Volvo XC90 Complaints (2019)

42 consumer complaints on file.

#11661326May 15, 2025
UNKNOWN OR OTHER
Car shut off while driving and rebooted. Was precessed by the infotainment system crashing and then rebooting a minute prior. Car made a sound like a grunting sound right as it shut down.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11651860March 31, 2025
ELECTRICAL SYSTEM
There was a leak on the evaporator coil within the AC system for this car. We started having issues with the AC around the 56,500 mile mark ([XXX]). After a couple of rounds of recharging the system with refrigerant and looking for a leak, the repair shop finally found the leak on the evaporator coil system. The repair was quoted cost $4,854.03. The evaporator coil During the summers when the AC was not working, this was definitely a safety concern. Riding in the car with no AC in the summertime in Hawaii is brutal. The $4,854.03 cost for the evaporator coil replacement, did not include the amount of money we spent the first two go arounds looking for the leak and recharging the system with refrigerant. After doing some research and talking to the repair shop the evaporator coil replacement work it seems that this is a very common failure on this model/year Volvo. I also noticed it looks like they already had a similar recall out for this failure on other similar Volvos. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) I would like to have Volvo USA to address this issue and fix this common issue and recall this year model.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11635297January 10, 2025
VISIBILITY, AIR BAGS, SEAT BELTS
The contact owns a 2019 Volvo XC90. The contact stated that after stopping and parking the vehicle, the vehicle failed to turn off. The contact's fiancée arrived on the scene and was able to turn off the vehicle; however, the vehicle later failed to restart, and the gear shifter seized. The message "Gear Lever Lock" was displayed. The vehicle was towed to an independent mechanic, who diagnosed that the panoramic sunroof seal strip had a gap, allowing debris and water into the vehicle, clogging the drain, and rendering the vehicle inoperable. The mechanic disassembled the entire interior and allowed it to dry before reassembling. The contact was informed that the front passenger’s side air bag sensor, seat belt buckle, and seat belt tensioner needed to be replaced. The vehicle was not repaired. The contact related the failure to Technical Service Bulletin: TJ 35503.3.0 (Panoramic sunroof, sealing strip has a gap). The manufacturer was made aware of the failure. The failure mileage was approximately 65,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11629383December 7, 2024
UNKNOWN OR OTHER
There was a leak on the evaporator coil within the AC system for this car. We started having issues with the AC around the 56,500 mile mark ([XXX]). After a couple of rounds of recharging the system with refrigerant and looking for a leak, the repair shop finally found the leak on the evaporator coil system. The repair was recently completed on 10/22/2024 at the cost $4,254.03. This car has roughly 66000 miles on it now (12/07/2024). The evaporator coil During the summers when the AC was not working, this was definitely a safety concern. Riding in the car with no AC in the summertime in South Carolina is brutal. The $4,254.03 cost for the evaporator coil replacement, did not include the amount of money we spent the first two go arounds looking for the leak and recharging the system with refrigerant. After doing some research and talking to the repair shop who completed the evaporator coil replacement work it seems that this is a very common failure on this model/year Volvo. I also noticed it looks like they already had a similar recall out for this failure on other similar Volvos. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11629386December 7, 2024
ENGINE
Vin: [XXX] We just had the starter go bad at roughly 66000 miles. When the repair shop had removed the bad starter they noticed a very odd failure. The nut/stud on the starter was stripped. They stated that this was definitely from a manufacturing defect. I can provide the bad starter and receipt of the cost of replacement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11621462October 23, 2024
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
The contact owns a 2019 Volvo XC90. The contact stated while reversing out of a parking space, the contact depressed the brake pedal; however, the vehicle failed to stop. The contact pumped the brake pedal and then depressed the brake pedal to the floor for the vehicle to come to a stop. There were no warning lights illuminated. The vehicle was towed to be diagnosed and it was determined that the brake master cylinder and the brake booster had failed internally, causing a vacuum leak. The contact was informed that the brake master cylinder and brake booster needed to be replaced, the brake lines needed to be bled, and the brake control module needed to be calibrated. The vehicle was scheduled to be repair but had not yet been repaired. The manufacturer was made aware of the failure. The failure mileage was 49,800.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11621625October 23, 2024
UNKNOWN OR OTHER
The chrome trim started peeling on the center console, near cup holders. This revealed a razor sharp edge on which I cut my finger. All of the exterior door handles have chrome trim and are peeling. Last week my [XXX] daughter cut her finger as a result of a sharp peeled chrome edge. Many reports of this on volvo forums. Some dealers will repair for free, others want to charge for this defective, safety hazard. My service provider said they could not fix for free and wanted $3800 for the repair. This is a known issue and a safety hazard that Volvo is not addressing, see for example: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
2
Deaths:
0
#11600947July 10, 2024
SERVICE BRAKES, HYDRAULIC
The contact owns a 2019 Volvo XC90. The contact stated that while stopped and attempting to accelerate, the brake became inoperable. There were no warning lights illuminated. The vehicle was towed two times and taken to the local dealer, where it was diagnosed three times that the brake booster had failed. The vehicle was repaired, but the failure persisted. The manufacturer was not contacted. The failure mileage was unknown. The VIN was not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11597916July 1, 2024
ENGINE
Engine began to misfire. According to Volvo, there is a problem with the valve ring(s) not sealing, oil coming into the #4 piston chamber and excessive oil consumption. Vehicle has under 95K miles, and has been properly maintained, but Volvo is saying we are outside warranty period.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11575869March 6, 2024
UNKNOWN OR OTHER, AIR BAGS, ELECTRICAL SYSTEM
There are many form online stating that Volvo has an issue with water leaking/water drainage line from the sunroof. The water leaked into some components of the airbag and electrical system. After the first time taking to the dealership they were no issue with the system and the vehicle was fine that incident happened back in 2020. The same issue happened again where water was leaking in from the sunroof area (I am assuming because it looks the same as last time) this time the water is in the driver side, and there was a puddle of water forming where the gas and brake paddles are. After noticing the water puddle I try to close the sunroof and turns out the sunroof no longer functions with the electronic control right in front of the sunroof. I also took the initiative to open some of the trims where the side air bags are and it turns out that the area are completely soaked. I do no know if this will cause an issue to the airbag or not but I am worries that prolong exposure to water will compromised the integrity of the airbag system. What's was is that since it affected the electronic for the sunroof what if it affect the sensors for the air bag system.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11566201January 18, 2024
STRUCTURE:BODY, ELECTRICAL SYSTEM, LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Rear passenger door won’t open. We had freezing temps in Colorado, when I tried to open the rear door to get my 2 month old out of the car the door would not open. Apparently this is a known problem for this vehicle the rear door motors spontaneously stop working.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11566341January 18, 2024
UNKNOWN OR OTHER
Air conditioning failed to function as soon as vehicle lease was up. Less than 45k miles on a 3 year old car. Stopped working, hot air blowing in the middle of summer no less. This does not appear to be a part that is on the maintenance interval list. This does not appear to be an isolated incident when researching this fault now over a year later.The climate control system failing on a new car on a part that cannot be reasonably serviced seems problematic to say the least. I asked the dealer to consider a good will repair on more than one occasion as I had literally just moved from a lease to a finance purchase. No luck on that.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11542433September 4, 2023
AIR BAGS
AIRBAG LIGHT WAS ON. DEALER VERIFIED AIRBAG WARNING LIGHT ON. CONNECTED TO VIDA AND RECEIVED CODE (SRS-BB15381B HIGH VOLTAGE BATTERY POWER SUPPLY DISCONNECT DEPLOYMENT LOOP CONTROL. GENERAL ELECTRICAL FAILURES. CIRCUIT RESISTANCE ABOVE THRESHOLD ). THEY REPLACED TERMINALS 11 & 12 IN THE LOW VOLTAGE CONNECTOR AT THE HIGH VOLTAGE BATTERY. REFERENCING TJ 37119-0. MY VOLVO FACTORY EXTENDED WARRANTY WOULD NO COVER THE REPAIR.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11541932August 31, 2023
ENGINE
According to Volvo, there is a problem with the valve ring(s) not sealing, oil coming into the #1 piston chamber and excessive oil consumption. However, they have yet to provide everything clearly in writing with an explanation. As mileage was about 89K when we first brought into them for what we viewed as major engine problems, they are saying we are outside warranty period.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11501084January 10, 2023
ELECTRICAL SYSTEM
The contact owns a 2019 Volvo XC90. The contact stated that upon returning to the vehicle, she noticed that her sunglasses case and tennis can located in the interior of the vehicle had been chewed. The contact stated that upon looking further, she noticed that the third row seats leather coating had been chewed. However, the contact had not transported pets on the vehicle. The vehicle was taken to the dealer who inspected the vehicle and informed the contact that rodents were entering the interior of the vehicle through a hole they had created on the rubber seal between the dashboard and the engine compartment. The dealer informed the contact that the rodents were attracted by the soy-based wires coating. The manufacturer was notified of the failure of the failure and informed the contact that she would need to pay a repair fee as the vehicle would not be repaired under warranty. The dealer replaced the leather coating on the seats and the seats stuffing. The dealer installed a new seal on the hood, wrapped tape around the soy-based wires coating to prevent rodents intrusion. The vehicle was repaired. The failure mileage was approximately 38,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11480231August 19, 2022
SERVICE BRAKES, BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
On 23rd July 2022 my son went underneath a reversing XC90 2019 vehicle. The front wheel went over his leg and arm. He miraculously survived and the event was close to taking his life. The vehicle was my wife's car. We are in possession of the surveillance video which shows that the vehicles safety features failed. Although the vehicle was left in the reverse gear, the car was stationary, after having been in a forward motion. This sequence automatically engages the park brake and only deactivated when the pedal is pressed. The pedal was not pressed. In addition the video shows the door was open when the brake was deactivated. Another safety feature which failed to prevent the event. My wife was outside of the car and pushing on the rear of the car, trying to stop it driving over my son. Both my wife at the rear bumper and my son on the floor behind the vehicle on the floor, failed to activate the reverse sensors safety feature. Although a small post did after the vehicle drove over my son. I have a video I can email but is too big for the upload feature. Please let me know how to send the video: be warned the video is not very pleasant. After the event I had the vehicle codes read at the local Volvo dealership. Multiple codes related to failures in the parking brake were identified. I contact Volvo and have been assisting them over the last two weeks with their investigation. They have had the car for 4 hours to run this investigation and I am aware the engineers in Sweden are involved. They have now come back to me and asked to see the vehicle again to read more codes. I have been very disappointed in Volvo through this process. The video clearly shows an "Event". and they keep referencing back to the car being fine at the point of the inspection; failing to reference or acknowledge the event timing itself. I am at the point I need to make sure their investigation is being done correctly, since I feel they are playing with words and not telling me the truth.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11471587June 29, 2022
ELECTRICAL SYSTEM, VISIBILITY:SUN/MOON ROOF ASSEMBLY
Water damage to the electrical system from blocked drainage by sunroof; potential mold damage
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11464259May 11, 2022
STRUCTURE:BODY
The rear right passenger door is stuck in a locked state. It's not possible to open that door from the interior or the exterior. Locking and unlocking the doors does not solve the problem. Activating and deactivating the child lock system does not solve the problem either. Turning the engine on and off does not solve the problem. This is extremely unsafe in case of a collision where the passenger needs to be evacuated from the car with no access to the other side of the vehicle. The car has not been inspected by anybody, yet. I'll take the vehicle to the dealership for repair. The door has been like this for a several days now, as of 05/11/2022. There were no signs or other symptoms prior to this problem. There are no signs or messages about this malfunction. Upon looking online on some Volvo owners forums, this problem has occurred to more people before on different models as well. To be clear, this is not a case of the door being stuck due to low temperatures. It has been well above the 40's in the last week at my location in South County, Rhode Island.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11439155November 3, 2021
SERVICE BRAKES
The front rotors on my truck had to be changed twice already. The truck has 25k miles on it. The dealer warrantied them both times but they keep putting in the same kind of rotors. After a few month of driving with the new rotors the steering starts to shake when brakes are applied. The front brake pads also wear out pretty quickly. With only 25k miles they told me I needed new ones. I have invoices if needed to prove the rotors have been changed twice
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11428347August 9, 2021
ELECTRICAL SYSTEM, POWER TRAIN:AUTOMATIC TRANSMISSION
The contact owns a 2019 VOLVO XC90. The contact stated that while her foot was on the brake pedal and while talking with a friend outside her vehicle, she had decided to place the vehicle into park. After approximately 8-10 minutes, the vehicle independently accelerated forward without warning and crashed into her friend's garage door. The air bags deployed immediately upon impact. An automatic safety feature on the vehicle detected the crash and automatically notified the police; a police report was filed. The contact sustained bruising to her left arm and leg and the passenger sustained bruising to her stomach. Due to the failure, the contact had the vehicle towed a dealer where it remained in their possession. The manufacturer had yet to be notified of the failure. The contact's insurance was able to retrieve the EDR report from the vehicle which showed that the vehicle accelerated prior to the crash; however, it did not determine if the vehicle was in parking gear when it crashed. The vehicle had yet to be repaired. The failure mileage was approximately 50,000.
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0

← Back to Volvo XC90