Toyota Tacoma Complaints (2004)

415 consumer complaints on file.

#10779069October 1, 2015
STRUCTURE:BODY:DOOR, ELECTRICAL SYSTEM, LATCHES/LOCKS/LINKAGES
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. THE CONTACT STATED THAT THE DRIVER SIDE DOOR'S ELECTRONIC LOCK SYSTEM FAILED. THE DOOR LOCKED ON ITS OWN AND DID NOT UNLOCK WITH THE INTERIOR OR EXTERIOR DOOR HANDLES. THE PASSENGER SIDE DOOR WAS USED TO EXIT THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES FOR THE FAILURE A DIAGNOSTIC WAS PERFORMED, WHICH WAS UNABLE TO LOCATE A FAILURE CODE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. UPDATED 1/19/16 LN; UPDATED4/16/18*JB *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10776483September 24, 2015
SUSPENSION, UNKNOWN OR OTHER
THERE IS FRAME ROT ON THE VEHICLE WEAKENING THE FRAME AND SUSPENSION COMPONENTS. THE WORST AREA OF ROT IS ON THE DRIVERS SIDE OF THE VEHICLE WHERE THE REAR LEAF SPRING ATTACHES TO THE FRAME. THIS AREA ALSO HAS THE GAS TANK AND FUEL LINES AND REAR BRAKING LINES. I WAS NEVER NOTIFIED OF A RECALL. UPON DISCOVERY OF THIS HAZARD I NOTIFIED THE DEALER AND WAS TOLD MY VEHICLES RECALL HAD ENDED. I ALSO NOTIFIED TOYOTA CORPORATE AND WAS TOLD THERE IS NOTHING THEY CAN DO. TOYOTA TACOMAS HAVE HAD FRAME ROT ISSUES WITH RECALLS THAT HAVE AFFECTED THE REAR BRAKES FUEL LINES AND TANK. I FEEL IT IS UNFAIR OF TOYOTA TO ADMIT AN ONGOING PROBLEM AND REPLACE FRAMES ON TRUCKS WITH THIS ISSUE, YET DENY ME BECAUSE I WAS NOT MADE AWARE OF IT. HAVING A WINDOW OF TIME ON A RECALL THAT IS A HUGE ISSUE IS NOT FAIR. NOW I HAVE AN UNSAFE VEHICLE, THAT I AM AFRAID TO PUT MY CHILDREN IN, AND NO WHERE TO TURN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10766341September 21, 2015
STRUCTURE:BODY, WHEELS
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 12V542000 (TIRES); HOWEVER, THE MANUFACTURER AND THE DEALER REFUSED TO REMEDY THE RECALL DUE TO EXCESSIVE CORROSION OF THE SUBFRAME. THE CONTACT STATED THAT THE VEHICLE RECEIVED AN ANTI-CORROSION COATING TREATMENT PRIOR TO THE RECALL NOTIFICATION. THE CONTACT WAS INFORMED BY THE MANUFACTURER THAT THE ANTI-CORROSION TREATMENT WAS PERFORMED OUTSIDE OF THE RECALL; THEREFORE, NULLIFYING THE RECALL REMEDY TO THE LIFT PLATE FOR THE SPARE TIRE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 99,876.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10766452September 21, 2015
FUEL/PROPULSION SYSTEM
DRIVING AT 35 MPH, HEAR A DRAGGING NOISE AND PULL TO THE SIDE OF THE ROAD. I LOOKED UNDER THE CAR A SAW THAT THE METAL STRAPS HOLDING THE GAS TANK TO THE CAR HAD RUSTED THRU, ALLOWING THE TANK TO DROP DOWN TO ABOUT 3 INCHES ABOVE THE ROADWAY, CAUSING THE TANK TO DRAG THE GROUND
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10764702September 17, 2015
SEAT BELTS:FRONT:RETRACTOR
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. THE CONTACT STATED THAT THE SEAL BELT RETRACTORS ON THE DRIVER AND PASSENGER SIDES FAILED TO FUNCTION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10763485September 14, 2015
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR REPLACEMENT TIRES; HOWEVER; THE TECHNICIAN DISCOVERED THAT THE STRUCTURE OF THE VEHICLE HAD EXCESSIVE CORROSION. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS UNSAFE TO DRIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 91,000. UPDATED 11/19/15*LJ *CN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10760633September 1, 2015
STRUCTURE:BODY
NEAR TERMINAL FRAME ROT. EXCESSIVE RUSTING OF FRAME. NO RUST ON BODY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10749479August 18, 2015
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. THE CONTACT STATED THAT THE FRAME PREMATURELY RUSTED. THE VEHICLE WAS UNABLE TO PASS AN INSPECTION DUE TO THE FAILURE. THE DEALER AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE AND PROVIDED NO REMEDY. THE APPROXIMATE FAILURE MILEAGE WAS 147,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10748763August 14, 2015
SUSPENSION, FUEL/PROPULSION SYSTEM
THE OWNER FOUND A RECALL ON 2004 TOYOTA TACOMAS ON THE INTERNET. THIS RECALL SPECIFIED THAT THERE WAS A MANUFACTURING DEFECT IN THE FORMULATION OF THE UNDERCOATING. THIS MANUFACTURING DEFECT RESULTED IN THE RUSTING OF THE SUSPENSION, AND TIRE PLATE. UPON INSPECTION OF THE VEHICLE BY A TOYOTA DEALER, IT WAS FOUND THAT THE A-FRAME IS RUSTED THROUGH, THE LEAF SPRINGS ARE FAILING AND ARE BOWED IN THE OPPOSITE DIRECTION, GAS TANK MOUNTS ARE RUSTED AND THE UNDER BODY OF THE GAS TANK HOUSING IS RUSTING THROUGH. TOYOTA DEEMED THE VEHICLE UNSAFE BUT REFUSED TO DO ANYTHING BECAUSE THE RECALL HAD EXPIRED. THE OWNER NEVER RECEIVED A NOTICE BY MAIL DURING THE RECALL PERIOD. IF THE OWNER WOULD HAVE RECEIVED THE RECALL NOTICE HE WOULD HAVE BROUGHT THE VEHICLE IN FOR INSPECTION AND REPAIR. THIS VEHICLE HAS LOW MILEAGE AND IF IT WERE NOT FOR THESE MANUFACTURING DEFECTS, COULD BE DRIVEN FOR ANOTHER 10 YEARS. CONTACT WITH ANY COMMON ROAD HAZARD SUCH AS A BUMP OR POT HOLE COULD CAUSE THE BOW SPRINGS TO FAIL, AND THERE IS A POSSIBILITY OF GAS TANK RUPTURE, EXPLOSION AND DEATH.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10748136August 12, 2015
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. THE CONTACT STATED THAT THE SKID PLATE WAS RUSTED ON THE FRONT END OF THE VEHICLE AND THERE WAS EXTENSIVE RUST AND CORROSION ON THE FRAME. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN COATED THE RUST, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 181,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10734653July 16, 2015
STRUCTURE:BODY
THE BODY FRAME OF MY TOYOTA IS RUSTED AND I WAS TOLD BY THE DEALERSHIP THAT TOYOTA CONTACTED THE OWNERS OF THE VEHICLES (EFFECTED YEARS) TO HAVE THE FRAMES REPLACED. I HAVE NOT BE CONTACTED BY TOYOTA ABOUT THE RUST AND CORROSION ON MY TRUCK AND THE RUST IS VERY BAD. I WAS TOLD THAT IF THE FRAME CRACKS WHILE DRIVING, IT'S A MAJOR SAFETY ISSUE. PLEASE HELP!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10732846July 9, 2015
SERVICE BRAKES, SUSPENSION, VEHICLE SPEED CONTROL
GOING 35 MILES AN HOUR THE VEHICLE WILL START TO PULL TO THE SIDE AND THE BALL JOINT WILL COME OUT ALSO THE ABS SENSOR CABLE WILL BRAKE AND YOU WILL HAVE TO REPLACE IT A $2500 DOLLAR SPENCE FOR A TOYOTA MALFUNCTION IN THE SUSPENSION I HAVE A FRIEND IN CALIFORNIA THAT HAS ONE A YEAR EARLY MODEL THAN MINE A 2003 TOYOTA TACOMA AND HE TOLD ME ABOUT THIS PROBLEM HAD HAPPEN TO HIM IN THE FREEWAY ABOUT 60 MPH TO HIM A HAD TO LEARN THE HARD WAY IF YOU HAVE A TOYOTA TACOMA PLEASE I AM WARNING YOU TO HAVE THE BALL JOINT REPLACE BEFORE ITS TO LATE THE NEW BALL JOINTS ARE WARRANTY FOR LIFE BUT I WILL CHECK IN TO THAT IF I STILL HAVE THE PICK UP IN FOUR YEARS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10731785July 2, 2015
SUSPENSION
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. THE CONTACT STATED THAT THE REAR AND FRONT PASSENGER SPRING CHASSIS WERE CORRODED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SPRING CHASSIS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 99,370.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10731579July 1, 2015
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. WHILE THE VEHICLE WAS UNDERGOING MAINTENANCE, THE TECHNICIAN DISCOVERED THAT THE VEHICLE HAD EXCESSIVE CORROSION ON THE FRAME AND STATED THAT THE VEHICLE WAS UNSAFE TO OPERATE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE DEFECT WAS PART OF A LIMITED SERVICE CAMPAIGN, BUT THE VEHICLE WAS NOT INCLUDED. THE APPROXIMATE FAILURE MILEAGE WAS 101,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10730397June 25, 2015
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. AFTER THE VEHICLE WAS INSPECTED, THE TECHNICIAN STATED THAT THE FRAME WAS RUSTED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 167,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10726733June 23, 2015
UNKNOWN OR OTHER
RECALL ON FRAME AND I BROUGHT IT TO DEAL WHERE THEY SAID FRAME WAS NOT DEFECTED. ONE YEAR LATER FRAME IS CORRODED AND RUSTED OUT. CALL DEALER AND SAID IT WAS MY PROBLEM RECALL ENDED 6 MONTHS AGO. HOW CAN THEY GET AWAY WITH THIS!!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10725494June 16, 2015
STRUCTURE:BODY, SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. WHILE DRIVING 45 MPH, THE CONTACT HEARD AN ABNORMAL POPPING NOISE UNDER THE VEHICLE. THE CONTACT DISCOVERED THAT THE LOWER BALL JOINT FAILED AND THE WHEEL WENT UNDER THE VEHICLE. THE CONTACT NOTICED THE FRAME SKIDDING ON THE HIGHWAY. THE VEHICLE WAS TOWED AWAY, BUT WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 228,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10724647June 10, 2015
STRUCTURE:BODY, UNKNOWN OR OTHER
I PURCHASED A USED 2004 TOYOTA TACOMA 4X4 4 YEARS AGO IN NY. I MOVED TO MA 2 YEARS AGO AND TOOK TRUCK TO A CAPE COD TOYOTA DEALER AND ASKED THEM TO CHANGE OIL AND TELL ME IF THERE WERE ANY ISSUES I NEEDED TO DEAL WITH. TO MAKE A LONG STORY SHORT THEY TOLD ME ABOUT THE SPARE TIRE RUST RECALL AND MADE THE REPAIR. WHEN WE PICKED UP THE TRUCK THEY GAVE IT A CLEAN BILL OF HEALTH. THEY THEN SAID "BY THE WAY, YOU HAVE A TINY HOLE IN FRAME THAT MAY NEED TO BE TAKEN CARE OF AT SOME POINT-NOT URGENT." FAST FORWARD 2 YEARS- A GARAGED TRUCK THAT ONLY HAD AN ADDITIONAL 7,000 MILES. WE TOOK IT FOR THE MA STATE INSPECTION AND IT FAILED. THEY SAID IT NEEDED A NEW MUFFLER. WE TOOK IT TO OUR LOCAL CAPE COD MECHANIC WHO CALLED AND SAID THE PROBLEM WAS MUCH BIGGER- THE ENTIRE FRAME IS RUSTED OUT AND IT IS NOT SAFE TO DRIVE. WE FILED A COMPLAINT WITH TOYOTA CORPORATE AND THEY WON'T DO ANYTHING. THE DEALER CALLED TO SAY COME PICK IT UP EVEN THOUGH THEY KNOW IT IS NOT SAFE TO DRIVE. HOW MUCH IS A LIFE WORTH? OBVIOUSLY TOYOTA DOESN'T CARE. HELP PLEASE!!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10724054June 8, 2015
STRUCTURE:FRAME AND MEMBERS
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. THE CONTACT OBSERVED THAT THE BED FRAME ON THE DRIVER SIDE OF THE VEHICLE WAS LOWER THAN THE PASSENGER SIDE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BED FRAME WAS ROTTED, FRACTURED, AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 93,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10723805June 7, 2015
STRUCTURE:BODY
HAD 2004 FRAME RECALL TESTED BY DEALER AND THEY APPLIED THE UNDERCOATING IN 2012. THE TRUCK WILL NOT PASS INSPECTION DUE TO HOLES ROTTING THROUGH FRAME AND EXCESSIVE CORROSION. THE TRUCK IS IN PERFECT SHAPE OTHERWISE AS TOTAL BODY WAS REPAINTED AT THE TIME OF THE UNDERCOATING. THIS TERRIBLE INFORMATION TO HEAR WHEN YOU PURCHASED THE TRUCK BRAND NEW AND PLANNED ON PASSING IT DOWN. ITS 11 YEARS OLD AND A LAWN ORNAMENT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tacoma