Toyota Tacoma Complaints (2003)

360 consumer complaints on file.

#11474053July 15, 2022
SUSPENSION, STRUCTURE:FRAME AND MEMBERS
The contact owns a 2003 Toyota Tacoma. The contact stated that the entire subframe of the vehicle was rusted due to severe corrosion. There were no warning lights illuminated. The vehicle was taken to an independent mechanic who confirmed the subframe corrosion. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 200,000. The VIN was not available. The contact stated that there was an opportunity to have the frame of the vehicle coated but that make the corrosion worse. The contact feels as though the vehicle is unsafe to drive.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11468987June 13, 2022
AIR BAGS
The local dealership Cloninger Ford /Toyota told me that I need to replace the airbag ECU and Pretensioner on drivers side. The cost estimate was $1,500.00. I have seen that Toyota has given recalls on other models for this defect. I have a 2003 Toyota Tacoma. I am submitting this complaint with hopes for my case to be considered. The airbag light cam on on my truck 2 months ago and Cloninger Toyota replaced the front seat belt assy. and erased dics. This cured the problem (light on) for a few weeks. Please consider this issue for recall further than you have at this point.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11445196December 28, 2021
AIR BAGS
Truck crashed into rocks on shoulder and rolled over. Driver side Windshield and roof crushed. Air bag did not deploy. Sheriff took a report of crash.HI213530034 Greenspot road. Highland , CA. Vehicle is in possession of coparts authorized by USAA insurance
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11420436June 10, 2021
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
The contact owns a 2003 Toyota Tacoma. The contact stated while changing the oil, he noticed that the undercarriage of the vehicle was rusted which resulted in the sub-frame being compromised. The vehicle was diagnosed but not repaired. The manufacturer was informed of failure of the failure but offered no assistance. The failure mileage was approximately 140,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11420490June 10, 2021
STEERING, SUSPENSION, UNKNOWN OR OTHER
While driving, on the highway, the rear shock absorber support mount came loose, allowing the truck bed to come loose from the frame/chassis. Fortunately only the passenger side came loose, keeping the truck's bed attached to the rear of the truck I later found that this particular model has a problem with Frame rot which generated a Toyota bulletin. I bought the truck from Toyota, as a used truck in 2011, but received no notifications of this potentially hazardous vehicle. If the bed had come loose at highway speed, any vehicle following the 2003 Toyota Tacoma truck would have been severely damaged or potentially resulted in the death of the people in the cars following behind me and the truck. There was a Toyota bulletin issued previously which was not disclosed to me at the time of purchase. The vehicle has been in Toyota shops regularly for inspections, maintenance and other repairs but the shop never mentioned anything about a "rusty" frame. Upon further research, I have found multiple Toyota Tacoma owners with similar issues with the frame. I believe Toyota knowingly manufactured and sold a defective product with serious potential safety issues. This vehicle either should be banned from the road for the safety of all drivers.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11407284April 9, 2021
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT STATED WHILE THE VEHICLE WAS PARKED IN THE GARAGE, RODENTS ATE THE FUEL LINE CAUSING A FUEL LEAK. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO HALEY TOYOTA OF ROANOKE (1530 COURTLAND RD NE, ROANOKE, VA 24012) WHERE IT WAS DIAGNOSED WITH THE FUEL LINE NEEDING TO BE REPLACED. THE VEHICLE HAD BEEN REPAIRED TWICE HOWEVER, THE ISSUE RECURRED. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 75,000. THE VIN WAS UNAVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11406253April 3, 2021
SUSPENSION, UNKNOWN OR OTHER
THE FRAME IS ROTTED AND WAS NEVER ADDRESSED TO BE FIXED
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11402626March 12, 2021
TIRES, STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 12V542000 (TIRES) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT STATED THAT WHILE HAVING A ROUTINE CHECK UP AT LITHIA TOYOTA OF REDDING (250 E. CYPRESS AVE, REDDING, CA 96002, (530) 250-3207) THE TECHNICIAN INFORMED HIM THAT THE SPARE TIRE HAD SEVERE CORROSION, AS WELL AS THE REAR SUBFRAME. THE VEHICLE WAS NOT REPAIRED DUE TO PART NOT BEING AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE RECALL HAD EXPIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 450,000. PARTS DISTRIBUTION DISCONNECT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11400357March 11, 2021
SEATS, UNKNOWN OR OTHER
ONCE YOU FASTEN THE SEAT BELT, IT TIGHTENS WITH ANY MOVENT AND RESTRAINS THE BODY TO THE POINT THAT DISABLES MOVEMENT OR EVEN BREATHING. THIS IS VERY UNSAFE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11398310February 28, 2021
STRUCTURE:BODY, SEAT BELTS, SUSPENSION
I NOTICED A SMALL HOLE UNDERNEATH THE PASSENGER SIDE OF THE FRAME JUST IN FRONT OF THE LEAF SPRING AND NOW THE HOLE HAS GROWN TO THE SIZE OF A QUARTER. THERE IS ALSO QUITE ALOT OF RUST UNDERNEATH THE TRUCK AS WELL AS THE SPARE TIRE HOLDER. I LIVE IN CALIFORNIA AND THIS TRUCK WAS PURCHASED FROM A TOYOTA DEALERSHIP IN PENNSYLVANIA. THANKS FOR YOUR COOPERATION. SINCERELY,[XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11397954February 25, 2021
STRUCTURE:BODY
WHEN I WENT TO THE GARAGE FOR THE YEARLY INSPECTION, I WAS INFORMED BY THE MECHANIC THAT THE FRAME ON MY TACOMA WAS RUSTED SEVERELY WITH MAJOR HOLES AND COULD NOT BE INSPECTED. I WAS TOLD THAT THERE WAS A RECALL ON THE FRAME FOR SUCH ISSUES AND THAT I SHOULD CALL THE DEALER WHO SOLD THE TRUCK. BEING AS THE DEALER WAS NO LONGER OPEN (RETIRED), I WAS UNABLE TO SPEAK TO HIM. II CALLED THE TOYOTA COMPANY, AND WAS TOLD THAT THE RECALL WAS NO LONGER IN EFFECT AND THAT THEY COULD NOT HELP ME. I ASKED WHY I WAS NOT INFORMED ABOUT THIS RECALL AS I WAS THE REGISTERED OWNER OF THE VEHICLE, I WAS TOLD THAT "EVERYONE THAT OWNED ONE SHOULD HAVE GOTTEN A NOTICE." I WROTE A LETTER TO THE TOYOTA COMPANY IN JANUARY 2020 AND DID NOT RECEIVE A REPLY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11387151January 8, 2021
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT STATED WHILE THE VEHICLE WAS AT AN INDEPENDENT MECHANIC FOR ROUTINE MAINTENANCE, IT WAS DISCOVERED THAT THE UNDERCARRIAGE WAS RUSTED AND CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE HOWEVER, OFFERED NO ASSISTANCE. THE WARRANTY WAS EXPIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 123,208.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11366133October 24, 2020
SUSPENSION
FRAME IS RUSTING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11362151October 1, 2020
STRUCTURE:BODY
RUST, CORROSION, OR OTHER FAILURE OR DETACHMENT OF EXTERIOR BODY AND FRAME COMPONENTS, THE VEHICLE IS ROTTED UNDERNEATH
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11352934September 3, 2020
UNKNOWN OR OTHER
I TOOK MY TACOMA FOR STATE INSPECTION AND THEY COULD NOT LIFT IT BECAUSE THE FRAME HAS A HOLE THROUGH IT AT THE FRONT MOUNTING POINT OF THE REAR SPRING ON THE DRIVERS SIDE. THE MECHANIC TOLD ME HITTING A SEVER BUMP OR A POTHOLE COULD SNAP THE FRAME IN HALF. I HAVE OWNED THE TRUCK FOR ALMOST 10 YEARS AND NEVER RECEIVED A RECALL NOTICE ABOUT THE FRAME, ONLY ON THE SPARE TIRE CARRIER. I'M NOT A COMPUTER EXPERT AND DON'T KNOW HOW TO ADD A PICTURE OF THE FRAME TO THIS DOCUMENT. I DO KNOW THAT I NEED THE TRUCK BUT I AM UNABLE TO GET IT INSPECTED TO DO SO. PLEASE HELP.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11349866August 17, 2020
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS, STRUCTURE:BODY
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE'S SUBFRAME HAD RUSTED THROUGH WITH FIVE HOLES TO THE SUBFRAME. THE VEHICLE WAS TAKEN TO BENNETT TOYOTA (1951 LEHIGH ST, ALLENTOWN, PA 18103), WHERE IT WAS CONFIRMED THAT THERE WERE FIVE HOLES IN THE SUBFRAME AND THAT THE SUBFRAME NEEDED TO BE REPLACED. THE DEALER INFORMED THE CONTACT THE VEHICLE WAS OUT OF WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS OUT OF WARRANTY AND OFFERED NO FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 143,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11341339July 24, 2020
SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY, STRUCTURE:BODY
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT STATED THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO INDEPENDENT MECHANIC, WHERE SHE WAS INFORMED THAT THE DRIVER?S AND PASSENGER?S SIDE REAR SUBFRAME AND REAR LEAF SPRING WERE FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS TAKEN TO BERLIN CITY TOYOTA OF PORTLAND LOCATED AT 191 RIVERSIDE ST, PORTLAND, ME 04103 (207) 618-6528, AND THE DEALER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 160,000.*DT 8/14/2020 EDIT BY [XXX]: I WOULD ALSO LIKE TO ADD THAT THE TACOMA WAS BROUGHT INTO THE SEASHORE TACOMA DEALERSHIP IN NEW JERSEY BACK IN 2013 FOR A DIFFERENT RECALL AND THE FRAME RECALL WAS NEVER ADDRESSED OR BROUGHT UP TO ME WHILE MY TACOMA WAS THERE. I WOULD ALSO LIKE TO NOTE THAT IN 2016 WHILE I WAS STATIONED IN ALASKA, I RECEIVED A POST CARD ABOUT THE EXTENDED WARRANTY. I PROMPTLY CALLED THE NUMBER AND WAS ADVISED THAT THE WARRANTY DID NOT PERTAIN TO MY TACOMA. OTHERWISE, I WOULD HAVE PUT IT ON THE FERRY TO JUNEAU FOR THE INSPECTION. LASTLY, I HAVE OWNED THIS TACOMA SINCE 2009. IT AS BEEN STATIONED WITH ME FOR 4 YORK IN FL, 4 YORK IN NJ, 4 YORK IN SITES, AK AND 2 YEARS IN ME. IT ALSO PREVIOUSLY LIVED BETWEEN IN KY AND FL PRIOR TO ME. HAD I BEEN ASKED THE RIGHT QUESTIONS ABOUT THE ORIGIN OF THE TACOMA THEN I'M SURE THEY WOULD HAVE TOLD ME THE TRUCK WAS ELIGIBLE FOR THE EXTENDED WARRANTY. *DT INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11329736June 19, 2020
STRUCTURE:BODY
A LOT OF RUST ON THE FRAME AND RUST UNDERNEATH. CLEAN AND WELL TAKEN CARE BUT THE RUST STILL EXIST. I EVEN HAVE TO REPLACE THE EXHAUST BECAUSE IT FALL OFF DUE TO THE RUST. THE RUST UNDERNEATH ARE ALMOST EVERYWHERE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11327993June 9, 2020
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS, STRUCTURE:BODY
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT STATED THAT THE SUBFRAME AND UNDERCARRIAGE OF THE VEHICLE WAS RUSTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS UNSAFE TO DRIVE. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOT INFORMED OF THE FAILURE. THE MANUFACTURER WAS INFORMED OF FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11327499June 6, 2020
STRUCTURE:BODY, SUSPENSION
I PURCHASED MY 2003 TACOMA SECOND HAND BACK IN 2015 WHICH SERVES AS MY PRIMARY VEHICLE TO THIS DAY. AFTER RETURNING FROM A YEAR LONG DEPLOYMENT OVERSEAS, I HAD A FEW FRIENDS OVER ON 4JUN OF WHICH ONE WAS ADMIRING MY TRUCK UNTIL HE LOOKS UNDERNEATH AND NOTICES ALL THE FRAME RUST. HE ADVISES THAT THERE IS A RECALL ON IT AND I SHOULD CONTACT MY TOYOTA DEALER TO GET IT SERVICED. FEELING DISTRAUGHT, I GO ONLINE AND LOOKUP RECALLS FOR MY CAR WHICH LED ME TO THE "FRAME RUST" SAFETY ISSUE ON A MANY TOYOTA MODELS TO INCLUDE MY OWN. THE ADVISEMENT SUGGESTS SAFETY CONCERNS WITH THE FRAME RUSTING THROUGH DUE TO FACTORY NEGLIGENCE IN SUFFICIENTLY COATING WITH ANTI-CORROSION MATERIALS. FURTHER RESEARCH IN OTHER FORUMS STATE OTHER TOYOTA OWNERS DESCRIBING IT AS FRAME RUST ALTOGETHER AND NOT JUST ON THE SPARE TIRE PLATE. ISSUES DESCRIBED INCLUDE THE ISSUE CAUSING THE LEAF SPRING TO SNAP AND THE FRAME ITSELF RUSTING THROUGH. INSPECTION OF MY TRUCK PROVES TRUE TO ALL ACCOUNTS DESCRIBED. I CONTACTED SERVCO TOYOTA IN HONOLULU, HI THE VERY NEXT DAY AND SPOKE TO A NICE LADY. I EXPLAINED HOW I BECAME THE OWNER OF THE VEHICLE SINCE 2015 AND WAS NEVER MADE AWARE OF THIS RECALL. SHE CHECKED MY VIN TO CONFIRM THAT I WAS AFFECTED BY IT, HOWEVER THE RECALL HAS EXPIRED AS OF 2018 SO THERE IS NOTHING THEY CAN DO. SHE GAVE ME THE 1-800 NUMBER TO TOYOTA WHICH LED ME NOWHERE AND KEPT DIVERTING ME BACK TO SERVCO TOYOTA INSTEAD OF THEIR MAIN OFFICE..... WHAT FRUSTRATES ME THE MOST IS THAT TOYOTA PROVIDED ME NO NOTICE OR WARNING ABOUT THIS RECALL. SO HOW CAN I REACT TO SOMETHING I WAS NEVER MADE AWARE OF. SAFETY RECALLS SHOULD NEVER HAVE EXPIRATION DATES AS IT REMAINS A SAFETY ISSUE UNTIL ITS PROPERLY REMEDIED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tacoma