Toyota Tacoma Complaints (2016)

324 consumer complaints on file.

#11622470October 29, 2024
UNKNOWN OR OTHER
Paint is chipping off in several places and have read this is a major problem with tacomas in the white color
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11620850October 20, 2024
ENGINE
Coolant leaking
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11619340October 11, 2024
STRUCTURE:BODY
The paint on my 2016 Toyota Tacoma is failing after a few years of owning the truck, it has been well maintained and washed but the problem keeps getting worse. I have searched online and it seems to be an issue with white and magnetic grey colored Toyota cars but no recall on magnetic grey paint.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11617152September 30, 2024
UNKNOWN OR OTHER
I have recently been made aware of the Super White paint recall and know that is not yet in full force or able to be serviced at this time. That being said, it appears that the recall only covers " paint peeling along the exterior door window frames and front inner fenders under the hood on certain Tacoma vehicles with 040 Super White paint color", But there are multiple reports of this entire paint job being defective over multiple generations as well as paint outside of these areas specified. This recall should cover an entire repaint and is extremely frail in quality otherwise.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11617153September 30, 2024
SEATS, ELECTRICAL SYSTEM
Seat heating module for my driver seat has melted and is further irrepairable without buying the entire harness to fix the issue. There are multiple reports of this happening across forums.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11614574September 14, 2024
POWER TRAIN
I purchased the vehicle new and noticed right away that the transmisson would clunk right away when I put it into gear[ it's an automatic]. I asked the dealership about it and they said it was normal and no issues. Now I'm [XXX] and have owned many cars so.... Anyway, over the years I've asked several times and they say no issue. Now, just this morning, my wife found an article about the issue and Toyota is finally admitting there IS an issue. What can I do? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11609722August 20, 2024
SEATS
The seat heater thermostat under the driver’s seat melted and charred while heater was in use Fire danger. Dealer said this happens to a small number of vehicles of similar age and manufacture date. This was inspected by the dealership. No lights or warns came on before, during or after. I noticed the seat heater stopped working. I inspected the fuse. The fuse was not burned out. I found the melted part under the seat in the heater wiring harness assembly. I have removed the fuse at this time to prevent energizing the harness further.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11608277August 13, 2024
UNKNOWN OR OTHER
I purchased this vehicle in May 2016. The vehicel has the "Super White" paint package. In late May 2019 I noticed the paint was starting to peel off the door frame, above the headlights and above the windshield. I contacted the Toyota Dealership where I purchased the vehicle, Desert Toyota of Tucson) and they told me there was a recall on the paint and that I would be receiving a letter from Toyota USA about this. A year went by and I contacted Toyota USA, and was told there was no recall on my vehicle due to paint peeling. I again contacted Toyota USA in 2021 (Incident # 210719-000344) regarding the peeling paint which was getting worse and was again told no recall due to peeling paint. I have spoken with the dealership several times about this and I keep getting told that I will be receiving a letter from Toyota USA, but there is a backlog. I called Toyota USA again this morning 8/13/2024 and was told no recall on my peeling paint, yet my dealer insists there is one. Toyota USA told me to conatct the NHTSA about this, so I have.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11604958July 28, 2024
STRUCTURE:BODY
At approx 75K miles hood latch popped open. Noticed hood was open while driving on highway. Only the 2nd safety latch was holding it closed. Pulled over to close it but it would not fully latch. Noticed latch had a lot of rust. Did not bother taking it to a dealer or repair shop. Bought an aftermarket latch and easily installed myself which solved the issue. Very glad hood did not fully fly open which could have been catastrophic.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11567943January 26, 2024
SEATS
I had a heated seat failure. I do have the parts available for inspection. I removed the seat to find that the sub assy-seat heater and connecting wiring harness had been burnt which could potentially cause a fire. Toyota part numbers effected are: sub assy - 87501-0C020, wiring harness in the heater assy - 87510-04040 which was replaced by 87510-04050. I reported the issue to Toyota. There were no warning lights or indicators that there was an issue. The heated seat indicator light still shows the seat as on even though it was not heating. Toyota service bulletin T-SB-0130-18 has been issued about this issue, so Toyota obviously knows there is an issue. I've read in forums online that the root issue is the wiring not being large enough to handle the power to the seat, so ultimately replacing the factory parts would not guarantee the issue will not happen again.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11567897January 25, 2024
SERVICE BRAKES
At 55,000 miles Brake fluid began leaking into passenger cabin. Brake fluid leaks on to brake pedal and driver footwell. Obviously a safety issue and dealer is asking approx 2000 dollars to repair. Failing component is a brake master cylinder that is specific to the Off Road and Trd Pro Tacomas that have a traction control feature called “crawl” for off road use. After an online search, this issue seems common in these models.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11561317December 21, 2023
POWER TRAIN
AT shifter was stiff from purchase. I thought this was normal. Sometimes it shifted OK, most times not. Had independent repair shops lubricate the shifter multiple times to no avail. Then the shifter wouldn't move at all and I was in a traffic lane causing a dangerous situation. Had truck towed to an independent repair shop that found a second way to lubricate the shaft. Curious how many trucks left the factory without AT shaft lubricated.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11560544December 17, 2023
EXTERIOR LIGHTING
Just like with the other double cab Tacoma recalls I am hearing about, the third rear tail light is leaking water into my access cab. The interior smells like mildew. I’m not sure why my truck is not covered by the recall, but it is experiencing the exact same situation. Water leaking through the deteriorated seal of the break-light. I think with accompanying mold build up.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11557704November 30, 2023
SEATS
What component or system failed or malfunctioned, and is it available for inspection upon request? Heated seat heating module. How was your safety or the safety of others put at risk? Module burned out during usage and emitted fire odor and smoke when burnt out (potential fire hazard if kept on). Has the problem been reproduced or confirmed by a dealer or independent service center? [XXX] Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Unknown. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? None. 2016 Tacoma limited heated seat heating module overheated/burned out with slight smoke under seat during minimal usage (texas based). TSB [XXX] released in October 2018, about the time most of the 2016 (produced in 2015) are going out of warranty, and based on frequency of usage and locale (warmer climates observe less usage) - also even though parts used are the same, VIN is apparently not affected. Toyota will not honor TSB even though the burn out can be a potential fire hazard if not known/smelled especially while traveling and buckled into seat belt (similar to Mercedes heated seats caught on fire). No notice provided by Toyota of TSB at time of issue. Item should be a recall as it affects many 2016-2018 Tacoma's and is a fire safety and burn hazard. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11556360November 21, 2023
FUEL/PROPULSION SYSTEM, ENGINE
Fuel injector(s) leaked without any warning, causing engine to loose power on freeway. We were fortunate to be able to move over to the shoulder before the truck lost all power. Vehicle was towed to dealer and it was determined that the injector leaked fuel into engine causing engine failure. Repairs needed include engine block, heads sub assembly, injectors and assorted other parts total for parts and labor $19,256 No warning lights or symptoms prior to this problem. Truck has been running fine with no problems, only has 41,000 miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11555781November 18, 2023
UNKNOWN OR OTHER
On 10/30/2023 Toyota stopped supporting Scout GPS Link. This is the Toyota installed navagation system and the only navagation system that works with the Toyota display/audio system. All other navagation systems are blocked from the Toyota system. Navagation is now reduced to using a Cell Phone display and audio. Well this option works it is much less safe as the display is much lower beneath the driver's normal line of sight. Eyes must be taken off the road for a much longer period and looking at a much smaller display. While not as big a safety risk as other vehicle problems this may provide NHTSA with the opportunity to track the safety impact of vehcile navigation systems vs hand held nagivation systems.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11543336September 8, 2023
SERVICE BRAKES, UNKNOWN OR OTHER
Truck had to be abandoned after I attempted to start it and the brake pedal was stiff and the ignition would not allow starter to function. Dashboard message indicated a brake problem with transmission interlock. The next day, after viewing a U-Tube video on the problem (same make/model/year) I held the starter button in for 12-15 seconds with no foot on the brake. The engine started but the transmission remained locked in Park. Tow truck operator was able to release the shifter using an access port and screwdriver and found that he could drive it up onto the inclined platform. Once in place on the platform he shifted to Park and found it was again locked. This issue disabled the truck in a traffic area where it could not be started or shifted into Neutral to move it...a dangerous situation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11533177July 19, 2023
UNKNOWN OR OTHER
White paint is peeling off in multiple places on the body of the vehicle. There is a change.org petition with 5,000+ signatures, yet Toyota has refused to do anything about the issue. https://www.change.org/p/toyota-motor-company-hold-toyota-accountable-for-2008-2022-tacoma-super-white-peeling-paint
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11529214June 27, 2023
POWER TRAIN
My 2016 Toyota Tacoma has had multiple oil leaks in the timing cover. The dealer has already fixed this issue twice and the timing cover is currently leaking oil. This leak is expensive to fix because it involves removing the engine and the transmission to properly seal the timing cover. This is a know defect that poses a serious safety concern as the oil leak may go from a small leak to a large leak quickly, causing the engine to fail. Additionally the air pressure from driving can cause the oil to end up everywhere which can lead other components to degrade and fail. Because the fix is so complex, the process to remove and reinstall the engine and transmission may result in other mistakes. During one of the attempts to fix the issue, the dealer forgot to replace an engine bolt and forgot to hook up a vent hose. The cost to fix this issue is so high that it makes it too expensive for many to fix.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11512057March 15, 2023
ELECTRICAL SYSTEM, ENGINE, SERVICE BRAKES
Vehicle is designed in such a way as to allow moisture accumulating in drivers side floor mat and carpeting to wick upward and be deposited on the primary vehicle wiring harness located in the drivers side kick panel. The moisture collected travels down into the backside of the various female connectors and corrodes the conductors and receptacles that result in short circuits between the various vehicle components including the ignition, engine shutoff, temperature sensors, Antilock Breaking, Blind Spot Monitoring, Fuel Gauge, Forward Vehicle Lighting (high and low beam), Security, Traction Control and other critical vehicle systems. On February 5th, 2023 I returned to my vehicle to find the security alarm sounding in the parking lot of a local business, both the keyless entry system and key-fob were unresponsive and would neither silence the alarm or unlock the vehicle. After manually unlocking the door handle the alarm ceased, the vehicle started as normal and then began indicating a failure of the BSM system, while underway the ABS indicated it had also failed and upon arrival at our destination the engine would not turn off even with the emergency shutdown routine prescribed for unintended acceleration cases. In addition, the high beams would be triggered by unrelated button operation occasionally fail to turn off, the fuel gauge, temperature readouts and climate control provided unintelligible values. The vehicle was returned to to dealership where it was determined that water from the floormats was able to contaminate and cause systemwide failure. The repair was to replace the entire wire harness which would not be covered by warranty. On 3/15/2023 I reached out to Toyota Headquarters' Customer Engagement team and was advised that Toyota was aware of the problem and had no interest or obligation in rectifying the situation, regardless of my concerns that this presented a clear safety hazard to both operators and the general public.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tacoma