Toyota RAV4 Complaints (2019)

906 consumer complaints on file.

#11610629August 24, 2024
ENGINE
A warning message appeared that stated: “Engine maintenance required - Visit your dealer”. At that time my vehicle had 38,796 miles on it. I contacted the Service Advisor at Toyota of Newnan who advised that it was likely the Coolant Bypass Valve on the engine and that they have had issues and repairs relating to that condition on their RAV4 and Corolla models. Their mechanics confirmed that this was the fault and that failing to have it repaired / replaced could result in engine overheating and engine seizing which could result in lose of vehicle control and endanger other vehicles on the road. Sensing the urgency, I had the repair / replacement completed at a cost of $846.68. Service advisor stated that many of the other vehicles with the same problem were still under warranty and repaired at no cost to the consumer. In my opinion this recurring defect among two Toyota model lines is occurring with enough regularity to warrant Toyota issuing at least a Service Bulletin and covering the cost of the repair and reimbursement to those that had to pay for the repair.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11609549August 19, 2024
ENGINE
Check engine light came on. Ran codes in vehicle and showed code P2681-15 engine coolant bypass valve needs replaced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11609157August 17, 2024
ENGINE
2019 RAV4 with 50120 miles engine maintenance light. It is a very common problem with Rav4s. coolant bypass valve...... My brother has same model same problem. Spent $600 to replace it. Toyota is charging $600-$1000 to replace defective part.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11609023August 16, 2024
ENGINE
2019 rav4 at 59,000 miles engine maintenance required popped up. Went to the dealer, service advisor knew exactly that coolant control valve needed to be replaced because it being so common. I looked it up and coolant bypass valves in the 2019–2023 RAV4 and Corolla models. Some owners have reported that this defect could affect the vehicle's performance and longevity. Now I have to spend almost 1,000 for a repair I didn’t even cause because Toyota built a faulty valve.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11607975August 12, 2024
ENGINE
Engine error message showed up after extended warranty expired by 600 miles. To fix the error message Toyota charge $871 total combined diagnostic, part and labor. The problem was coolant by pass valve shorted.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11608079August 12, 2024
ENGINE, UNKNOWN OR OTHER
Coolent valve needed to be replaced
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11608118August 12, 2024
Other/I am not sure, Carry Handle, Shell, Base
Maxi-Cosi Emme 360… MAJOR SAFETY CONCERN! When in the locked position with confirmed “locked” emblem visible, the car seat can easily be knocked loose and rotated. There are of course several warning labels on the side that say do not attempt to rotate the seat while in the locked position without using the appropriate release handle. The amount of light force I am apply is extremely minimal and nothing compared to the torsion that will be exerted to the car seat during a serious collision. We have already contacted the manufacturer directly, this is now the second car seat we have received with the same issue. We have been on the phone with tech support. They have no idea what’s happening and cannot resolve the issue. Again, this is a very serious safety concern with the car seat.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11607810August 11, 2024
ENGINE, POWER TRAIN, UNKNOWN OR OTHER
Toyota Rav4 2019 XLE - Engine Coolant Pump Performance/Stuck Off Error code P26CB milage 56,920 Toyota says this is NOT covered by the 5 year power train warranty. For years Toyota has manufactured this water pump that freezes up due to manufacturing defect that allows the magnetic base housing to rupture. Dealers want to replace entire pump (or at least charge for it) verses replacing the frozen plastic rotor. Dealer claims this is not covered under 5 year power train warranty. Why not? My car temp started climbing and took me hours to get home (10 miles) as I kept stopping for hours waiting for engine cool and sprinkling water from bottles over the engine and trans housing where it butts against the engine (silver brading). (This was late in weekend night - repair shops not open. I do see a recall investigation started (no recall yet) and just wanted to add my complaint to the issue. At first the temp gauge read normal but later started climbing. The engine light did come on the the DB2 said P26CB.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11606592August 5, 2024
ENGINE
Coolant bypass valve
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11606637August 5, 2024
UNKNOWN OR OTHER
“Engine maintenance required, see dealer” message appeared on dash. Message cannot be cleared and blocks important information while driving. Diagnostic was performed and no codes were observed. Toyota dealership stated that the message is due to a faulty engine coolant bypass valve.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11606143August 2, 2024
POWER TRAIN
I have the 2019 Toyota RAV4 Adventure that was manufactured with a defective differential, per T-SB-0067-20, Toyota has acknowledged that the differential were defective and that affected thousands of 2019-2020 RAV4 Adventure and Limited trim models. The defective part number is 41110-42050 and the new, superceded part number is 41110-42054. I reached out to Toyota numerous times to rectify the issue has the differential clunks and could seize causing loss of control. My vehicle was deemed a "total loss" due to hail damage and Toyota refuses to assist because of the total loss, but the vehicle was manufactured with the defective part and my vehicle suffers the VERY same issue as that a non-total loss vehicle suffers. The title status is irrelevant as the defective differential was installed BEFORE the total loss, so the title status is inconsequential. This is a safety concern because the differential could fail due to seizure, shatter, explode resulting in a loss of control and injury to me the driver and others on the road. I've expressed this numerous times with Toyota.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11605791August 1, 2024
ENGINE
Upon reaching 50k miles, vehicle prompted a "engine maintenance required, please contact dealer" message. Upon inspection at the dealer, I was told this is a common issue in newer Toyota RAV4/Corollas and employees have been seeing this issue continuously. There is no way to bypass this message without getting the part replaced and the replacement runs anywhere ~$800 -$1000. How are so many people dealing with the same issue and Toyota has yet to issue a recall?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11605063July 29, 2024
VISIBILITY
The contact's daughter owns a 2019 Toyota Rav4. The contact stated that the driver’s and passenger’s side front windows became inoperable. There were no warning lights illuminated. The vehicle was taken to the local dealer, who diagnosed that the window regulators on the driver's side and passenger's side front windows needed to be replaced. The vehicle was not repaired. The contact who is a mechanic stated that the steel cable in the plastic had deteriorated, and water and moisture had entered the vehicle, causing corrosion. The contact replaced both window regulators. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 63,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11604874July 27, 2024
STEERING
sounds caused by the steering wheel when traveling at 40 to 60 mph. It gets louder as you turn the steering wheel.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11604494July 25, 2024
ENGINE
Coolant bypass valve failure The issue has been confirmed by a service center and was told a very common failure in my make & model of car. Warning light came on dash board and immediately had checked at service center. The fix is $900, which is frustrating because a class action lawsuit is being gathered for this same defect in my same model of car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11604355July 24, 2024
STRUCTURE:BODY, UNKNOWN OR OTHER
The rear power liftgate metal hinges are peeling away from the body of the vehicle. My liftgate doesn't close properly and is out of alignment to stay safely latched closed and has become 100% unusable. There is a 1.5 inch gap (you can see light and water can enter) on rear pass. side and the door is tightly jammed closed on the rear driver side. After speaking with a Toyota service manager, he casually let me know he sees this frequently. I have learned this is a very known issue yet Toyota will do nothing to prevent these defective hinges from being installed or cover repairs. The service manager told to take it to the collision center to get quoted on a repair. I did and my out of pocket cost (because Toyota won't take responsibility for this defect) is between $700 and $2700, depending how much damage occurred to other components caused by the defective hinges (the collision company has also stated they've done many of these repairs). My vehicle showed no visible sign of failure prior to breaking. It would occasionally fail to close, as if an object was in the way, but upon re-trying to power liftgate button, it would close. Sometimes it would take 3 to 4 times to be successful. But, it never appeared as if it was out of alignment or damaged until last weekend when I tried to close it and it forced closed itself VERY incorrectly. Considering my vehicle was purchased less than 5 years ago, brand new, this shouldn't be happening. It definitely shouldn't be showing this kind of wear on a vehicle I haven't even had to change brakes, tires or a simple headlight on the ENTIRE ownership of the vehicle. When I use those items every single day. My liftgate is used 1 time or less a week. The cost of this repair is half what I still owe on it and I didn't even do anything to cause it, it happened due to faulty hinges that are NOT safe. How do I know my hatch won't open while driving? Or that it won't break opposite and my liftgate becomes unsecured from my suv altogeth
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11603936July 23, 2024
ENGINE
Hi there. As of June 17, 2024, there is a class action lawsuit against Toyota regarding issues with the coolant bypass valves in the 2019–2023 RAV4 and Corolla models. Some owners have reported that this defect could affect the vehicle's performance and longevity, potentially leading to expensive repairs. The plaintiffs allege that Toyota has violated the Magnuson-Moss Warranty Act, the Florida Deceptive and Unfair Trade Practices Act, and California's Unfair Competition Law, Consumers Legal Remedies Act, and Song-Beverly Consumer Warranty Act. They are seeking a jury trial, declaratory and injunctive relief, and punitive damages. I encountered the same issue on July 3, 2024, and visited Toyota Scott Clark (Charlotte), where I was charged $129 for diagnostics and $835.60 for further service to fix the problem. I am not willing to pay for this service, and Toyota has refused to cover the cost. I am joining the class action lawsuit against Toyota.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11603675July 22, 2024
ENGINE
Coolant bypass valve
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11603775July 22, 2024
POWER TRAIN
Defective coolant bypass valve. Defective valve can cause total engine failure and mechanical failure leading to accident or injury up to and including death. Has been confirmed by service center. Engine service required light is on and will not go off there was no warnings of any issues prior to the light turning on. This is an expensive out of pocket fix in upwards of $1000.00
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11603661July 21, 2024
ENGINE
My engine maintenance light will not shut off due to a engine coolant bypass valve circuit short to battery. I also have warm fluid dripping on my feet when ac is on. The dealer says water under the dash is from from recalled roof rails. There has been a recall for code that pops up on my mechanic Toyota number20TA04. Dealer says he does haven't code so toyota hasnt issued any issues or re all for engine bypass valve. Toyota now has a class action law suit for this part. I can't afford $700 repair, can't see the messages or my speed due to the engine maintenance required on my screen which can't be reset. This is dangerous and can cause the need to have engine replaced, start engine fires. Toyota has known this issue for 5 yrs and needs to be held accountable.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota RAV4