Toyota RAV4 Complaints (2023)

149 consumer complaints on file.

#11663790May 29, 2025
ENGINE, ELECTRICAL SYSTEM
During a rain Storm water was able to leak into my air intake box causing my air filter to become soaked. This caused my car to malfunction, come to an abrupt stop, alerting me of a "engine and steering failure" shutting my car off and becoming stranded on the highway.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11662468May 21, 2025
STEERING, ENGINE
Was driving in heavy rain after about a 35 mile commute and put the car in park. After about 5 minutes of sitting in park the car turned completely off by itself for a couple of seconds and restarted. Warning message “engine stopped steering power low” popped up on dash and was visible smoke coming from under the hood with a slight burning smell. This is a first incident for the car as it has been driven for about 2 years with a little over 35,100 miles on it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11662256May 21, 2025
ENGINE, VISIBILITY/WIPER, STEERING
My Toyota RAV 4 the power steering light comes on and says low & it always happens when it’s heavy raining and my wipers are on. The car just stops & wont start again for about 20 mins. This is super dangerous and has happened 4 times now
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11660599May 13, 2025
ENGINE
This problem has occurred twice now. First time: 4/19/2023 The car was brought to the car wash, I pulled into my parking spot the car shut off. When I attempted to turn the car back on the car would not start. The car showed a check engine light along with a steering wheel with an exclamation point. The dash said "Engine Stopped Steering Power Low". The car was immediately brought to the dealership after the car would start. The dealership did not find anything wrong along with no codes. The dealership assured me this would not happen while driving. Second Time: 5/9/2025 The car stalled mid driving in the rain and said "Engine Stopped Steering Power Low", car would not turnback on. Car has not been brought to the dealership again due to them not responding. This problem happening while driving puts not only my life at risk but everyone on the road.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11659981May 9, 2025
ELECTRICAL SYSTEM, ENGINE, STEERING
I was driving down [XXX] The car was moving along fine then when I pushed the gas it would jerk back and shake. I pulled off the highway and was able to coast into a gas station, but the engine stopped working as I was driving while cars were coming behind me. I could have been stopped in the middle of traffic with no way to get out. The power steering light came on as well as a light that said the engine was cut off. We just bought the car used with 22k miles on it and put an additional 3k miles on. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11659811May 8, 2025
WHEELS, STEERING, SUSPENSION
After routine service at South Coast Toyota in Costa Mesa, CA, I unknowingly drove my 2023 Toyota RAV4 Hybrid for over a week with two missing lug nuts and one extremely loose lug nut on the front passenger wheel. The service performed on April 5, 2025, included an oil change, tire rotation, and full inspection. No issues were reported to me at pickup. Over the next several days, I heard increasing thumping and metallic noises from the front right wheel area, especially at highway speeds. On [XXX], while driving with children in the car, the vehicle made loud metal screeching noises and the steering became impaired—I could not complete a basic turn. I limped the car home at 4 mph. Upon inspection, I found two lug nuts missing and one so loose I could unscrew it by hand. I had the car towed back to South Coast Toyota on April 18. The dealership admitted two lug nuts were missing but failed to apologize or fully document the issue. I was told via text that the only action needed was replacing the missing lug nuts. I received no formal inspection report or confirmation that the vehicle was safe. I paid out of pocket for a third-party inspection at a separate Toyota dealership, which confirmed that the previously recommended sway bar replacement was unnecessary and that my tires and components were in better condition than initially claimed. This was a clear service-related safety failure that could have led to wheel detachment and a serious accident. I drove over 200 miles on freeways with children in the vehicle. The dealership failed to follow basic safety protocols and has not taken responsibility. I am reporting this to NHTSA in the interest of safety and accountability. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11659158May 6, 2025
ENGINE, ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
Was sitting in my car in the rain and all of a sudden the engine cut off. The check engine light came on and the error message on the dashboard said " Engine Power Reduced". If I try to put it in anything but Park, it won't let me. I have never had this issue, or any issue with this car. If I had been driving, this would have run me off the road.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11659130May 5, 2025
STEERING, ENGINE
UNKNOWN: It happened during a heavy storm on my 40 miles to work and all the symbols lights suddenly lit up on the dashboard. The car died and the steering wheel got heavy when I tried to pull to the emergency lane. Luckily I was able to pull over, but it almost caused an accident as I was in the middle lane. I tried to start up the car again, but it would crank up, but died instantly and the dash would show "Ignition on" on the top left and "Engine Stopped: Power Steering Low". I called the dealership and talked to the service department and the service advisor think it was the battery, but he told me to try starting it after 5-10 minutes, if not, to call the tow company and tow the car to dealership for further inspection. I let it sit for 10 minutes and was able to start it back up and drove it straight to the nearest Toyota Dealership. While driving to the dealership, the car kept choking/stalling when pressing on the gas after braking. They examined with their scanners and the battery was in good condition and my car has gas (about 3/4 tank full) and they said the scans reported no issues. This is a concerning issue as I could had lost my life or possibly cause major accident and involve other people life.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11659025May 5, 2025
ELECTRICAL SYSTEM, ENGINE, UNKNOWN OR OTHER
While raining, noticed smoke coming from under the hood, engine seemed as if it didn’t have any power. Car shut off. While attempting to restart I seen a message in dashboard that said Engine stopped: steering power low. Took a while to get car cranked again after multiple attempts. Message in dashboard disappeared after multiple attempts to restart nor is there a message in remote application health status section.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11658607May 2, 2025
STEERING, ENGINE
It’s pouring rain and my engine stopped and a message popped up saying “engine stopped power steering low”
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11657975April 30, 2025
VEHICLE SPEED CONTROL, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
On 2 occasions while driving on a flat straight Interstate Highway using the adaptive cruise control, with no vehicle in front of me, the vehicle has suddenly tried to stop. Pressing the Cancel button for the adaptive cruise control would not shut the system Off. When the accelerator was depressed to attempt to get the car moving forward, it continued to try to stop the vehicle even harder. Pressing the brake pedal also did not disengage the adaptive cruise control. I had to allow the vehicle to creep off the highway, then Shutdown the vehicle and then Restart to resume driving.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11657204April 28, 2025
STEERING
My engine shut off (would not turn back on!) and displayed message: “Engine Stopped. Steering Power Low”. I brought it to the dealership the next morning. I was told that the power steering was electric, they could not duplicate the message, and to bring it back if it does it again. I’m concerned because what happens if it occurs again while I’m driving on the interstate?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11657041April 27, 2025
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
The multimedia screen powers on and off consistently.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11656842April 25, 2025
UNKNOWN OR OTHER
I drive through heavy rain for about 20 miles and I got to my mom’s house, put the car in park for about 5 minutes, when I get back in the car the car shut off when I put it in drive and was smoking. Now it will not crank up.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11656674April 25, 2025
ELECTRICAL SYSTEM, ENGINE
I was sitting in a drive thru with my car in drive , foot on break and all of a sudden it starts to shake and struggle to stay on . Then it stalls out , engine shuts completely off and my check engine light came on! The error messages on the screen read : Engine stopped , power steering low , precollision system malfunction , and parking brake malfunction. As I tried to restart it , It wouldn’t start back up and stay on at all. After a good 20 min or so , and after being pushed out of the drive thru and my order canceled, my car starts back up as if nothing happened. Had my car checked for codes , and guess what ? NOTHING ! It’s happened to me about 6 times in about a year and two month of owning it ! Nobody can figure out what the problem is . I also have issues randomly with my radio screen . When my phone is hooked up to CarPlay , it will sometimes kick me out and reconnect by itself , the screen completely shutting off and turning back on by itself , there’s times I was listening to pandora and it won’t allow me to click my station and show the song playing , and other issues. Had this happen too many times to count and within the first couple months of owning it , I took it back and they couldn’t figure out the issue. It never happened while they had it .
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11656505April 24, 2025
STEERING
Was driving to work, pulled in put the car in gear. The car turns off staying low power steering fluid. Couldn’t get it to start. I go in work my shift have my brother meet me. The car starts after sitting 9 hrs and I took it to Toyota. I have only had this car a month and it does this. Low power steering shouldn’t cut an engine off. If anything it should just be hard to steer. These new cars need to be tweaked. If Toyota can’t fix this they will not get any more business from me.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11656496April 24, 2025
STEERING
I was sitting in a drive trough getting breakfast, I go to pull off and my car cuts off. Couldn’t get it to restart. Had to push it out of the way. Power steering low. Granted this cat is just 2 years old. It’s done this before last year after having it one full year same thing. Luckily after letting it sit for 20-30 minutes it started and I got it to Toyota. Low power steering shouldn’t cut an engine off. If anything just be hard to drive. These new cars need to be tweaked. If Toyota can’t fix this they will not get any more business from me.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11655638April 19, 2025
ELECTRICAL SYSTEM, STEERING, UNKNOWN OR OTHER
I went to start my car , the engine turned off stating power steering low engine off . Then tried again and got more errors likes brake engaged power off also the lane monitor was not working.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11654811April 15, 2025
AIR BAGS, SERVICE BRAKES, FUEL/PROPULSION SYSTEM
Sudden surge and acceleration upon parking. I had brakes depressed pulling into a parking space when the vehicle felt like it jumped and quickly accelerated. It veered left missing the parked van in front of me but crashing into the parked Honda Accord two spots over and one in front. It crashed into the back tire and fender area of the passenger side of the Honda pushing it completely out of its spot and sideways. My vehicle kept going even though pushing the brakes to stop. I had to force it into park to stop. The car’s air bags deployed but my Toyota’s airbags nor crash warning system worked.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11653710April 9, 2025
STEERING, LANE DEPARTURE: ASSIST, ELECTRICAL SYSTEM
This vehicle is going to kill someone. Not only does it have this unintentional steering issue, but the electrical system keeps going out. The dash has been replaced and there are still issues. The adaptive cruise control used to hard brake now it pulsates when lane changing which isn’t cool if you’re passing people because then you’re turn in front of them and braking right away. The radio requires the vehicle to be turned completely off, wait, and then turn back on. The unintended steering will take you into incoming traffic, in the opposite lane, or even off-roading even when there is nothing in front of you. The compass randomly disappears. The Tim roof literally exploded while we were doing 80mph down the interstate. The curtain was closed or we would have had glass all over. The window blew out and up. If something hit the window it would have blown in and down. I have reported these safety issues to Toyota and they keep telling me that nothing is wrong. The steering issue has happened at least 7 times since I owned it. I have provided Toyota with pictures and videos showing these things and they’re still telling me that nothing is wrong but they even have a form that talks about the “unintended steering” issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota RAV4