Toyota Tacoma Complaints (2012)

295 consumer complaints on file.

#10937804December 28, 2016
ENGINE
MY 2012 TOYOTA TACOMA CHECK ENGINE AND TRACTION CONTROL LIGHT CAME ON. TRUCK WENT IN LIMP MODE, WHICH WAS VERY UNSAFE. TOOK MY TRUCK TO AUTO ZONE TO HAVE THE CODES READ. MY TRUCK CODE WAS P2442. AIR INJECTION SYSTEM SWITCH VALVE STUCK OPEN. THIS IS A KNOWN ISSUE TO TOYOTA TUNDRA TRUCKS BUT NOT FOR THE TACOMA.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10937939December 28, 2016
ENGINE, FUEL/PROPULSION SYSTEM
DRIVING ON THE STREET TO WORK ONE MORNING, THE TRAC OFF AND CHECK ENGINE LIGHTS BOTH SUDDENLY APPEARED. I THEN NOTICED THAT MY TRUCK WAS NOT ABLE TO ACCELERATE PAST ~40 MPH. GOING UPHILL, MY TRUCK WAS LIMITED TO ONLY ~20 MPH. MY TRUCK WENT INTO THIS "SAFE MODE." I CONNECTED AN OBD DEVICE AND THE CAME UP WITH THE FOLLOWING TWO CODES: P2440 AND P2442. THE CODES REFER TO "SECONDARY AIR INJECTION SYSTEM SWITCHING VALVE STUCK OPEN" FOR BANKS 1 AND 2, RESPECTIVELY. I DID SOME FURTHER RESEARCH ON THE CODES, AND IT TURNS OUT THIS IS A COMMON ISSUE ON 2012 TACOMAS. APPARENTLY, THE VALVE FOR THE SECONDARY AIR INJECTION SYSTEM IS STUCK OPEN DUE TO MOISTURE AND/OR CARB BUILD UP. I BELIEVE THIS IS A DESIGN/ENGINEERING ISSUE. PART REPLACEMENT COSTS ~$480 FOR EACH VALVE ASSEMBLY. LABOR CAN RANGE ANYWHERE BETWEEN $200-$500. IF THIS IS A KNOWN ISSUE THAT IS COMMON TO A LOT OF 2012 TACOMAS, THEN I BELIEVE TOYOTA SHOULD BE PROACTIVE SUCH AS RELEASING AN OFFICIAL RECALL OR EVEN IMPLEMENT SOME TYPE OF REIMBURSEMENT. NOTE THAT MY TRUCK HAS ~80,000 MILES ON IT. AS AN OWNER, I SHOULDN'T SUFFER FROM AN ENGINEERING DESIGN FLAW AND I SHOULDN'T BE FINANCIALLY RESPONSIBLE TO REPAIR/FIX THE ISSUE. ANY ASSISTANCE WOULD BE HELPFUL. THANK YOU AND HAPPY HOLIDAYS! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10937441December 26, 2016
ENGINE
ENGINE CODE P2442 & P2440: SECONDARY AIR INJECTION SYSTEM SWITCHING VALVE BANK 2. TRUCK ONLY HAS 40,000 MILES ON IT. DEALER WHAT $1800.00 TO MAKE REPAIRS. TOYOTA HAS A PROBLEM WITH THE PART AND THEY NEED TO FIX IT. NOTHING LIKE HAVING NUMEROUS FAILURES AND LEAVING THE CUSTOMER TO PAY FOR THE POOR ENGINEERED PART. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10937233December 23, 2016
ELECTRONIC STABILITY CONTROL (ESC), ENGINE, POWER TRAIN
2012 TACOMA WITH 37,00 MILES: WHILE LEAVING A PARKING LOT AND TRYING TO ACCELERATE ON TO A BUSY HIGHWAY, (60MPH SPEEDS), TRUCK WOULD NOT ACCELERATE AND "CHECK ENGINE" AND "TRAC OFF" LIGHTS ILLUMINATED. VEHICLE WENT INTO "LIMP MODE" AND WOULD NOT GO FASTER THAN 35 MPH. I HAD TO QUICKLY PULL OFF THE ROAD AS TO NOT CAUSE AN ACCIDENT. IF THIS HAD THIS OCCURRED WHILE TRAVELING AT NORMAL HIGHWAY SPEED (60 MPH+), WOULD DEFINITELY BE IN A WRECK DUE TO THE SUDDEN DOWNSHIFT AND DECELERATION. I TOOK VEHICLE TO LOCAL AUTO PARTS STORE AND RECEIVED THE CODE P2442: SECONDARY AIR INJECTION SYSTEM SWITCHING VALVE STUCK OPEN BANK 2. FROM RESEARCHING, THIS IS A KNOWN PROBLEM WITH 2012 TACOMAS, AND HAD PREVIOUSLY BEEN AN ISSUE WITH OLDER TUNDRAS, WHICH TOYOTA ISSUED A TSB FOR. TOYOTA REFUSES TO REPAIR THIS UNDER WARRANTY (EITHER POWERTRAIN OR FEDERAL EMISSIONS) EVEN THOUGH THE FAILED PART IS DIRECTLY TIED TO THE EMISSIONS SYSTEM! THE SYSTEM IS USED TO PUMP ADDITIONAL AIR INTO THE EXHAUST MANIFOLD UPON STARTUP TO DILUTE THE OVER-RICH CONDITIONS THAT LEAD TO INCREASED POLLUTION. (HOW IS THAT NOT AN EMISSIONS RELATED PART?) THE FAILURE OR WARPING OF THE ONE-WAY CHECK VALVE CAUSES HOT EXHAUST GASES TO BACKFLOW INTO THE SOLENOID, AND MELTING THE GASKETS. THIS ENDS UP BLOCKING THE SEALING PLATE AND CAUSING IT TO REMAIN IN THE OPEN POSITION. THE DANGER IS THAT THE HOT EXHAUST IS THEN FED INTO A PLASTIC AIR PUMP CAUSING IT TO POTENTIALLY MELT OR CATCH FIRE! THE FACT THAT THIS FORCES THE VEHICLE INTO "LIMP MODE" IS ALSO A HUGE SAFETY CONCERN AS IT WILL NOT ALLOW THE VEHICLE TO TRAVEL ABOVE 35 MPH AND COULD LEAD TO SERIOUS ACCIDENTS IF TRAVELING AT HIGH SPEED ON THE INTERSTATE OR HIGHWAY DUE TO THE UNEXPECTED, SUDDEN DECELERATION. FAILED ASSEMBLY IS TOYOTA PART NUMBER : 25710-31020. THIS PART NUMBER HAS BEEN SUPERSEDED BY P/N: 25710-31022 AND TOYOTA CHARGES BETWEEN $1500-$3200 TO REPLACE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10936109December 18, 2016
ENGINE, ELECTRICAL SYSTEM
WHEN I WAS LEAVING WORK THE OTHER NIGHT MY 2012 TACOMA WENT INTO LIMP MODE AND PRESENTED THE CEL AND TRAC OFF LIGHTS ON THE DASH. AFTER REVIEWING THE MANY BLOGS ON THE SUBJECT AND TAKING THE VEHICLE TO THE MECHANICS, I HAVE FOUND OUT THAT THE SECONDARY AIR VALVE IS LIKELY STUCK IN THE OPEN POSITION. THE MECHANIC HAS QUOTED ME A PRICE OF $1,142 ($780 FOR THE PART) TO REPLACE THE WHOLE SYSTEM (VALVE NOT SOLD SEPARATELY). I UNDERSTAND THAT THIS IS A COMMON PROBLEM WITH TUNDRAS/SEQUOIAS AND 2012 TACOS. HOWEVER, ONLY THE TUNDRAS ARE UNDER ANY TYPE OF WARRANTY. I BOUGHT A TACOMA BECAUSE THE LAST TWO TOYOTA'S HAVE RUN 300K MILES + WITH REGULAR MAINTENANCE. THIS TYPE OF EXPENSIVE REPAIR DUE TO POOR ENGINEERING IS LUDICROUS AND SHOULD BE A WARRANTY ISSUE. I GUESS TOYOTA WANTS TO BE TERRIBLE LIKE EVERYONE ELSE. GREAT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10928483November 29, 2016
ENGINE, POWER TRAIN, VEHICLE SPEED CONTROL
CHECK ENGINE LIGHT CAME ON, TRAC OFF LIGHT IS ON. MY TRUCK HAS NO POWER AND IS UNSAFE TO DRIVE. THE DTC IS P2442. SECONDARY AIR INJECTION SYSTEM SWITCH VALVE STUCK OPEN BANK 2. TOYOTA KNOWS THEY HAVE A EMISSIONS ISSUE. MY VEHICLE IS AT THE DEALERSHIP NOW.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10927200November 21, 2016
ENGINE
CHECK ENGINE AND TRAC OFF LIGHTS CAME ON. VEHICLE ACCELERATION BECAME VERY SLUGGISH. I FELT THE VEHICLE BECAME A SAFETY HAZARD AS IT HAD ALMOST NO ACCELERATION . MERGING INTO TRAFFIC BECAME DANGEROUS BECAUSE OF LACK OF ACCELERATION. HAD LOCAL SHOP CHECK TRUCK AND ERROR CODES RETURNED WERE P2440 AND P2442 WHICH THEY SAID INDICATED SECONDARY AIR INJECTOR PUMP NEEDS TO BE REPLACED. EST CHARGE ABOUT $2000!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10927329November 21, 2016
ENGINE
MY CHECK ENGINE LIGHT CAME ON AND MY VEHICLE ENTERED "LIMP MODE," WHICH KEEPS THE CAR UNDER ABOUT 35MPH AND PREVENTS IT FROM ACCELERATING QUICKLY. THE CEL READ AS A SECONDARY AIR INTAKE SYSTEM PROBLEM (P2440 AND P2442). JUDGING BY THE MULTITUDE OF SIMILAR COMPLAINTS I HAVE FOUND, THIS IS A SYSTEMIC PROBLEM THAT TOYOTA REFUSES TO RECTIFY FOR TACOMAS BUT HAS ALREADY ADMITTED TO FOR TUNDRAS. THIS IS A SERIOUS DANGER TO DRIVERS IF THE VEHICLE ENTERS "LIMP MODE" WHILE THEY ARE DRIVING THROUGH AN INTERSECTION OR IN HEAVY TRAFFIC. IT ISEEMS ALSO RIDICULOUS FOR TOYOTA TO EXPECT TACOMA OWNERS TO SPEND THOUSANDS OF DOLLARS TO FIX THEIR POORLY DESIGNED PART, ESPECIALLY CONSIDERING THE PART IS NOT VITAL TO THE PERFORMANCE OF THE ENGINE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10927320November 21, 2016
POWER TRAIN
WE JUST PAID TOYOTA A LITTLE OVER $2,000 TO REPLACE THE SECONDARY AIR INJECTION SYSTEM. THE SWITCHING VALVE WAS STUCK CLOSED ACCORDING TO TOYOTA. THIS IS A 4 YEAR OLD TRUCK. IT IS UNREAL TO SPEND THIS KIND OF MONEY THIS EARLY FOR THIS. THE TUNDRA HAS RECALLS FOR THIS SAME ISSUE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10924933November 8, 2016
FUEL/PROPULSION SYSTEM
SECONDARY AIR INJECTION SYSTEM: STARTED THE VEHICLE AND CHECK ENGINE LIGHT CAME ON. OBD READ P2440/P2442. WHILE DRIVING UPHILL ON A VERY BUSY HIGHWAY, THE VEHICLE LOSS POWER AND WOULD NOT GO FASTER THAN 20MPH AND THE RPM'S RAMMED UP. AFTER SOME SOME RESEARCH FOUND OUT THIS IS A COMMON PROBLEM WITH THE TACOMA IN WHICH TOYOTA WAS AWARE OF.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10923959November 3, 2016
ENGINE
2012 WITH 78,000 MILES, THREW CODES P2440, P2442. SAME AS EVERY OTHER TACOMA OWNER IN THIS YEAR RANGE. BAD VALVES AND PUMP ON THE SECONDARY AIR INJECTION UNIT. COST TO REPAIR AROUND 1,000 DOLLARS DOING THE WORK MYSELF. VERY DISAPPOINTED AS THIS IS MY THIRD TACOMA AND HAD PLANNED ON KEEPING THIS ONE FOR A LONG TIME.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10910895October 1, 2016
SERVICE BRAKES
SHORTLY AFTER BUYING MY TACOMA NEW I NOTICED THAT MY ANTI-LOCK BRAKES WERE SENSITIVE AND WOULD LOCK UP WITHOUT WARNING AND THE STOPPING DISTANCE CAN VARY EVERY TIME I APPLY THE BRAKES. I BROUGHT THIS UP TO MY DEALER'S SERVICE DEPARTMENT DURING ROUTINE OIL CHANGES AND WAS TOLD THAT THIS IS NORMAL. THE VARIED STOPPING DISTANCE CAUSES PROBLEMS SINCE THE TRUCK COULD SUDDENLY STOP SHORTER THAN NORMAL AND CATCH TRAFFIC BEHIND ME OFF GUARD AND CAUSE AN ACCIDENT. OTHER TIMES IT FEELS LIKE THE BRAKES AREN'T WORKING EVEN THOUGH I AM PRESSING FIRMLY AND WONDERING IF I'M GOING TO STOP IN TIME TO AVOID HITTING A CAR IN FRONT OF ME. ON EMERGENCY QUICK STOPS MY BRAKES WILL LOCK UP AND WITH THE VARIED STOPPING DISTANCES I'M SURPRISED I HAVEN'T BEEN IN A POSITION WHERE THE STOPPING DISTANCE IN AN EMERGENCY WAS MORE THAN NORMAL CAUSING ME TO CRASH. I WOULD SAY THAT MY ONLY COMPLAINT SO FAR ON THIS TRUCK IS THE BRAKES AND MUCH BETTER THAN THE TRUCK THAT I TRADED IN BECAUSE OF SEVERAL PROBLEMS WITH IT'S ELECTRICAL, BRAKING (IT'S BRAKES WERE POOR BUT AT LEAST YOU COULD STOP WHEN YOU WANTED), BUILD QUALITY, AND OTHER ISSUES. THIS CLEARLY ISN'T NORMAL AND IF THE DEALER SAYS IT IS, HOW CAN SOMEONE GET IT FIXED WITHOUT TRADING IT IN. THIS IS THE ONLY ISSUE I HAVE WITH THIS TRUCK BUT IT'S BIG ENOUGH TO TRADE IT IN. I SPENT $30K FOR THIS TRUCK AND WOULD RATHER KEEP IT BUT IT HAS GOTTEN TO THE POINT THAT I DON'T FEEL SAFE DRIVING IT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10908249September 20, 2016
ENGINE, POWER TRAIN, VEHICLE SPEED CONTROL
TACOMA WENT IN "LIMP MODE" ENGINE LIGHT AND TRAC OFF LIGHT ILLUMINATED; CAUSE THE CAR TO BE EXTREMELY UNDER POWER. VEHICLE EXTREMELY UNDER POWER CAUSING TO BE DANGEROUS IN TRAFFIC. CODE P2442 SECONDARY INJECTION SYSTEM FAILURE; COMMON TO OTHER TOYOTA VEHICLES INCLUDING TUNDRA'S. TOYOTA ACTED RESUMABLE WITH TUNDRA'S WITH EXTENDING WARRANTY REPAIRING BUT AT THIS TIME REFUSES TO REPAIR KNOWN FAILURES IN TACOMA'S.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10906463September 14, 2016
UNKNOWN OR OTHER
SECONDARY AIR INJECTION FAILURE AT 58K MILES. DEALER QUOTED $2200 TO REPLACE VALVES AND PUMP. SEVERAL FAILURES WITH 2012 REPORTED
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10906719September 14, 2016
FUEL/PROPULSION SYSTEM
THE AIR INJECTION PUMP WENT OUT AND HAD TO BE REPLACED, AND THERE IS ONLY 18,200 MILES ON THE VEHICLE. THE CHECK ENGINE LIGHT CAME ON WHILE DRIVING, AND I WAS ABLE TO DRIVE THE VEHICLE TO THE DEALERSHIP BEFORE "SAFE MODE" KICKED IN. TOYOTA WAS ABLE TO REPLACE THE DEFECTIVE PART. I UNDERSTAND FROM READING ON THE INTERNET THAT THIS IS TURNING OUT TO BE A COMMON PROBLEM FOR THIS VEHICLE, AND WISH TO ADD MY EXPERIENCE TO THE LIST.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10905648September 11, 2016
UNKNOWN OR OTHER
THE SECONDARY AIR INJECTION PUMP'S VALVES WENT BAD WITH THE VEHICLE ONLY HAVING 30K MILES. THIS CAUSED THE TRUCK TO GO INTO LIMP MODE AND DID NOT ALLOW FOR ACCELERATION WHILE DRIVING. THIS IS A VERY DANGEROUS ASPECT WHEN DRIVING ON THE FREEWAY. NOTHING HAPPENED TO THE VEHICLE TO CAUSE THIS FAILURE, IT JUST STARTED UP ONE DAY AND WAS BAD.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10904460September 7, 2016
ENGINE, POWER TRAIN, UNKNOWN OR OTHER
SECONDARY AIR INJECTION SWITCHING VALVE FAILURE STUCK IN OPEN POSITION CAUSING LIMP MODE IN THE TRUCK. TRUCK IS NOT ABLE TO GET TO SPEED ABOVE 40 MPH. THIS HAPPENED AS I WAS PULLING OUT OF MY NEIGHBORHOOD ONTO A STATE ROUTE WITH SPEED LIMIT OF 55 MPH AND CARS GOING WAY FASTER THAN THAT. THIS COULD POSE A DANGER IF SITUATIONS WHERE SPEED IT REQUIRED TO GET OUT OF THE WAY OF ANOTHER CAR. TRUCK ONLY HAS 57K MILES ON IT. THIS IS A SUPPLEMENTAL EMISSIONS SYSTEM AND SHOULD NOT CAUSE THE TRUCK TO BE USELESS IF FAIL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10903824September 6, 2016
ENGINE
57,000 MILES ON TRUCK WENT INTO LIMP MODE, P2440 AND P2442 CODE SHOWED SECONDARY AIR INJECTION VALVE DEALER QUOTED $2000, SAID THEY WOULDN'T COVER ANYTHING
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10903636September 5, 2016
ENGINE
THE SECONDARY AIR INJECTION PUMP FAILED AT 62,000 MILES. FOR SPECIFICS IT SHOWED THE CODES P2440 AND P2442. THIS WAS KNOWN PROBLEM ON THE PREVIOUS MODEL TUNDRAS, THE SERVICE MGR AT RODLAND TOYOTA SAID THEY HAD ALREADY REPLACED THREE PUMPS ON TRUCKS OF THE SAME YEAR THAT WEEK.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10899383August 29, 2016
ENGINE
THE SECONDARY INJECTION PUMP WENT OUT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tacoma