Saturn Ion Complaints (2004)

898 consumer complaints on file.

#11186249March 12, 2019
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2004 SATURN ION. WHEN ATTEMPTING TO START THE VEHICLE, IT FAILED TO START. THE CONTACT MENTIONED THAT THE FAILURE WAS INTERMITTENT. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC THREE TIMES AND THE BATTERY AND CRANK SENSOR WERE REPLACED, BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11182157February 23, 2019
STEERING
THE STEERING WHEEL JUST STOPPED. IT STIFFENED UP AS IF THE CAR WAS TURNED OFF WHILE I WAS DRIVING NEARLY CAUSING ME TO CRASH. I TOOK THE CAR TO THE DEALERSHIP TO ASK THEM TO CONSIDER REPAIRING THE PROBLEM BASED UPON THE FACT THAT THERE ARE SO MANY (400,000 SATURN IONS ON THE ROAD) COMPLAINING OF THE SAME PROBLEM. GMC TOLD ME THAT SINCE THE VEHICLE HAS NO RECALL; THEY COULD NOT REPAIR MY CAR.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11176627February 12, 2019
STEERING, SUSPENSION, WHEELS
THE POWER STEERING STOPS WORKING WHILE YOU ARE DRIVING WITHOUT NOTICE .WHEN YOU ARE TRUNING IT IS HARD,ALSO THE BEARING AND STRUTS ARE ALSO VERY RUFF.ALMOST HAD A WRECK WHEN TURING
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11165466January 6, 2019
STEERING
WHILE ON A NEIGHBOR HOOD DRIVING AT APPROX. 35 MPH I STEERING WHILE WAS DIFFICULT TO TURN AND THEN LOCKED ITSELF IN STRAIGHT POSITION. IT IS PARKED NEXT TO HOME ON CITY CURB SIDE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11141056October 17, 2018
STEERING
TL* THE CONTACT OWNS A 2004 SATURN ION. WHILE DRIVING VARIOUS SPEEDS, THE POWER STEERING SUDDENLY MALFUNCTIONED AND THE STEERING WHEEL BECAME VERY DIFFICULT TO TURN IN EITHER DIRECTION. IN ADDITION, "POWER STEERING" DISPLAYED ON THE INSTRUMENT PANEL. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 111,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11131268October 2, 2018
ELECTRICAL SYSTEM:IGNITION:SWITCH, STEERING, SERVICE BRAKES, HYDRAULIC, AIR BAGS
2004 SATURN ION. CONSUMER WRITES IN REGARDS TO AIRBAG SAFETY RECALL. CONSUMER STATES THAT THEY WERE NEVER NOTIFIED OF RECALL AND DURING AN AUTO ACCIDENT AIRBAGS DID NOT DEPLOY. *LD *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11131545September 25, 2018
STEERING
TL* THE CONTACT OWNS A 2004 SATURN ION. WHILE THE CONTACT'S VEHICLE WAS ATTEMPTING TO MAKE A TURN, ANOTHER VEHICLE CRASHED INTO THE PASSENGER SIDE OF THE VEHICLE. THE PASSENGER SIDE AIR BAG DEPLOYED. THE STEERING ABILITY WAS LOST AND THE VEHICLE SHUT DOWN. THERE WAS NO WARNING INDICATOR ILLUMINATED. A POLICE REPORT WAS FILED. THERE WERE NO INJURIES. THE VEHICLE WAS DAMAGED, BUT WAS NOT TOTALED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE CONTACT CALLED ALL STAR CHEVROLET OF OLIVE BRANCH AT 678-829-0246 (LOCATED AT 7240 CRAFT-GOODMAN RD, OLIVE BRANCH, MS 38654) AND WAS INFORMED TO BRING THE VEHICLE TO THE SHOP. THE CONTACT ASKED THE TECHNICIAN TO ASSIST WITH TOWING, BUT THE TECHNICIAN DID NOT HELP. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 150,000.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11102391June 18, 2018
FUEL/PROPULSION SYSTEM
2004 SATURN ION 2.2/4 ENGINE STARTED SMELLING GAS FUEL LINE ISSUES FOUND ... OTHERS HAVING SAME ISSUE THERE ARE RECALLS BUT ONLY ON CERTAIN VIN #S 107,000 MILES HOW MANY CARS BEFORE NATION WIDE RECALL ??!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11099970June 5, 2018
UNKNOWN OR OTHER
WHEN STOPPED AT EITHER A TRAFFIC LIGHT OR STOP SIGN, ONCE I TAKE MY FOOT OFF OF THE BRAKE AND PLACE IT ON THE GAS PEDAL THE CAR HESITATES LIKE IT'S GASPING FOR GAS HOWEVER, THE GASPING ONLY HAPPENS FOR A FEW SECONDS AND THEN THE CAR DRIVES NORMALLY! WHAT IS STUMPING ME, WHY DOES THE NEW PROBLEM ONLY HAPPEN INTERMITTINGLY! I JUST HAD A REBUILT TRANSMISSION INSTALLED BACK IN MARCH OF 2018 BECAUSE THE CAR ORIGINALLY HAD A PROBLEM WITH THE TRANSMISSION SLIPPING INTO GEAR! I TOOK THE CAR BACK TO AAMCO, THE PLACE THAT INSTALLED THE REBUILT TRANSMISSION AND ADVISED THEM THAT MY CAR WAS ACTING UP AGAIN WITH A NEW PROBLEM. BECAUSE THE NEW PROBLEM HAPPENS INTERMITTENTLY, THERE ARE NO ERROR CODES SHOWING FOR THE MECHANIC TO GIVE A DIAGNOSIS OF THE NEW PROBLEM. I AM SO FRUSTRATED BECAUSE THE CAR WAS MY FIRST CAR AND BEING RETIRED AND ON A FIXED BUDGET ANOTHER CAR ISN'T SOMETHING I CAN INVEST IN!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11088776April 18, 2018
STEERING
I PURCHASE THIS CAR ON 04/12/2018 FROM A LOCAL DEALER, EVERYTHING WORKED FINE, UNTIL 2 DAYS LATER. I WAS DRIVING ON THE HIGHWAY WHEN SUDDENLY THE STEERING BECAME HARD TO TURN. I THEN PARKED THE CAR FOR A FEW DAY WHEN I STARTED IT UP STEERING WORKED ALRIGHT FOR ABOUT A HALF MINUTE, THE STOPPED WORKING AGAIN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11079693March 15, 2018
ELECTRICAL SYSTEM
WHEN CAR IS PARKED IN DRIVEWAY, I HAVE TROUBLE REMOVING KEY FROM IGNITION. I DO NOT KNOW WHY THIS IS HAPPENING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11063289January 17, 2018
SERVICE BRAKES, ELECTRICAL SYSTEM, UNKNOWN OR OTHER
I'VE HAD SEVERAL TIMES WHERE MY CAR WASN'T AS STABLE AS IT SHOULD BE. THE CAR ITSELF RUMBLES AND JERKS A LOT ON CITY STREETS AND AS I GET OFF THE HIGHWAY. IN THE PAST THERE'S BEEN A FEW ISSUES WITH THE BREAKS. DURING WINTER TIME, THE CAR WON'T START UP (I HAVE A NEW BATTERY NOW AND IT STILL HAPPENS). ACCELERATION IS OCCASIONALLY DELAYED. LASTLY THERE'S A CLICKING NOISE COMING FROM THE PASSENGER SIDE OF THE CAR WHICH CONTINUES FROM THE TIME THE KEY IS IN THE IGNITION UNTIL I TAKE IT OUT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11061569January 10, 2018
VEHICLE SPEED CONTROL
THE CAR ONCE AGAIN ACCELERATED AT A STOP SIGN AND I HAD TO AIM FOR A SNOE ENBANKMENT TO NOT GO INTO TRAFFIC. IF NOT FOR THE SNOW I COULD HAVE WENT ON TO THE SIDEWALK ANS POSSIBLY HIT SOMEONE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11061118January 8, 2018
VEHICLE SPEED CONTROL
THE CAR STARTED TO ACCELERATE INTO CROSSING TRAFFIC WITH MY FEET FIRMLY ON THE BREAKS. IT HAPPENED THREE TIMES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11058553January 4, 2018
UNKNOWN OR OTHER
TAKATA RECALL 2004 SATURN ION. WHILE STOPPED AT A TRAFFIC LIGHT WITH FOOT ON THE BRAKE (FOOT COMPLETELY OFF THE GAS PEDAL AND GAS PEDAL WAS NOT STUCK ON ANYTHING), THE ENGINE REVVED WITHOUT WARNING (4000-4500 RPM, AND RPMS WOULD STAY ELEVATED AND WOULDN'T COME BACK DOWN TO A NORMAL IDLE) AND THE VEHICLE WAS ACCELERATING INDEPENDENTLY. MY BRAKES KEPT CAR FROM MOVING, BUT IF YOU TAKE YOUR FOOT OFF THE BRAKE, THE CAR WILL VIOLENTLY LAUNCH FORWARD. THIS HAS HAPPENED WHILE STOPPED AND WHILE DRIVING. WHILE DRIVING, RPMS WENT TO 4000-4500, AND CAR STARTED ACCELERATING ON ITS OWN, EVEN THOUGH MY FOOT WAS OFF THE GAS PEDAL. AGAIN, RPM'S STAYED ELEVATED AND WOULD NOT COME BACK DOWN. THE FAILURE HAS RECURRED MULTIPLE TIMES INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING ON 12/28/2017. THE TECHNICIAN CLEANED THROTTLE BORE AND REPLACED THE MAP SENSOR, BUT THE FAILURE PERSISTED. SINCE MY VISIT TO MECHANIC, I'VE HAD THREE MORE INCIDENTS. TWO TIMES WHILE DRIVING, RPM'S WENT UP TO 4000-5000 RPM AND WOULDN'T LOWER. HAD TO PULL OVER SHUT CAR OFF, WAIT SEVERAL MINUTES AND TURN CAR BACK ON. ALSO, IT WAS DIFFICULT TO STOP BECAUSE THE CAR WAS ACCELERATING AND WANTED TO MOVE FORWARD, SO ONCE I WAS SLOWED DOWN, I PUT CAR IN IDLE, PRESSED BRAKE UNTIL STOPPED, THEN SHUT CAR OFF. I TRIED TO TURN CAR BACK ON 10 SECONDS LATER, AND RPMS WERE STILL 4-4500. SHUT CAR OFF AGAIN, WAITING 2-3 MINUTES, TURNED CAR BACK ON AND IT APPEARED 'NORMAL.' THIS IS THE MOST DANGEROUS AUTO ISSUE I'VE EVER EXPERIENCE AND EVER HEARD OF.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11056103December 22, 2017
STEERING
TL* THE CONTACT OWNS A 2004 SATURN ION. AFTER STARTING THE ENGINE, THE POWER STEERING SENSOR REMAINED ILLUMINATED AND THE STEERING WHEEL BECAME VERY DIFFICULT TO TURN. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE LOCAL DEALER (PELLAGRINO CHEVROLET IN WESTVILLE, NJ) WAS NOTIFIED OF THE FAILURE AND A SERVICE APPOINTMENT WAS SCHEDULED. THE MANUFACTURER WAS ALSO NOTIFIED AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS PREVIOUSLY SERVICED IN NOVEMBER OF 2011 PER AN UNKNOWN RECALL. THE FAILURE MILEAGE WAS 98,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11023724September 15, 2017
STEERING
IN PARKING LOT ON LEAVING A STORE THERE WAS NO POWER STEERING MAKING IT VERY HARD TO DRIVE. NEXT I WENT TO A GAS STATION AND FILLED MY TANK. WHEN I LEFT THE STEERING WAS OKAY....THE DASH SYMBOL FOR POWER STEERING WAS NOT LONGER SHOWING. I LOST POWER STEERING ONCE BEFORE AND THE DEALER FIXED IT. (INVOICE INCLUDED) THE FIRST INCIDENT WAS REPAIRED AT MILEAGE 83,868. THE CURRENT ON HAPPENED AT MILEAGE 99,199. THERE WAS NO ACCIDENT INVOLVED EITHER TIME. I HOPE THIS WILL NOT HAPPEN ON A CURVY ROAD WHICH IS NEAR OUR HOME. HAD THE STEERING GONE OUT ON THAT AT 35 TO 40 MPH I'M NOT SURE I COULD HAVE SUCCESSFULLY COPED WITH THE SITUATION. SURELY ONCE THE DASH LIGHT POWER STEERING COMES ON ONCE IT MEANS THAT THE VEHICLE SHOULD BE SERVICED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11022769September 12, 2017
SERVICE BRAKES
I BOUGHT MY 2004 SATURN ION 2 COUPE AND HAD TO REPLACE THE FRONT ROTORS IN THE FIRST 2 YEARS, THEY WERE WORN DOWN TO THE IRON. I BOUGHT AMERICAN STEEL ROTORS FROM MIDAS. I'M STILL USING THE NEW ROTORS AND EVERYTHING, INCLUDING THE BRAKES, ARE STILL LIKE NEW. MY CAR IS IN A GARAGE AND I DON'T DO MUCH DRIVING. I HAD THE SAME PROBLEM WHEN I HAD MY NEW 1992 SATURN SL1. NOW I'M TOLD MY SWAY BAR IS GOING AGAIN. THIS WILL BE THE 3RD TIME. I WAS TOLD THAT WAS NORMAL FOR THE BRAKES AND THE SWAY BAR BECAUSE IT'S A SATURN AND I NEEDED TO DRIVE IT AND APPLY THE BRAKES HARDER AND PARTS FOR THE SWAY BAR ON THE 2004 HAD TO BE IMPORTED AND WERE POORLY MADE. I FIND THIS SUSPICIOUS TO SAY THE LEAST. I HAVE NEVER BEEN IN AN ACCIDENT OR EVEN A FENDER BENDER. I NOTED 2006 ON MY SATURN 2010 FROM IT'S FIRST PROBLEM, A YEAR LATER ON THE SWAY BAR AND A COUPLE MORE YEARS ON THE 2ND SWAY BAR. THE 1992 SATURN WAS AN ONGOING SITUATION WITH THE ROTORS TILL I JUNKED IT AROUND 2011.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11018943August 22, 2017
ELECTRICAL SYSTEM, POWER TRAIN
1. THE IGNITION SWITCH WILL NOT DISENGAGE...SOMETIMES AFTER MOTOR IS TURNED OFF AND CAR IS IN PARK THE CAR MUST BE TURNED BACK ON FOUR OR FIVE TIMES BEFORE THE IGNITION WILL ENGAGE CORRECTLY. THE VEHICLE IS STATIONARY...IN THE PARK POSITION....KEY WILL LOCK INSELF AND NOT DISENGAGE. THE CAR WAS ON A CITY STREET WHEN THIS OCCURRED. IT BEGAN TO OCCUR FIVE MONTHS AGO...NOW IT HAPPENS AT LEAST TEN TIMES A WEEK. 2. ALL ELECTRICAL SYMBOLS ON DASHBOARD SAY: COOLANT...BUT WHEN CHECKED THE COOLANT IS FINE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11012910August 4, 2017
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
TOOK MY VEHICLE FOR INSPECTION IT PASSED SAFETY AND FAILED EMISSIONS ! THERE IS NO ENGINE CHECK LIGHT ON
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Saturn Ion