Toyota RAV4 Complaints (2020)

652 consumer complaints on file.

#11541981August 31, 2023
ELECTRICAL SYSTEM, STEERING
High Voltage Warning and Low Power to Steering reading on the dashboard. Service engine warning!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11541774August 30, 2023
ENGINE
Coolant Bypass Valve on my 2020 RAV4. There needs to be a recall; even Toyota dealerships in the Dallas/Fort Worth metroplex say that there needs to be a recall. Service advisors say this is a big problem they see daily and with all cars and at all mileage. The cost to replace the Coolant Bypass Valve in my car = $855- RIDICULOUS!! In addition, due to the constant “Engine Maintenance Required” message on the screen triggered by the Coolant Bypass Valve needing to be replaced, that can’t be removed, all other car related information and/or service issues, is unable to be seen…which is dangerous!! Toyota used to be one of the best car manufacturers for quality and reliability, but now, their quality has tanked…
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11541001August 27, 2023
UNKNOWN OR OTHER, ENGINE
Coolant value had to be replaced apparently this happens more than we realize and if it’s a repetitive issue for many I believe it should be looked into. Thanks
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11539918August 21, 2023
POWER TRAIN
Engine stalled on highway, was fortunate other drivers allowed us to get to the inside lane and on the shoulder. It bucked a couple times a few minutes earlier. A host of warning lights came on the dash. car did restart after ignition cycled off and on. Had over 1/2 tank fuel. Dash warnings that remained on CEL yellow. parking assist Radar and lane assist. Power steering seemed weak. No cruise control. Over the next 550 miles with engine shut offs during fuel stops dash warnings went out and car returned to normal. No longer trust this car with 70,000 miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11539826August 21, 2023
FUEL/PROPULSION SYSTEM
Fuel tank fill up only 9-10gal wherein published rating to 14gal tank. There should be a recall on changing fuel pump but my VIN does not show any recall
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11539636August 20, 2023
AIR BAGS, ELECTRICAL SYSTEM, STRUCTURE:BODY
There is a recall for the roof rails leaking water which can damage the air bags and electrical components. They will not fix the roof with new gaskets unless you actually see the water coming in. My concern is that it is leaking and I'm just not seeing it because the 110 degree weather. I do not want to be in an accident with my wife and kids in the car and have the air bags not work. They should fix the gaskets before it leaks and leads to further potential damage or even life threatening results(air bags being wet and not deploying). They will not fix my roof until it actually starts leaking even tho there is a recall in place. This is ridiculous.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11539493August 19, 2023
ENGINE, ELECTRICAL SYSTEM
I was driving and out of nowhere this warning came on engine maintenance required, and this now a normal maintenance required that means an oil change. The problem with this warning is the coolant bypass valve, and I’m not the only one with this issue, my car has only 32100 miles only, this a ridiculous for a new car. Plus it seem that this issue only comes on with tha A/C on
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11539586August 19, 2023
ENGINE
My car is leaking coolant and needs a new coolant bypass valve. It seems like it is happening to every rav4 and camry. They put in faulty parts.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11539295August 18, 2023
STEERING
The contact owns a 2020 Toyota Rav4. The contact stated while driving 45 MPH, the vehicle lost motive power while accelerating. The contact heard a ding and became aware of an irregular voltage spike, steering power, and other unknown messages were displayed before quickly disappearing. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 172,600.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11539395August 18, 2023
UNKNOWN OR OTHER
My Engine Maintenance Required light had appeared on dashboard and found out that is my coolant bypass valve that needed to be replaced. had on online, to find that this is a issue with Toyota, that people had to have this replaced. I had purchased my vehicle back in 2021, and just had this issue 2023. I took to the dealership and was told that it was that part. they are replacing the part going through the extended warranty insurance, but this is concerning, that if this OE part has a defect, that once my warranty expires that I will have this problem again and have no way on coverage.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11539105August 17, 2023
ENGINE
Coolant Bypass Valve failure at 41K miles. Confirmed by dealership. "Engine Maintenance" warning light came on before taking to dealership.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11538713August 15, 2023
UNKNOWN OR OTHER
The engine maintenance light came on to visit the dealer. It's because of the Coolant Bypass Valve.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11538275August 13, 2023
POWER TRAIN
Got an oil change Monday 8/7/23 When I left the dealership & arrived home the “engine maintenance required” light came on. Contacted dealership next day (service was done at Maita Toyota of Sacramento) let them know about what happened they told me they’d do a diagnostic on the vehicle. Car was at 43,772 miles when I dropped it back off at dealership. They ended up letting me know the diagnosis was the coolant by pass value / hoses were bad and needed to be replaced. However - Toyota would not cover the repair because of their current powertrain warranty expiring on my vehicle. After researching online this seems to be a common issue with this year of rav4. I was luck enough to have extended warranty and only had to pay a $200 deductible but had I not it would be been almost $800 I would have had to pay. Toyota should be made aware of this issue. As an overheating issue can cause dozens of other problems with the car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11538088August 12, 2023
ENGINE
Coolant Bypass valve internal short.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11537932August 11, 2023
UNKNOWN OR OTHER
A known issue that has been occurring to many people with the coolant bypass valve system going out very soon after purchasing. I bought a 2020 Toyota rav4 and my bypass coolant valve has malfunctioned and needs replaced and of course is outside of the warranty. Per many google searches this is a common issue and should be addressed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11537498August 9, 2023
ENGINE
The Engine Maintenance Required Visit your Dealer came on and wouldn’t go away. I took it into Toyota and they charge $166 dollars to run a diagnostic. Plus what ever it cost to fix it. Turns out that 2020 Toyota RAV 4 Have an issue with the coolant by pass it’s a pipe if left unfixed it can make the car over heat and it’s part of the radiator can cost $700 to fix at the dealership. My car is only 3 years old it shouldn’t have this issues and be costing my hundreds of dollars to fix.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11537532August 9, 2023
ENGINE
The engine maintenance required light came on at 56,000 miles and would not reset even after a scheduled oil change. The Toyota dealership neglected to evaluate this light when I brought my car in for servicing. After getting a diagnostic, it was found that the coolant bypass valve needed to be replaced which was at least $600. I was advised that the vehicle was to not be driven long distances as it could result in more damage to the car. This is my 4th expensive repair on this 3 year old car in 1 year. This is my very first Toyota, & I am extremely disappointed. I bought a Toyota anticipating a low maintenance, high quality vehicle and have had nothing but issues.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11536679August 5, 2023
ENGINE
There is a known issue with the coolant bypass valve failing. Dealerships are charging over $600 to fix and many people are having the same issue. The engine maintenance required message is persistent, and will not allow you to bypass it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11536047August 2, 2023
UNKNOWN OR OTHER
Coolant bypass valve just gave out on car was informed by dealership that this is an ongoing problem with my make of car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11535175July 29, 2023
ENGINE
The vehicle has a message engine maintenance required. The Toyota dealership diagnostic was that the coolant bypass valve needed to be replaced. The dealer told us they are getting at least 6 Rav4 a week coming in with the same issue. The part replacement isn't covered manufacturer under warranty. This needs to be a recalled part.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota RAV4