Toyota Tacoma Complaints (2006)

782 consumer complaints on file.

#11342455July 30, 2020
UNKNOWN OR OTHER
RUSTY FRAME, I WAS JUST TOLD BY MY LOCAL TOYOTA THAT MY FRAME RECALL EXPIRED LAST JANUARY 2019. I WAS NOT AWARE THAT A RECALL EXPIRES, NOW MY DAUGHTER HAS TO DRIVE AN UNSAFE VEHICLE. THERE IS ONE SPOT ON THE FRAME WHERE I CAN PUT MY WHOLE HAND INTO. PLEASE ADVISE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11337398July 4, 2020
SERVICE BRAKES, POWER TRAIN, SUSPENSION
EXCESSIVE CORROSION AND RUSTED THROUGH FRAME THAT IS UNABLE TO SUPPORT WEIGHT OF VEHICLE. HAD A BRAKE LINE BUST DUE TO BEING RUSTED OR CORRODED OUT. ALSO SUSPENSION SHOWS EXCESSIVE RUST AND CORROSION. COOLING LINES CORRODED. POWER STEERING LINES CORRODED. TRANSMISSION LINES CORRODED. ANY METAL LINE IS THAT'S ATTACHED TO THIS VEHICLE ARE CORRODED. AND ALL BRACKETS AND HARDWARE ATTACHED TO FRAME AND EVEN THE METAL PULLEYS ALL EXCESSIVELY CORRODED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11337237July 2, 2020
AIR BAGS:FRONTAL:DRIVER CLOCKSPRING/SPIRAL CASSETTE
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED THAT THE CLOCKSPRING FAILED TO FUNCTION AS DESIGNED, WHICH CAUSED THE AIR BAG WARNING LIGHT TO ILLUMINATE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V092000 (AIR BAGS). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 173,170.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11328316June 11, 2020
AIR BAGS, SEAT BELTS
PREVIOUS OWNER REMOVED DRIVER AIRBAG AND SEAT BELT HARNESS (WEBBING ONLY) DUE TO RECALLS. THE PART THAT CAUSED THE RECALL FOR THE SEAT BELT IS STILL ATTACHED TO THE VEHICLE. LOCAL DEALERSHIP WILL NOT HONOR RECALL. CONTACTED TOYOTA (CASE #[XXX]) AND THEY TOO WILL NOT HONOR THE RECALL. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11326005May 26, 2020
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS, SUSPENSION
WHEN INSPECTING THE LEAF SPRING REPLACEMENT FROM A RECALL, FOUND THE FRAME CORRODED TO THE POINT THAT IT WILL FAIL. (SEE PHOTO). TOYOTA HAD A RECALL ON THESE FRAMES AND THIS TRUCK FELL UNDER THE GUIDELINES.WHEN I CONTACTED TOYOTA THEY SAID THIS WAS AN EXTENDED WARRANTY AND HAD EXPIRED.SAID THEY SENT NOTIFICATION WHICH I NEVER RECEIVED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11325342May 20, 2020
STEERING, SUSPENSION, UNKNOWN OR OTHER, STRUCTURE
THIS VEHICLE IS COVERED IN THE TOYOTA RUSTY FRAME LAWSUIT. AS SUCH, IT HAS BEEN INSPECTED BY 2 DIFFERENT DEALERS AND DEEMED NOT TO NEED A FRAME REPLACEMENT BOTH TIMES. IT WAS TREATED WITH CRC. ITS LAST INSPECTION WAS IN NOVEMBER OF 2018. ON SUNDAY, MAY 17TH, 2020, THE FRAME BROKE AT THE FRONT CROSS-MEMBER CAUSING THE LEFT FRONT LOWER CONTROL ARM TO SEPARATE AND STEERING THE VEHICLE/CONTROLLING THE VEHICLE BECAME NEAR IMPOSSIBLE. FORTUNATELY FOR ME, THIS HAPPENED IN A PARKING LOT BACKING OUT OF A PARKING SPACE AND TURNING LEFT (IN REVERSE AT LOW SPEED) AFTER A FULL 2 WEEKS OF DRIVING IN THE MOUNTAINS OF WEST VIRGINIA. I QUESTION ALL INSPECTIONS OF FRAMES BEING PERFORMED WITHIN THE TOYOTA DEALER NETWORK AND HOPE THAT NOBODY HAS THIS FAILURE WHILE THEY ARE DRIVING AT SPEED AS THE RESULTS WILL BE CATASTROPHIC. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11323175May 4, 2020
STRUCTURE:BODY
TL* THE CONTACT OWNED A 2006 TOYOTA TACOMA. THE CONTACT STATED THAT THE ENTIRE SUBFRAME WAS SEVERELY RUSTED. THE VEHICLE WAS TAKEN TO TOYOTA SOUTH (961 FOUR MILE RD, RICHMOND, KY 40475, (859) 624-1313) AND THE CONTACT WAS INFORMED OF TOYOTA WARRANTY ENHANCEMENT PROGRAM ZH6 HOWEVER, THE WARRANTY PERIOD WAS EXPIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 262,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11321945April 22, 2020
STRUCTURE:BODY
TOYOTA WAS FORCED TO GIVE A WARRANTY ENHANCEMENT FOR FRAMES ON A NUMBER OF TRUCKS BECAUSE OF RUST. THE WARRANTY HAS EXPIRED BUT I SILL HAVE THE OLD RUST PRONE FRAME. THIS SHOULD HAVE BEEN A RECALL THAT DOES NOT EXPIRE, WHAT HAPPENS TO ME DOWN THE ROAD WHEN MY FRAME FAILS? SINCE THE PROBLEM WILL NOT GO AWAY HOW IS THE WARRANTY LIMITED? THIS IS NOT RIGHT, HOW CAN I RESELL A TRUCK THAT HAS A FAULTY FRAME? I AM UPSET THEY GOT AWAY WITH OUT A RECALL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11321520April 18, 2020
STEERING
STEERING BECAME VERY STIFF WHILE DRIVING IN TOWN YESTERDAY. UPON MAKING A RIGHT TURN AT A FAMILIAR INTERSECTION, IT BECAME DIFFICULT TO MAKE THE TURN DUE TO VERY STIFF STEERING. THE FRONT END OF MY TRUCK CAME VERY CLOSE TO A VEHICLE COMING INTO THE INTERSECTION FROM THE STREET I WAS TURNING INTO, AND THEN THE USUAL RETURN OF MY WHEELS TO STRAIGHT AHEAD DID NOT OCCUR AS EXPECTED, AND I HAD TO QUICKLY FORCE THE STEERING WHEEL BACK BEFORE I RAN UP OVER THE CURB ON MY RIGHT. LUCKILY THE CAR COMING INTO THE INTERSECTION HAD BEEN FAR ENOUGH BACK FROM THE INTERSECTION THAT WE DID NOT COLLIDE, AND IF I HAD NOT FORCED THE STEERING WHEEL BACK AT THE END OF THE TURN I MAY HAVE HIT PEDESTRIANS ON THE SIDEWALK. UPON INVESTIGATING THIS PROBLEM WITH A MECHANIC IMMEDIATELY AFTER THE INCIDENT (YESTERDAY AFTERNOON) AND AT ONLINE FORUMS, THE MOST LIKELY CAUSE SEEMED TO BE THE U-JOINT ON THE LOWER INTERMEDIATE SHAFT OF THE STEERING COLUMN DOWN JUST BEFORE THE STEERING GEAR, JUST INSIDE THE LEFT FRONT WHEEL. PER SOME ONLINE FORUM ADVICE, I USED PENETRATING OIL ON THAT U-JOINT TO LOOSEN IT, WITH GOOD RESULTS (STIFFNESS IS NOW GONE). BUT THIS SEEMS MOST LIKELY TO BE A TEMPORARY FIX. I DOUBT THAT LOOSENING THE U-JOINT TODAY WILL KEEP IT FROM A REPEAT PERFORMANCE AT SOME UNKNOWN AND UNPREDICTABLE TIME. CLEARLY THIS COULD CAUSE ACCIDENTS, AND PER ONLINE FORUMS, IT HAS APPARENTLY BEEN A KNOWN ISSUE FOR A WHILE. THERE ARE NO GREASE FITTINGS ON THE U-JOINT, SO THERE IS NO WAY TO PUT A MORE PERMANENT LUBRICANT (GREASE) INTO THE BEARINGS OF THE U-JOINT. ALSO, THE U-JOINT IN QUESTION IS NOT PROTECTED BY A RUBBER BOOT, AND IS COMPLETELY EXPOSED TO ALL THE WATER, DIRT, AND SALT THAT SPLASHES UP WHILE DRIVING. OTHERS HAVE NOTED THAT SPRAYING WITH PENETRATING OIL OR THE LIKE IS ONLY A TEMPORARY FIX, AND THE STIFF STEERING PROBLEM RETURNS AFTER A TIME, MAKING AN ACCIDENT MUCH MORE LIKELY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11319099March 24, 2020
SUSPENSION
THE SUBJECT VEHICLES' REAR SUSPENSION SYSTEM CONTAINS LEAF SPRINGS THAT ARE CONSTRUCTED OF EITHER THREE OR FOUR LEAVES. THERE IS A POSSIBILITY THAT A LEAF COULD FRACTURE DUE TO STRESS AND CORROSION. IF THIS OCCURS AND THE VEHICLE CONTINUES TO BE OPERATED, THE BROKEN LEAF COULD MOVE OUT OF POSITION AND CONTACT SURROUNDING COMPONENTS, INCLUDING THE FUEL TANK. SAFETY RISK: IF THE BROKEN LEAF CONTACTS THE FUEL TANK REPEATEDLY, IT COULD PUNCTURE THE TANK AND CAUSE A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, THIS COULD RESULT IN A FIRE. REMEDY: TOYOTA WILL REPLACE THE LEAF SPRINGS WITH NEWLY DESIGNED ONES. IT HAS BEEN REPAIRED I NEED TO HAVE IT SHIPPED OFF ISLAND ASAP
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11315970March 4, 2020
STRUCTURE:BODY, ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
THE ENTIRE FRAME OF THIS GARAGE KEPT TRUCK IS COMPLETELY RUSTED THOUGH. THIS TRUCK AS ONLY 61,000 MILES ON IT & IS UNSAFE TO DRIVE. THE REAR LEAF SPRING MOUNTS ARE BROKEN & HAVE PUNCTURED THE GAS TANK. THE ELECTRICAL WIRING TO DO WITH THE SAFETY NEUTRAL SWITCH, WHICH IS TIED INTO THE ENTIRE FROM WIRING HARNESS HAS CAUGHT FIRE TWICE. TOYOTA HAS BEEN NOTIFIED ABOUT ALL OF THIS, IN DETAIL, & THEY COULD CARE LESS ABOUT MY OWN OR ANYONE ELSE'S SAFETY. THERE ISN'T A SCRATCH ON THIS TRUCK & HAS REALLY LOW MILES YET IS SO UNSAFE TO USE BECAUSE OF POOR CONSTRUCTION ON TOYOTA'S PART.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11315663March 2, 2020
STRUCTURE:BODY, UNKNOWN OR OTHER
MY 2006 TOYOTA TACOMA WAS RECALLED DUE TO TOYOTA'S FRAME RUST AND CORROSION ISSUE. AFTER NOTIFICATION, JULY 2015, I BROUGHT MY CAR TO TOYOTA OF WALLINGFORD (DEALER) AS INSTRUCTED IN THE RECALL NOTICE FOR A FRAME INSPECTION. THE DEALER INSPECTED THE TRUCK FRAME AND SAID IT WAS NOT ELIGIBLE FOR A NEW FRAME AS THE FRAME PASSED THEIR INSPECTION. I DISPUTED THIS BECAUSE I WAS ABLE TO PUSH MY FINGER THROUGH PARTS OF THE FRAME. THEY INSISTED THAT THE INTEGRITY WAS SOUND. THEIR RECOMMENDATION WAS TO SPRAY THE CAR WITH A CORROSION RESISTANT COVERING (CRC). AFTER SOME DEBATE I TOOK THEIR RECOMMENDATION AND AUTHORIZED THE WORK. THE CRC WAS A THICK BLACK GEL THAT COVERED THE FRAME, SO RUST, ROT AND DETERIORATION WAS COMPLETELY HIDDEN. IN RETROSPECT, I BELIEVE THEY INTENTIONALLY COVERED THE RUST SO ISSUES COULD NOT BE DETECTED AND RE-INSPECTION DID NOT OCCUR. RECENTLY I HAD TO REPLACE THE TIRES ON THE TRUCK. WHEN THE TIRE DEALER PUT THE TRUCK ON THE LIFT HE NOTICED THE FRAME WAS BOWING AND LARGE PIECES OF THE FRAME WERE MISSING. THE CRC WAS STILL COVERING THE RUST BUT LARGE HOLES IN THE FRAME WERE DETECTED. THE TIRE SPECIALIST WOULD NOT WORK ON THE TRUCK DUE TO THE UNSTABLE FRAME, SO I QUICKLY CALLED THE TOYOTA DEALER TO RE-INSPECT THE FRAME. THEY CONCLUDED THAT THE FRAME WAS ROTTED AND NEED TO BE REPLACED, BUT INFORMED ME THAT THE DEADLINE UNDER THE RECALL HAD JUST PASSED ON 1/31/19. THEY WOULD NOT COVER ANY REPAIRS ALTHOUGH I FOLLOWED EVERY STEP AND ENDURED EVERY INCONVENIENCE FOR A ROT ISSUE THAT THEY WERE ALWAYS RESPONSIBLE FOR. UNSATISFIED WITH THE DEALER'S RESPONSE, I CONTACTED TOYOTA DIRECTLY AND THEY REAFFIRMED THAT THEY WOULD NOT COVER THE FRAME. TOYOTA DID NOT RESOLVE ALL ISSUES RELATED TO THEIR FAULTY FRAMES. THEY BRILLIANTLY CAME UP WITH A SOLUTION THAT HID THE RUST AND ROT AND SAVED THE COMPANY MILLIONS BY MASKING THE ISSUE AND NOT REPLACING THE BAD FRAMES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11308987February 13, 2020
UNKNOWN OR OTHER
BODY FRAME PERFORATION CAUSED BY RUST AFTER REMEDIATION BY TOYOTA PURSUANT TO THE TERMS OF A CLASS ACTION LAWSUIT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11301583January 24, 2020
VEHICLE SPEED CONTROL
ON DECEMBER 1, 2019 I WAS BACKING INTO A GAS STATION FILL UP SPOT. AS I LET OFF THE GAS TO APPLY PRESSURE TO THE BRAKES THE TRUCK REVVED UP AND STARTED ACCELERATING IN REVERSE. I APPLIED AS MUCH PRESSURE TO THE BRAKES AS POSSIBLE ONLY TO CONTINUE ACCELERATING IN REVERSE. I COULD FILL THE TRUCK'S BRAKES ATTEMPTING TO STOP THE VEHICLE BUT THE TRUCK'S BACK TIRES ARE SQUEALING OVER POWERING THE BRAKES. I FINALLY COME TO A STOP ON ONE OF THE POLES THAT PROTECTS THE GAS PUMPS AFTER HITTING ANOTHER VEHICLE. I HAVE CONTACTED TOYOTA AND THEY SENT A THIRD PARTY COMPANY TO PULL THE INFORMATION FROM THE EVENT DATA RECORDER. I WAS TOLD I WOULD GET A REPORT OVER WHAT THEY SAID HAPPENED WITHIN 30 DAYS AFTER THE THIRD PARTY HAS INSPECTED THE VEHICLE. IT HAS NOW BEEN 37 DAYS AND TOYOTA IS REFUSING TO GIVE ME ANY INFORMATION. I HAVE DONE ALL THE RECALLS THAT HAVE BEEN ISSUED ON THE 2006 TACOMA. ON ONE RECALL THEY INSTALLED AN OVERRIDE THAT WOULD HAVE DECREASED ACCELERATION IN THE EVENT THAT BOTH THE BRAKE AND GAS WERE BEING DEPRESSED AT THE SAME TIME. THIS DID NOT WORK IN MY ACCIDENT. I HAVE NOTICED ON THIS SITE THAT THERE ARE 144 OTHER COMPLAINTS ON THIS MAKE AND MODEL OF TRUCK OF THE SAME THING OCCURRING, YET THAT IS NOT ENOUGH TO SAY THAT THE TRUCK IS UNSAFE? I AM CONVINCED THAT THE TRUCK IS A DANGER AND TOYOTA IS NOT RESPONDING AND HAVE MISSED THE DEADLINE OF GETTING ME THE REPORT WITHIN 30 DAYS.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11298601January 11, 2020
UNKNOWN OR OTHER
DEALER DID NOT APPLY THE CORROSION RESISTANT COMPOUND TO THE FRAME DURING THE WARRANTY ENHANCEMENT PERIOD AS I REQUESTED. THEY DID NOT NOTIFY ME WHEN THEY WERE CAPABLE OF DOING SO UNTIL AFTER THE WARRANTY WAS EXPIRED.AS A RESULT DURING THE WARRANTY PERIOD, THE FRAME DEVELOPED MAJOR RUST PERFORATION RESULTING IN FRAME CRACKING.AT THAT POINT THE VEHICLE WAS UNSAFE TO DRIVE.THE DEALER ALSO WOULD NOT REPLACE THE FRAME AS PER THE WARRANTY ENHANCEMENT PROGRAM. I MADE NO PROGRESS WITH EAST MADISON TOYOTA OR TOYOTA CORPORATE OVER THIS ISSUE.I HAVE FILED A COMPLAINT WITH TOYOTA CORPORATE, THE BETTER BUSINESS BUREAU AND ALSO CONTACTED DATCP. I AM BASICALLY GETTING NOWHERE WITH THIS ISSUE AND AM LEFT WITH A VEHICLE SITTING IN THE BACKYARD USELESS.IF THEY KNOW THE FRAME IS FAULTY WHY DON'T THEY FIX IT ? I COULD HAVE BEEN KILLED OR KILLED SOMEONE ELSE DRIVING DOWN THE ROAD WITH THIS DANGEROUS PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11291462December 27, 2019
ENGINE
WHEN FIRST STARTUP IN MORNING, I HEAR A BAD KNOCKING NOISE IT GOES AWAY AFTER THE ENGINE WARMS UP BUT AS SOON AS IT COOLS OFF, IT IS BACK AGAIN.. HAPPENS MOSTLY WHEN IT IS COOLER
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11286925December 4, 2019
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. WHILE THE VEHICLE WAS UNDERGOING A ROUTINE INSPECTION AT MAUI TOYOTA (320 HANA HWY, KAHULUI, HI 96732, (808) 877-2781), THE MECHANIC NOTICED RUST ON THE CHASSIS AND A HOLE IN THE FRAME. THE CONTACT HAD TO SIGN A WAIVER. THE VEHICLE WAS REPAIRED AND IN DRIVABLE CONDITION. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 75,895. *DT*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11278091November 4, 2019
ENGINE
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. WHILE THE VEHICLE WAS PARKED, THE CONTACT COULD SMELL SMOKE NEAR THE VEHICLE. THE CONTACT OBSERVED FLAMES AROUND THE FRONT DRIVER'S SIDE WHEEL. WHILE THE VEHICLE WAS ON FIRE, THE CONTACT DROVE THE VEHICLE HOME TO EXTINGUISH IT WITH A FIRE EXTINGUISHER. THE FIRE AND POLICE DEPARTMENTS WERE NOT CONTACTED. THE CONTACT CALLED PAT LOBB'S TOYOTA OF MCKINNEY (LOCATED AT 3350 S CENTRAL EXPY, MCKINNEY, TX 75070, (214) 544-8696) AND INFORMED THEM OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 137,816.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11278159November 4, 2019
STRUCTURE:BODY, SUSPENSION
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT TOOK THE VEHICLE TO SERVCO AUTO KAUAI (LOCATED AT 2477 ULU MAIKA ST, LIHUE, HI 96766, (877) 292-9755) FOR INSPECTION. THE CONTACT WAS INFORMED THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION) AND THE BODY FRAME WAS RUSTED THROUGH. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 99,985.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11277721November 2, 2019
STRUCTURE:BODY
WHEN TOYOTA RECALLED TAKOMA TRUCKS FOR FRAME RUST I TOOK IT TO THE DEALER AND WAS TOLD IT DIDN'T HAVE ENOUGH RUST TO QUALIFY. NOW WHEN I HAD IT CHECKED OU THE MECHANIC SAID IT ISN'T SAFE TO DRIVE ANY MORE. WHEN I COMPLAINED TO TOYTA CUSTOMER SERVICE THEY SAID THE TIME FOR REPLACING THE FRAMES WAS OVER. THE TRUCK IS STILL DANGEROUS TO DRIVE AND I FEEL THE FRAME SHOULD BE REPLACED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tacoma