BMW X5 Service Bulletins (2001)
72 manufacturer communications on file.
- December 1, 2015•Document ID: 10147861Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B120808
- Date Added:
- November 13, 2018
- Manufacturer:
- BMW
SummarySI B12 08 08 Engine Electrical Systems December 2015 Technical Service This Service Information bulletin supersedes SI B12 08 08 dated April 2008. The vehicle's NOx emissions may exceed the legally mandated limits. By completing this Service Action, the DME is programmed with revised software to correct this situation.
Associated Products (6)Associated Documents - February 1, 2015•Document ID: 10057707Service Bulletin/Repair InstructionsAIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE; INTERIOR LIGHTING
- Mfr Comm. #:
- SI B65 04 14
- Date Added:
- June 22, 2015
- Manufacturer:
- BMW
SummaryBMW:SOME BMW MODELS MAY OR MAY NOT DISPLAY AIRBAG WARNING LIGHT. *TA
Associated Products (39)Associated Documents - October 1, 2014•Document ID: 10057566Service Bulletin/Repair InstructionsEXTERIOR LIGHTING:HEADLIGHTS
- Mfr Comm. #:
- SIB-63-09-14
- Date Added:
- June 10, 2015
- Manufacturer:
- BMW
SummaryBMW: SOME VEHICLES, WITH 552 OPTION, ARE EXPERIENCING A MALFUNCTION OF LED HEADLIGHT ON ONE WHERE IT FLICKERS ON AN DOFF DURING DRIVING AND THE CONTROL CHECK MESSAGE IS INDICATING DEFECTIVE DRIVING LIGHT OR PARKING LIGHT. *PE
Associated Products (29)Associated Documents - November 1, 2013•Document ID: 10150160Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- 120913
- Date Added:
- December 3, 2018
- Manufacturer:
- BMW
SummaryState Inspection and Emission (I/M) Test Fails Due To an Invalid VIN Number. The customer of an affected vehicle may fail to pass an I/M test due to a non-compliant 17digit vehicle identification number (VIN) stored in the DME (Digital Motor Electronic). The VIN read out and displayed on the state test printout does not match the actual VIN of the vehicle. If the DME was reprogrammed using the previously available BMW service equipment (e.g., Progman, GT1), it is possible that only the last 7 digits of the VIN were entered into the DME, and positions 4 through10 may only contain default characters. For example: The state I/M tester or OBD scan tool may read out WBAAA00000A123456 instead of the correct full 17-digit VIN, WBAZZ03492A123456.
Associated Products (60)Associated Documents - September 1, 2013•Document ID: 10053585Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:ENGINE:DIESEL
- Mfr Comm. #:
- SIB-17-02-09
- Date Added:
- November 8, 2013
- Manufacturer:
- BMW
SummaryBMW: OIL LEAKS FROM THE AIR HOSE ON TURBOCHARGER. THIS IS DESIGNATED FOR E70, AND E90 MODELS WITH M57Y DIESEL ENGINES. SERVICE ENGINE SOON LAMP MAY BE ILLUMINATED. *KB
Associated Products (26)Associated Documents - July 1, 2013•Document ID: 10150039Service Bulletin/Repair InstructionsEQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL; EQUIPMENT; VISIBILITY:SUN/MOON ROOF ASSEMBLY
- Mfr Comm. #:
- 541309
- Date Added:
- December 3, 2018
- Manufacturer:
- BMW
Summary"?Panoramic Sunroof Repair Instructions. INFORMATION Sunroof Repair Instructions: The panoramic sunroof contains several ""mechanism sets"" which can be repaired and/or replaced independently in the event of a mechanical failure. When performing such a repair to any of these sets, the TIS/ISTA Repair Instructions (REP) should always be consulted. Due to the complex nature of these repairs, a set of complementary instructions with additional detail, explanation, and photos has been developed. The attached Repair Instructions should always be used in conjunction with the TIS/ISTA REP. "
Associated Products (38)Associated Documents - May 1, 2013•Document ID: 10149603Service Bulletin/Repair InstructionsVISIBILITY
- Mfr Comm. #:
- 541309
- Date Added:
- November 26, 2018
- Manufacturer:
- BMW
Summary"Panoramic Sunroof Repair Instructions. INFORMATION Sunroof Repair Instructions: The panoramic sunroof contains several ""mechanism sets"" which can be repaired and/or replaced independently in the event of a mechanical failure. When performing such a repair to any of these sets, the TIS/ISTA Repair Instructions (REP) should always be consulted. Due to the complex nature of these repairs, a set of complementary instructions with additional detail, explanation, and photos has been developed. The attached Repair Instructions should always be used in conjunction with the TIS/ISTA REP. Refer to the following repair attachments: Front Glass Mechanism repair E53, E61, E70, E83, E91.pdf Rear Glass Mechanism repair E53, E61, E70, E83, E91.pdf Wind Deflector Mechanism repair E53, E61, E70, E83, E91.pdf Sunshade Mechanism repair E53, E61, E83.pdf Sunshade Mechanism repair E70, E91.pdf All panoramic roofs for the above-listed models are conceptually similar and utilize similar repairs. NOTE: An E83 (X3) sunroof cassette is used for demonstration of the repairs. Some differences may exist between this and other models. The following prerequisite work is required in order to replace the following kits (in addition to removing the cassette from the car and glass from the cassette): Front Glass Mechanism - None. Rear Glass Mechanism - Remove the front glass mechanism. Wind Deflector Mechanism - Remove the front glass mechanism; remove the rear glass mechanism. Sun shades and Shade Mechanism - None Sunroof Mechanical 3D Animation: A 3D animation has been developed in order to clarify how the sunroof mechanism operates, as well as how it is assembled and disassembled. To view this animation, open Interactive Career Pathways (ICP) and select ""Replace Front and Rear Glass Panel Mechanic"" from the Technical Service Information section of the home page. This animation allows you to: * Operate the mechanism and view from any angle; * Add or remove parts and then cycle the sunroof; * S
Associated Products (38)Associated Documents - March 1, 2013•Document ID: 10051971Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; ELECTRICAL SYSTEM:12V/24V/48V BATTERY
- Mfr Comm. #:
- SIB-61-05-12
- Date Added:
- April 25, 2013
- Manufacturer:
- BMW
SummaryBMW: BATTER DISCHARGED BECAUSE OF UNFAVORABLE DRIVING PROFILE. THIS IS CAUSED ON SHORT TRIPS (LESS THAN 3 MILES) OR WHEN THE TELEPHONE OR ENTERTAINMENT SYSTEM IS USED FOR UP TO 30 MINUTES WHILE VEHICLE IS STATIONARY. MODELS X5, X6 ALL MODEL YEARS AFFECTED. *KB
Associated Products (29)Associated Documents - March 1, 2013•Document ID: 10040177Service Bulletin/Repair InstructionsEXTERIOR LIGHTING:BRAKE LIGHTS
- Mfr Comm. #:
- SIB-63-10-09
- Date Added:
- August 16, 2011
- Manufacturer:
- BMW
SummaryBMW: THE BRAKE LIGHT FAILS AND THE BULB HOLDER IS DEFORMED DUE TO HIGH TEMPERATURES AND THE COMPOSITION OF THE HOLDER. *RM UPDATED ON 4/25/2013. *KB
Associated Products (16)Associated Documents - December 1, 2012•Document ID: 10051419Service Bulletin/Repair InstructionsFUEL SYSTEM, GASOLINE
- Mfr Comm. #:
- SIB160712
- Date Added:
- March 6, 2013
- Manufacturer:
- BMW
SummaryBMW: SERVICE ACTION: REPLACE THE LEFT AND RIGHT FUEL LEVEL SENSOR. DUE TO HIGH PROPORTION OF ETHANOL IN THE FUEL, THE INTERNAL MECHANISMS OF THE FUEL LEVEL SENSORS MAY SWELL. THIS MAY INHIBIT THE MOVEMENT OF ONE OR BOTH OF THE FUEL LEVEL SENSORS. *JS
Associated Products (29)Associated Documents - December 1, 2012•Document ID: 10051299Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- SIB-010511
- Date Added:
- March 5, 2013
- Manufacturer:
- BMW
SummaryBMW: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. N52K ENGINE DMTL PUMP: EMISSIONS WARRANTY EXTENSIONS TO 10 YEARS/120,000 MILES. BMW HAS BECOME AWARE OF A POTENTIAL PROBLEM WITH THE DURABILITY OF THE TANK LEAK DIAGNOSTIC MODULE (DMTL) PUMP ON MY 2007,2008, AND 2009.*JS
Associated Products (15)Associated Documents - September 1, 2011•Document ID: 10042704Service Bulletin/Repair InstructionsEXTERIOR LIGHTING:HEADLIGHTS
- Mfr Comm. #:
- SIB-63-05-11
- Date Added:
- January 7, 2012
- Manufacturer:
- BMW
SummaryBMW: ON CERTAIN VEHICLES, THE XENON HEADLAMP OFTEN HAVE NO TROUBLE FOUND WHEN RETURNED AND TESTED THRU WARRANTY PARTS SYSTEM. THE ROOT CAUSE IS NOT POSSIBLE TO BE IDENTIFY. *PE
Associated Products (26)Associated Documents - August 1, 2011•Document ID: 10029605Service Bulletin/Repair InstructionsAIR BAGS
- Mfr Comm. #:
- SIB-65-75-06
- Date Added:
- July 13, 2009
- Manufacturer:
- BMW
SummaryBMW SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. THE AIRBAG WARNING LAMP (AWL) IS ILLUMINATED, TOGETHER WITH THE PASSENGER AIRBAG STATUS LAMP (POL). THE PROBLEM MAY BE INTERMITTENT. MICROCRACKS IN THE OC3 SEAT MAT. *PE UPDATED 9/30/11. *PE
Associated Products (14)Associated Documents - July 1, 2011•Document ID: 10040852Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:ENGINE
- Mfr Comm. #:
- SIB-12-15-11
- Date Added:
- September 13, 2011
- Manufacturer:
- BMW
SummaryBMW: THE SERVICE ENGINE SOON LIGHT IS ON. THERE ARE TROUBLE CODES STORED FOR THE CRANKSHAFT SENSOR. NO DRIVEABILITY ISSUES. *RM
Associated Products (31)Associated Documents - October 1, 2010•Document ID: 10037238Service Bulletin/Repair InstructionsSEATS:FRONT ASSEMBLY:POWER ADJUST
- Mfr Comm. #:
- SIB-52-08-09
- Date Added:
- May 14, 2011
- Manufacturer:
- BMW
SummaryBMW: THERE ARE NOISES WHEN ADJUSTING THE FRONT DRIVER OR PASSENGER SEATES. *RM
Associated Products (20)Associated Documents - September 1, 2010•Document ID: 10037078Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:WIRING; ELECTRICAL SYSTEM:SOFTWARE; AIR BAGS
- Mfr Comm. #:
- SIB-65-36-09
- Date Added:
- May 4, 2011
- Manufacturer:
- BMW
SummaryBMW: THE AIRBAG WARNING LAMP IS ILLUMINATED DUE TO A SOFTWARE ERROR. *RM
Associated Products (21)Associated Documents - August 1, 2010•Document ID: 10037027Service Bulletin/Repair InstructionsSTRUCTURE:BODY:TAILGATE; ELECTRICAL SYSTEM:WIRING
- Mfr Comm. #:
- SIB-51-26-10
- Date Added:
- April 28, 2011
- Manufacturer:
- BMW
SummaryBMW: MODEL E70 EQUIPPED WITH AN AUTOMATIC TAILGATE. THE REAR TAILGATE MAY NOT OPERATE IN EITHER DIRECTION DUE TO WIRING DAMAGE. *RM
Associated Products (13)Associated Documents - August 1, 2010•Document ID: 10037026Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:12V/24V/48V BATTERY; ELECTRICAL SYSTEM; EQUIPMENT:ELECTRICAL
- Mfr Comm. #:
- SIB-61-08-10
- Date Added:
- April 28, 2011
- Manufacturer:
- BMW
SummaryBMW: ELCTRONICALLY DISCONNECTING THE JUNCTION BOX WITHOUT DISCONNECTING THE BATTERY WILL CAUSE DAMAGE TO THE REAR POWER DISTRIBUTION BOX. *RM
Associated Products (25)Associated Documents - August 1, 2010•Document ID: 10037025Service Bulletin/Repair InstructionsEXTERIOR LIGHTING
- Mfr Comm. #:
- SIB-63-02-01
- Date Added:
- April 28, 2011
- Manufacturer:
- BMW
SummaryBMW: PROCEDURE FOR DETERMINING AND REPLACING INCANDESCENT AND HALOGEN LIGHT BULBS UNDER WARRANTY. *RM
Associated Products (217)Associated Documents - July 1, 2010•Document ID: 10037010Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:ENGINE
- Mfr Comm. #:
- SIB-11-08-03
- Date Added:
- April 27, 2011
- Manufacturer:
- BMW
SummaryBMW: SIX DIFFERENT MODELS EQUIPPED WITH THE M54 ENGINE COULD HAVE VALVE COVERS BREAK IN COLD WEATHER AND RUIN THE ENGINE. THIS IS DUE TO MOISTURE ACCUMULATION. *RM
Associated Products (27)Associated Documents