Volvo XC40 Complaints (2023)

48 consumer complaints on file.

#11555285November 15, 2023
FUEL/PROPULSION SYSTEM, VEHICLE SPEED CONTROL, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
The vehicle was driving on cruise control at 55 mph approaching an intersection with a stop sign. Attempted to brake to cancel the cruise control, but vehicle sped and continued gathering speed so that the driver lost any control over the speed. Frantic application of the brake did not have any effect on the speed. The vehicle shot across a south bound highway, collided with traffic signs in the center, crossed northbound lanes, jumped a four foot berm and landed in bushes where the air bags deployed.
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#11552613October 30, 2023
TIRES
The contact owns a 2023 Volvo XC40 equipped with Pirelli Tires, Tire Line: Scorpion Zero, Tire Size: 235/45/R20, DOT Number: 1XB1H884J5022. The contact stated that the message "Low Air Pressure" was displayed. Upon inspection, it was discovered that the rear passenger’s side tire was flat. The vehicle was towed to the local dealer who replaced the tire. Later, while driving approximately 35 MPH, the front driver’s side tire had a blowout. The cause for the failures was not yet determined. The manufacturer was not notified of the failure. The failure mileage was 3,588.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11550725October 18, 2023
SERVICE BRAKES
I am reporting 2 incidents for my 2023 Volvo XC40, both involving failure of brakes to engage. The 1st incident occurred on 26 August 2023. The 2nd incident occurred on 20 September 2023. A full description of both incidents, including 2 photos of the incident scenes, is attached. The 1st incident involved a collision with a Jersey wall and crosswalk signal activation sign. Repair of the resulting damage required replacement of a mirror assembly that was destroyed and some repainting.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11547353September 29, 2023
FORWARD COLLISION AVOIDANCE, POWER TRAIN, ELECTRICAL SYSTEM
The contact owns a 2023 Volvo XC40. The contact stated that while her son was driving at various highway speeds, the brakes inadvertently activated, causing the vehicle to abruptly stop even though were no other vehicles or objects nearby. Additionally, the vehicle occasionally stalled and hesitated while accelerating. The contact also stated that the display screen occasionally became inoperable, and messages and safety warnings were not available to the driver. The vehicle was taken to the local dealer who was unable to duplicate the failure. The dealer had replaced unknown sensors, but the failure persisted. The manufacturer was not notified of the failure. The failure mileage was 13,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11526950June 14, 2023
FORWARD COLLISION AVOIDANCE
The contact owns a 2023 Volvo XC40. The contact stated while driving 65 MPH, the Forward Collision Avoidance system activated without a vehicle nearby and the vehicle experienced phantom braking. The contact stated that the failure occurred on three separate occasions. The vehicle was taken to the dealer, but the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 6,500. The contact stated that they have experienced multiple failures with their vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11520580May 5, 2023
SERVICE BRAKES, HYDRAULIC
The contact owns a 2023 Volvo XC40. The contact stated that while driving at approximately 30 MPH, he was approaching a stop light when he depressed the brake pedal to stop the vehicle however, the brake pedal stiffened. The contact stated that he had to apply pressure to the brake pedal when suddenly the ESC warning light, the brake warning light, the ABS warning light, and another unknown warning lights were illuminated. The contact then stated that in the same instance, the RPMs inadvertently increased to 1000 without acceleration when he desperately pumped the brake pedal multiple times to stop the vehicle however, the vehicle started to decrease in speed as the vehicle proceeded through the red stop light. As a result, another vehicle crashed into the front end of the contact’s vehicle. The air bags did not deploy. The driver of the other vehicle sustained an unknown injury that required medical attention. A police report was filed. The contact’s vehicle was towed to the dealer however, the contact was uninformed of the diagnoses. The vehicle was repaired. The contact notified the manufacturer by email of the failure and to inquire of a recall and the contact was informed that the VIN was included in the manufacture recall R10217. The contact stated that he then received a recall notification of the NHTSA Campaign Number: 23V012000 (Service Brakes, Hydraulic). The failure mileage was approximately 300.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11511962March 15, 2023
ELECTRICAL SYSTEM
The contact owns a 2023 Volvo XC40. The contact stated that the SOS button had malfunctioned and had caused several different calls to be made except for a call for roadside assistance. The contact contacted the dealer; however, the vehicle was not diagnosed. The vehicle had not been repaired. The manufacturer was made aware of the failure. The approximate failure mileage 700.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11496420December 7, 2022
UNKNOWN OR OTHER
We were notified by email of a computer update to our 2023 Volvo XC40 Recharge (it stated it would automatically download the update then ask us to initiate the installation). The next day I was charging the car. The car is programmed for 1 pedal driving. After disconnecting the charger, I got into the car, put my foot on the brake, and placed the car in reverse. When I released the brake, the car just took off in reverse. It should not have moved until I pushed on the accelerator. I am theorizing that the car was either in the middle of the download or had just finished the download portion of the update. This problem persisted after I put the car in Drive. I drove about 2 blocks and parked the car. After about 10 minutes I put the car in Drive and it returned to the 1 pedal drive mode and the computer screen in the car showed a message that the update was ready for installation. The car drove normally for 20 miles to our house. We installed the update after arriving home. My wife drove the car the following morning. She experienced no further problems.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo XC40