Saturn Ion Complaints (2005)

573 consumer complaints on file.

#10377428January 13, 2011
ELECTRICAL SYSTEM
VEHICLE WILL START INTERMITTENTLY ON COLD AND/OR DAMP MORNINGS. ONLINE RESEARCH HAS SHOWN THE CAUSE TO BE A DEFECTIVE BODY CONTROL MODULE (BCM; A COMPONENT OF THE FACTORY-INSTALLED ANTI-THEFT SYSTEM), CONFIRMED BY AN EXPERIENCED AUTOMOTIVE TECHNICIAN. SAID TECHNICIAN HAS STATED TO COMPLAINANT THAT VEHICLE MAY BE SUBJECT TO RECALL DUE TO DEFECTIVE BCM; HOWEVER, ACCORDING TO NHTSA, THIS VEHICLE IS UNDER RECALL ONLY FOR EXTERIOR LIGHTING ISSUES (NHTSA CAMPAIGN ID #09E012000). COMPLAINANT REQUESTS DETAILED RECALL INFORMATION FOR THIS SPECIFIC PART (BCM), FOR THIS SPECIFIC MAKE AND MODEL OF VEHICLE (LISTED ABOVE). IF NO SUCH RECALL EXISTS, COMPLAINANT REQUESTS A RECALL BE INITIATED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10374779January 5, 2011
VISIBILITY
DRIVERS SIDE WINDSHIELD WIPER HAS BROKEN OFF AT THE BASE. NO SNOW IN AREA THAT WOULD OVERLOAD. I HAVE HEARD OTHER SIMILAR PROBLEMS WITH THIS MODEL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10374787January 5, 2011
AIR BAGS:FRONTAL, SEAT BELTS
MY GIRLFRIEND AND I WERE IN AN AUTOMILE ACCIDENT BY HITTING A DEER HEAD ON THEN LOSING CONTROL OF THE VEHICLE AND HITTING AND EMBANKMENT HEAD ON. WE HIT THE EMBANKMENT SO HARD THAT THE 2005 SATURN ION BOUNCED BACK OFF AND ENDED UP IN THE MIDDLE OF THE ROAD. THE AIRBAGS NEVER DEPLOYED AND THE SEAT BELT NEVER CAUGHT RESULTING MY GIRLFRIEND TO BE INJURED BY THE STEERING WHEEL WITH LACERATIONS TO HER CHIN AND HER TEETH WENT THROUGH THE BACK OF HER LIP AND ALSO NECK AND BACK INJURIES FROM THE HARD IMPACT. THE INSURANCE COMPANY TOTALED THE CAR BECAUSE OF THE FRONT FRAME AND UNDERNEATH DAMAGE IT CAUSE. SHE HIT SO HARD THAT THE WHOLE FRONT END WAS PUSHED INTO THE MOTOR AND THE MOTOR WAS PUSHED BACK INTO THE FIREWALL. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10372672December 28, 2010
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT WHEN TRYING TO START THE VEHICLE, THE LOCK OUT WARNING LIGHT WOULD ILLUMINATE AND THE VEHICLE FAILED TO START. THE CONTACT STATED THAT THE FAILURE WOULD ONLY OCCUR ON AN INTERMITTENT BASIS WHEN THE TEMPERATURE WAS 35 DEGREES AND BELOW. THE VEHICLE WAS INSPECTED BY A DEALER WHO INFORMED THE CONTACT THAT THEY WOULD NEED TO REPLACE THE STARTER. THE STARTER FOR THE VEHICLE WAS REPLACED YET THE FAILURE PERSISTED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 20,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10371229December 19, 2010
EXTERIOR LIGHTING
2005 SATURN ION TURN SIGNAL LIGHTS STOPPED BLINKING, BUT LAMPS NOT BURNED OUT. GM DEALER RECOMMENDS REPLACEMENT OF THE BODY CONTROL MODULE AND EXTENSIVE AND COSTLY REPAIR! CAN'T FIND PARTS. CANNOT PROPERLY OPERATE VEHICLE WITH EXPIRED INSPECTION STICKER REQUIRED IN LA. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10370308December 12, 2010
STEERING
2005 SATURN ION POWER STEERING GOES OUT RANDOMLY WHILE DRIVING AT ANY SPEED. VERY DANGEROUS AND POTENTIALLY DEADLY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10369526December 7, 2010
ELECTRICAL SYSTEM, LATCHES/LOCKS/LINKAGES
PASSLOCK MALFUNCTION DUE TO FAULTY IGNITION SWITCH CAUSES NO CRANK AND ACTIVATION OF 10 MINUTE RELEARN SEQUENCE. ONLY HAPPENS WHEN TEMPERATURES ARE BELOW 40 DEGREES. HAS ALWAYS HAPPENED EVER SINCE I BOUGHT THE CAR JANUARY 3RD, 2009. FREQUENCY OF OCCURRENCE HAS INCREASED, AND I'M SCARED THAT IT WILL CAUSE A CRASH IF I HAPPEN TO STALL IN TRAFFIC. THE REMEDY TO THIS SITUATION HAS BEEN DISCUSSED IN NUMEROUS TECHNICAL FORUMS ON THE INTERNET - ALL OF WHICH POINT TO REPLACEMENT OF THE IGNITION SWITCH. THE CAUSE IS THOUGHT TO BE EXCESSIVE GREASE APPLIED TO THE INTERNALS OF THE SWITCH. I THINK GM SHOULD RECALL THE AFFECTED UNITS EXHIBITING THIS PROBLEM AND PROVIDE NO COST REPLACEMENT OF THE IGNITION SWITCH. THIS IS NOT A NEW PROBLEM. THOUSANDS OF OWNERS HAVE BEEN EXPERIENCING THIS AGGRAVATING AND SOMETIMES DANGEROUS TECHNICAL FAULT. GM IS IGNORING THE ISSUE AND OFFERING SATURN OWNERS ABSOLUTELY NO ASSISTANCE TO CORRECT THIS SERIOUS PROBLEM. IF GM DOES NOT ACT, THE LAW OF AVERAGES SAYS THAT EVENTUALLY SOMEONE MAY BE INJURED OR KILLED AS A RESULT OF THIS MALFUNCTION. PLEASE HELP US. THIS ISN'T FAIR AT ALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10368405November 30, 2010
STEERING
TL*THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT THE POWER STEERING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL INTERMITTENTLY. THE VEHICLE WAS INSPECTED BY THE DEALER WHO STATED THAT THE STEERING COLUMN NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 75,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10366404November 16, 2010
ELECTRICAL SYSTEM:IGNITION
ON MULTIPLE OCCASIONS, I COULD NOT RELEASE THE CAR KEY FROM THE IGNITION. I COULD TURN OFF THE ENGINE, BUT THE KEY WOULD NOT DISENGAGE FROM THE ACC MODE. RELEASING THE KEY WOULD TAKE ANYWHERE FROM A FEW SECONDS TO A FEW MINUTES. THESE WERE INCIDENTS THAT COULD NOT BE TIED TO ANY SPECIFIC ACTION FROM THE DRIVER AND THAT WOULD OCCUR RANDOMLY. EVERY TIME I DROVE, I WAS AFRAID THE KEY WOULD GET STUCK AND THAT THIS WOULD FINALLY BE THE TIME THAT I COULD NOT GET IT OUT. THIS IS A SAFETY CONCERN WHEN THERE ARE SEVERE WEATHER CONDITIONS AND THE BATTERY IS IN DANGER OF DYING. THE GM DEALERSHIP FOUND WHAT THEY THOUGHT WAS THE PROBLEM AND THE SOLUTION WAS TO COMPLETELY REPLACE A RANGE OF PARTS. ANOTHER MECHANIC FOUND A DIFFERENT PROBLEM (A MALFUNCTIONING CYLINDER OF SORTS) AND REPLACED IT AND FOR THE FIRST TIME IN YEARS, I CAN DRIVE SAFELY AND WITH THE PEACE OF MIND KNOWING THAT THE KEY WILL NO LONGER GET STUCK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10366306November 15, 2010
ELECTRICAL SYSTEM
VEHICLE DID NOT CRANK OR START WHEN KEY TURNED. PASSLOCK CODE BLINKED. CHECK ENGINE LIGHT ON. KNOWN NHTSA ITEM NUMBER : 10007431 NO CRANK, NO START WHEN AMBIENT TEMPERATURES IS COLD - DIAGNOSTIC TROUBLE CODES (DTCS) B2960 AND OR B3033 ARE SET.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10365407November 11, 2010
ENGINE AND ENGINE COOLING:ENGINE
THE KEY STICKS IN THE IGNITION WHENEVER I TRY TO TURN THE CAR OFF. IT TAKES AWHILE BEFORE I AM ABLE TO GET IT OUT, CAUSING THE BATTERY TO DRAIN. I HAVE HAD TO REPLACE MY BATTERY ALREADY. THIS IS A MAJOR ISSUE THAT AFTER DOING SOME RESEARCH A VERY COMMON ISSUE FOR ION OWNERS. WITH IT BEING SO COMMON I DON'T UNDERSTAND WHY A RECALL HAS NOT BEEN DONE. I COULD HAVE BEEN STRANDED SOMEWHERE BECAUSE OF THIS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10365124November 9, 2010
STEERING
POWER STEERING MESSAGE COMES UP ON MY 2005 SATURN ION 3-- I WAS DRIVING AND IT ALL OF A SUDDEN BECAME VERY HARD TO TURN THE WHEEL LEFT OR RIGHT-- I HAVE REPLACED THE POWER STEERING MOTOR AND IT STILL DOESN'T WORK AND NOW THEY TELL ME I MAY HAVE TO REPLACE THE WHOLE POWER STEERING COLUMN- GM EXTENDED THE WARRANTY TO 10 YRS OR 100,000 MILES WHICHEVER OCCURS FIRST -WELL I HAVE 5 YEARS WITH MY COMPANY AND I BOUGHT IT BRAND NEW AND I HAVE OBVIOUSLY GONE HIGHER THAN THE 100,000 MILES AND NOW GM WILL NOT COVER THE EXPENSES.. THERE NEEDS TO BE A RECALL FOR THIS DEFECTIVE POWERSTEERING ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10364097November 4, 2010
STEERING
WHILE DRIVING MY 2005 SATURN ION THE POWER STEERING WENT OUT. AFTER I STOPPED AND CHECKED THINGS UNDER THE HOOD I RESTARTED THE CAR THEN THE POWER STEERING WAS WORKING AGAIN. A FEW MINUTES LATER THE POWER STEERING WENT OUT AGAIN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10363942November 3, 2010
STEERING
2005 SATURN ION 2 COUPE, POWER STEERING GOES OUT ACCOMPANIED WITH A CHIME AND A PWR STR WARNING ON DASH. RESETS AFTER CAR IS TURNED OFF AND RESTARTED. PROBLEM RECURS SHORTLY AFTER RESET. DTC CODE C0475 .THERE IS A RECALL ON CHEVY COBALT FOR THIS SAME PROBLEM BUT NOT ON THIS CAR, FROM WHAT I UNDERSTAND THEY ARE ACCENTUALLY THE SAME CAR. PART # ON THE POWER STEERING MOTOR IS 995-10800 WHICH IS THE PART # FOR A COBALT POWER STEERING MOTOR. GM SAYS THERE IS SPECIAL COVERAGE ON THIS ISSUE BUT ONLY IF IT FAILS. NO RECALL ? I WILL BE INSTALLING A NEW MOTOR PART # 19257875 TO FIX THIS PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10363779November 2, 2010
ELECTRICAL SYSTEM
SATURN ION 2005 MODEL DOES NOT RELEASE KEY FROM IGNITION AFTER YOU TURN OFF THE CAR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10361704October 22, 2010
ELECTRICAL SYSTEM:IGNITION
TL*THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT WHEN SHE SHUT THE VEHICLE OFF, SHE WAS UNABLE TO REMOVE THE KEY FROM THE IGNITION. THE FAILURE OCCURRED EVERY TIME SHE DROVE THE VEHICLE. SHE HAD TO WAIT FIFTEEN MINUTES BEFORE SHE WAS ABLE TO REMOVE THE KEY FROM THE IGNITION. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT SHE HAD TO HAVE THE VEHICLE REPAIRED BY THE DEALER AT HER EXPENSE. THE CURRENT MILEAGE WAS APPROXIMATELY 97,000. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10357296September 24, 2010
STEERING
I HAVE A 2005 SATURN ION WHICH IS NOW OVER 100,00K MILES. THE POWER STEERING SUDDENLY WENT OUT WITH NO WARNING SIGNALS ON DASHBOARD. THERE IS NO FLUID RESERVOIR TO PUT THE FLUID AND THE CAR IS NOT UNDER WARRANTY BECAUSE OF MILEAGE. I TRIED TURNING THE CAR OFF AND ON AGAIN AND STILL NO LUCK. AFTER READING UP ON THE SATURN ISSUE, I LEARNED THAT THERE ARE MANY OTHERS WITH DIFFERENT MAKES AND YEAR OF THE SAME MODEL HAVING THE SAME ISSUES. I HAVE NO MONEY TO REPAIR THIS VEHICLE AND WOULD LIKE TO KNOW IF SATURN (GM) IS GOING TO DO A RECALL ON THIS ISSUE. IT COST OVER $900.00 TO FIX THIS ISSUE. I HAVE TRIED CONTACTING SATURN DEALERS BUT OF COURSE THE COMPANY HAS BEEN SOLD. I HAVE CONTACTED A GM DEALERS REPAIR SHOP AND WAS TOLD THAT THEY JUST TRY TO REPAIR THE ISSUE THEY ARE NOT ABLE TO HELP WITH WARRANTY ISSUES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10354821September 10, 2010
STEERING
NO FAILURE YET. ELECTRIC POWER STEERING ON MY 2005 SATURN ION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10354355September 7, 2010
STEERING
I WAS TURNING INTO A PARKING LOT 7/5/2010, IN A 2005 SATURN ION, WHEN THE POWER STEERING LIGHT CAME ON, AND POWER STEERING STOPPED WORKING. NOW, IT HAPPENS ALMOST CONSTANTLY, THE POWER STEERING KEEPS GOING OUT, IT HAPPENED 10 TIMES JUST TODAY 7/7/2010. EVERY TIME, I HAVE PULLED OVER SHUT THE CAR OFF AND WAITED A FEW MINUTES, BEFORE RESTARTING CAR AND CONTINUING, JUST AS THE TSB FROM GM ADVISES. THE CAR ONLY HAS 50,000 MILES, AND YET THE POWER STEERING IS OUT ON IT. GM HAS ISSUED A RECALL FOR CHEVROLET COBALTS, PONTIAC G5, ETC, FOR THE ELECTRIC POWER STEERING, YET HAVE NOT FOR SATURN IONS, EVEN THOUGH THEY ARE NEARLY THE SAME VEHICLE, AND HAVE THE SAME PARTS AND PROBLEMS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10352857August 30, 2010
ELECTRICAL SYSTEM
TL*THE CONTACT OWNS 2005 SATURN ION. THE CONTACT STATED THAT IN COLD WEATHER THE VEHICLE WOULD NOT START. THE CONTACT HAD TO WAIT 15 MINUTES BEFORE THE VEHICLE WOULD START. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHO COULD NOT FIND A PROBLEM WITH THE VEHICLE AFTER A DIAGNOSTIC TEST. THE DEALER SUGGESTED REPLACING THE STARTER AND THE CONTACT AGREED WITH THE REPAIR. AFTER THE VEHICLE WAS REPAIRED THE VEHICLE CONTINUED TO HAVE AN ISSUE STARTING IN COLD WEATHER. THE CONTACT STATED THAT THE MANUFACTURER SHOULD ISSUE A RECALL. THE FAILURE MILEAGE WAS 125,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Saturn Ion