSAFE AND DANGEROUS TO THE CONSUMER. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10485913November 24, 2012
SERVICE BRAKES
WHEN BACKING OUT OF DRIVEWAY WENT TO STOP AND PEDDLE WENT TO FLOOR,BLOWING BRAKE FLUID ALL OVER ROAD.I HAVE READ MANY ARTICLES ON THIS PROBLEM,WITH CHEVY PRODUCTS.THANK HEAVENS I WAS NOT DRIVING ON THE HIGHWAY AND THIS HAPPENED. ENOUGH SAID SHOULD BE A RECALL,OR REIMBURSEMENT FOR REPAIRS ALL READY FINISHED ON THESE CORRODED LINES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10485928November 24, 2012
SERVICE BRAKES
BRAKE LINES ON TRUCK ARE EXTREMELY CORRODED, AREAS AFFECTED ARE CROSSING THE REAR END ALONG THE CHASSIS AND UNDER THE HOOD WHERE NO MOISTURE IS PRESENT. ALL LINES ON TRUCK WILL NEED TO BE REPLACED AS THIS IS AN EXTREME SAFETY HAZARD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10485835November 23, 2012
SERVICE BRAKES
TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 2500 HD. THE CONTACT STATED THAT WHILE DRIVING 5 MPH INTO A RESIDENTIAL DRIVEWAY, THE BRAKE PEDAL ABNORMALLY TRAVELED TO THE FLOORBOARD. THE CONTACT INSPECTED THE VEHICLE AND DISCOVERED THAT THE BRAKE LINES WERE COMPLETELY RUSTED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED AND AN APPOINTMENT WAS SECURED FOR THE CONTACT TO TAKE THE VEHICLE TO THE DEALER. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 109,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10485858November 23, 2012
SERVICE BRAKES, SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE BRAKING TO A STOP, THE BRAKE PEDAL ABNORMALLY TRAVELED TO THE FLOORBOARD. THE CONTACT HAD NOT TAKEN THE VEHICLE TO THE DEALER OR A MECHANIC FOR INSPECTION OF THE FAILURE OR FOR REPAIRS. THE CONTACT STATED THAT THE BRAKE LINES WERE FRACTURED. THE FAILURE AND THE CURRENT MILEAGES WERE 20,000. UPDATED 12/19/12 *CN THE CONSUMER STATED THE VEHICLE WAS REPAIRED. UPDATED 1/9/2013 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10485410November 21, 2012
SERVICE BRAKES
BRAKE LINES HAD EXCESSIVE AMOUNT OF CORROSION/RUSTED CAUSING A LEAK(S). LINES GOING FROM THE ABS MODULE TO THE FRONT BRAKES WERE FOUND TO BE LEAKING. LINES GOING FROM THE ABS SYSTEM TO THE RESERVOIR WERE ALSO RUSTED AND REQUIRED REPLACEMENT. LINES FROM THE ABS SYSTEM TO THE REAR BRAKES BEGAN LEAKING A WEEK LATER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10485312November 20, 2012
SERVICE BRAKES
TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE REAR BRAKE LINES FAILED TWO WEEKS PRIOR TO THE FRONT BRAKE LINES FAILING. THE CONTACT HAD TO HAVE THE ENTIRE BRAKE LINE SYSTEM REPLACED DUE TO RUST. THE FAILURE MILEAGE WAS UNKNOWN, BUT THE CURRENT MILEAGE WAS 132,000. UPDATED 01/02/2013*LJ THE CONSUMER RETURNED FROM A 125 MILE TRIP, AFTER THAT DAY THE FAILURE OCCURED. THE CONSUMER BACKED THE TRUCK DOWN THE DRIVEWAY. THE BRAKE PEDAL WENT TO THE FLOOR. UPDATED 1/9/2013 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10485061November 18, 2012
SERVICE BRAKES
I WAS ATTEMPTING TO STOP AT A TRAFFIC LIGHT AND RUPTURED A BRAKE LINE,WHEN I INSPECTED THE BRAKE LINES THEY WERE COMPLETELY RUSTED. I'VE OWNED SEVERAL CHEVROLETS AND HAVE HAD BRAKE LINE PROBLEMS WITH THE LAST THREE I'VE OWNED ,ALL RUSTED PREMATURELY IN MY OPINION. I THINK WITH A SAFETY ISSUE SUCH AS THIS GM SHOULD RECALL AND REPLACE WITH STAINLESS BRAKE LINES ALL VEHICLES OF LESS THAN TEN YEARS OLD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10484947November 16, 2012
SERVICE BRAKES
AUG. 1,2012 RIGHT FRONT LINES BURST. NOV.15,2012 LEFT FRONT BRAKE LINES BURST. SHOP RECOMMENDED THAT ALL BRAKE LINES CORRODED AND NEEDED REPLACED. ESTIMATED $1600 TO 1800 PER RACETRACK AUTO BERLIN MARYLAND. I HAVE ALREADY PAID $200 FOR THE RIGHT BRAKE LINE AND EXPECT APPROX THE SAME BILL FOR THE LEFT CORRODED LINE. PLEASE HELP, THIS IS A SAFETY ISSUE! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10483994November 11, 2012
ELECTRICAL SYSTEM
MY INSTRUMENT PANEL IS DRAINING THE POWER CAUSING PROBLEMS WITH THE LIGHTS THERE IS A CLICKING SOUND AND LIGHT DIMMING WHEN THE TRUCK IS RUNNING. I WAS TOLD THE CHANGE THE IGNITION SWITCH WHICH WAS DONE BUT THAT DIDN'T HELP WITH THE PROBLEM. I DON'T KNOW WHAT ELSE TO DO ABOUT THIS PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10483937November 10, 2012
SERVICE BRAKES
I WAS DRIVING INTO MY DRIVEWAY WHEN I TRIED TO STOP THE BRAKE PEDAL WENT ENTIRELY TO THE FLOOR. THE TRUCK SEEMED AS THOUGH IT WAS GONNA HIT MY GARAGE. THANKFULLY I HAVE GOOD REFLEXES AND WAS ABLE TO HIT THE PARKING BRAKE (WHICH ISN'T AN EASY TASK IN A P/U TRUCK. WHEN I GOT OUT, I NOTICED A LARGE LEAK UNDER MY DRIVER DOOR. WITH FURTHER INVESTIGATION I FOUND THE BRAKE LINES WERE SEVERELY CORRODED. ONE OF THEM HAD SPRUNG A LEAK AND WAS SPRAYING BRAKE FLUID EVERYWHERE. THE OVER ALL STATE OF THE BRAKE LINE SYSTEM IS IN HORRIBLE CONDITION. I HAD THIS HAPPEN TO ME BEFORE IN MY '93 CHEVY TRUCK... BUT ITS EXPECTED AT TWICE THE AGE OF MY '03 TRUCK. I SAW THE NHTSA HAD AN INVESTIGATION THAT WAS ABOUT EXACTLY WHAT HAPPENED TO ME AND WANTED TO REPORT IT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Silverado