Toyota Tacoma Complaints (2016)

324 consumer complaints on file.

#11511000March 9, 2023
STEERING
POWER STEERING ISSUES, LEAKS, CORRODED. CAN LEAD TO ENTIRE RACK AND PINON REPLACEMENT. STEERING IS TIGHT, ACTIVE FLUID LEAK(S); TOYOTA DEALER THAT IT WAS PURCHASED FROM KNEW IT WAS LEAKING BUT REFUSED TO INVESTIGATE FURTHER. PER TOYOTA, POWER STEERING LEAKS CAN CAUSE ENGINE COMPARTMENT FIRE, VEHICLE SHOULD NOT BE DRIVEN UNTIL LEAK IS REPAIRED. HOWEVER, TOYOTA SERVICE DEPARTMENT WOULD NOT LOCATE THE LEAK AND REMEDY, LET ME DRIVE KNOWING IT COULD BE POTENIALLY HAZARDOUS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11509402February 27, 2023
UNKNOWN OR OTHER
Toyota has a recall for all of the White vehicles EXCEPT for the tacoma. The tacoma has the same issues with paint flaking off in sheets yet they will not cover the repairs or extend the recall to include the truck. There are thousands of us that have signed a change.org petition and complained to toyota but haven't received any support. My paint started flaking when it was just past the 36 month warranty. currently this flaking is on 9 of my body panels. Link to the online petition with photos. https://www.change.org/p/toyota-motor-company-hold-toyota-accountable-for-2008-2022-tacoma-super-white-peeling-paint
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11507715February 16, 2023
POWER TRAIN
Timing chain cover is leaving oil.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11505879February 6, 2023
ELECTRICAL SYSTEM, SEATS
Driver’s side front seat not delivering heat despite switch lamp indicating it’s on and working. Further exploration reveals passenger side seat heater working as it should. I checked wiring harness and connections under driver’s seat only to discover plastic connector entering amplifier scorched and melted with two of four pins destroyed (Red and Green wires). I believe the wire gauge sized for this system is improper and therefore represents a fire hazard. About the time the seat heater failed, I smelled a burning odor inside the car for a short time but didn’t associate the two events until later. The vehicle has 135,998 miles on it and therefore out of warranty. I spoke to the dealer who explained he’s had similar issues from other customers and added there is no recalls at this time.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11500806January 9, 2023
UNKNOWN OR OTHER, STRUCTURE:BODY
Recent in December wife said there’s a musty odor in truck. While vacuuming carpet on Friday 1/6/23 water came to surface. Searched everywhere for leak and found the 2 vents behind back seats had bad gaskets and leaking bad. After getting access under carpet, passenger side was dry but growing mold and drivers side is holding slimy water. The back seats are a little higher and we’re dry but signs of mold as well. These vents pop out through the cab outward but the bed has to be removed to replace them. I used silicone to seal from inside to stop water intrusion. Dealership no help, report and claim filed with Toyota corporate, insurance company and waiting for response. During the holidays, wife road in my truck several times and ended up spending a week in the hospital due to a fungal infection in her lungs and may be linked to the mold. While on a chat group, Tacoma Owners Group and Tacoma World, there are numerous other owners with the same issue and no help from Toyota.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11497655December 15, 2022
ENGINE
This vehicle is equipped with Toyota V6 Motor that was new in 2016. The issue is the Timing Chain Cover leaks oil. This was an issue on Toyota Motors before 2016 and Toyota issued a TSB for those. However Toyota has refused to acknowledge this ongoing issue in its post 2016 Motors. This is a very well know issue by Toyota.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11494588November 22, 2022
ENGINE
driving full speed car suddenly slows and light on dash reads accelerator and brake pressed at same time, although my foot is nowhere near the brake. This is 3rd time it has happened, Toyota say's it doesn't come up as error on their computer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11493345November 13, 2022
STRUCTURE:BODY
Hood latch, the hood would not fully close and lock! The dashboard warning light would come on indicating the latch was not working. The hood would be open approx 1/2 inch. Tried opening and closing numerous times. Finally, tied the hood closed with a bungee. Went to the local Toyota dealership. They (Service Technician) said he sees often! Sprayed with a solvent. Indicated corrosion around the small spring. A few weeks later, driving and the hood popped, secondary latch kept the hood from fully opening! Dashboard warning light illuminated. I pulled over and tied hood to secure until I could get to the Garage again! Indicated the spring was weak......no repair! Waiting for a disaster to happen at highway speed! Checked Google, and numerous reports by other 2016 owners for same problem!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11493228November 11, 2022
ELECTRICAL SYSTEM, SEATS
While driving down the road with my driver seat warmer on, the heating element and/or associated electronics burned a hole in the seat canvas and through the jacket I was wearing. I think a small fire started which I put out with my finger and then I turned off the seat heater.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11492383November 5, 2022
SUSPENSION
The control arm of the driver side fail during driving , I lost control of my Tacoma then the alarm stering activate. Then is was dificult to control the pickup and i almost hit a car that was next to me. When i take to the machanic shop he was alarm by the situation he told me that this was very dangerous , he found that the driver control arm was with a welding failure that i should make a request for the damages to the Toyota.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11491128October 27, 2022
FUEL/PROPULSION SYSTEM, POWER TRAIN, WHEELS
Vehicle made a loud bang from the rear of the vehicle , then started to slow down slightly without brakes applied. And then suddenly within a few more feet the Rear wheels locked up without brakes applied. Traveling at between 35- 45mph the vehicle skidded causing vehicles behind me to also skid to avoid hitting me. Truck would not move from this position , I was stuck in the lane without a shoulder to move close to . I was shaken pretty bad, out of fear I popped the truck into reverse and the rear of the truck made a loud bang or loud pop noise. It wouldn’t move back so I put it back in drive and it made another bang noise and started to roll forward with a lot of resistance . There was no safe place to park, I was close to home so I continued home driving very slow with my hazard lights on . Please help. I towed the truck to Servco Kauai Toyota 9-23-2022, they did not look at the truck until 10-20-2022 almost a month it sat at the Toyota. I went home and checked online to see if anyone had the same problem and found Tech. Bulletins and a Recall for this problem, I did not receive a letter for this recall. I had no idea there was even a Recall. Service advisor [XXX] and Service Manager [XXX]told me my vehicle does not fall into the criteria of this recall. Service Manager [XXX] said they are not part of Servco and this dealership would not perform this recall because it is a maintenance issue ( What ?) Please help . I towed My truck home , I m trying to sell my truck as is because the dealership gave me a quote of over $7000 to fix this problem. No one wants to buy my truck in this condition. Aloha [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11484570September 15, 2022
STRUCTURE:BODY, UNKNOWN OR OTHER
2016 TOYOTA TACOMA. CONSUMER WRITES IN REGARD TO PAINT ON THE ROOF OF VEHICLE BEING DISENTEGRATED. THE CONSUMER STATED THE MANUFACTURER WAS NOTIFIED, BUT DECLINED ANY ASSISTANCE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11482488September 1, 2022
ELECTRICAL SYSTEM
System Failure lost all directional and hazard lights on this vehicle . With no directional signals can cause a serious accident. vehicle is at dealership. component has not been inspected by the manufacture . No warning just stop working. This vehicle has no separate Flasher relay. Toyota did not honor the last request to fix a electrical issue. should be a recall for this issue as other Toyota Tacoma owners had the same issue
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11475269July 22, 2022
UNKNOWN OR OTHER
This tailgates passenger side rear hinge and bushing. Failed to hold integrity. My 4-year-old attempted to help me and load my truck up with some camping gear. He pulled the handle like he has before to drop the tailgate. The tailgate has a soft dampener built into it. This time the tailgate came of. I'm glad I was within arm's distance of him. I was able to grab the tailgate before it hit or perhaps could have crushed him. This could have Caused severe bodily injury or death. They were absolutely no warning signs before the situation happened. Upon further investigation you can find the right passenger bushing in multiple different pieces. Not sure what caused the failure in this part. But if I wasn't close by it could have seriously injured my child. And I suppose if the tailgate wasn't properly latched driving down the highway the tailgate could have come off also causing a large accident.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11474608July 18, 2022
AIR BAGS
I was involved in an accident and the airbags on my 2016 Toyota Tacoma did not deploy.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11472885July 8, 2022
EXTERIOR LIGHTING:FOG LIGHTS
The contact owns a 2016 Toyota Tacoma. The contact stated that while driving, the driver’s side fog light housing melted. There was an abnormal odor of smoke. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 143,749.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11472718July 7, 2022
ENGINE, POWER TRAIN
Vehicle pulls or skips a gears when driving
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11465484May 20, 2022
POWER TRAIN, VEHICLE SPEED CONTROL
I brought my truck into Miller Toyota of Anaheim due to a violent shuddering and acceleration at about 40 to 50 mph. This could have caused driver to lose control and injure themselves, passengers, and other drivers on the road. Dealership diagnosed the problem as a bad torque converter in the transmission and said it would cost about $3200.00 to repair. Couldn't afford that so I took vehicle to an independent repair shop and they notified me that there was a Toyota Service Bulletin that addressed this concern and that they would have to do a complete reprogramming update of Transmission Control Module. I haven't had any issues since this was done but the dealership should have been aware of this problem which could be potentially fatal. There were no warning lamps, messages or other symptoms prior to this failure or during the failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11459879April 6, 2022
ELECTRICAL SYSTEM, SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
The contact owns a 2016 Toyota Tacoma. The contact stated that while attempting to activate the seat warmer, he noticed that the seat warmer was inoperable. The contact researched and read that the module underneath the seat could potentially burn causing the seat warmer not to operate as designed. The contact stated that it was a common failure. The contact stated that he then looked at the module in his vehicle and saw that it was melted. The contact had not noticed any smoke or a burning odor. The dealer and manufacturer were notified of the failure. The failure mileage was 45,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11455349March 5, 2022
ENGINE
There is a known factory defect on a robotic seal around the engine block, in which the robot misses a half inch piece of the engine block, causing oil seepage and leaking of engine oil. The problem is on dozens of Toyota forums and I have also consulted with two different dealerships that have verified this. The 4 cylinder engines in the Tacoma have already been recalled for this issue but they are offering no reimbursement or recall on the 6 cylinder engines. The engine begins leaking oil early in it its life as mine has been. An engine should not fail at 20k 30k or 80k miles due to a factory defect. Toyota should be offering a fix for this issue as it will significantly cut the life of rhe engine. This can cause engine fire and various other safety issues in these trucks if enough engine oil leaks down into a hot engine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tacoma