Toyota Tacoma Complaints (2007)

541 consumer complaints on file.

#11521107May 9, 2023
SUSPENSION, STRUCTURE:BODY, UNKNOWN OR OTHER
Frame is massively rusted and is hazardous. Need full replacement.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11513219March 22, 2023
STRUCTURE:BODY
As part of the Tacoma Frame Replacement program (ZH6 and H0F), I brought my Tacoma to my Toyota dealer. They deemed my frame to NOT qualify for the replacement and lazily applied corrosion resistant spray to the rust on the frame that quickly flaked off. As soon as the program ended, the frame deteriorated quickly. There are 3 spots on the frame where my hand can slide through near the front of the frame on both the driver side and the passenger side. I have removed about 5 pounds of frame/rust from the interior of the frame and the exterior of the frame. I have contacted Toyota several times and been told that there are no appeals or anything I can do except pay for a new frame out of pocket, sell, or try to repair.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11509226February 27, 2023
SUSPENSION
Frame is completely rusted. the rear gas tank strap where it attaches to the frame corroded through and the strap dropped and was dragging on the ground. the gas tank also dropped and made it difficult to remove the gas cap. upon further inspection the frame is completely rusted through in spots. in 2014 a rust protective coating was applied by a dealer. it did nothing to stop the rust it just covered it. the steel is delaminating underneath the coating. It was just a band-aid to get them out of warranty period. these frames should have been a full recall. the strap could of easily hit the ground and bounced up and punctured a brake line or the gas tank. with it sparking on the ground a fire could of happened. The tacoma is in immaculate condition except for the frame. this is my 4th toyota and the only one that has had a problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11503141January 23, 2023
STRUCTURE:FRAME AND MEMBERS
2007 TOYOTA TACOMA. CONSUMER WRITES IN REGARD TO RUSTED FRAME. THE CONSUMER IS REQUESTING ASSISTANCE WITH A RUSTED FRAME AS THE VEHICLE WILL NOT PASS INSPECTION DUE TO THIS DEFECT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11501661January 13, 2023
STRUCTURE:BODY
We bought the truck used in 2021 when it had 114,000 mi. Looked great, drives great. Now our mechanic tells us there are rust spots all over the frame — and that there is a recall. I looked into the recall and the window closed last year. Is it legal for Toyota to stop a recall when it is such a big safety issue? Buyers of used cars need to know about this site to check for recalls. I think very few people know about this app.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11476374July 28, 2022
SUSPENSION, STRUCTURE:BODY, UNKNOWN OR OTHER
Yesterday, 7/27/2022, I had my 2007 Toyota Tacoma Access Cab at my mechanic's shop for a minor issue. While on the lift he noticed significant rust on the frame rails. He brought me over and showed me extensive areas where the metal was completely rusted through. I have never seen anything like this on even the oldest of vehicles. Subsequently I did a search online and found that this was a known issue for many years of Tacoma truck frames, but I was never notified by Toyota or anyone including the local Toyota dealer where I have had services done. I cannot believe a company as well established as Toyota would allow such a potentially serious problem to go unaddressed. Toyota should be held responsible for selling defective and dangerous vehicles and be required to effect repairs as soon as possible completely at their cost. (see article below) https://www.vehiclehistory.com/articles/toyota-tacoma-most-years-are-reliable-but-some-2005-2010-models-struggle-with-rusty-frames-faulty-leaf-springs
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11475776July 25, 2022
UNKNOWN OR OTHER
Truck has been well kept and maintained since purchase 2008. We are the 2nd owner. Won't pass inspection due to a rust spot on frame.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11470297June 21, 2022
STRUCTURE:BODY
Crack on the frame.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11469987June 19, 2022
SUSPENSION
I purchased NEW a Toyota 2007 Tacoma, After year of ownership I found heavy surface rust around the chassis and hardware components. I went to dealership and they stated that it was surface rust and were not able to rustproof . After 10 years I was assigned to SMA in FT Bliss TX were I was for 12 months on Active duty orders . Once I return and picked up truck from storage I found chassis completely rusted with several areas that were in critical need of repair. I contacted Toyota and was informed I missed the cut off date for recall repair . I will be repairing on my own but its a injustice that there is a such monetary preference than safety of the consumer who purchase vehicle out right for the reliability .
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11468556June 10, 2022
STRUCTURE:BODY, SERVICE BRAKES, UNKNOWN OR OTHER
The entire chassis is rusted underneath. This vehicle is only 14 years old and the brake lines are completely rusted, the rear bumper cross arm that holds the frame from side to side is rusted. Multiple parts under the rear are having to be replaced due to the rust!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11466874May 31, 2022
SUSPENSION
Took my 2007Tacoma for its State inspection, it failed due to a severely rusted frame. Shelor Motor Mile and Toyota have refused to replace the frame on a truck they admitted having that problem
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11463742May 7, 2022
STEERING
Steering has developed a clunk at low speeds. Appears intermediate shaft is bad. Dealer wants over 500 to replace. Online it is a very common problem. The steering shaft goes bad ..how much more dangerous can you get?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11460626April 13, 2022
STRUCTURE:FRAME AND MEMBERS
The contact owns a 2007 Toyota Tacoma. The contact stated that the passenger's side frame, driver's side frame, and the subframe of the vehicle were severely corroded, including the area where the fuel tank was located. The vehicle was taken to the dealer to be repaired under NHTSA Campaign Number: 14V604000 (Suspension) however, the dealer informed the contact that they could not mount the leaf springs as the frame was severely corroded. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 130,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11456290March 11, 2022
FUEL/PROPULSION SYSTEM
The rear strap that holds the gas tank to the bottom of the truck broke. When It came loose on one side it dropped to the street and was bounced up and bent up against the flexible, rear brake line. The brake line was not cut. The strap end dragged on the street causing sparks. I had no idea what all the noise was coming from. I thought I might have a loose exhaust pipe. I drove it a couple days until I noticed the metal hanging down. I used a mirror to see what it was and took it in right away for replacement. It cost me $330. The bracket could have cut the brake line, or pierced the gas tank. The tank could have dropped and blown up. I have never heard of this problem before. I've had older pick ups for 40 years with no such problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11450976February 8, 2022
STRUCTURE:BODY, SUSPENSION, SERVICE BRAKES
I was totally aware of the recall for these year models of Tacoma and I brought the truck in several times to have the frame inspected and asked for it to be replaced. The folks at Dorschel Automotive group turned me away saying it did not meet the "rust perforation standard." Lo and behold, when Dorschel was bought by Bob Johnson Auto Group, the first time I took it in they recognized that the frame was entirely rotted and would not pass inspection. At this point, I called Toyota Customer Service and they said they would not honor the recall as it is outside the window of time. Yet this is not a matter of me not taking proper action. I did. I did my due diligence and I am being harmed by the negligence of the service managers at Dorschel. I made Toyota aware that the frame inspection was not done properly. I could see visible rust and I made mention of that. Now I am in a really tough spot. The truck only has around 130K miles on it and planty of useful life but for this faulty frame. Consumer stated attempted to access the benefits under the warranty recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11440236November 12, 2021
UNKNOWN OR OTHER
The truck was getting repaired and the mechanic showed me the bottom of the truck and rust was everywhere. The bottom frames is rusty and has some rust holes.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11438617October 29, 2021
STRUCTURE:BODY
in 2020 my mechanic notified me my frame was rusted and would not pass next inspection. i did further research on line and discovered there was a recall of which i never recieved any notification. i also discovered there was a class action lawsuit case # 2:15-cv-02171-fmo-ffm. i contacted toyota and filed a complaint case # 210402000664. they called back saying there was nothing they could do, the frame corrosion warrentee end 8-21-2019. not great news seeing i was not notified of recall or law suit... by the way there are 3 toyotas sitting in my driveway. i have not moved in 20 years , and my phone number has never changed.i have since had the repairs made by replacing the crossmember and patch welding the rusted area at my own expence ( 1000.00$). i have reciepts. there is a lot of life left in my tacoma, i am dissapointed toyota did not help in any way , shape or form....if there is a recall you should stand by your product! i was dismissed to go away and deal with it on my own... so i wish to file a formal complaint against toyota america . im sure there are others out there like me. please help , philip delacruz
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11435725October 6, 2021
STRUCTURE:BODY
The contact owns a 2007 Toyota Tacoma. The contact stated that the chassis was completely rusted, resulting in the vehicle being undrivable. The vehicle was taken to an independent mechanic where it was diagnosed with needing the chassis to be replaced. The manufacturer was informed of the failure and informed the contact that they were unable to assist. The failure mileage was approximately 71,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11433051September 15, 2021
SUSPENSION
The frame of my truck is rusting away and it’s getting worse and worse and I called Toyota to see if they would fix it because of their previous Tacoma rusty frame recall and they denied me.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11433056September 15, 2021
SUSPENSION:SUBFRAME/MOUNTING BRACKET
The contact owns a 2007 Toyota Tacoma. The contact stated while inspecting the vehicle, he noticed that the rear suspension subframe was corroded and had fractured. The contact called the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 140,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tacoma