Toyota 4Runner Complaints (1996)

161 consumer complaints on file.

#10993315June 5, 2017
STRUCTURE:BODY
WHILE CORNERING IN CITY DRIVING I HEARD A CLUNKING NOISE AND INVESTIGATED WHEN I ARRIVED HOME. THE FRAME HAS CORROSION AT THE RIGHT REAR TRAILING ARM BRACKET. THE BRACKET WAS RUSTED AWAY FROM THE FRAME AT THE TOP BUT STILL ATTACHED AT THE BOTTOM. THE BRACKET AND FRAME WERE WELDED WITH ADDTIONAL METAL. I CHECKED THE REST OF THE FRAME AND NOTICED THERE IS ALSO A HOLE IN THE CROSSMEMBER BELOW THE DRIVERS SEAT AND OTHER LARGER RUSTED HOLES ALONG THE FRAME. THIS IS A MAJOR SAFETY CONCERN. I WILL HAVE TO TAKE IT TO A FRAME SHOP AS TOYOTA SAYS THERE IS NO RECALL ON THE 4RUNNER ONLY THE TACOMA AND TUNDRA. I KNOW MANY OTHER 3RD GENERATION 4RUNNER OWNERS WHO HAVE THE SAME PROBLEM. THE VEHICLE BODY HAS NO RUST OTHER THAN A SMALL SURFACE AREA AT THE DRIVERS DOOR ROCKER PANEL AND NEAR THE WINDSHIELD. THE VEHICLE IS VERY WELL MAINTAINED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10972189April 13, 2017
SUSPENSION
FRAME BADLY ROTTED CROSSMEMBER FOR TRANSMISSION AND LEFT REAR ARE WORST .
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10938869December 30, 2016
STRUCTURE:BODY
I OWN A 1996 TOYOTA 4RUNNER THAT HAS FRAME IS RUSTED WITH LARGE HOLES. IT HAS NOT CAUSED AN ACCIDENT YET BUT I BELIEVE THE MANUFACTURER SHOULD BE HELD ACCOUNTABLE. ESPECIALLY WHEN THE SAME COMPANY HAS REPLACED FRAMES AND BOUGHT BACK OTHER MODELS FOR THE EXACT SAME ISSUE. HOW AM I (AS A 4RUNNER OWNER) JUST OVERLOOKED AND BRUSHED ASIDE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10908527September 21, 2016
UNKNOWN OR OTHER
FRAME IS SO ROTTED IT WON'T PASS INSPECTION. SEEMS TO BE A COMMON PROBLEM WITH TOYOTA. THEY REPLACED FRAMES ON THE TACOMA AND A FEW OTHERS, WHY NOT THE 4 RUNNER.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10904932September 9, 2016
STRUCTURE:BODY
TRAVELING NB APPROACHING GREEN LIGHT AND A CAR RAN RED LIGHT IN INTERSECTION. THE CAR ON SB SWERVED ON MISS THEM, HIT THEM ANYWAY AND HIT ME HEAD ON. BOTH ON THEIR AIR BAGS WENT OFF AND MINE DID NOT. I AM STILL IN PHYSICAL THERAPY FOR PARTIAL ROTATOR CUFF TEAR, SPRAINED NECK, BACK, SHOULDER, ELBOW AND I STILL CANNOT USE RIGHT ARM FROM ELBOW DOWN. I HAVE NOT WORKED SINCE THE ACCIDENT. I WANT TO KNOW WHY MY AIR BAGS DID NOT GO OFF.
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#10894693August 10, 2016
STRUCTURE:BODY
SECOND OWNER OF THIS SUV THAT I HAVE OWNED FOR 12 YEARS. FRAME RUST ISSUES HAVE PROCEEDED TO THE POINT WHERE ONE MONTH AGO, THE LEFT REAR LATERAL AXLE LINK BRACKET BROKE FREE FROM THE FRAME. THE CAR IS NOW UNSAFE TO DRIVE BECAUSE THE REAR AXLE IS NOT TIED TO THE FRAME ON THE DRIVER'S SIDE. MECHANIC TOLD ME IT MIGHT BE ABLE TO BE FIXED/WELDED, BUT THE REST OF THE FRAME IS SO BAD THERE ISN'T MUCH TO WELD TO. I HAVE FOUND NUMEROUS OTHER COMPLAINTS ONLINE ABOUT THIS GENERATION 4RUNNER AND ITS FRAME RUST ISSUES. I ALSO FOUND MANY CASES WHERE THE EXACT SAME ISSUE WITH THE AXLE LINK BRACKET HAS OCCURRED. THIS REALLY SEEMS TO BE A BROADER ISSUE THAT TOYOTA HAS NOT REMEDIED FOR 4RUNNER OWNERS. DISAPPOINTED THAT I'M NOT ABLE TO KEEP THIS LONGER LIKE I'D PLANNED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10888078July 25, 2016
UNKNOWN OR OTHER
FRAME RUST ISSUE. REAR SHOCK AND SPRING MOUNT ON FRAME HAS BROKEN DUE TO EXCESSIVE RUST.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10871337May 28, 2016
STRUCTURE:BODY
1996 TOYOTA 4RUNNER WILL NOT PASS PENNSYLVANIA SAFETY INSPECTION DUE TO FRAME RUST AND DETERIORATION. EXTENT OF DAMAGE MAY INHIBIT REPAIR WITHOUT TOTAL FRAME REPLACEMENT. VEHICLE IS NOT OPERABLE WITHOUT INSPECTION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10862417May 1, 2016
STRUCTURE:BODY
I HAVE OWNED MY 4RUNNER FOR 26 YEARS AND I HAVE METICULOUSLY CARED FOR IT. ONE OF MY SHOCKS GAVE WAY AND I BROUGHT IT IN FOR MY TECHNICIAN TO INSPECT IT. UPON MY HIS INSPECTION I WAS NOTIFIED ABOUT THE EXTENSIVE RUST ON THE FRAME AND OTHER PARTS UNDER THE TRUCK SUCH AS THE GAS LINE. I WAS INFORMED THAT MY ENGINE RUNS STRONG WITH 209K ON IT. MY TECHNICIAN WOULD NOT DO ANY REPAIRS TO THIS FRAME BECAUSE OF HOW COORS ICE IT WAS. HE SHOWED ME SEVERAL FINGERS GOING THROUGH A STRESS POINT NEAR THE REAR AXEL. THE TRUCK LOOKS BEAUTIFUL AND IS NOW USELESS WITH THE RUSTY FRAME. I LIVE IN SALTY CT AND BELIEVE THE FRAME WAS NOT PROPERLY CONDITIONED FROM THE FRAME FACTORY. VIN NUMBER: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10850376March 18, 2016
AIR BAGS
TAKATA RECALL. WAS NOTIFIED ALMOST A YEAR AGO ABOUT THE AIR BAG RECALL AND STILL HAVE NOT BEEN PROVIDED A FIX.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10836354February 16, 2016
SUSPENSION, UNKNOWN OR OTHER
KNOWN DOCUMENTED ISSUES WITH TOYOTA 4RUNNER FRAME ROT. THIS PARTICULAR VEHICLE THE CONTROL ARM SUPPORT BRACKETS ARE SHOWING SIGNS OF RUST THROUGH WITH HOLES APPEARING IN THE BRACKETS. THIS IS DOCUMENTED WITH PHOTOS! THE VEHICLE WAS PURCHASED NEW BY MY FATHER IN 96, ALWAYS GARAGE KEPT ,IN 2006 I BOUGHT THE VEHICLE FROM HIM AND ALSO IS KEPT IN A DRY GARAGE NOT SITTING OUT OVER MOIST SOIL. THE 4RUNNER HAS NEVER BEEN IN A ACCIDENT. I AM A CERTIFIED MECHANIC WHO PERFORMS SAFETY INSPECTIONS AS I WORK FOR ENGINEERING UNIVERSITY. IT CAME TO MY ATTENTION WHEN I WAS HEARING AND READING STORIES OF THESE 3RD GENERATION 4RUNNERS HAVE STABILITY PROBLEMS DIRECTLY RELATED TO THE RUSTED OUT FRAME SUPPORT BRACKETS THAT HOLD THE CONTROL ARMS IN PLACE FOR THE REAR AXLE. THIS IS A MAIN FRAME COMPONENT , IF THE SUPPORT BRACKET BREAK FREE IT ALLOWS THE AXLE TO WANDER AROUND AS IT'S NOT BEING HELD IN PLACE, CAUSING LOSS OF STEERING STABILITY, IT IS A ROAD HAZARD THAT IS EVENTUALLY GOING TO KILL PEOPLE . I HAVE A 95 BLAZER THAT WAS PURCHASED SIX MONTHS BEFORE THE 4RUNNER AND I STILL HAVE IT! THE BODY ON THE BLAZER IS LITERALLY RUSTED EVERYWHERE HOWEVER,THE INTEGRITY OF THE FRAME IS STILL SOLID BUT THE FRAME IS RUSTED BADLY ! CONVERSELY, THE BODY ON THE 4RUNNER IS EXCELLENT ESPECIALLY FOR THE YEAR, HAVING A RUSTED OUT BODY IS A APPEARANCE ISSUE NOT A SAFETY RELATED ISSUE AS IN THE 3RD GENERATION TOYOTA 4RUNNER THAT RESIDE IN THE UPPER MIDWEST. TOYOTA HAS A A BUY BACK PROGRAM WITH TUNDRA PICKUPS THAT HAVE FRAMES THAT ARE SAFETY HAZARDS. I FEEL THESE 4RUNNERS ARE NO DIFFERENT THAN THE TUNDRAS, TOYOTA SHOULD HAVE THE FRAMES EITHER REPLACED OR BUY THE VEHICLE BACK! I TOOK GREAT CARE OF THIS 4RUNNER IT LOOKS GREAT ,HOWEVER I CAN NOT SELL IT DUE TO THE POSSIBILITY OF THE CONTROL ARM BREAKING FREE FROM THE FRAME CAUSED BY INSIDE FRAME ROT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10821595January 21, 2016
STRUCTURE:BODY
FRAME BROKE DUE TO RUST BY THE LOWER CONTROL ARM GOING STRAIGHT DOWN THE ROAD DOING ABOUT 30MPH ALMOST CAUSING ME TO GO OFF THE ROAD. HAD IT TOWED TO A LOCAL GARAGE TO FIND OUT IT WAS RUSTED THROUGH IN SEVERAL PLACES AND THE MECHANIC TOLD ME IT WAS A COMMON PROBLEM WITH THIS YEAR OF 4RUNNER. IF THIS HAD HAPPENED GOING DOWN THE HIGHWAY IT COULD OF COSTED ME MY LIFE OR SOMEONE ELSE'S AND BEING AS COMMON OF A PROBLEM AS IT IS I FEEL IT SHOULD BE ADDRESSED THERE'S NO REASON A FRAME SHOULD RUST AS BAD AND AS QUICK AS THIS CONSIDERING IT HAS BEEN UNDERCOATED EVERY YEAR OF ITS LIFE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10787949November 3, 2015
STRUCTURE:BODY
TL* THE CONTACT OWNS A 1996 TOYOTA 4RUNNER. WHILE DRIVING 40 MPH, THE VEHICLE BEGAN TO WOBBLE UNCONTROLLABLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRAME ON THE DRIVER SIDE HAD COMPLETELY RUSTED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 224,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10760591August 31, 2015
STRUCTURE:BODY
HI, THE FRAME IS EXTREMELY RUSTED. IT HAD A SMALL TEAR ON A WELD. NOW IT HAS A LARGE TEAR IN THE FRAME. IT APPEARS THAT IT IS RUSTING AT ALL THE WELD POINTS AT A ACCELERATED RATE AND OR THE FRAME ITSELF IS NOT THICK ENOUGH. I HAVE READ OF HUNDREDS OF OTHERS THAT OWN THIS CAR AND THE FRAME HAS RUSTED THROUGH. I KNOW THAT THE TACOMA HAS BEEN RECALLED AND IT HAS THE EXACT SAME FRAME-------PLEASE ADVISE AS THIS CAR IS NOT EVEN 20 YEARS OLD......THE CAR IS IN GREAT CONDITION OTHERWISE AND IN NO WAY SHOULD BE READY FOR THE JUNK YARD........
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10758725August 24, 2015
SUSPENSION
ON DECEMBER 31, 2014 WE WERE DRIVING IN HILLSBORO, OH AND NOTICED A POPPING AND CRACKING NOISE UPON STOPPING AND ACCELERATING. ON THE WAY HOME, WE NOTICED THAT THE NOISE SUBSIDED. ON JANUARY 1, 2015, WENT TO DRIVE THE VEHICLE JUST OUTSIDE OUR CORPORATION LIMIT AND NOTICED THAT THE VEHICLE WAS SWAYING BACK AND FORTH LIKE A BOAT OUT ON THE WATER, AND THOUGHT IT WAS JUST CAUSED BY EXCESSIVE WIND. ON JANUARY 2, 2015 WE WERE TRAVELLING ON US 35 TOWARDS CHILLICOTHE, OH AND HIT A RIPPLE IN THE ROAD AND THE FRONT END OF THE VEHICLE STARTED SWAYING VIOLENTLY AT ABOUT 45 MPH. WE PULLED THE VEHICLE OFF THE ROAD AND THOUGHT IT WAS IN THE FRONT END AND COULDN'T SEE ANYTHING. WE TOOK OFF AGAIN AND IT DID THE SAME THING AT ABOUT THE SAME SPEED AND PULLED OFF THE ROAD AND DECIDED TO TAKE IT TO GUSWEILER TOYOTA IN WASHINGTON C.H. OH APPROXIMATELY 3 MILES AWAY. A TECHNICIAN INFORMED US THAT THE FRAME WAS BROKEN WHERE THE LEFT REAR TORTION BAR HOOKS TO THE FRAME. HAD THE VEHICLE TOWED HOME AND UPON FURTHER INSPECTION WE FOUND THAT THE FRAME HAS CRACKS ALL THROUGH IT. WE PURCHASED THE VEHICLE IN SEPTEMBER 2013 FROM A USED CAR DEALER WHO BOUGHT IT FROM JOSEPH AIRPORT TOYOTA IN DAYTON OH. TO DATE WE ONLY PUT 5,169 MILES ON IT AND IT HAS BEEN JUST SITTING EVER SINCE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10735007July 19, 2015
UNKNOWN OR OTHER, STRUCTURE:BODY
I RECENTLY BOUGHT MY 1996 4RUNNER AT THE BEGINNING OF 2015. THERE WAS SOME RUST ON THE FRAME BUT NO NOTICEABLE DAMAGE FROM THE OUTSIDE. NOW, SIX MONTHS LATER I HAD IT LOOKED AT BECAUSE THE EXHAUST SYSTEM BECAME INCREASINGLY LOUD. THE MECHANIC LOOKED AT THE FRAME WHILE LOOKING AT THE EXHAUST SYSTEM AND HE FOUND THAT THE FRAME HAD ROTTED FROM THE INSIDE OUT. HE RECOMMENDED I DO NOT DRIVE IT ANYMORE AS IT IS UNSAFE. HE SAID HE WOULD NEVER ATTEMPT TO REPAIR DAMAGE SUCH AS MY 4RUNNER HAS. MY VEHICLE ONLY HAS 166,000 MILES ON IT. THERE IS NO REASON THE FRAME SHOULD BE AS DAMAGED AS IT IS OR TO HAVE IT RUSTED FROM THE INSIDE OUT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10717222May 18, 2015
STRUCTURE:BODY
I HAVE EXTREME FRAME RUST.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10712169April 22, 2015
SUSPENSION
AS I WAS MAKING A RIGHT HAND TURN FROM A STOP, THE VEHICLE BECAME SEVERELY POOR HANDLING. UPON INSPECTION, IT WAS REALIZED THAT THE MOUNTING FLANGE FOR THE RIGHT REAR CONTROL ARM AND FRAME HAD RUSTED THROUGH AND THE CONTROL ARM WAS NO LONGER CONNECTED TO THE FRAME. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10694406March 16, 2015
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS, SUSPENSION
MY SON WAS DRIVING VEHICLE AND HIT A POTHOLE CAUSING DAMAGE TO THE VEHICLE. AFTER FURTHER INSPECTION THE FRAME HAD BROKE INTO BECAUSE IT WAS RUSTING FROM THE INSIDE OUT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10682784February 11, 2015
STRUCTURE:BODY
I WAS DRIVING DOWN THE HIGHWAY WITH MY SON IN THE CAR WHEN I HEARD A LOUD NOISE COMING FROM THE PASSENGER SIDE OF THE TRUCK AND IMMEDIATELY FOLLOWED WITH A LOSS OF CONTROL. LUCKILY IT WAS IN THE AFTERNOON AND RUSH HOUR HAD YET TO HIT SO THE NEAREST CARS/TRUCKS WERE ABLE TO AVOID ME. I LIMPED TO THE SIDE OF THE HIGHWAY AND LOOKED UNDER THE TRUCK ONLY TO SEE THAT THE FRAME RAIL ON THE PASSENGER SIDE HAD COMPLETELY SNAPPED IN HALF. UPON FURTHER INSPECTION IT HAD CLEARLY RUSTED FROM THE INSIDE OUT. I HAVE KEPT THE TRUCK IN EXCELLENT SHAPE, REGULAR MAINTENANCE, ETC AND EVEN CHECKED FOR RUST SINCE I KNEW THIS WAS AN ISSUE. HOWEVER SINCE IT RUSTED FROM THE INSIDE OUT, I HAD NEVER EVEN NOTICED. GOT IT TOWED TO THE DEALER WHO WOULD PROCEED TO INFORM ME THAT THE ONLY FIX FOR IT WAS A NEW FRAME. PERFECT 4RUNNER, LOW MILES, WITH EXCELLENT CARE TAKEN TO MAKE SURE IT WOULD LAST 300K, AND NOW ITS WORTH LESS THAN A ROTTEN BANANA. TALK ABOUT A PUNCH TO THE FACE. IM JUST THANKFUL MY FAMILY AND I WERE NOT HURT IN THIS MESS. I'VE READ ABOUT THE CONSTANT RUST ISSUES WITH THESE TRUCKS AND I PRAY THAT IT DOESN'T HURT AN ENTIRE FAMILY SOMEWHERE IN THE FUTURE OTHER THAN THEIR WALLET. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota 4Runner