Saturn Ion Complaints (2006)

1,235 consumer complaints on file.

#10432418October 21, 2011
STEERING
DRIVING DOWN THE FREEWAY THE CHIME SOUNDED AND THE "PWR STR" MESSAGE DISPLAYS IN THE MESSAGE CENTER. THE POWER STEERING NO LONGER WORKS. AFTER MUSCLING THE VEHICLE HOME I PARKED IT AND STARTED IT THE NEXT MORNING AND THE VEHICLE WAS BACK TO NORMAL. HAD AN IDENTICAL EXPERIENCE ON THE FREEWAY A WEEK LATER. THE DEALERSHIP DOESN'T BELIEVE ME BECAUSE IT'S BACK TO NORMAL WHEN I TAKE IT TO THEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10432173October 20, 2011
STEERING
AFTER BEING ON THE ROAD IN MODERATE CITY TRAFFIC ON A CLEAR DAY FOR APPROXIMATELY 5 MINUTES, I HEARD AN AUDIBLE ALERT THEN THE VISUAL ALERT "PWR STR" APPEARED ON THE DASHBOARD DISPLAY, AND I NO LONGER HAD POWER STEERING. I CONTINUED MY 35+ MILE DRIVE HOME, MAKING ONE STOP ON THE WAY. WHEN I RESTARTED THE CAR AFTER THAT STOP, THE POWER STEERING WAS ONCE AGAIN WORKING. THE PROBLEM DID NOT RECUR FOR SEVERAL DAYS, THEN HAPPENED AGAIN. FOR THE PAST 25 DAYS OR SO, THE PROBLEM HAPPENS EVERY TIME THE CAR IS RUNNING, SOMETIMES HAPPENING AFTER HAVING TRAVELED ONLY 100 FEET AND SOMETIMES NOT HAPPENING UNTIL WELL AFTER THAT. THIS IS A DEFINITE SAFETY CONCERN. IN THE EVENT THE STEERING FAILED WHILE A CORNER WAS BEING NEGOTIATED, THE OUTCOME COULD BE TRAGIC. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10430497October 17, 2011
STEERING, SERVICE BRAKES, HYDRAULIC
CAR WAS PARKED ON A SLIGHT INCLINE. HAND BRAKE WAS ON. TURNED ON IGNITION AND ENGINE STARTED. PUT RIGHT FOOT ON BRAKE AND RELEASED HAND BRAKE. PLACED CAR IN REVERSE AND BEGAN TO LIFT FOOT OFF BRAKE. CAR BEGAN TO ROLL BACKWARD, BUT WHEN I APPLIED PRESSURE TO THE FOOT BRAKE TO SLOW THE CAR I FOUND THAT I HAD NO POWER BRAKES AND NO POWER STEERING. IT TOOK A GREAT DEAL OF EFFORT TO STOP THE CAR FROM CONTINUING TO ROLL BACKWARDS. BY NOW THE ENGINE HAD STOPPED RUNNING AND SEVERAL ALERT LAMPS WERE LIT ON THE CONTROL PANEL. OVER SEVERAL DAYS BEFORE THIS INCIDENT, I HAD NOTICED INTERMITTENT AND MOMENTARY POWER STEERING FAILURES WHEN I WAS DRIVING AT SLOW SPEEDS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10430383October 16, 2011
STEERING
I WAS DRIVING AND GOING AROUND A CIRCLE AND ALL OF SUDDEN IT WAS HARD TO STEER,A CHIME AND POWER STEERING LIGHT WAS ON THE DASH,I PULLED OVER INTO A PARKING LOT. I TURNED ENGINE OFF.OPENED THE HOOD TO CHECK ON SERPENTINE BELT IF BROKEN, BUT THE BELT WAS GOOD. I STARTED THE ENGINE AND THE POWER STEERING WAS WORKING AGAIN,AS IF NOTHING HAPPENED.A WEEK LATER IT HAPPENED AGAIN,AS I WAS DRIVING STRAIGHT,I PULLED OVER TURNED ENGINE OFF,RESTART AGAIN AND THE POWER STEERING WORKING OK,I CALLED THE GM DEALER SERVICE DEPT.AND THEY SAID THERE IS NO RECALL OR T.S.B. FROM GM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10430235October 14, 2011
STEERING, ELECTRICAL SYSTEM
FOR THE PAST 5 MONTHS, THE SATURN ION 3 POWER STEERING WILL INTERMITENTLY GO OUT. WHEN I FIRST START THE CAR THE POWER STEERING WORKS FINE, AND THEN AT ANY RANDOM TIME THE CAR MAKES A DING,DING NOISE AND THEN THERE IS NO POWER STEERING. IF THE CAR IS SHUT OFF AND TURNED BACK ON THE POWER STEERING IS FINE. THEN A FEW MILES DOWN THE ROAD IT TURNS OFF AGAIN, ALMOST EVERY DAY. THIS MAKES IT VERY DIFFICULT TO TURN CORNERS. THE NEXT PROBLEM IS IF IT IS DAMP OR COLD (BELOW 60) IN THE MORNING AT 8AM THE CAR WILL NOT TURN OVER OR START, UNTIL THE SUN COMES OUT AND WARMS UP THE CAR, BY NOON THE CAR STARTS JUST FINE. I CAN GET IT STARTED IF I PLACE TWO WARM BLANKETS ON THE BATTERY AND MOTOR AND WAIT A FEW MINUTES, THEN THE CAR WILL START. THE DRIVERS SIDE WINDOWS HAVE ALSO STOPPED WORKING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10430243October 14, 2011
FUEL SYSTEM, GASOLINE
WAS MAKING A LEFT TURN CROSS TRAFFIC. WAITED FOR A BREAK IN CARS TO GO. I HIT THE GAS AND IT MOVED THEN THE ENGINE DIED IN CROSS TRAFFIC. MY WIFE ALMOST GOT HIT FROM ONCOMING TRAFFIC. THE MIL LIGHT CAME ON. I AM A MECHANIC FOR THE STATE OF IDAHO. I COULD SEE FUEL DRIPPING. I REMOVE FUEL TANK TO FIND LEAK. FOUND TO BE A CRACKED FUEL PUMP. THIS IS GOING TO KILL SOMEONE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10430260October 14, 2011
STEERING
WHILE DRIVING SOUTHBOUND ON HIGHWAY 99, THE POWER STEERING LIGHT CAME ON AND STEERING BECAME TIGHT AND HARD. AFTER FURTHER RESEARCH SATURN DOES KNOW ABOUT THIS PROBLEM AND HAS ONLY ISSUED A SPECIAL POLICY AND NOT A RECALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10429302October 10, 2011
STEERING, STEERING:ELECTRIC POWER ASSIST SYSTEM
THIS HAPPENED ON MY DAUGHTERS 2006 SATURN ION WITH LESS THAN 25,000 MILES. SHE HAD BEEN MAKING A RIGHT HAND TURN IN A DOUBLE TURN LANE OFF AN ANGULARED INTERSECTION (ABOUT 60 DEGREES). SHE WAS IN THE OUTSIDE LANE WITH A SEMI-TRUCK MAKING THE TURN ALONG SIDE, LEFT OF HER. SHE WAS GOING APPROX. 25 MPH. WHEN SHE LOST THE POWER STEERING AND ALMOST VEERED UNDER THE TRAILER. THANK GOD SHE DIDN'T GO UNDER UNDER IT OR SHE PROBABLY WOULD HAVE BEEN KILLED. THE EPS HAS FAILED 4 TIMES SINCE. I SEE THAT GM HAS ACKNOWLEDGED THIS PROBLEM WITH THEIR OTHER MODELS AND POSTED RECALLS FOR THEM, BUT NOT FOR SATURN. 846 SATURN COMPLAINTS TO ODI AND 3,489 REPORTS TO GM AND NO RECALLS!!! HOW MANY PEOPLE HAVE TO REPORT A CRASH OR SADLY ENOUGH, HAVE TO DIE, BEFORE SOMETHING IS DONE. I'VE BEEN OUT OF WORK FOR SOMETIME AND CAN NOT AFFORD THE REPORTED $1,000 REPAIR AT A DEALER THAT ADMITS THERE IS A PROBLEM. NHTSA AND OR GM, STAND UP FOR WHAT IS RIGHT AND DO SOMETHING. SINCE WHEN IS THE LOSS OF STEERING NOT A MAJOR ISSUE!!! *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10429096October 7, 2011
SUSPENSION
THE FRONT BOTH DRIVER AND PASSENGER SIDES MAKE NOISE WHEN GOING OVER BUMPS OR UNEVEN SURFACES. THUMPING, RATTLING FROM FRONT OF CAR WITH SUSPENSION. THE CONTROL ARMS AND SHIFTS ARE WORN AND NEED TO BE COMPLETELY REPLACED WITH NEW BUSHINGS AND NEW BALL JOINTS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10428916October 6, 2011
STEERING, ELECTRICAL SYSTEM
I AM BEGINNING TO BELIEVE THAT THE ISSUE WITH THE SATURN ION IS AN ELECTRICAL OR COMPUTER BASED. I PUT IN A COMPLAINT EARLIER ABOUT HOW THE CAR SHUTS OFF IN THE MIDDLE OF MAKING TURNS. THIS MORNING AS I WENT TO WORK I WAS MET WITH THE AUTOMATIC STEERING NOT WORKING. AT FIRST I THOUGHT THAT MAYBE THE EMERGENCY BREAK WAS STILL UP. I CHECKED MY STEERING FLUID AND IT IS FULL. I TURNED THE CAR OFF AND THEN ON AGAIN AND TRIED TO MOVE THE WHEEL. NO DICE. I DROVE THE CAR TO WORK FIGHTING WITH THE STEERING ALL THE WAY THERE. WHEN I GOT TO WORK I CALLED FOR ASSISTANCE TO GET MY CAR TO A SHOP. AFTER MAKING THE ARRANGEMENTS, I WENT TO TRY TO STRAIGHTEN UP THE VEHICLE SOMEWHAT SO THAT OTHERS COULD PARK BESIDE ME AND SO THE TOWING COMPANY COULD GET IT OUT. TO MY AMAZEMENT THE CAR STEERING WORKED FINE. THERE ARE SEVERAL COMPLAINTS ON THE WEB ABOUT THIS ISSUE, THE KEY GETTING STUCK IN THE IGNITION, THE KEY BEING REMOVED FROM THE IGNITION AND THE CAR ENGINE CONTINUING TO RUN ANYWAY, AND THE SHUTTING OFF WHILE GOING OVER TRACKS AND MAKING TURNS WITH THE SATURN ION 2004-2007. PLEASE GET GMC TO FIX THESE ISSUES. WHAT MAKES ME REALLY ANGRY IS THAT THE COMPANY KNOWS, THEY SIMPLY ARE AVOIDING FIXING THE PROBLEMS AND ONLY FOCUS ON THE FUEL PUMP PROBLEM. SOMEBODY IS GOING TO GET KILLED SOONER OR LATER BTW THE SHUTTING OFF ISSUE OR THE STEERING WHEEL ISSUES. I HOPE YOU GUYS LOOK INTO THESE ISSUES AND DEMAND THAT GMC FIXES THEM BEFORE THEN. THANKS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10428449October 4, 2011
FUEL SYSTEM, GASOLINE, FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
2006 ION. STRONG GAS SMELL DEVELOPED OVER A WEEK IN SEPT 2011. AN INDEPENDENT TECHNICIAN FOUND GAS LEAKING FROM TOP OF TANK. RESEARCH LEAD ME TO NHTSA CAMPAIGN ID NUMBER: 09V419000. GM PERFORMED THE RECALL ON ONLY 53K CARS IN AZ AND NV IN OCT 2009. SEEMS THE FUEL PUMP MODULE CONNECTIONS ARE MADE OF PLASTIC AND CRACK WITH HEAT AND ROAD VIBRATION. HOWEVER, A CALL TO SATURN REVEALED THEY ARE HIDING BEHIND A VIN SPECIFIC RECALL AND THAT THE OTHER THOUSANDS OF IONS WITH THIS SERIOUS SAFETY-DEFECT ARE ONLY COVERED BY GM FOR 10 YR/120K MILE "SPECIAL COVERAGE WARRANTY" EXTENDED TO THIS DEFECTIVE PART. HAD SATURN/GM INFORMED ME MY CAR MIGHT BURST INTO FLAMES BACK IN FEB 2010, WHEN THEY WERE TO NOTIFY THE 53K OWNERS IN AZ AND NV, I WOULD HAVE HAD THIS REPAIR DONE ASAP AS I WOULD STILL BE UNDER THEIR "SPECIAL COVERAGE" LIMITATION. I AM ANGERED AND OUTRAGED THAT GM SEEMS TO TAKE THE POSITION OF "LET'S WAIT UNTIL THE CAR BECOMES A DEATH-TRAP" BEFORE WE TELL PEOPLE THEY MIGHT BE IN DANGER AND REPLACE THE DEFECTIVE PARTS. WITH NO NOTIFICATION, I CONTINUED TO DRIVE MY ION. NOW THAT THE CAR ACTUALLY HAS BECAME LIFE-THREATENING, I AM "NOT COVERED" BY GM'S SPECIAL COVERAGE. MY ION DOES NOT QUALIFY BECAUSE I AM OVER THIS ARTIFICIAL LIMIT IF 120K MILES. ALL VEHICLES WITH THIS DEFECTIVE PART SHOULD HAVE BEEN NOTIFIED. THIS IS CRIMINALLY NEGLIGENT. BET YOU MY MILEAGE WAS BELOW THIS ARTIFICIAL LIMIT IN FEBRUARY 2010. BECAUSE THE PROBLEM DIDN'T SHOW UP UNTIL AFTER 200+ DAYS OF OVER 90 DEGREE DAYS IN EAST TEXAS - I HAVE TO PAY $600 TO REPAIR THEIR OBVIOUS DEFECT. THE REPAIR COSTS ARE UNFAIR, BUT THE SAFETY ISSUE SCREAMS FOR JUSTICE. I GUESS SOMEONE'S FAMILY WILL HAVE TO DIE IN A TRAGIC FIREBALL BEFORE SOMEONE TAKES GM TO TASK FOR THIS SERIOUSLY DANGEROUS FUEL SYSTEM DEFECT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10428707October 4, 2011
STEERING
TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE STEERING WHEEL WOULD INTERMITTENTLY SEIZE WHILE DRIVING 30 MPH AND ABOVE. WHENEVER THE FAILURE RECURRED, THE CONTACT WOULD STOP THE VEHICLE AND SHUT IT OFF. UPON RESTART, THE VEHICLE WOULD OPERATE AS NORMAL. A POWER STEERING SERVICE LIGHT WOULD ALSO ILLUMINATE ON THE INSTRUMENT PANEL DURING THE FAILURE AND A WARNING BELL WOULD SOUND. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, BUT THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 104,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10428036September 30, 2011
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2006 SATURN ION. WHILE PARKED, THE CONTACT NOTICED A FUEL ODOR EMITTING IN THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THERE WAS A LEAK FROM THE FUEL PUMP MONITOR THROUGH THE FUEL LINE AND LEADING TO THE FUEL TANK. THE MECHANIC STATED THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 09V419000 (FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP) THAT COULD HAVE BEEN RELATED TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 45,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10427788September 28, 2011
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
ON 9/27/2011 I WAS UNABLE TO TURN THE KEY TO THE OFF IN MY IGNITION. THE CAR STAYED ON AND I CANNOT REMOVE THE KEY FROM THE ON POSITION. THERE ARE THOUSANDS OF COMPLAINTS ONLINE REGARDING THE VERY SAME PROBLEM WITH THE SATURN ION. THIS IS A SAFETY PROBLEM AND IS VERY DANGEROUS. THIS VEHICLE AND/ OR PART MUST BE RECALLED. *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10427821September 28, 2011
STEERING, ELECTRICAL SYSTEM
ON SUNDAY, SEPTEMBER 25TH, 2011, I WAS DRIVING ON A FAMILIAR ROAD IN TOWN WHEN ALL OF THE WARNING LIGHTS ON MY VEHICLE SUDDENLY ILLUMINATED AND BEGAN BLINKING. THE SPEEDOMETER, FUEL GAGE, TEMPERATURE GAGE, AND RPM INDICATOR ALL WENT DOWN TO ZERO AND THE MESSAGE CENTER BEGAN SAYING "TRAC OFF" AND "PWR STR." AS THIS HAPPENED, MY POWER STEERING WENT OUT. I PULLED OVER AND TURNED MY CAR OFF. MY CAR WOULD NOT TURN BACK ON. AFTER ABOUT ONE MINUTE, I WAS ABLE TO START MY CAR AGAIN AND RESUME DRIVING AS NORMAL. THIS HAS HAPPENED ON FOUR OTHER OCCASIONS SINCE THE FIRST TIME, THREE DAYS AGO. THE LAST TIME IT HAPPENED I WAS GOING AROUND A CURVE AND I ALMOST WENT INTO THE DITCH. IN ADDITION, IT IS ALSO IMPORTANT TO NOTE THAT AT 40,000 MILES, THE VEHICLE BEGAN HAVING THE SAME ISSUE (MESSAGE CENTER OCCASIONALLY FLASHING "TRAC OFF" AND "PWR STR", AND THE ABS AND EMERGENCY BREAK LIGHTS GOING ON). THE DEALER FOUND THAT THE STEERING COLUMN WAS SHORTING OUT AND HAD TO REPLACE THE STEERING COLUMN IN THE VEHICLE. THIS LEADS ME TO BELIEVE THAT THIS IS AN ELECTRICAL PROBLEM... *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10427669September 27, 2011
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT WHILE DRIVING FUEL FUMES WERE EMITTED INTO THE VEHICLE. THE CONTACT ALSO MENTIONED THAT HE COULD SEE FUEL LEAKING UNDERNEATH THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURE WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFERED ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 09V419000 (COMPONENT: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 65,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10427221September 26, 2011
STEERING, AIR BAGS
WHILE DRIVING MY 2006 SATURN ION INDICATOR CHIMED AND PWR STR LIGHT DISPLAYED. I LOST STEERING CONTROL AND ALMOST WRECKED. I PULLED OFF THE ROAD KILLED THE CAR UPON RESTARTING ENGINE EVERYTHING WAS FINE. FIVE MINUTES INTO MY TRIP PROBLEM HAPPENED AGAIN. ALSO, SOMETIMES WHEN I DRIVE THE CAR THE PASSENGER AIRBAG IS ON AT OTHER TIMES IT TURNS OFF ON IT OWN. BOTH ARE THESE ARE VERY DANGEROUS ESPECIALLY FOR ME BEING A SINGLE MOTHER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10426948September 23, 2011
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE KEY WOULD NOT TURN IN THE IGNITION TO SHUT OFF THE VEHICLE AFTER SEVERAL ATTEMPTS. THE VEHICLE WAS IMMEDIATELY TAKEN TO AN AUTHORIZED DEALER WHERE THE BATTERY WAS DISCONNECTED AND A DIAGNOSTIC TEST WAS PERFORMED. A PART WAS ORDERED AND THE VEHICLE WOULD BE REPAIRED UPON AVAILABILITY. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 35,256. UPDATED 10/27/11*BF UPDATED 3/30/12 *CN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10426581September 21, 2011
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE KEY COULD NOT BE REMOVED FROM THE IGNITION. THE VEHICLE WAS LEFT PARKED AND RUNNING UNTIL THE BATTERY DIED. THE VEHICLE WAS LATER TOWED TO THE DEALER AND THEY ADVISED HER THAT THE HOUSING IGNITION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED APPROXIMATLEY TEN MONTHS LATER. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 43,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10426522September 20, 2011
FUEL SYSTEM, GASOLINE
BEGAN EXPERIENCING A STRONG ODOR OF RAW GAS AND FUMES IN AUGUST OF 2011. I SCHEDULED AN APPOINTMENT WITH MY LOCAL REPAIR FACILITY TO HAVE THE PROBLEM EVALUATED. UPON RAISING THE VEHICLE AND DOING A VISUAL INSPECTION OF THE FUEL SYSTEM, RUN MARKS FROM GASOLINE COULD BE SEEN COMING DOWN FROM THE TOP OF THE TANK. AN EVAP TEST WAS PERFORMED AS WELL AND SMOKE COULD BE SEEN RISING OUT OF THE TANK AREA. THE TANK IS PLASTIC AND NO VISUAL CRACKS COULD BE SEEN. MY TECHNICIAN FELT THIS WAS UNUSUAL AT SUCH LOW MILEAGE. AFTER FURTHER DIGGING THE TECHNICIAN DISCOVERED A RECALL ON THE FUEL PUMP MODULE FOR MY YEAR, MAKE AND MODEL. I WAS ADVISED TO RETURN TO THE DEALER TO SEE IF IT WAS COVERED WHICH I DID. I FOUND OUT THAT MY VEHICLE DID NOT FALL UNDER THE FACTORY RECALL. I RETURNED TO MY REGULAR MECHANIC TO HAVE THE PROBLEM RESOLVED. ONCE THE TANK WAS LOWERED ANOTHER EVAP TEST WAS PERFORMED. THE TEST REVEALED THAT THE FUEL SUPPLY LINES COMING OFF THE FUEL PUMP SENDING UNIT WERE LEAKING. THIS WAS WERE THE TWO HOSES WERE PRESS FITTED TO THE SENDING UNIT FROM THE FACTORY. THE ONLY MEANS OF CORRECTING WAS TO REPLACE THE ENTIRE FUEL PUMP MODULE. I HAD THE REPAIR COMPLETED USING AN OE FUEL PUMP MODULE. I FEEL AFTER READING THE PARAMETERS SET FORTH UNDER THIS RECALL THAT MY VEHICLE SHOULD HAVE BEEN REPAIRED UNDER THIS RECALL. I URGE NHTSA TO ONCE AGAIN EVALUATE THIS DEFECT. IN MY OPINION THESE DEFECTIVE PARTS WERE USED ON MORE VEHICLES THAN INITIALLY STATED. THIS IS A SEVERE SAFETY ISSUE AND HAS THE POTENTIAL FOR SERIOUS INJURY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Saturn Ion