Toyota Tacoma Complaints (2002)

333 consumer complaints on file.

#10663593December 11, 2014
TIRES
TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 12V542000 (TIRES). HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VIN WAS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10652144November 3, 2014
STRUCTURE:BODY
AT THE YEARLY REQUIRED STATE INSPECTION THE VEHICLE FAILED DUE TO THE FRAME BEING RUSTED OUT WITH HOLES. IT APPEARS TO BE A VERY COMMON ISSUE WITH THIS VEHICLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10648454October 17, 2014
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE CONTACT STATED THAT THE FRAME WAS COMPLETELY CORRODED. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE FRAME OF THE VEHICLE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILE WAS 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10643815October 10, 2014
STRUCTURE:FRAME AND MEMBERS
TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. WHILE THE VEHICLE WAS UNDERGOING ROUTINE SERVICE, THE INDEPENDENT MECHANIC DISCOVERED THAT A REAR SECTION OF THE SUBFRAME WAS RUSTED AND CORRODED. IN ADDITION, TWO BRACKETS THAT SECURED THE BODY TO THE SUBFRAME DETACHED DUE TO RUST AND CORROSION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 123,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10640242September 30, 2014
STRUCTURE:BODY
DRIVING AT 35 MPH WENT OVER BUMP LEAF SPRING WENT UP THROUGH FRAME CAUSING VEHICLE TO BECOME OUT OF CONTROL. VEHICLE WAS INSPECTED AT VALENTI TOYOTA IN WESTERLY RI AND VEHICLES FRAME IS ROTTED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10636987September 17, 2014
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE HAVING ROUTINE MAINTENANCE PERFORMED, THE TECHNICIAN NOTIFIED HIM THAT THE VEHICLE HAD EXTENSIVE RUST AND CORROSION ON THE FRAME CAUSING IT TO WARPED AND CRACKED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INDICATED THAT THE CONTACT WAS NOT INCLUDED IN A THE LIMITED MANUFACTURER SERVICE CAMPAIGN. THE DEALER WOULD NOT APPLY THE CORROSION TREATMENT, BECAUSE THEY CLAIMED THE VEHICLE HAD A SALVAGED TITLE. THE CONSUMER DISPUTED THE DEALERS CLAIM AND PROVIDED PROOF. UPDATED 10/01/14.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10630770September 4, 2014
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE HAVING THE VEHICLE INSPECTED, THE TECHNICIAN MADE HIM AWARE THAT THE FRAME HAD COMPLETED RUSTED AND CRACKED. THE INDEPENDENT MECHANIC DIAGNOSED THAT THE FRAME NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 168,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10629040August 28, 2014
STRUCTURE:BODY, SUSPENSION
PART OF THE FRAME SUDDENLY BROKE FROM THE FRAME RAIL UNDER THE DRIVER'S SIDE OF THE VEHICLE, RESULTING IN A SIGNIFICANT PORTION OF MATERIAL LOOSING ALL STRUCTURAL INTEGRITY. THIS WAS DUE, IT SEEMS, TO A MANUFACTURING DEFECT IN THE FRAME QUALITY LEADING TO EXCESSIVE ROT AND RUST. THE VEHICLE IS NOW STRUCTURALLY UNSOUND AND THUS UNABLE TO BE DRIVEN SAFELY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10628193August 25, 2014
STRUCTURE:FRAME AND MEMBERS
TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. WHILE THE VEHICLE WAS BEING SERVICED FOR AN UNRELATED REPAIR, THE MECHANIC NOTICED THAT THE ENTIRE FRAME WAS COMPLETELY RUSTED. THE VEHICLE HAD NOT BEEN REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 162,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10627086August 21, 2014
STRUCTURE:FRAME AND MEMBERS
TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. WHILE DRIVING APPROXIMATELY 30 MPH, THE DRIVER SIDE FRAME DETACHED AND THE CONTACT LOST CONTROL OF THE VEHICLE. THE DEALER STATED THAT THE FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 148,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10622561August 15, 2014
STRUCTURE
TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE HAVING THE ANNUAL STATE INSPECTION PERFORMED, THE INSPECTOR NOTIFIED HIM THAT THE ENTIRE SUB FRAME, REAR BUMPER AND FRONT PASSENGER SIDE WHEEL WELL WERE EXCESSIVELY CORRODED. NEITHER THE DEALER NOR THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 167,152.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10617916July 31, 2014
STRUCTURE:BODY
EXCESSIVE FRAME RUST. I BROUGHT IT INTO A TOYOTA DEALER FOR AN INSPECTION FOR RUST TO THE SPARE TIRE CARRIER. THE DEALER REFUSED TO PERFORM THE INSPECTION BECAUSE THEY SAID THE FRAME WAS TOO RUSTY FOR THEM TO SAFELY PERFORM THE INSPECTION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10617311July 29, 2014
STRUCTURE
FRAME RUSTED AND CRACKED. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10617130July 29, 2014
POWER TRAIN
I TOOK IN MY 2002 TACOMA FOR AN OIL CHANGE AND WAS TOLD THAT THEY COULD NOT PUT IT UP ON THE LIFT DUE TO EXCESSIVE CORROSION ON THE FRAME. I ONLY RECENTLY BOUGHT THE TRUCK IN OCT. 2013 WITH 65K MILES ON IT. ALL ELSE WORKS FINE. AFTER EXPLAINING THE ISSUE TO TOYOTA THEY ADVISED ME TO TAKE IT TO THE DEALERSHIP FOR INSPECTION. THE DEALERSHIP THEN TOLD ME THAT THEY WERE ONLY COVERING THE RUSTED SPARE WHEEL CASING IN THE RECALL, NOT THE ENTIRE FRAME, AND ADVISED ME TO TAKE IT UP WITH TOYOTA CORPORATE. THE MODEL BEFORE THE '02 WAS RECALLED DUE TO EXCESSIVE CORROSION ON THE FRAME (IN COLD WEATHER STATES) HOWEVER THE PROBLEM SEEMS TO PERSIST IN LATER MODELS. HAS ANYONE HAD LUCK CALLING TOYOTA ABOUT THIS? I'M IN A TOUGH SPOT AS I PURCHASED THE TRUCK RECENTLY (ALTHOUGH THE RUST DAMAGE DID NOT APPEAR AS BAD THEN AND I'M WONDERING IF SOME COATING WAS APPLIED AT THE DEALER) AND WOULD HAVE MISSED ANY RECALL ON THE FRAME IF THERE HAD BEEN ONE. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10616916July 28, 2014
STRUCTURE:FRAME AND MEMBERS
TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE COULD NOT BE INSPECTED BECAUSE THE SUBFRAME WAS CORRODED. THE CONTACT RECEIVED A NOTICE FOR AN UNRELATED RECALL. THE DEALER INSPECTED THE VEHICLE PER THE RECALL AND RELEASED THE VEHICLE BACK TO THE CONTACT. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE NHTSA CAMPAIGN NUMBER WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10616231July 25, 2014
SUSPENSION, STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
THE SWAY BAR ARM BRACKET ON THE PASSENGER SIDE OF THE VEHICLE PULLED OUT OF THE FRAME DUE TO CORROSION. THE VEHICLE WAS FOUND TO HAVE CORROSION PERFORATIONS IN MULTIPLE AREAS OF THE FRAME. FRAME HAS EXCESSIVE CORROSION AND I HAVE BEEN ADVISED VEHICLE IS NOT SAFE TO OPERATE. MANUFACTURER REFUSES TO DO ANYTHING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10616083July 24, 2014
STRUCTURE:BODY
FRAME CRACKED AT RIGHT REAR BOX RAIL... *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10609269July 9, 2014
FUEL SYSTEM, GASOLINE, STRUCTURE, TIRES:TEMPORARY/EMERGENCY SPARE TIRE
MY FUEL TANK IS RUSTED COMPLETELY THROUGH TO THE POINT OF LEAKING GAS. I KNOW TOYOTA HAS RECALLED THE FRAME (REPLACED) AND THE SPARE TIRE HOLDER (NOT YET REPLACED) DUE TO RUST. SEEMS LIKE THE WHOLE UNDERSIDE IS RUSTING OUT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10598479June 16, 2014
SUSPENSION, STEERING, STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
I RECENTLY TOOK MY 2002 TOYOTA TACOMA INTO THE LOCAL DEALER, DCH IN WAPPINGERS FALLS NY, BECAUSE OF LEAK IN THE RACK AND PINION STEERING. UPON LOOKING AT THE VEHICLE,THEY OBSERVED A CRACKED AND RUSTED FRAME. WE TOOK THE CAR DOWN AND I WENT TO MY LOCAL REPAIR SHOP FOR A SECOND OPINION. THAT REPAIR SHOP HAD SAID THERE WAS A FRAME RECALL FOR THAT YEAR. I CALLED TOYOTA IN CALIFORNIA AND THEY CONFIRMED THERE WAS A RECALL FOR THAT YEAR AND THAT THEY SENT OUT A NOTICE, BUT IT HAD TO BE BROUGHT BY THE END OF 2012. I TOLD THEM I NEVER RECEIVED THE NOTICE. THERE HAVE BEEN 2 OTHER RECALLS FOR THE VEHICLE WHICH I DID RECEIVE NOTICES. THEY CHECKED WITH THEIR COMPLIANCE OFFICE AND SAID THEY DID SEND IT TO ME. I ASKED HOW MANY NOTICES WENT OUT AND THEY SAID ONE AND THEY DO NOT SEND THEM CERTIFIED MAIL. WHEN I STATED THAT I NEVER RECEIVED THE NOTICE, THEY TOLD THERE WAS A DEPARTMENT THAT MAY STILL BE ABLE TO ASSIST ME. AFTER OPENING UP A CASE WITH TOYOTA, THEY CAME TO THE CONCLUSION, THERE WAS NOTHING THEY CAN DO ABOUT IT BECAUSE I FAILED TO BRING THE CAR IN BY THEIR DEADLINE. I TOLD THEM AGAIN THAT I NEVER RECEIVED THE NOTICE AND THAT I DON'T FEEL SAFE DRIVING THE VEHICLE WITH A RUSTED AND CRACKED FRAME. THIS SEEMS TO BE PROBLEM WITH A GOOD DEAL OF TOYOTAS. I WAS HOPING FOR SOME KIND OF HELP, SINCE THEY'VE ADMITTED THE PROBLEM AND I NEVER RECEIVED THE NOTICE AND WE, AT THIS POINT HAVE ONLY THEIR WORD THAT THEY SENT ME A NOTICE. THANK YOU. TOYOTA CASE# 1405131065. UPDATED 07/03/14
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10598296June 14, 2014
UNKNOWN OR OTHER, STRUCTURE
I CALLED TOYOTA IN 2012 TO ASK ABOUT FRAME. WAS TOLD I DIDN'T QUALIFY. HAVE HAD TO REPLACE EVERYTHING ATTACHED TO FRAME IN A 2 YEAR PERIOD. LAST FALL THE GAS TANK FELL OFF. FRAME SO RUSTED IT WOULDN'T HOLD IT. CALLED TOYOTA AGAIN, AS RECOMMENDED BY MECHANIC, WAS TOLD I DIDN'T QUALIFY. WENT TO DEALER FOR RECALL REPAIR ON SPARE TIRE HOLDER, THEY COULDN'T FIX IT. TOO RUSTED. TOLD ME IT S NOT SAFE TO DRIVE. TOLD ME TO CALL TOYOTA. I DID. TOLD ME I DIDN'T QUALIFY BECAUSE RECALL EXPIRED. EXPIRED?! I HAVE NEVER RECEIVED A RECALL NOTICE!! I HAVE LIVED AT THE SAME ADDRESS FOR 32 YEARS. THEY FOUND ME THIS TIME, THEY SHOULD HAVE FOUND ME FOR THAT ONE. NOW WHAT? I AM OUT WELL OVER $3500 DOLLARS I'VE PAID OUT THE LAST 3 YRS AND ITS NOT SAFE! NEED HELP HERE. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tacoma