Volvo XC90 Complaints (2016)

197 consumer complaints on file.

#11461846April 22, 2022
STRUCTURE:BODY
Rear Door lock failed with the first symptom of not being able to open the door. Once door was opened the door failed to close/latch. I think this is a safety concern because it would be impossible to get at the rear seat occupant in the event of a crash/heath issue. Then once the door finally opened it failed to latch which made it dangerous to drive the car at all because the door would fling open.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11456883March 15, 2022
ENGINE, UNKNOWN OR OTHER
There is an open recall for certain 2016 XC 90s related to cracks in the coolant pipes. My vin doesn’t have a recall attached but in the last 2.5 years I have owned the vehicle I have had to change this part 2 times. I feel my vin/vehicle should be part of the recall. My local dealer is not willing to assist nor Volvo Customer Service.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11456338March 11, 2022
ENGINE
Engine oil Level decreases rapidly, this can cause the engine to burn up and possibly catch file or lock the engine. Dealer has started oil consumption test.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11455801March 9, 2022
PARKING BRAKE:ELECTRICAL
The contact owns a 2016 Volvo XC90. The contact stated that upon start of her vehicle, the parking brake message and a yellow flashing brake light appeared on the instrument panel. The contact took the vehicle to the dealer where they informed her that a wire connected to the parking brake was detached and need to be replaced. The contact was given an estimate for the repair and the wire was replaced. The manufacturer was notified of the failure and offered no assistance; the manufacturer referred her to NHTSA to file a complaint. The vehicle had been repaired. The failure mileage was approximately 128,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11454986March 3, 2022
AIR BAGS, ELECTRICAL SYSTEM, SEATS
While driving the vehicle the "SRS Airbag" warning light comes on, I took the vehicle to the dealership which indicated the "seat harness" would need to be replaced. The seat harness has a integrated chip to alert the airbags to work properly. Volvo has had previously recalls for this issue on 2016 XC 90 vehicles but my VIN isn't included in the recall, I feel they need to expand the recall knowing their are several vehicles having this exact issue. Air bags are federally regulated and this is a safety related issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11453307February 21, 2022
UNKNOWN OR OTHER
The door lock actuators were poorly designed, allowing water intrusion. This causes the actuator to rust and freeze up making it impossible to unlock the door and open it from the inside or outside. There was no warning about this, it just stopped working one day. If someone had been in the backseat when it stopped working they would have had to crawl across to the other side to get out. What if there had been an accident and you could not get your child or baby out the nearest door quickly. We have been waiting nearly three weeks now for the replacement part, a part we were told by Volvo has been redesigned so this should not happen again. A part we (our insurance) has to cover. What about the other locks on the car, are they going to fail and lock us in the car? Why is Volvo not replacing these actuators.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11451404February 10, 2022
ENGINE
Leaking Coolant @44,804 miles: I was told it's not covered by the warranty and I had to pay out of pocket for the repair at the dealership. Now I just learned Volvo recalled 34,600 of the 2016 Volvo XC90 with the same problem in Year 2019, and my car's VIN is not on the list even though it's the same model, year and the same problem. Burning Excessive Engine Oil started @ 48,000 miles. I want to know if the problem is covered under the extended warranty I bought. There are a lot of similar complaints online. Refer to https://www.swedespeed.com/threads/2016-xc90-burning-massive-amounts-of-oil.639838/ Leaking Coolant @ 50,000 miles again.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11449685February 1, 2022
ENGINE
My car has begun to burn excessive oil. I am having to use 1 quart of oil every 1,000 miles. This is in addition to getting a routine oil change. Took vehicle to Volvo dealership for an oil consumption test, cost around $550, and had to drive 1245 miles and then bring car back. Brought car back and dealership confirmed car is using/burning excessive oil. Issue is with the o rings and gaskets needing to be replaced. Employee at dealership said this is known issue with the 2016 model burning excessive oil. Many threads online relating/reporting the same issue about oil consumption and believe a recall is warranted to fix this know issue with Volvo. Mileage is around 89k.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11447529January 14, 2022
UNKNOWN OR OTHER
Rear doors stop opening from outside and interior
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11446840January 10, 2022
STRUCTURE:BODY
In freezing weather conditions the rear door latches become inoperable. They close fully, but do not latch. My wife was backing out of the driveway this morning an a door opened next to my son. This is UNACCEPTABLE and Volvo has not responded in an acceptable manner. I was told to bring it in for service.... it has only 3 functioning doors at the moment!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11443923December 15, 2021
ENGINE
I purchased my vehicle used in February 2021. On the morning of December 14, 2021 we got a low coolant warning, please pull over safely message on the way to work. We just so happened to be near a gas station and was able to put half a container of 50/50 coolant and continue driving. On our return home we got the same message but noticed a major leak once we made it home. We had Volvo tow the vehicle to Northpoint Volvo in Alpharetta, GA and it appears to be having the exact same issue as what was previously preparing under recall 19V-308. I tried reporting this to the dealer and Volvo Customer Service but both tell me the recall was fixed in 2019 for my vehicle. If the issue is "fixed" how can I be facing the EXACT same issue just two years later.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11443475December 11, 2021
STRUCTURE:BODY
Door lock unable to open. Door is unlocked and the outside and inside fail to open the door. Door lock actuator is jammed
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11443190December 9, 2021
TIRES, TIRES:TREAD/BELT
I just recently bought this car. And there was a vibration and a pull to the right so I brought it back to the dealer which is echo Park of Tampa. I said they needed to do the alignment and balance and they did that and it still is doing all the same things and the shaking is progressively becoming quickly I experienced this exact same thing in my Mazda that also had Continentals on it. And brought it back to the dealer four times in 9 months and they put brand new set of Continentals on every time and the same shaking would quickly reoccur. And shortly after I traded that Mazda in the tires were recalled. Experiencing the same exact symptoms with my Volvo with these Continental tires these are eco technology cross contact 235 55 R19 (105v) There's no specific incident nor a specific tire. This is every time (all tires) you get in the car from every mile per hour from the second you start moving to 70 or 80 and the shaking is getting progressively worse. I will be contacting Continental cuz I'm not sure if these are even added on the recall list but they need to be. It's scary driving especially since i nearly died in an auto accident because of a tire blow out.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11431716September 4, 2021
ENGINE
We just purchased this 2016 Volvo XC90 last week from an out of town dealer and it suddenly sprung a major coolant leak this morning while driving and isn’t safely drivable without fire hazard as it’s getting so hot. This model was part of recall on coolant hoses, but is listed as having 0 pending recalls on the nhtsa website.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11417805May 19, 2021
ELECTRICAL SYSTEM, ENGINE, POWER TRAIN
The attached file outlines details - 1.After a recent car wash at a Shell Service Station…..April 5,2021, upon starting the vehicle – the computerized dashboard displayed erratic and incomplete information. It attempted to indicate multiple system failures – eg brakes, suspension, and others too garbled to understand. The entire driver’s console and information center display which were designed to show all of the vehicle operating modes and driver information were compromised and not functioning correctly. The Start/Stop Switch would no longer shut the engine down. I could not get the vehicle to shift out of Park. I found myself quite concerned about a highly computerized vehicle now running with no apparent operator control. I could not be certain whether the engine was being cooled properly from its electrical fans because the cabin was becoming uncomfortably hot. None of the environmental controls worked. Even the electric windows were affected. There were no engine safety indicators of any kind visible working to ensure electrical, engine oil pressure, coolant temperature….none of the other operator information systems were working properly and the engine still could not be shut down. I found myself uncomfortable getting out of the vehicle since it has so many self-driving, collision avoidance steering and braking functions that could be affected. I did not want to risk being run over by my own car. Nor, could I allow the vehicle to move, possibly on its own…so I sat in it for about 3 hours sweating while waiting for a Volvo Tow Service to arrive. The Tow operator was somehow able to get the gear shift to move and was able to back the vehicle out to the street and onto his truck. He was also unable to shut the engine down and towed it to the Neillo Volvo Dealership about 3.5 miles away, here in Sacramento CA. I had deep concerns about safety with this vehicle being towed with the engine still running. All of the instrumentation remained unusable. The consumer stated after the sunroof clogged d
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11416043May 11, 2021
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, LANE DEPARTURE: BLIND SPOT DETECTION, FORWARD COLLISION AVOIDANCE: WARNINGS
MY ROOF IS LEAKING, IT WAS COMING OUT THE FRONT CABIN LIGHT. THIS PROBLEM CAN BE FOUND NOTED ON MANY WEBSITES WITH PICTURES FOR MY YEAR/MODEL. THEN WE STARTED GETTING ERRORS WITH SUSPENSION AND MY WIFE GOT A WARNING SHE SHOULD STOP THE CAR. SHE GOT IT HOME AND WE FOUND THE WATER HAD NOW LEAKED INTO THE REAR RIGHT QUARTER PANEL WHERE AT LEAST 1 COMPUTER IS STORED. THAT AREA HAD AT LEAST 1' OF WATER IN IT. I HAD TO PULL A DRAIN PLUG TO DRAIN IT. THE DEALERSHIP CONFIRMED THE COMPUTER WAS FRIED ($2600) AND HAD PREVIOUSLY SAID OUR DRAINS WERE CLEAR AND THE FIX WAS A NEW REAR SEAL. WHILE THEIR ANOTHER PERSON HAD JUST GOTTON THAT SUNROOF $2K FIX ON THEIR CAR. THE COMPUTER HAS DISABLED THE BLIND SPOT LIGHTS ON THE SIDE MIRRORS, FRONT COLLISION WARNING AND ASSUME AUTO BRAKING, THE REAR CAMERA IS OUT, AND GPS. THESE ARE THE THINGS THAT ARE OBVIOUS, I DON'T KNOW WHAT ELSE IS DISABLED I DON'T KNOW. THE DEALER ALSO SAID THEY WERE LIMITED ON THE FAULT CODES THEY COULD GET BECAUSE OF THE FAILURE AS WELL. IN DOING MORE RESEARCH FOR 'VOLVO SUNROOF LEAK' I FOUND A SITE CALLED TOPCLASSACTIONS.COM WITH SEVERAL INDIVIDUAL INCIDENCES OF NEWER YEARS AND OTHERS MODELS WHERE THE ROOF LEAKS INTO THE REAR AND FRIES THE COMPUTER. ONE NOTED ' THAT HAPPENED WHILE I WAS DRIVING! I LOST BRAKES AND ENGINE POWER, THE GEAR BOX GOT LOCKED. EVENTUALLY I PULLED INTO PARKING LOT. AT THAT POINT I TRIED TO TURNED OFF THE ENGINE OF THE CAR BUT IT WOULDN'T LET ME.' SOMEONE ELSE NOTED BRAKE FAILURE AS WELL. THE SUNROOF ISSUE IS NOT UNCOMMON AND VOLVO IS GIVING CONSUMERS THE RUN AROUND WHEN THEIR DESIGN LEAKS AND DAMAGES THE COMPUTER CONTROLLING KEY SAFETY FEATURES. THESE ARE 'NEW' CARS 2016 AND UP. THERE ARE ALSO INSTANCES WHERE THE CONSUMER PAYS TO GET THE LEAK 'FIXED' AND IT CONTINUES TO LEAK THEREFORE INCREASING THE CHANCE OF THE SAFETY COMPUTER FAILING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11415268May 5, 2021
STRUCTURE:BODY
MY PASSENGER REAR DOOR HANDLE BROKE INTERNALLY WHERE IT COULD NOT BE OPENED FROM THE INSIDE OR THE OUTSIDE OF THE VEHICLE. BOTH REAR DOOR HANDLES FAILED AND AFTER DRIVING AROUND WITH MY KIDS HAVING TO GO IN AND OUT OF THE CAR THROUGH THE FRONT I FINALLY RECEIVED A LOANER FOR 5 WEEKS UNTIL THE PARTS WERE AVAILABLE TO REPAIR THE DOORS. IT APPEARS THE FRONT DRIVER AND FRONT PASSENGER HANDLE MAY FAIL. IT IS VERY SCARY TO HAVE YOUR KIDS IN A CAR AND NOT BE ABLE TO OPEN THE DOOR FROM THE INSIDE OR THE OUTSIDE. I LOOKED ONLINE AND THERE WERE LOTS OF RECENT ACCOUNTS OF XC90 AND XC60S HAVING THIS ISSUE IN EUROPE AND AMERICA. THE DEALERSHIP SAID IT WASN'T COVERED UNDER THE WARRANTY. I ENDED UP PAYING FOR THE LABOR AND VOLVO CORPORATE PAID FOR THE $900 PART INSIDE THE DOOR.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11413653April 24, 2021
STRUCTURE:BODY, ELECTRICAL SYSTEM, VISIBILITY/WIPER
WHEN DRIVING MY VOLVO AFTER IT HAS RAINED AND I BEGIN TO BREAK, WHILE ON A ROAD WITH A MINIMAL DECLINE, RAIN WATER POURS INTO THE CABIN. I WAS TOLD BY VOLVO SERVICE TECHNICIANS THE WATER IS NOT ABLE TO CHANNEL THROUGH THE SUNROOF CHANNELS CORRECTLY DUE TO CORROSION OR CLOGGING IN THE DRAINAGE TUBES/SUNROOF TRAY ASSEMBLY. THE WATER POURS INTO THE CABIN NEAR THE INTELLISAFE/REARVIEW MIRROR AREA. THIS EVENT CREATES A DISTRACTION TO THE DRIVER ESPECIALLY IF BREAKING WHILE ON A RIGHT HAND CURVE AS THE WATER POURS OUT TOWARDS THE DRIVERS FIELD OF VISION. FOR FEAR OF WATER DAMAGING ANY ELECTRICAL SAFETY COMPONENTS, OR THE INTEGRITY OF THE INTERIOR MATERIALS I PULL OVER TO DRY THESE COMPONENTS. THIS EVENT OCCURS WHEN EVER IT RAINS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11413390April 22, 2021
ENGINE
TL* THE CONTACT OWNS A 2016 VOLVO XC90. THE CONTACT STATED WHILE DRIVING 70 MPH, THE VEHICLE STARTED LOSING MOTIVE POWER AS THE REDUCED ENGINE PERFORMANCE WARNING LIGHT ILLUMINATED. THE CONTACT HAD THE VEHICLE TOWED TO FLORENCE TOYOTA (2300 W. PALMETTO ST, FLORENCE, SC 29501) WHERE THE MECHANIC REPLACED THE SPARK PLUGS HOWEVER, CYLINDER #2 WAS STILL UNRESPONSIVE. THE VEHICLE WAS THEN TOWED TO BEACH VOLVO (855 JASON BLVD #2, MYRTLE BEACH, SC 29577) WHERE THE VEHICLE WAS DIAGNOSED AND SHE WAS INFORMED THAT THE ENGINE NEEDED TO BE REPLACED. THE CONTACT THEN HAD THE VEHICLE TRANSFERRED TO STILLMAN VOLVO CARS (1290 WILMINGTON PIKE, WEST CHESTER, PA 19382) WHERE SHE WAS INFORMED THAT A PIECE OF CYLINDER HAD FRACTURED AND IT APPEARED AS THOUGH RODENTS MIGHT HAVE TAMPERED WITH THE CYLINDER LEADING TO THE ENGINE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND A CLAIM WAS FILED. THE VEHICLE WAS NOT YET REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 105,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11412820April 19, 2021
UNKNOWN OR OTHER
THE INSIDE DOOR HANDLES (LEVERS TO OPEN THE DOORS)- HAVE A THICK METALLIC PAINT THAT CHIPS OFF AND CAUSES FINGERS TO BE CUT.
Crash:
No
Fire:
No
Injuries:
2
Deaths:
0

← Back to Volvo XC90