Toyota 4Runner Complaints (1999)

330 consumer complaints on file.

#10346149July 29, 2010
STRUCTURE:FRAME AND MEMBERS
TL* THE CONTACT OWNS A 1999 TOYOTA 4 RUNNER. THE CONTACT NOTICED THAT THE REAR AXLE DRIVE TRAIN AREA WAS EXHIBITING SEVERE RUST. PRIOR TO NOTICING THE RUST, THE CONTACT STATED THERE WAS A LEAK OF UNKNOWN FLUID FROM THE REAR AXLE. THE VEHICLE WAS NOT DIAGNOSED. THE FAILURE MILEAGE WAS 110,000 AND THE CURRENT MILEAGE WAS 175,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10328255April 30, 2010
STRUCTURE:FRAME AND MEMBERS
OUR 1999 4RUNNER RECENTLY WENT TO THE DEALER FOR AN INSPECTION, WHERE WE LEARNED THAT THE FRAME ON THE TRUCK WOULD NOT PASS INSPECTION BECAUSE THERE ARE SOFTBALL SIZE HOLES IN IT. THE TRUCK IS NOT SAFE TO DRIVE AS A RESULT. THERE HAS BEEN A SIMILAR ISSUE ON THE TUNDRA FRAMES, WHICH WERE PART OF A BUY BACK PROGRAM FROM TOYOTA. WE WERE TOLD WE COULD HAVE A NEW FRAME PUT ON, BUT IT WOULD COST MORE THAN THE TRUCK IS WORTH AND THE TRUCK WOULDN'T BE THE SAME AGAIN. OUR TOYOTA DEALER HAS GIVEN US A PHONE NUMBER (AND WE HAVE A CLAIM NUMBER) FOR TOYOTA AND WE HAVE MADE OUR CASE WITH THEM, BUT NO ACTION HAS BEEN TAKEN AND THE DEALER HAS BASICALLY SAID THERE IS NOTHING FURTHER HE CAN DO. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10325460April 13, 2010
POWER TRAIN
1999 TOYOTA 4RUNNER REAR DIFFERENTIAL HOUSING RUSTED THROUGH. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10324197April 7, 2010
STRUCTURE:FRAME AND MEMBERS, SERVICE BRAKES, HYDRAULIC
UPON A NORMAL MAINTENANCE ON THE FRONT BRAKES MY MECHANIC FOUND THAT THE FRONT FRAME WAS RUSTED TO A DANGEROUS LEVEL. I WILL HAVE TO HAVE PLATES WELDED ONTO THE FRAME TO MAKE IT SAFE TO DRIVE. THIS SHOULD NOT HAPPEN ON A VEHICLE THAT IS ONLY 11 YEARS OLD AND CAREFULLY MAINTAINED. THE VEHICLE IS A 1999 TOYOTA 4 RUNNER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10313816February 24, 2010
POWER TRAIN
INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) I HAVE A 1999 TOYOTA 4RUNNER. BACK IN SEPTEMBER 2009 THE GAS PEDAL GOT STUCK AT FULL THROTTLE WHILE I WAS DRIVING IT. I APPLIED THE BRAKES - PULLED OVER AND TURNED OFF THE KEY. IT SCARED ME TO DEATH. MY DAD LOOKED AT IT AND FOUND THAT THE THROTTLE CABLE PLASTIC COATING WAS COMING APART AND GOT STUCK IN THE CABLE SHIELDING. I CALLED TOYOTA AND THEY SAID IT WOULD COST AROUND $300 TO REPLACE THE DEFECTIVE CABLE. IS THIS A COMMON PROBLEM WITH 1999 TOYOTA 4RUNNERS? SINCE THIS IS DEFINITELY A SAFETY ISSUE, WHY WON'T TOYOTA FIX IT AT THEIR EXPENSE? I CONTACTED TURNER TOYOTA IN MONTROSE COLORADO AND TALKED TO [XXX] IN THE SERVICE DEPARTMENT. [XXX] *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10312143February 19, 2010
POWER TRAIN:AUTOMATIC TRANSMISSION
1999 TOYOTA 4RUNNER, THE LEFT REAR WHEEL AXLE SEAL IS LEAKING GEAR OIL ALL OVER THE LEFT REAR WHEEL AND BRAKE. I HAVE HAD THE REAR AXLE SEALS REPLACED 5 - 7 TIMES: DECEMBER 2006, JUNE 2007, DECEMBER 2007, JUNE 2008, DECEMBER 2008, AND NOW AGAIN IT IS LEAKING FEBRUARY 2010. THE INDEPENDENT AUTO REPAIR BUSINESS WHERE I TAKE MY VEHICLE SUBSCRIBES TO "ALL DATA' WHICH ASSISTS MECHANICS ALL OVER THE COUNTRY IN SHARING WORK DONE ON VEHICLES; ASSISTING IN DIAGNOSING SIMILAR PROBLEMS, ETC. THERE ARE A TREMENDOUS NUMBER OF SIMILAR LEFT REAR AXLE SEAL FAILURES ON TOYOTA 4-RUNNERS AND PICKUPS 1999 - 2001 WHICH USE THE SAME AXLE LISTED IN THE ALL DATA WEB SITE. MANY OF THESE LIST MULTIPLE TIMES THE SEAL AS FAILED ON THE SAME VEHICLE. . I MY CASE WE HAVE BEEN GETTING THE SEALS FROM TOYOTA. THE REAR BRAKE ON THE LEFT SIDE IS COVERED IN AXLE GREASE WHICH IN MY OPINION WILL SERIOUSLY LIMIT MY BRAKING ABILITY AND COULD CONTRIBUTE TO AND ACCIDENT. I WAS NOT ABLE TO STOP AND REAR ENDED ANOTHER VEHICLE IN THE SUMMER OF 2007. FORTUNATELY NO ONE WAS INJURED IN THIS ACCIDENT. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10310483February 15, 2010
AIR BAGS:FRONTAL
AIR BAGS FAILED TO DEPLOY ON FEB. 10, 2010 FOLLOWING A SERIOUS FRONT END CRASH (30-50 MPH) OF OUR 1999 TOYOTA 4 RUNNER. AS A RESULT WIFE WAS HOSPITALIZED FOR 2 DAYS WITH CONCUSSION, SPRAINED NECK AND PTSS.CALIFORNIA HIGHWAY PATROL RESPONDED. REPORT TAKEN. *TR
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#10310501February 15, 2010
ELECTRICAL SYSTEM, FUEL SYSTEM, GASOLINE
SUDDEN LOSS OF POWER WHEN DRIVING 1999 TOYOTA 4RUNNER SR5. FUEL GAUGE READS FULL AND VEHICLE STALLS DUE TO NO FUEL IN TANK. I HAVE BEEN ABLE TO VERIFY THAT THIS IS A KNOWN ISSUE TO TOYOTA AND THAT THEY HAVE REFUSED TO CORRECT THE PROBLEM UNDER WARRANTY EVEN THOUGH THEY HAVE ACKNOWLEDGED THAT A PROBLEM WITH THE PART AS DELIVERED IN THIS VEHICLE AND THEY ISSUED TSB:EL010-00 TITLED "FUEL GAUGE INACCURACY" TO FIX THE PROBLEM ONLY UNDER WARRANTY. THIS IS NOT A WARRANTY ISSUE, BUT A SAFETY ISSUE AS VEHICLE CAN RUN OUT OF FUEL AND STALL WITHOUT WARNING AT HIGH RATES OF SPEED ON CONGESTED HIGHWAYS. THIS ISSUE HAS NOT BEEN RESOLVED. I HAVE HAD TO USE THE ODOMETER TO GUESS HOW MUCH FUEL IS REMAINING THE FUEL TANK AT ANY GIVEN TIME. FACTORS SUCH AS HIGHWAY CONDITIONS, WEATHER, NECESSARY USE OF 4WD CAN IMPACT THE NUMBER OF MILES ACHIEVED IN A SINGLE TANK OF GAS. ALSO, FUEL TANK MUST BE FILLED TO TOP WHEN REFUELING TO MOST ACCURATELY GUESS NUMBER OF MILES THAT CAN BE DRIVEN BEFORE THE VEHICLE STALLS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10306189February 4, 2010
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
I HAVE A 1999 TOYOTA 4RUNNER THAT HAS THE SAME PROBLEM WITH THE ABS AS IS BEING REPORTED FOR THE 2010 PRIUS, ONLY WORSE. WHEN THE ABS KICKS IN ON SLICK OR UNEVEN SURFACES, THE VEHICLE GOES INTO A FREELY-FLOATING MODE FOR 5+ SECONDS. THERE IS NO BRAKING CAPACITY AT ALL DURING THAT TIME AND STEERING IS DIFFICULT. THE VEHICLE IS COMPLETELY OUT OF CONTROL DURING THAT TIME. I HAVE HAD MULTIPLE NEAR-MISSES WHICH WOULD HAVE RESULTED IN SERIOUS HARM TO MYSELF AND OTHERS AND A FEW INCIDENCES WHERE I ENDED UP RUNNING OFF THE ROAD (ONCE INTO A RAVINE) OR HITTING MEDIAN STRIPS W/O INVOLVING OTHER VEHICLES. I TOOK MY VEHICLE TO THE TOYOTA DEALER TWICE ABOUT THIS ISSUE. ONCE I WAS TOLD I WAS NUTS, THAT THE ABS COULDN'T POSSIBLY BEHAVE THAT WAY; AND THE OTHER TIME I WAS TOLD THAT, "OH YEAH, THAT'S HOW ABS WORKS." NO EXAMINATION OR CORRECTION WAS OFFERED. MY STRATEGY HAS BEEN TO ALWAYS TOUCH THE BRAKES SO GENTLY THAT ABS DOESN'T KICK IN, BUT THIS WINTERS SNOWY WEATHER HAS DEFEATED THIS PLAN. WHENEVER I BRAKE ON A SLICK, SNOWY SURFACE THE ABS KICKS IN NO MATTER HOW GENTLY I TOUCH THE BRAKES. LAST WEEK, I HAD AN EXTREMELY HARROWING CLOSE CALL WHEN MY VEHICLE WENT CAREENING OUT OF CONTROL INTO AN INTERSECTION WHEN ANOTHER VEHICLE WAS PASSING THROUGH IT. THIS WAS ON A SIDE STREET WHEN I WAS MOVING VERY SLOWLY AND HAD BEGUN THE GENTLE BRAKING AT LEAST 30' BEFORE THE INTERSECTION... BUT THE ABS KICKED IN, AND I COULD NOT STOP BEFORE SLIDING INTO THE INTERSECTION. (FOR THE REQUIRED FIELD ASKING FOR THE INCIDENT DATE, I'LL GIVE THE DATE OF THIS MOST RECENT NEAR-MISS, BUT THERE HAVE BEEN MANY INCIDENTS OVER THE YEARS.) *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10304211February 3, 2010
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 1999 TOYOTA 4RUNNER.THE CONTACT STATED ON TWO DIFFERENT OCCASIONS HIS VEHICLE ACCELERATED INTO THE INTERSECTION.THE CONTACT STATED AS HE PUT HIS FOOT ON THE BRAKES THE VEHICLE ACCELERATED INTO A BUILDING. THE VEHICLE WAS DAMAGED BUT THERE WERE NO INJURIES.THE CONTACT DROVE HIS VEHICLE TO THE DEALER AND THEY CHECKED THE VEHICLE AND STATED THERE IS NO PROBLEM WITH THE VEHICLE.THE CONTACT TOOK HIS VEHICLE TO HIS OWN MECHANIC AND WAS TOLD TO TAKE THE FLOOR MATS OUT AND SEE IF HE EXPERIENCED THE SAME PROBLEM. THE CONTACT CALLED THE MANUFACTURER AND WAS TOLD TO TAKE THE VEHICLE TO THE DEALER FOR THEM TO CHECK IT. THE FAILURE MILEAGE WAS 170,000.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10303515February 1, 2010
VEHICLE SPEED CONTROL
IN SEPTEMBER 2009, I WAS STARTING MY 1999 TOYOTA 4RUNNER IN MY DRIVEWAY. I DRESSED THE CLUTCH AS USUAL AND TURNED THE KEY. THE ENGINE STARTED, I HEARD A "POP", AND IT BEGAN RUNNING AT FULL THROTTLE AND WAS RACING FOR SEVERAL MINUTES UNTIL I FINALLY TURNED IT OFF. THE RPM GAUGE WAS AT ITS MAXIMUM. I DID NOT HAVE A FLOOR MAT ON THE DRIVERS SIDE, I DID NOT HAVE MY FOOT ON THE GAS, AND WAS NOT DOING ANYTHING TO RACE THE ENGINE. I COULD NOT MAKE THE ENGINE STOP RACING. I TRIED TO PUT MY FOOT ON THE GAS PEDAL AND THEN RELEASED IT. IT WAS STILL RACING, AND THE GAS PEDAL WAS NOT DEPRESSED OR CAUGHT ON ANYTHING. FORTUNATELY, THE CAR WAS STILL IN NEUTRAL WITH THE PARKING BRAKE ON. IT WAS VERY SCARY, AS I COULD NOT MAKE THE ENGINE STOP RACING. I HAD TO TURN THE ENGINE OFF TO STOP IT. I TOOK IT TO THE TOYOTA DEALER, THEY COULD FIND NOTHING WRONG AFTER INSPECTING WITH A "SCAN TOOL" AND THE WIRING LOOKED GOOD. THEY SAID THAT IT WAS BECAUSE A PACK RAT HAD BEEN IN THE ENGINE AT THE TIME. (THAT'S A PRETTY LAME EXCUSE.) THEY SAID THEY COULD "CLEAN THE THROTTLE" AND "FLUSH THE FUEL LINE" WHICH I HAD THEM DO (COST $300.) BECAUSE I WAS SCARED TO DRIVE THE CAR UNTIL THEY DID SOMETHING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10295887December 15, 2009
STRUCTURE:FRAME AND MEMBERS
RUST ON THE STRUCTURAL AND SUSPENSION COMPONENTS IS EXCESSIVE. I HAVE HAD WELDING DONE TO REPAIR SUSPENSION BRACKETS. THE REAR TRANSFER CASE IS SO THIN THAT OIL IS LEAKING THROUGH RUST HOLES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10294572December 5, 2009
FUEL SYSTEM, GASOLINE
VEHICLE STALLS AND DIES ON FREEWAY ALMOST CAUSING WRECK. FIND OUT THERE IS NO FUEL IN TANK EVEN THOUGH FUEL GAUGE READS 1/2. TOYOTA SAYS TSB EL010-00 ADDRESSES KNOWN DEFECTIVE 1999 AND 2000 FUEL GAUGES AND ALSO ADDRESSES SOME GAUGES INACCURATELY READING EMPTY WHEN 4 GALLONS REMAIN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10293598November 25, 2009
STRUCTURE:FRAME AND MEMBERS
1999 TOYOTA 4RUNNER, FRAME RUST ALONG THE ENTIRE FRAME. BODY SHOP WOULD NOT TRY TO REPAIR DUE TO LIABILITY. I LIVE IN NJ WHERE THE SALT IS NOT AS BAD AS IN THE NORTHERN STATES. THE SAFETY ISSUE IS THE REAR END SEPARATING FROM THE FRAME AS THEIR IS RUST THROUGH WERE THE REAR SUSPENSION CONNECTS TO THE FRAME. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10286898October 9, 2009
STRUCTURE:FRAME AND MEMBERS
1999 TOYOTA 4-RUNNER- I NOTICED THE REAR END SWAYING WILDLY AT EVEN LOW SPEEDS. I NOTICES THAT THE REAR END HAD BECOME DETACHED FROM FRAME. I WENT TO A PROFESSIONAL WELDER WHO HAD PREVIOUSLY DONE SOME WORK FOR ME. HE SAID THAT THE FRAME COMPONENTS WERE SO BADLY DETERIORATED THAT NOTHING COULD BE DONE. I WENT TO STEET TOYOTA IN UTICA N.Y., AND THEY TOLD ME THAT MY VEHICLE WOULD COST OVER $15,000 TO REPAIR. THE FRAME AND COMPONENTS WERE INDEED DEFECTIVE, BUT I HAD NO RECOURSE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10269495May 20, 2009
FUEL SYSTEM, GASOLINE
WHILE DRIVING ON INTERSTATE DURING RUSH HOUR, IN THE PASSING LANE AT 70 MPH, THE VEHICLES ENGINE QUIT, LOST ALL POWER STEERING, BRAKES, ETC. VERY DANGEROUS FOR ME AND MY FAMILY. WAS ABLE TO DRIFT TO A TURN AROUND. BOTTOM LINE, VEHICLE HAD RUN OUT OF GAS, EVEN THOUGH FUEL GAUGE SHOWED A LITTLE OVER 1/2 TANK. THIS IS VERY DANGEROUS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10268238May 8, 2009
POWER TRAIN:MANUAL TRANSMISSION, SUSPENSION:REAR
SEVERAL SUSPENSION AND STRUCTURAL COMPONENTS OF MY 1999 4RUNNER ARE SHOWING EXCESSIVE RUST. THE WORST OF WHICH IS ON THE REAR AXLE AND DIFFERENTIAL HOUSING. I'VE RECENTLY HAD TO WELD A BROKEN STABILIZER BRACKET. THE DIFFERENTIAL HOUSING HAS RUSTED SO BAD THAT A HOLE HAS FORMED AND GEAR OIL IS LEAKING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10266722April 25, 2009
STEERING
THE TRAILING ARMS IN THE REAR HAVE BROKEN. FIRST THE RIGHT AND I HAD IT REPAIRED AND NOW THE LEFT AND IT CANNOT BE REPAIRED DUE TO THE METAL BEING SPONGY. IT IS ALSO CALLED THE SWAY BAR LINK. THE STEERING HAD BECOME ERRATIC AND I TOOK IT IN TO BE LOOKED AT AND RECEIVED THE BAD NEWS. TOYOTA HAS NO RESPONSE. THE 4RUNNER HAS THE SAME BODY AS THE TACOMA BUT THERE IS NOT RECALL ON THIS LEMON. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10264990April 11, 2009
FUEL SYSTEM, GASOLINE
DRIVING ON I-79 IN PASSING LANE AT 65 MPH, THE ENGINE QUIT, COMPLETE LOSS OF POWER STEERING AND BRAKES..RUSH HOUR. MOST DANGEROUS THAT HAS EVER HAPPENED TO ME. COASTED TO SIDE OF ROAD, TOWED TO GARAGE, ENGINE WILL NOT START, SHOWS A LITTLE OVER 1/2 TANK ON FUEL GAGE..ENDS UP, WAS OUT OF FUEL ! GAUGE GAVE FALSE READING. THE VEHICLE HAS ONLY 54,000 MILES ON IT. I DID FIND A TOYOTA TSB EL010-00 THAT ADDRESSES THIS EXACT PROBLEM, BUT I WAS NEVER NOTIFIED OF IT. MY VEHICLE WAS BOUGHT FROM A TOYOTA DEALER WITH MY NAME AS THE NEW OWNER ON RECORD. THIS IS THE MOST DANGEROUS THING TO HAPPEN, NO INDICATION OF LOW FUEL LEVEL, NO FUEL LOW WARNING LIGHT,,GAUGE WAS SHOWING A LITTLE OVER 1/2 TANK. THIS NEEDS TO BE ADDRESSED AS A RECALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10263245March 27, 2009
FUEL SYSTEM, GASOLINE
FUEL GAUGE BEGAN SHOWING INACCURATE READINGS. USUALLY SHOWED AT OR NEAR FULL REGARDLESS OF ACTUAL FUEL VOLUME IN TANK. AFTER A COUPLE WEEKS IT JUST STAYED AT THE FULL MARK. MORE RECENTLY, ABOUT THE BEGINNING OF MARCH, 2009, UPON STARTING THE VEHICLE THE GAUGE WOULD OCCASIONALLY DROP TO THE EMPTY MARK, AND THE LOW FUEL INDICATOR LIGHT WOULD FLASH. IT WOULD REMAIN THIS WAY UNTIL THE VEHICLE WAS TURNED OFF. UPON TURNING THE KEY BACK TO THE ON POSITION, OR RESTARTING THE VEHICLE, THE GAUGE WOULD RETURN TO THE FULL MARK AND REMAIN THERE. REPLACING THE FUEL SENDER AS STATED IN TSB EL010-00 HAS NOT CORRECTED THE PROBLEM. IMMEDIATELY AFTER REPLACING THE FUEL SENDER THE GAUGE READ ABOUT 3/4 FULL BUT THE TANK WAS NEARLY EMPTY. AFTER FILLING THE TANK THE GAUGE MOVED TO FULL BUT IT CONTINUES TO ACT AS IS DID BEFORE REPLACING THE SENDER, EVEN AFTER GOING THROUGH THE CALIBRATION PROCEDURE MULTIPLE TIMES. ACCORDING TO THE VEHICLE VIN, AS SHOWN IN THE TSB, REPLACING THE COMBINATION PLATE (CIRCUIT BOARD) IN THE INSTRUMENT CLUSTER IS NOT NEEDED. BUT THE FUEL GAUGE STILL ALWAYS READS FULL, OR EMPTY, AS IT DID BEFORE REPLACING THE FUEL SENDER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota 4Runner