Toyota Tacoma Complaints (2012)

295 consumer complaints on file.

#11010947July 27, 2017
FUEL/PROPULSION SYSTEM, POWER TRAIN
CHECK ENGINE LIGHT ON, TRAC OFF LIGHT ON, ENGINE POWER WEAK CHECK ENGINE CODE- P2441. THIS HAS BEEN A COMMON ISSUE WITH TOYOTA SUVS, AND TRUCKS! CAR IS PUT INTO LIMP MODE. EXTENDED WARRANTY ON TUNDRA WITH SAME PART PROBLEM. NOT TACOMA. SHAMEFUL AND DANGEROUS FOR TACOMA OWNERS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11005324July 14, 2017
FUEL/PROPULSION SYSTEM
SECONDARY AIR INJECTION ERROR CODES P2440, P2441,P2442. LOSS OF POWER DUE TO AIR INJECTOR STUCK. VEHICLE WILL NOT ACCELERATE BEYOND 20-30 MPH. THIS IS AN EMMSISIONS REQUIREMENT BUT WARRANTIES ON TACOMAS WILL NOT COVER BEYOND 3YRS/35K MILES. TUNDRAS HAVE TUNDRAS HAVE SAME KNOWN ISSUES AND TOYOTA INCRWASED WARRANTY TO 10 YRS/150K MILES. SUDDEN LOSS OF POWER IS ALSO A SAFETY ISSUE WHILE DRIVING ON HIGHWAYS. OWNERS ARE PAYING THOUSANDS IN REPAIRS FOR SOMETHING THAT SHOULD BE COVERED UNDER WARRANTY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11004155July 10, 2017
SERVICE BRAKES, ELECTRICAL SYSTEM, UNKNOWN OR OTHER
DRIVING AT HIGH WAY SPEED; THE ABS LIGHT, PARKING BRAKE LIGHT, TRACTION LIGHT, LOST POWER TO WINDOWS, A/C, RADIO, POWER STEERING, ENGINE WAS RUNNING ROUGH, THEN THE CHECK ENGINE LIGHT CAME ON. COULD BE A SAFETY ISSUE OF CONTROL OF VEHICLE FOR DRIVERS NOT PAYING ATTENTION. TOYOTA DEALER SAID THE ROOT CAUSE WAS A BAD CELL IN BATTERY THAT CAUSED THE IGN#2 FUSE TO BE BLOWN. THESE BATTERIES HAVE KNOWN ISSUES TO BE BAD FROM THE FACTORY. REPORTED EARLIER ABOUT 30000 MILES THE FACTORY BATTERY WOULD NOT START VEHICLE AND DEALER SAID THEY REPLACED BECAUSE OF A BAD CELL. I OWN A 2008 TOYOTA TACOMA ALSO , SAME MODEL AND MAKE AS BEING REPORTED AND THAT BATTERY HAS BEEN REPLACED 2 TIMES FOR SAME REASON.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11003672July 7, 2017
ENGINE
TL* THE CONTACT OWNS A 2012 TOYOTA TACOMA. AFTER STARTING THE VEHICLE, THE CHECK ENGINE, TRACTION CONTROL, AND MAINTINENCE INDICATORS REMAINED ILLUMINATED. WHILE DRIVING, THE VEHICLE WOULD NOT ACCELERATE PAST 25 MPH. THE VEHICLE WAS TAKEN TO AUTONATION TOYOTA IN HOUSTON, TEXAS WHERE IT WAS DIAGNOSED THAT THE ENGINE AIR PUMP AND AIR VALVE WERE FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 45,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11002478June 30, 2017
POWER TRAIN
I HAVE 27,000 MILES ON MY TRUCK AND THE REAR DIFFERENTIAL IS DEFECTIVE. I AM AFRAID IT WILL LOCK UP AT HIGH SPEEDS, 55 MPH + AND CAUSE AN ACCIDENT!! TOYOTA WON'T FIX IT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10995601June 16, 2017
ENGINE
TL* THE CONTACT OWNS A 2012 TOYOTA TACOMA. WHILE DRIVING 62 MPH, THE CHECK ENGINE INDICATOR ILLUMINATED AND THE VEHICLE BEGAN TO LOSE POWER. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A LIMP HOME SETTING. THE CONTACT STATED THAT HE WAS AES CERTIFIED. THE CONTACT STATED THAT THE TOW HITCH WAS IN USE WHEN THE FAILURE OCCURRED. THE VEHICLE WAS TAKEN TO A LOCAL DEALER (FIORE TOYOTA VOLKSWAGEN 1000 S. LOGAN BLVD, HOLIDAYSBURG, PA 16648) WHERE IT WAS DIAGNOSED THAT THE SECONDARY AIR INJECTION SWITCHING VALVE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BY THE CONTACT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT DID NOT OFFER ANY ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 88,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10995268June 15, 2017
ENGINE
I WAS LEAVING WORK AND PULLING ONTO THE HIGHWAY WHEN I NOTICED MY CHECK ENGINE LIGHT CAME ON, AS WELL AS THE TRAC OFF LIGHT. I WENT TO PULL INTO TRAFFIC AND IMMEDIATELY REALIZED THAT WHATEVER WAS WRONG PUT MY TRUCK INTO LIMP MODE AND HAD A 2500 RPM LIMIT. THIS WAS A 60 MPH HIGHWAY AND I COULDN'T GO MORE THAN 35 MPH. THE TRAFFIC COMING WAS IMMEDIATELY UPON ME AND I HAD TO PULL OVER AND PUT ON MY HAZARD LIGHTS AS THESE VEHICLES HAD TO SLAM ON THEIR BRAKES, HONK, AND SWERVE AROUND ME. I BROUGHT IT INTO THE DEALERSHIP AND THEY READ CODE P2442. WHICH IS FOR A STUCK SECONDARY AIR INJECTION VALVE. THEY FOUND WATER IN THE VALVES AND THEY HAD TO BE REPLACED. DOING SOME RESEARCH I FOUND THIS IS A VERY COMMON ISSUE IN 2ND GEN TACOMAS, MOSTLY THE 2012. THIS A VERY WELL KNOWN ISSUE, ESPECIALLY TO TOYOTA, AND THEY HAVE SO FAR DONE NOTHING ABOUT IT. THIS LED TO A VERY DANGEROUS NEAR CRASH INCIDENT WHICH I THEN HAD TO PAY OVER 1200 DOLLARS TO FIX. THIS IS COMPLETELY UNACCEPTABLE. TOYOTA MUST AT LEAST TAKE OWNERSHIP OF THEIR POORLY DESIGNED PARTS AND COVER THE REPLACEMENT OF THESE VALVES AND PUMPS. THIS IS HAPPENING ALL OVER THE COUNTRY ON A CONSISTENT AND PERSISTENT BASIS. PLEASE MAKE TOYOTA ADDRESS THIS, THEIR CUSTOMERS DESERVE SO MUCH BETTER.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10995396June 15, 2017
ELECTRONIC STABILITY CONTROL (ESC), VEHICLE SPEED CONTROL
I HAVE CHECK ENGINE LIGHT ON AND THE TRAC OFF LIGHT ON. THIS COMMON PROBLEM WIYHE TUNDRA MODEL. ALOT OF TACOMA OWNER HAVE SAME PROBLEM BUT TACOMA DOE NOT HAVE EXDENDED WARRANTY LIKE THA TUNDRA. MY TRUCK ONLY HAVE 59K MILES IT'S ONLY 5YEARS AND 3 MONTHS OLD THEY SAID WON'T COVER THE PROBLEM. PROBLEM 1 SECONNDARY INJECTION SYSTEM VALVE I HAVE TO CODE P2440 P2442.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10994287June 10, 2017
UNKNOWN OR OTHER
P2442
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10993736June 7, 2017
ENGINE
SECONDARY AIR INJECTION SYSTEM (P2442). THIS HARDWARE DEFECT HAS BEEN A RECALL FOR TUNDRA BUT NOT FOR TACOMA. THE PART IS DEFECTIVE ON MOST 2012 TACOMA AND VERY EXPENSIVE TO REPLACE. THERE ARE SAFETY ISSUE AS THE VEHICLE UNABLE TO ACCELERATE, BUT ONLY ABLE TO LIMP. THERE ARE MANY DISCUSSIONS ABOUT THIS ISSUE BUT TOYOTA HAS NOT DONE ANYTHING ABOUT THIS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10993149June 5, 2017
UNKNOWN OR OTHER
P2442 TOYOTA SECONDARY AIR INJECTION SYSTEM SWITCHING VALVE STUCK OPEN BANK 2 I HAVE GOT THIS CODE THREE TIMES NOW AND THE SECONDARY AIR INJECTION PUMP AND VALVES WILL HAVE TO BE REPLACED. THERE IS 33,282 MILES ON THE TRUCK RIGHT NOW. MANY, MANY, MANY COMPLAINTS ONLINE ABOUT THIS ISSUE BUT TOYOTA IS IGNORING IT. $1900 FIX IS VERY STEEP FOR A TRUCK WITH 33K MILES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10992726June 1, 2017
ELECTRONIC STABILITY CONTROL (ESC), ENGINE, UNKNOWN OR OTHER
VEHICLE WAS IN MOTION ON RAINY, WET HIGHWAY WHEN CHECK ENGINE LIGHT WENT ON AND TRACTION CONTROL WAS SHUT OFF. THE SECONDARY AIR INJECTION SWITCHING VALVE IS APPARENTLY STUCK CLOSED, WHICH FOR SOME REASON SHUTS OFF THE TRACTION CONTROL. IT IS MY UNDERSTANDING FROM SPEAKING WITH OTHER TACOMA AND TUNDRA OWNERS THAT HAD THE VALVES GOTTEN STUCK OPEN, THE VEHICLE GOES INTO "LIMP MODE" WHICH AUTOMATICALLY DECREASES SPEED TO 20MPH. OBVIOUSLY, EITHER OF THESE OCCURRENCES ARE PARTICULARLY UNSAFE IN RAINY AND WET CONDITIONS, AND THE DECREASE IN SPEED IS UNSAFE DURING ANY HIGHWAY TRAVELING. THIS IS APPARENTLY A BIG ENOUGH ISSUE ON THE TUNDRA MODELS FOR TOYOTA TO EXTEND THE WARRANTY TO 150,000MI, YET THEY HAVE DONE NOTHING FOR THE TACOMAS WHICH HAVE AN IDENTICAL SYSTEM AND PARTS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10992580May 31, 2017
ENGINE, FUEL/PROPULSION SYSTEM
FAILURE OF THE SECONDARY AIR INJECTION PUMP AND VALVE EMISSION SYSTEM PROMPTED ENGINE TO RUN IN A REDUCED POWER MODE, AND THIS OCCURRED ON A ON A RELATIVELY NEW VEHICLE WITH BELOW AVERAGE MILEAGE. WHILE SETTING MAY PROTECT ENGINE, THIS CREATED AN UNSAFE DRIVING ENVIRONMENT FOR VEHICLE WITHIN FAST MOVING TRAFFIC. MY COMPLIANT IS NOT RELATED TO THE REDUCED DRIVING MODE THAT MAY HAVE PROTECTED THE ENGINE, BUT RATHER THE POOR DESIGN OF THE AIR-PUMP/VALVE SYSTEM THAT PREMATURELY FAILED CAUSING THE REDUCED POWER MODE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10992178May 30, 2017
POWER TRAIN
THE SECONDARY AIR INTAKE SYSTEM GOES OUT FAIRLY QUICKLY. MY VEHICLE IS AT 72,500 MILES. THIS CAUSES THE CAR TO GO INTO "LIMP" MODE WHICH MAKES THE CAR GO A MAXIMUM OF 40MPH. THIS CAN BE VERY DANGEROUS IF IT WERE TO KICK IN WHILE ENTERING THE HIGHWAY. IT IS AN EMISSIONS ITEM, BUT TOYOTA IS NOT COVERING IT UNDER THE EMISSIONS WARRANTY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10992077May 29, 2017
ENGINE
MY TRUCK'S CHECK ENGINE LIGHT AND TRAC OFF LIGHT CAME ON AND I TOOK IT TO MY LOCAL REPAIR SHOP. THE MANAGER TOLD ME THAT AFTER THE LEVEL 1 DIAGNOSTIC, A P2442 ERROR CODE APPEARED (SWITCHING VALVE STUCK). THE VALVES, AND AIR PUMP ARE PART OF THE SECONDARY AIR INJECTION SYSTEM WHICH DIVERTS SOME EXHAUST BACK INTO THE ENGINE TO REDUCE EMISSIONS OUTPUT. AS PART OF THE TRUCK'S EMERGENCY SYSTEM, THE TRUCK LIMITED THE ENGINE OPERATION PARAMETERS TO ABOUT 2000RPM, AND ABOUT 40MPH MAXIMUM. EXPRESS OIL CHANGE AND TIRE ENGINEERS QUOTED THE PARTS AT AROUND $1500, NOT INCLUDING LABOR. THE DAY OF DIAGNOSIS, THE TRUCK HAD 72,952 MILES AND WAS PURCHASED NOV. 2011. CURRENTLY UNABLE TO SAFELY DRIVE MY TRUCK IN NORMAL TRAFFIC. FACING A NEARLY $2K BILL, I DECIDED TO DO SOME DIGGING INTO EMISSIONS WARRANTY INFORMATION AND FOUND THAT THOSE PARTS WERE NOT GOING TO BE COVERED BY THE 8YR/80,000 MILE FEDERAL EMISSION CONTROL WARRANTY AS OUTLINED IN MY WARRANTY AND MAINTENANCE GUIDE, EVEN THOUGH THESE ARE A CRITICAL PART OF THE SYSTEM. WHILE ONLINE, I READ SEVERAL POSTS ON TACOMAWORLD.COM WHERE SEVERAL OTHERS WERE HAVING THE SAME ISSUES. WHAT WAS MORE CONCERNING WAS THAT THIS VERY SAME ISSUE WAS VERY COMMON IN TOYOTA TUNDRA NOT LONG AGO AND THE MANUFACTURER EXTENDED THEIR WARRANTIES TO COVER THE COSTS BECAUSE IT WOULD APPEAR TO BE A MANUFACTURER DEFECT. NOW, THE VERY SAME THING IS HAPPENING WITH TACOMA BUT THE EXTENDED WARRANTY HAS NOT BEEN EXTENDED TO MY TRUCK. THE SERVICE LIGHTS HAVE SINCE COME BACK ON AND THE TRUCK IS NOT DRIVABLE, I HAVE YET TO GET A HOLD OF TOYOTA BUT BECAUSE OF THE HOLIDAY, I WILL HAVE TO WAIT UNTIL THE MORNING BUT NOT EXPECTING MUCH. WHO WILL PAY FOR MY RENTAL CAR WHILE I'M PAYING THIS BILL? HTTPS://WWW.TACOMAWORLD.COM/THREADS/SECONDARY-AIR-INJECTION-SYSTEM-P2440-AND-P2442.370792/ HTTP://WWW.TUNDRAHEADQUARTERS.COM/BLOG/TOYOTA-WARRANTIES-AIR-INJECTION-PUMP/
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10991879May 26, 2017
ENGINE
AS I WENT FROM SIDE ROAD TO MAIN ROAD, TRUCK WOULD NOT ACCELERATE TO FULL SPEED EVEN WITH FOOT ON THE PEDAL, INDICATORS TRAC OFF AND CHECK ENGINE WERE LIT. WENT TO MECHANIC AND ERROR CODES P2440 AND P2442 INDICATED MALFUNCTION IN SECONDARY AIR INJECTION SYSTEM. WAS TOLD NEW AIR PUMP AND DIVERTER VALVE REQUIRED AT COST OF $2K. TRUCK HAS LESS THAN 30K ON IT,BUT IS 5 YEARS OLD. GOING INTO LIMP MODE IS DANGEROUS AS THE MAIN STREET IS 55MPH. TOYOTA STATES TUNDRAS HAVE SAME ISSUE THAT IS NOW COVERED BY 10 YEAR/150K WARRANTY, BUT NOTHING FOR TACOMA OWNERS. SO I AM QUITE ANGRY WITH THAT AS WELL. HAVE READ ONLINE THAT MANY OTHER OWNERS ARE HAVING SAME ISSUES. TOYOTA SHOULD RECALL THESE DEFECTIVE PUMPS AND VALVES IN ADDITION TO DISABLING THE LIMP MODE AS IT IS VERY DANGEROUS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10991068May 22, 2017
ENGINE
SECONDARY AIR INJECTION VALVE QUIT WORKING AND PUT MY TRUCK INTO A 'LIMP MODE.' DURING THIS TIME MY SPEED WAS CUT NO MORE THAN 40 M.P.H. I WAS MERGING ONTO THE HIGHWAY AT THE TIME AND IT CREATED A VERY UNSAFE CONDITION. I STARTED RESEARCHING THE ISSUE AND SAW A TON OF OTHER PEOPLE HAD THE EXACT SAME ISSUE. I'M SURE TOYOTA KNEW ABOUT IT AS WELL, BECAUSE THE MECHANIC AT THE DEALERSHIP DID. WHY DIDN'T THEY PUT OUT AN ALERT OR RECALL??
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10990807May 21, 2017
UNKNOWN OR OTHER
SECONDARY AIR INJECTION PUMP. RECEIVING P2442 CODE AND TRUCK IS GOING IN TO LIMP MODE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10986305May 18, 2017
ENGINE
2012 TOYOTA TACOMA. THE VEHICLE HAS CODES P2440, P2441, P2442 RELATING TO THE SECONDARY AIR INJECTION SYSTEM (SAIS) VALVES BEING STUCK OPEN/CLOSED. THIS APPEARS TO BE A COMMON PROBLEM WITH 2012 TACOMA VEHICLES AND SEVERAL YEARS FOR TUNDRA VEHICLES. FOR THE TUNDRA, TOYOTA INSTITUTED A CUSTOMER SUPPORT PROGRAM AND EXTENDED THE WARRANTY COVERAGE FOR THE SAIS. WITH THE VEHICLE HAVING ONLY 47,391 MILES, IT IS OUTRAGEOUS THAT THE SAIS WOULD HAVE ISSUES OR FAILURES ESPECIALLY BEING A TOYOTA. SINCE THE TRUCK IS IN LIMP MODE AND NOT SAFE TO DRIVE, IT WILL HAVE TO BE TOWED TO A DEALERSHIP. BETWEEN THIS ISSUE AND A NOISE AND PULLING PERIODICALLY FROM THE FRONT DIFFERENTIAL/DRIVETRAIN, WE ARE VERY DISAPPOINTED IN THIS VEHICLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10986103May 16, 2017
ELECTRICAL SYSTEM
MY 2012 TACOMA HAS A SPIRAL WIRE ISSUE THAT DEALER REFUSES TO FIX EVEN THOUGH THIS PART IS ASSOCIATED WITH THE TAKATA RECALL IN PREVIOUS YEAR MODELS WONDERING WHY THE RECALL STOPPED AT 2011 AND DOES NOT COVER THE ISSUE WITH MY TRUCK. CURRENTLY ONLY AFFECTIN THE USE OF MY HORN BUT AS SEEN IN PREVIOUS RECALLS COULD AFFECT MORE LTHINGS LATER ON.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tacoma