Toyota RAV4 Complaints (2020)

652 consumer complaints on file.

#11448769January 25, 2022
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL, AIR BAGS
The contact owns a 2020 Toyota RAV4 Hybrid. The contact stated that the vehicle had unintended acceleration at stop signs and red lights. The vehicle was taken to the dealer and diagnosed as having no failure. Four days later, the failure recurred and the vehicle crashed approximately 6 - 8 feet into the corner of the contact's residence. None of the air bags deployed upon impact. The contact received medical treatment the next day for bruising from her neck to groin, a torn rotator cuff, and neck and back injuries. Police and fire department reports were filed. The insurance company had not deemed the vehicle totaled. The vehicle remained at the contact's residence. The manufacturer was made aware of the failure and instructed the dealer to have the contact drive the vehicle back to the dealer. The failure mileage was approximately 8,000.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11448781January 25, 2022
UNKNOWN OR OTHER
Driving on the freeway and when randomly we hear a big bang, very loud and scary. Pulled the sunroof cover back to see that the sunroof had exploded/shattered into a million pieces. We were in alot of traffic heading to the mountains, my daughter was sitting in the back seat and this happened right above her head. Its been almost a month, sunroof on back order, didnt realize there was such a thing as exploding sunroofs until I searched the internet. My car is a lease and under warranty, but yet I am stuck with a $500 deductible to get this fixed. After reading all of these complaints how has this not been recalled? At the time of this happening, I had a few rocks also hit my windshield, for it to bounce off windshield and break a sunroof into a million pieces, this seems like a manufacture defect. We have turned this into our insurance company, but I feel like Toyota should cover this cost, as I had to come out of pocket for deductible and rental car
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11448807January 25, 2022
STRUCTURE:BODY
Rear liftgate hinges bend/broke at car body attachment Appears to be a metal issue with hinges Rear liftgate door will not seal, allowing exhaust gases to enter vehicle Problem was reported to Dealer at 25K mile mark, Dealer will not repair under new car warranty
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11448009January 19, 2022
UNKNOWN OR OTHER
The windshield on this vehicle is extremely fragile and cracks very easily. Many drivers of this vehicle have reported the same issue online with the windshield on the newest Toyota RAV4. Toyota simply refuses to do anything using the guise of "external influence" being the cause of a windshield crack - this same logic would apply to a small pebble or a tapping of a finger to cause a windshield crack.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11447823January 18, 2022
ELECTRICAL SYSTEM
On 8/25/21, Toyota Rav 4 Vehicle was parked in garage and caught fire burning down garage and house, minor injuries to occupants in house. Vehicle had recently 7/01/21 been repaired at dealership for battery discharge when parked by installation of new update to DCM Software according to TSB-0095-20 Rev2. The vehicle has been inspected by police, Hidalgo County, Texas Fire Marshall and Progressive Insurance Company Progressive. Origin of fire started in vehicle but cause of vehicle fire undetermined by Fire Marshall, Insurance Company related fire to charger plugged into dash of vehicle.
Crash:
No
Fire:
Yes
Injuries:
1
Deaths:
0
#11447512January 14, 2022
SERVICE BRAKES, VISIBILITY, ELECTRICAL SYSTEM
The contact owned a 2020 Toyota Rav4. The contact stated that while driving 45 mph with the cruise control activated and while coming to a red light, the driver depressed the brake pedal and the braking system malfunctioned causing the vehicle to not stop. The vehicle drove through a red light causing a collision with a second vehicle. During the crash the driver sustained rib and torso injuries, the front passenger sustained injured ribs and fractured tailbone and the rear passenger side occupant sustained a fractured tailbone. No further information was available regarding the second vehicle. During the crash, the vehicle was destroyed. A police report was taken at the scene and the vehicle was towed away. The contact indicated that prior to the incident the vehicle had been examined at the dealer for a possible braking problem but no trouble was found. The manufacturer and local dealer were notified of the incident. In addition, the contact indicated that the backup camera audible alarm was inoperable. The failure mileage was 9,000.
Crash:
Yes
Fire:
No
Injuries:
3
Deaths:
0
#11446615January 7, 2022
FUEL/PROPULSION SYSTEM
Toyota emphatically advertises that its 2020 RAV4 hybrids come equipped with a 14.5-gallon gas tank that can hit a 580-mile driving range. The cars suffer from the apparent fuel tank issue that harms both the environment and the benefit of the cars’ electric power. The RAV4 hybrids not only fail to comply with federal and state gas tank regulations, which prohibit the sale of vehicles that cannot fill 90 percent or within two gallons of their nominal gas tank capacity, but suffer from substantially reduced driving range. The fuel tank defect poses an environmental and safety hazard in that drivers are left to guess how much gas they have left and effectively encouraged to top off their fuel tanks in order to fill up as much as possible,
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11443634December 13, 2021
ELECTRICAL SYSTEM, ENGINE
In the sring of this year, i lightly drove through a water filled pothole in a parking lot when all of the displays went dark for a split second and then came back on like the car had just started. I called my dealership right away and was told that maybe some water had gotten into some wiring and caused the glitch but to call again ASAP if it happened again. On Dec 9, 2021 under dry and even surfaces while making a left turn the vehicle went dark again while driving but this time took a touch longer to re-engage. I called the dealership again to report this to be looked at during a maintenance appointment. They found nothing wrong, but suggested it was a feature the car does not have was turned on and they turned it off. I was then shown the button responsible for this ... it was for automatic high beams, NOT some engine efficency button. On Sunday, 12 12 2021 i went to start the car to go to work and it was completely dead, just a small clicking sound to be heard within the cabin. i had to get the car jumped to get it started on the second turn of the key after i removed it from the first attempt. I drove it to the dealership that day and i am still waiting for results. This needs to be adressed ASAP because its a potentially dangerous if not deadly situation if it conks out at highway speeds in front of a semi.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11441556November 24, 2021
UNKNOWN OR OTHER
On Sunday,11/21/2021, sitting in my Toyota Rav4 TRD Off Road with my wife in an outside parking lot to a medical office, when we heard a loud pop/bang. We got out of the vehicle and discovered that the sun roof had shattered. Nothing hit my car. We were parked in it it for 15 minutes. There was nothing around the vehicle. I taped the window with Gorilla Tape. Dealership inspected the car and told me the warranty does not cover glass. Dangerous situation! Potential for flying glass! There is no warning system for this type of incident.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11440715November 16, 2021
ELECTRICAL SYSTEM
This is regard to 2020 RAV4 XLE with 7,000 mileage battery dead issues twice due to software issue based on Toyota dealership reports. I do drive my car daily and car not sat in garage more than 2 days! On evening of July 24th I wan’t able to turn on the vehicle. It was totally dead. Had to request road assistance for jump then took the car to Toyota Sunnyvale for check. They mentioned the issue was the battery and then having hard time with them to replace it with a new one. They Assured and Confirmed with me couple of times on the phone and at the Service Center this issue will never ever happen again. I was told it was a software issue that was consuming the battery and company fixed the software and they updated on my car and it won’t happen again for sure. Morning of November 16th while was heading to work same story repeated again. Faced with a totally dead vehicle, called again for road assistance for a jump and car is now sitting at Toyota Sunnyvale Service Center for analysis. I cannot trust to Toyota Service Centers any more and now I cannot relay on my vehicle. I look forward for a reasonable response from Toyota Motor Corporation. Why customer has to face with dead battery, ask roadside assistance and visit the dealership to identify the problem? What if I was out of town or in situations that cannot get roadside assistance? Why if this software issue it was not software recall and customers was not informed? Why this issue happened twice? What guarantees this will never happen again?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11439865November 9, 2021
UNKNOWN OR OTHER, VISIBILITY:SUN/MOON ROOF ASSEMBLY
My name is [XXX]. My wife, myself, our 2 month old baby and our dog were driving back from a family vacation when our moon roof spontaneously exploded outward. It was an extremely loud noise and then sounded like it was raining glass. Our baby started screaming and crying from the noise. We were able to immediately and safely pull off the freeway to examine the vehicle. Upon inspection we noticed the remaining glass on the edges of the moon roof looked as if it were being pulled upwards. We are very lucky the screen was shut and nobody got hurt. The incident occurred on a sunny & clear, early afternoon while we were on the freeway going 55mph, there were no cars in front of us or beside us for more than a half mile, we were not near or passing under a bridge or an overpass. There were no warning lights or other symptoms before the incident happened, as well as no warning lights after the fact. There was absolutely no reason this should have happened or anything that we did to cause it or to stop it from happening. I took photos of the damage immediately after and it shows the remaining glass lifting outward. I did some online searching and found that this has happened to multiple other drivers with this exact make & model of vehicle, as well as multiple other years. I brought our car into Toyota within an hour of the incident occurring. One of their employees working said that she has heard of this happening before. I see this as a recurring incident with this model of car and it is extremely dangerous. We bought this vehicle with only 5k miles on it, less than 3 months ago from a Toyota dealership. We bought this car because we have a new baby and wanted a safe family vehicle. We are now terrified that this will happen again. We never would have imagined that anything like this would happened in the first place. From my recent research I am shocked that this vehicle issue has not been recalled. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11438647October 29, 2021
UNKNOWN OR OTHER
I want an investigation on Toyota Rav4 hybrid 2020 .It has a faulty traction control system . It kicks in on every bump and start the emergency braks vehicle jerks and driver gets confused . its a safety issue and may start causing accident on high speed
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11435490October 5, 2021
STEERING, AIR BAGS, LANE DEPARTURE: ASSIST
the car simply a LEMON big time was bought on 08/2020 thru the Santa Monica city Toyota Dealers...they are awful too. let my dad, 80, buy all extra insurances when its brand new car and has 3 years bumper to bumper warranty. he and me his daughter that is dedicated driver sometimes keep complain that its get bazuka after 35--39 and move up miles per hours, power steering wheel Out of control basically. can be turn 65 to 90 degree angle without even sorry to say spitting on it..., the UGLY safety feature that will help you to change the lane on freeway, we wouldn't even will be mentioning that. I think its million dollars case here as a LEMON LAW against Toyota Corporation
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11434064September 23, 2021
STRUCTURE:BODY, VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
The contact owns a 2020 Toyota Rav4. The contact stated that the mirror housings of the vehicle were melting. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed nor repaired. The approximate failure mileage was 8,500.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11434066September 23, 2021
VISIBILITY:REARVIEW MIRRORS/DEVICES, STRUCTURE:BODY
The contact owns a 2020 Toyota Rav4. The contact stated that the mirror housings of the vehicle were melting. The dealer was made aware of the failure and informed the contact that they could not assist as the failure was a manufacturer defect. The dealer referred the contact to the manufacturer. The manufacturer was notified of the failure advised the contact that they would follow up with the dealer. A case was opened. The contact stated the dealer took photographs of the failure. The contact stated the manufacturer contacted her and informed her that their field experts determined that the failure was not a manufacturer defect but an environmental issue called solar conversion. The vehicle was not repaired. The approximate failure mileage was 10,000
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11432370September 9, 2021
SEATS, UNKNOWN OR OTHER
I am reporting a PROBLEM - the headrests on the front driver and passenger seats will NOT stay down on my 2020 Toyota Rav4- they always slowly keep moving upwards- I guess from the natural vibrations of the road. I complained at the Toyota service department (at Wilde Toyota in Milwaukee Wisconsin) and they said that is how their headrests work in the Toyota Rav4 - they don't stay down. While this may not be an issue for a tall person, an average person of 5 ft 5 inch tall or shorter would have a serious problem with their head being smacked around when the headrest won't stay down - I have never experienced a headrest that won't lock in place and stay there- I think this could be terrible if I got into an accident and my headrest was in the wrong position. I am shocked that Toyota does not care. I think you should check into this. A manager there did acknowledge he has heard of this problem before and has had a few people complain about it but they don't think it is a big deal. - they were tall men so they didn't care - they like the headrest all the way up as far as it goes.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11429669August 18, 2021
FUEL/PROPULSION SYSTEM
My car’s distance to empty never goes above 420 miles, despite a visit to the Lexington MA Toyota dealership with this complaint. Published range is about 580 miles. The dealership reset values in the car, but this did not make any difference, and at no point during my ownership of the car (which was bought new) has the range on the dashboard when the tank is full exceeded 430 miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11427932August 5, 2021
AIR BAGS
The contact owned a 2020 Toyota RAV4.The contact stated while stopped at a red light the vehicle was struck from behind by a Ford F-150 which resulted in none of the air bags deploying. The contact sustained a broken nose, cheeks, dislocated shoulders, and back injury. The contact was transported by ambulance from the scene of the collision. A police report was taken and the vehicle was towed to a junkyard where it was determined to be destroyed. The manufacturer was informed of the failure and the contact was awaiting a reply. The failure mileage was approximately 54,354. The malfunction airbags according to Toyota Manufacturer.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11426967July 29, 2021
ELECTRICAL SYSTEM
Car sat for 4 days while we here hiking. Battery went dead. We were 15 miles up a gravel road and thankfully someone came by who had jumper cables. Reported issue to Toyota today and will take to dealer. Apparently, Toyota has no current fix for the battery drain when vehicle is off. Searched online and found 100s of reports of this same issue from 2019, 2020 rav4 owners, both hybrid and non-hybrid.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11424057July 9, 2021
UNKNOWN OR OTHER
While driving on the freeway, the panoramic sunroof exploded. I have photos showing the glass exploding up & outward (away from the vehicle), rather than downward as one would see if the glass had been impacted by a foreign object. Had I not had the sunroof screen closed glass would have come down onto myself along with any other passengers who could have been inside the vehicle, and possibly caused an accident with other vehicles. Currently the vehicle is at the Toyota dealership and I am awaiting inspection from Toyota's corporate department and my insurance company. There was no warning prior to this event occurring.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota RAV4