Volvo XC90 Complaints (2020)

34 consumer complaints on file.

#11639716January 30, 2025
EQUIPMENT
The contact owns a 2020 Volvo XC90. The contact stated that after plugging in the charger to the vehicle, the cable charger started blinking red. The contact had to jumpstart the vehicle to open the doors. The blinking red light on the cable charger had not stopped blinking. The contact related the failure to NHTSA Campaign Number: 18E086000 (EQUIPMENT); however, the VIN was not included in the recall. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11637504January 21, 2025
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Spontaneously the left back side door has failed to close on several occasions. It happened first while parked in the driveway and I had to use my body to get it shut. I went to have it checked out at the Volvo dealer and when I described it they told me several people had been in for service with the same issue. They told me one lady had it on 2 doors and another realized her door was open when it flung open mid-drive. They told me the car was just cold and that I needed to make sure the handle was flush with the door when trying to close it. The next day, I picked up my dry cleaning and hung it by that door and drove away. I wasn’t aware it failed to latch yet again and only realized it when it flung open while I was driving on the road. This is the same door next to my son’s car seat which is terrifying to think about. I ensured the handle was flush and it still wouldn’t close until I hip checked it shut 3 times. Without a clear cause or reasonable solution (it is not reasonable to expect this just because it’s cold out), it is imperative that Volvo address this on behalf of the safety of its customers.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11626185November 19, 2024
ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL
The instrument cluster display on my 2020 Volvo XC90 went completely out while driving my vehicle. This was a single point of failure and SAFETY ISSUE as it affected my speedometer, gas gauge, etc. I was driving without any functioning indicators on the highway when it went out. There was no advanced warning. The issue was fixed by my dealership and part replaced, invoice is attached. We have made multiple attempts to resolve this issue with Volvo Corporate, who has been non-responsive to the overall safety concern. Based on research Ford Motor Company (Part 573 Safety Recall Report 23V-506) faced a recall for their Escapes because of a similar safety issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11604353July 24, 2024
UNKNOWN OR OTHER
The sunroof of the vehicle started leaking water after 4 years of ownership. Upon bringing it to Volvo dealer, I am quoted $2500-3000 to fix and check for faulty electrical or mold in carpeting. This is a safety issue as the water could damage critical electrical components. This is a 2020 vehicle, basic faulty sealing should be covered as recall or known issue that the consumer is not liable for.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11584613April 22, 2024
AIR BAGS, ELECTRICAL SYSTEM
The airbag system detected a fault and caused an automated vehicle warning message, which, with further dealer diagnosis, caused the driver seat belt to have a ground fault issue, preventing the normal, safe, and fully operating vehicle airbags. The cause and what must be replaced to rectify the problem are unknown. Volvo has poor customer support and satisfaction regarding avoidable repairs, along with various documented airbag failure incidents confirming a severe issue with its system components that require government oversight and correction through a recall to ensure the safety and reliability of the safety systems that protect lives.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11555192November 15, 2023
UNKNOWN OR OTHER
The electrical rear axle system fails at around 39k miles in the Volvo XC90 with little notice. I purchased my pre owned 2020 XC90 recharge in Jan of 2023. The failure of the ERAD system Caused complete power failure instantly and the engine to cease operating at a high rate of speed (55mph) on the highway in flowing NYC traffic . After researching, I have found hundreds s of complaints of this issue as most happen just after warranty expiration . Leading me to believe that Volvo is knowingly selling cars with one product defects that could result in injury or death.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11511040March 9, 2023
ENGINE, POWER TRAIN, STEERING
The vehicle shudders randomly when taking off from a stopped position around 18mph. The vehicle shudders randomly when slowing down to make a right turn. The vehicle shudders when driving at higher speeds. It's not a violent shudder, but those riding in the vehicle feel it as well. The safety concern is two fold in that there is a fear of losing control at an inopportune time. Secondly, the constant shuddering over time is going to result in damaging other part of the vehicle, particularly the engine, that will present a safety hazard while driving. The vehicle was purchased used(certified). The dealer replaced collapsed engine mounts on left and right side and considered it resolved. Forman at dealer stated it is common with XC90's to have engine shudder as if this should be accepted. Because the engine shudder is happening at higher speeds now, we're going to return to dealer, but I do not expect a solution. I've seen others report similar issues with shuddering on Volvo forums and I haven't seen 1 solution that worked. This is a problem in a lot of XC90's. The attached documents also contain some attempted fixes to correct a drifting issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11483375September 7, 2022
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
The issue started a few months ago. The brake sensor light on the dash turned on and stayed on. We took it to the dealer and they said that they will not fix it because they can see coffee stains on the sensor. Basically they have brake sensors right under the center console where people drink coffee and the brake sensors are exposed so this can happen to any customer. Now they want to charge us 1600 dollars even though the SUV is about 2 years old and under full warranty. They want to screw their customers and don't care about their safety. This is the brake system of the car and now it's having issues with the adaptive cruise control inwhich the system turns off while in use. We are concerned about our safty and don't know what to do.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11464084May 10, 2022
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
The contact owns a 2020 Volvo XC90. The contact stated that while his wife was driving at an undisclosed speed, the vehicle experienced unintended acceleration while the brake pedal was depressed, causing the vehicle to crash into a parked vehicle. The contact's wife did not sustain any injuries, and no medical attention was received. A police report was filed. The manufacturer was not made aware of the failure. The failure mileage was approximately 25,000.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11455609March 7, 2022
SERVICE BRAKES
I need new rear brakes and rotors at 26,296. I have leased cars for the past twenty plus years and never had to replace brakes/rotors after a year and a half.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11432078September 8, 2021
ENGINE, FUEL/PROPULSION SYSTEM, UNKNOWN OR OTHER
I was driving the speed limit on the highway in my Volvo 2020 XC90 which was less than one year old. The vehicle lost acceleration power and then an engine performance light came on, then a check engine light. I pulled over immediately and my car engine caught fire under the hood. The entire front of vehicle was engulfed in flames within minutes. There were approximately 11k miles on the car and it had never been maintenanced or worked on in any way that would have caused an engine fire. It was clearly a fuel line fire and Volvo did not properly investigate. My insurance company said it was a fuel line fire but could not get information from the black box because it was destroyed. This car is incredibly unsafe and should be recalled. I have multiple videos and case files concerning this "thermal event". Volvo recalled this car in Europe because of this issue and says there are none in the USA.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11413682April 24, 2021
STRUCTURE:BODY
THE SPOILER COVER OVER THE THIRD BRAKE LIGHT CAME OFF ON I-95 IN THE MIDDLE OF THE FREEWAY FOR UNKNOWN REASONS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11329741June 19, 2020
SUSPENSION
PURCHASED A NEW 2020 XC90 T6 INSCRIPTION WITH THE AIR SUSPENSION. FROM THE FIRST TIME PULLING INTO OUR DRIVEWAY, THERE WAS A DISTINCT, MUFFLED, AGGRESSIVE "THUMP" IN THE FRONT AND REAR END. THE SOUND IS INDEPENDENTLY FROM THE FRONT OR REAR SUSPENSION, DEPENDING ON WHICH IS GOING OVER A BUMP. THIS OCCURS CONSISTENTLY WHEN IN SLOW SPEEDS AND GOING OVER AN ABRUPT BUMP, SUCH AS A SPEED BUMP OR AN AGGRESSIVE CUT OUT IN A DRIVEWAY WHICH IS MADE FOR WATER RUN OFF. ONCE THE SUSPENSION COMPRESSES, THE THUMP OCCURS ON DECOMPRESSION (REBOUND). I TOOK IT INTO THE ORIGINAL DEALER (VOLVO OF TUCSON). A 2019 XC90 T8 MOMENTUM (WITH AIR SUSPENSION) WAS GIVEN AS A LOANER. AS EXPECTED, THE LOANER VEHICLE MADE THE EXACT SAME THUMP SOUND FROM THE FRONT AND REAR SUSPENSION OVER THE EXACT SAME BUMPS. THE DEALER COULD NOT REPLICATE THE SOUND ON MY CAR. I PROVIDED THEM WITH NHTSA ID #'S: 10148803 AND 10128173 (VOLVO BULLETIN #'S: TJ32978 AND TJ3303.1.1). NO RESPONSE YET AS TO THE PROBLEM OR CORRECTION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11322553April 28, 2020
SERVICE BRAKES
ON FEBRUARY 5, 2020 I WAS INVOLVED IN A MINOR FENDER BENDER WHICH RESULTED WHEN I DROVE OFF ALIGHT AND THE CAR IN FRONT OF ME DID NOT TAKE OFF AND I HIT IT IN THE REAR AT A VERY LOW RATE OF SPEED. THE AUTO BRAKE DID NOT ENGAGE. I WAS NO MORE THAN ONE AND A HALF CAR LENGTHS BEHIND AND THE CAR WAS MOVING AT ONE TO TWO MILES PER HOUR. WHEN I HIT THE REAR OF THE CAR IN FRONT OF ME THE AIR BAGS DEPLOYED WHICH CAUSED ME TO HAVE A SLIGHT CONCUSSION AND CERTAINLY SCARED ME. THERE WAS LITTLE IF NO PHYSICAL DAMAGE TO THE VEHICLE. I CONTACTED VOLVO CUSTOMER CARE A FEW DAYS AFTER ADVISING THAT AUTO BRAKE SYSTEM DID NOT ENGAGE AND THE AIRBAG DEPLOYED. THE REPORT WAS TAKEN. I WAS ADVISED THAT THERE WERE NO PRIOR REPORTS OF THIS ISSUE. VOLVO REPAIR WAS NOT WILLING TO ACKNOWLEDGE MY CONCERN AND WOULD NOT CONFIRM THAT PRIOR TO THE REPAIR THERE-WOULD BE A REPAIR. CANDIDLY THEY WERE NOT GOING TO DO ANYTHING EXCEPT ACCEPT INSURANCE CHECK AND FIX IT. I NOW HAVE RECEIVED A RECALL NOTICE FOR THIS EXACT ISSUE WHICH I HAD REPORTED. I ADVISED THEN I WAS AFRAID OF THE CAR BECAUSE I WAS AFRAID THE AIRBAG WOULD DEPLOY UNNECESSARILY AGAIN. HOW DO I ADDRESS THE FACT THAT I WILL NOT USE THIS CAR ANY LONGER.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo XC90