Ram 5500 Service Bulletins (2015)

331 manufacturer communications on file.

• August 6, 2015•Document ID: 10149006

  Service Bulletin/Repair Instructions
  ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY

  Mfr Comm. #:

  05191925A

  Date Added:

  November 26, 2018

  Manufacturer:

  RAM

  Summary

  Radiator If vehicle comes in for transmission fluid leaking from trans-oil cooler fittings on the radiator, please check the following before replacing the radiator/cooler:~ 1. Remove both of the transmission lines from the cooler?s top/bottom flared fittings on the radiator. ~ 2. Loosen the hex nut on the top flared fitting on the radiator tank.~ 3. Torque the top flared fitting to 235 +/- 15 Lb-In.~ 4. Torque hex nut to 100 +/- 10 Lb-In.~ 5. Repeat for bottom flared fitting.~ 6. Reinstall transmission line per normal installation procedures and ensure correct fluid level.~ ~ If vehicle is in need of a new radiator for another reason, check the new radiator for correct torque on the trans-oil cooler fitting per steps 2-5 above.~ ~ If radiator has a yellow mark by the trans-oil cooler fittings the torque does not have to be checked.

  Associated Products (49)

  2019 Ram 15002018 Ram 15002018 Ram 25002018 Ram 35002018 Ram 45002018 Ram 55002018 Ram Promaster City2017 Ram 15002017 Ram 25002017 Ram 35002017 Ram 45002017 Ram 55002017 Ram Promaster City2016 Ram 15002016 Ram 25002016 Ram 35002016 Ram 45002016 Ram 55002016 Ram ProMaster 35002016 Ram Promaster City+ 29 more
  Associated Documents

  • DownloadMC-10149006-0001.pdf↗
• August 5, 2015•Document ID: 10149005

  Service Bulletin/Repair Instructions
  STEERING; STEERING:ELECTRIC POWER ASSIST SYSTEM

  Mfr Comm. #:

  05154400A

  Date Added:

  November 26, 2018

  Manufacturer:

  RAM

  Summary

  Pump - Power Steering Hydraulic NOTE: This Tech Tip is for gasoline engine JK vehicles only, manufactured before August 26, 2015. If the power steering pump is being replaced because the power steering fluid flow or pressure readings are below specification, the power steering fluid reservoir and cap assembly should also be replaced. Power steering reservoir and cap assembly 52126151AG or later should be used.

  Associated Products (49)

  2019 Ram 15002018 Ram 15002018 Ram 25002018 Ram 35002018 Ram 45002018 Ram 55002018 Ram Promaster City2017 Ram 15002017 Ram 25002017 Ram 35002017 Ram 45002017 Ram 55002017 Ram Promaster City2016 Ram 15002016 Ram 25002016 Ram 35002016 Ram 45002016 Ram 55002016 Ram ProMaster 35002016 Ram Promaster City+ 29 more
  Associated Documents

  • DownloadMC-10149005-0001.pdf↗
• August 4, 2015•Document ID: 10149004

  Service Bulletin/Repair Instructions
  ENGINE; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)

  Mfr Comm. #:

  05149141A

  Date Added:

  November 26, 2018

  Manufacturer:

  RAM

  Summary

  Camshaft Position Sensor If replacing a camshaft position sensor for P0340, P0344, P0345, P0349, P0365, P0369, P0390 or P0394 fault codes, please review information below and contact Tom Nies on his cell phone: (248) 494-0187. If no response is received within 15 minutes, please continue with repair. Before clearing any codes, please pull Freeze Frame and CamCrank Sync Event Monitor data (instructions below) from the PCM and send the PDF?s to Tom Nies by email: [email protected]~ Instructions to access Cam/Crank Sync Event Monitor: - From wiTECH main screen - Monitors tab - OBDII Monitors - Select Cam Crank Synchronization Event Monitor from the list - Should bring up 3 or 4 pages of data - Click on create PDF icon in lower right corner - email PDF to [email protected]

  Associated Products (49)

  2019 Ram 15002018 Ram 15002018 Ram 25002018 Ram 35002018 Ram 45002018 Ram 55002018 Ram Promaster City2017 Ram 15002017 Ram 25002017 Ram 35002017 Ram 45002017 Ram 55002017 Ram Promaster City2016 Ram 15002016 Ram 25002016 Ram 35002016 Ram 45002016 Ram 55002016 Ram ProMaster 35002016 Ram Promaster City+ 29 more
  Associated Documents

  • DownloadMC-10149004-0001.pdf↗
• August 4, 2015•Document ID: 10058295

  Service Bulletin/Repair Instructions
  EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.; ELECTRICAL SYSTEM:SOFTWARE

  Mfr Comm. #:

  SB-08-031-15REVB

  Date Added:

  August 29, 2015

  Manufacturer:

  DODGE

  Summary

  SOME VEHICLES NEED RADIO SOFTWARE UPDATE DUE TO INCORRECT NAVIGATION GUIDANCE EXITING HIGHWAY, TELEPROMPTER FAILS TO APPEAR WHEN VOICE RECOGNITION (VR) BUTTON IS PRESSED, BLIND SPOT CHIME INTERMITTENTLY FAILS TO TURN OFF, PREVIOUS RADIO CAMERA IMAGE IS DISPLAYED BEFORE CURRENT IMAGE. MODEL 2015 CHARGER, RAM 4500, 5500, RAM 3500, 2500, 1500 PICKUP, VIPER, CHEROKEE, CHALLENGER, GRAND CHEROKEE, DURANGO, CHRYSLER 300. *PE

  Associated Products (12)

  2015 Chrysler 3002015 Dodge Challenger2015 Dodge Charger2015 Dodge Durango2015 Dodge Viper2015 Jeep Cherokee2015 Jeep Grand Cherokee2015 Ram 15002015 Ram 25002015 Ram 35002015 Ram 45002015 Ram 5500
  Associated Documents

  • DownloadMC-10058295-0001.pdf↗
• August 3, 2015•Document ID: 10149003

  Service Bulletin/Repair Instructions
  ENGINE AND ENGINE COOLING:EXHAUST SYSTEM; EQUIPMENT

  Mfr Comm. #:

  04861963A

  Date Added:

  November 26, 2018

  Manufacturer:

  RAM

  Summary

  Evaporative System Integrity Monitor switch (ESIM) Prior to replacing this component on a 2015 Dodge Journey (JC), please call Bob Bruni at cell (248) 736-8958. If a response is not received within 15 minutes, then continue with the necessary repair.

  Associated Products (49)

  2019 Ram 15002018 Ram 15002018 Ram 25002018 Ram 35002018 Ram 45002018 Ram 55002018 Ram Promaster City2017 Ram 15002017 Ram 25002017 Ram 35002017 Ram 45002017 Ram 55002017 Ram Promaster City2016 Ram 15002016 Ram 25002016 Ram 35002016 Ram 45002016 Ram 55002016 Ram ProMaster 35002016 Ram Promaster City+ 29 more
  Associated Documents

  • DownloadMC-10149003-0001.pdf↗
• August 2, 2015•Document ID: 10149002

  Service Bulletin/Repair Instructions
  SEATS; SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

  Mfr Comm. #:

  04610124A

  Date Added:

  November 26, 2018

  Manufacturer:

  RAM

  Summary

  Element Assy- Heated Seat If any of the Front Heated Seats are Inoperable. Call Mike Wicker at cell (248) 821- 9350 with the Fault Code, so we can determine true root cause. If your call is not returned within 15 minutes, please continue with the repair

  Associated Products (49)

  2019 Ram 15002018 Ram 15002018 Ram 25002018 Ram 35002018 Ram 45002018 Ram 55002018 Ram Promaster City2017 Ram 15002017 Ram 25002017 Ram 35002017 Ram 45002017 Ram 55002017 Ram Promaster City2016 Ram 15002016 Ram 25002016 Ram 35002016 Ram 45002016 Ram 55002016 Ram ProMaster 35002016 Ram Promaster City+ 29 more
  Associated Documents

  • DownloadMC-10149002-0001.pdf↗
• August 1, 2015•Document ID: 10149000

  Service Bulletin/Repair Instructions
  SEATS

  Mfr Comm. #:

  1UU47DX9A

  Date Added:

  November 26, 2018

  Manufacturer:

  DODGE

  Summary

  Seat belt retractor - rear seat center Prior to ordering this part, call Gary Gebski at (248) 807-5874. If no response in 15 minutes, proceed with ordering the part

  Associated Products (49)

  2019 Ram 15002018 Ram 15002018 Ram 25002018 Ram 35002018 Ram 45002018 Ram 55002018 Ram Promaster City2017 Ram 15002017 Ram 25002017 Ram 35002017 Ram 45002017 Ram 55002017 Ram Promaster City2016 Ram 15002016 Ram 25002016 Ram 35002016 Ram 45002016 Ram 55002016 Ram ProMaster 35002016 Ram Promaster City+ 29 more
  Associated Documents

  • DownloadMC-10149000-0001.pdf↗
• August 1, 2015•Document ID: 10148946

  Service Bulletin/Repair Instructions
  EQUIPMENT; EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

  Mfr Comm. #:

  6th Edition 2015

  Date Added:

  November 26, 2018

  Manufacturer:

  CHRYSLER

  Summary

  Warranty Operations Newsletter Volume 1, Issue 6

  Associated Products (49)

  2019 Ram 15002018 Ram 15002018 Ram 25002018 Ram 35002018 Ram 45002018 Ram 55002018 Ram Promaster City2017 Ram 15002017 Ram 25002017 Ram 35002017 Ram 45002017 Ram 55002017 Ram Promaster City2016 Ram 15002016 Ram 25002016 Ram 35002016 Ram 45002016 Ram 55002016 Ram ProMaster 35002016 Ram Promaster City+ 29 more
  Associated Documents

  • DownloadMC-10148946-0001.pdf↗
• July 16, 2015•Document ID: 10058709

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM

  Mfr Comm. #:

  SB08-031-15REV-A

  Date Added:

  November 3, 2015

  Manufacturer:

  RAM

  Summary

  RA3 RA4 RADIO ENHANCEMENTS. BULLETIN INVOLVES INSPECTING AND UPDATING RADIO SOFTWARE *CN

  Associated Products (12)

  2015 Chrysler 3002015 Dodge Challenger2015 Dodge Charger2015 Dodge Durango2015 Dodge Viper2015 Jeep Cherokee2015 Jeep Grand Cherokee2015 Ram 15002015 Ram 25002015 Ram 35002015 Ram 45002015 Ram 5500
  Associated Documents

  • DownloadMC-10058709-0001.pdf↗
• May 30, 2015•Document ID: 10229248

  Service Bulletin/Repair Instructions
  BACK OVER PREVENTION; FUEL SYSTEM, GASOLINE

  Mfr Comm. #:

  2500115

  Date Added:

  January 9, 2023

  Manufacturer:

  RAM

  Summary

  Diesel Exhaust Fluid (DEF) Level Gauge Inaccurate Or Stuck This bulletin involves verifying the correct DEF level in the tank and if necessary, replacing the DEF pump module. A small number of customers may comment that their DEF level gauge is stuck for long periods of time or is erratic. The customer may also experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation a technician may find one or more of the following Diagnostic Trouble Codes (DTCs). ? P203B - Reductant Level Sensor Circuit Performance ? P203C - (Diesel Exhaust Fluid) Reductant Level Sensor Circuit Low. ? P203D - (Diesel Exhaust Fluid) Reductant Level Sensor Circuit High.

  Associated Products (8)

  2015 Ram 25002015 Ram 35002015 Ram 45002015 Ram 55002014 Ram 25002014 Ram 35002014 Ram 45002014 Ram 5500
  Associated Documents

  • DownloadMC-10229248-0001.pdf↗
• March 27, 2015•Document ID: 10144856

  Service Bulletin/Repair Instructions
  EXTERIOR LIGHTING; EXTERIOR LIGHTING:HEADLIGHTS

  Mfr Comm. #:

  08-030-15

  Date Added:

  September 24, 2018

  Manufacturer:

  RAM

  Summary

  Auto Headlamp Enhancements This bulletin involves checking Tunnel Detection values and performing a vehicle reconfiguration if needed. The customer may experience when exiting a dark parking structure or dark tunnel the auto headlamps may not turn off. The customer may also experience when driving on an over cast day the auto headlamps may cycle on and off frequently.

  Associated Products (10)

  2015 Ram 15002015 Ram 25002015 Ram 35002015 Ram 45002015 Ram 55002014 Ram 15002014 Ram 25002014 Ram 35002014 Ram 45002014 Ram 5500
  Associated Documents

  • DownloadMC-10144856-0001.pdf↗
• March 24, 2015•Document ID: 10144852

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM; SEATS; EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.; STEERING

  Mfr Comm. #:

  08-028-15

  Date Added:

  September 24, 2018

  Manufacturer:

  JEEP

  Summary

  RA2 Radio Software Enhancements This bulletin involves updating the radio's software. A customer may experience one or more of the following: ? Not able to change state of heated seats and/or steering wheel during stop event on Stop/Start vehicles. ? Touchscreen confirmation beep may be too loud (Grand Cherokee only). ? U0208-00 - Loss Communication With Heated Seat Control Module (Cherokee only). Improvements: ? Only allow vehicle settings to be changed in run mode. To help ensure settings are properly saved. ? Always gray out text message soft keys for non-supporting devices. ? Voice Recognition (VR) improved accuracy.

  Associated Products (7)

  2015 Jeep Cherokee2015 Jeep Grand Cherokee2015 Ram 15002015 Ram 25002015 Ram 35002015 Ram 45002015 Ram 5500
  Associated Documents

  • DownloadMC-10144852-0001.pdf↗
• March 24, 2015•Document ID: 10144851

  Service Bulletin/Repair Instructions
  STEERING; EQUIPMENT ADAPTIVE/MOBILITY; EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.; EQUIPMENT; SEATS

  Mfr Comm. #:

  08-029-15

  Date Added:

  September 24, 2018

  Manufacturer:

  JEEP

  Summary

  RG2 Or RJ2 Radio Software Enhancements This bulletin involves updating the radio's software. A customer may experience one or more of the following: ? Not able to change state of heated seats and/or steering wheel during stop event on Stop/Start vehicles. ? Touchscreen confirmation beep may be too loud. ? The radio does not allow selection of the Polish language. ? The radio fan continually runs at high speed. ? Customer perception may be the radio fan is too loud. Improvements: ? Only allow vehicle settings to be changed in run mode. To help insure settings are properly saved. ? Always gray out text message soft keys for non-supporting devices. ? Voice Recognition (VR) improved accuracy.

  Associated Products (7)

  2015 Jeep Cherokee2015 Jeep Grand Cherokee2015 Ram 15002015 Ram 25002015 Ram 35002015 Ram 45002015 Ram 5500
  Associated Documents

  • DownloadMC-10144851-0001.pdf↗
• February 6, 2015•Document ID: 10229185

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM

  Mfr Comm. #:

  1801215

  Date Added:

  January 9, 2023

  Manufacturer:

  RAM

  Summary

  Flash: 6.7L Diagnostic And System Improvements This bulletin involves reprogramming the Engine Control Module (ECM) with the latest available software. Several software improvements are available for vehicles equipped with a Cummins 6.7L turbo diesel.

  Associated Products (3)

  2015 Ram 35002015 Ram 45002015 Ram 5500
  Associated Documents

  • DownloadMC-10229185-0001.pdf↗
• February 6, 2015•Document ID: 10223606

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM; ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

  Mfr Comm. #:

  1801215

  Date Added:

  October 17, 2022

  Manufacturer:

  RAM

  Summary

  Flash: 6.7L Diagnostic And System Improvements This bulletin involves reprogramming the Engine Control Module (ECM) with the latest available software. Several software improvements are available for vehicles equipped with a Cummins 6.7L turbo diesel.

  Associated Products (3)

  2015 Ram 35002015 Ram 45002015 Ram 5500
  Associated Documents

  • DownloadMC-10223606-0001.pdf↗
• December 23, 2014•Document ID: 10229920

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM

  Mfr Comm. #:

  0807914b

  Date Added:

  January 17, 2023

  Manufacturer:

  DODGE

  Summary

  RA3 RA4 Radio Enhancements This bulletin involves inspecting and, if required, updating the radio software. A small number of customers may experience one or more of the following: Low battery condition due to the radio remaining powered up after the ignition has been turned off (U.S Markets Only). The Radio may switch from SiriusXM to an AM station by itself. Uconnect registration always present, can not remove Uconnect account. Teleprompter does not appear when pressing the Voice Recognition (VR) button. VR operation cancels while in media mode. Radio may display previous cameras image before displaying the current image.

  Associated Products (12)

  2015 Chrysler 3002015 Dodge Challenger2015 Dodge Charger2015 Dodge Durango2015 Dodge Viper2015 Jeep Cherokee2015 Jeep Grand Cherokee2015 Ram 15002015 Ram 25002015 Ram 35002015 Ram 45002015 Ram 5500
  Associated Documents

  • DownloadMC-10229920-0001.pdf↗
• December 23, 2014•Document ID: 10221091

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM; AIR BAGS; PARKING BRAKE

  Mfr Comm. #:

  0807914REVC

  Date Added:

  September 26, 2022

  Manufacturer:

  RAM

  Summary

  RA3 RA4 Radio Enhancements if required, updating the radio software. A small number of customers may experience one or more of the following: Low battery condition due to the radio remaining powered up after the ignition has been turned off (U.S Markets Only). The Radio may switch from SiriusXM to an AM station by itself. Uconnect registration always present, can not remove Uconnect account. Teleprompter does not appear when pressing the Voice Recognition (VR) button. VR operation cancels while in media mode. Radio may display previous cameras image before displaying the current image. Navigation lost vehicle position, during route calculation. Navigation displays are missing after vehicle heading changes. Navigation giving incorrect guidance to exit the highway. FM audio may switch to AM after ignition cycle. Text messages appear as sender?s phone number not their name. VR phone button may not work at times. Audio muted after AUX device is disconnected. VR, ? Listen? to text, will only play 1st message. Drive Mode: Eco, sport or normal setting may not be saved after key cycle (LA, LD, LX and ZD Only). Drive Mode: Shift light On/Off, out of sync (LA, LD, LX and ZD Only). SirusXM station information does not update. Speed adjusted volume, may not work. AM or FM seek or tuner soft keys may be missing. Display screen show ambient temperature as ?- - ? not normal values.Improvements: High Definition (HD) radio buffering. Spanish translation. Radio station, scroll feature. Drive Mode: Launch control button, text improvements (LA, LD, LX and ZD Only). Making assist calls. App functionality and screen displays. Displays correct media, song titles and tracks. Travel Link, Points Of Interest (POI), displaying movies and favorites. Incoming calls, audio enhancements (LA, LD and LX Only). Audio for strong AM stations. VR performance. Settings can only be changed in run mode, not ACC. Notify user when messaging features are not s

  Associated Products (12)

  2015 Chrysler 3002015 Dodge Challenger2015 Dodge Charger2015 Dodge Durango2015 Dodge Viper2015 Jeep Cherokee2015 Jeep Grand Cherokee2015 Ram 15002015 Ram 25002015 Ram 35002015 Ram 45002015 Ram 5500
  Associated Documents

  • DownloadMC-10221091-0001.pdf↗
• December 23, 2014•Document ID: 10062744

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM:SOFTWARE

  Mfr Comm. #:

  08-079-14REV.C

  Date Added:

  April 26, 2016

  Manufacturer:

  JEEP

  Summary

  SUMMARY TO BE PROVIDED ON A FUTURE DATE.

  Associated Products (10)

  2015 Dodge Challenger2015 Dodge Durango2015 Dodge Viper2015 Jeep Cherokee2015 Jeep Grand Cherokee2015 Ram 15002015 Ram 25002015 Ram 35002015 Ram 45002015 Ram 5500
  Associated Documents

  • DownloadMC-10062744-0001.pdf↗
• December 9, 2014•Document ID: 10229890

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM; EQUIPMENT

  Mfr Comm. #:

  0810814

  Date Added:

  January 17, 2023

  Manufacturer:

  RAM

  Summary

  RA2 Radio Software Enhancements This bulletin involves updating the radio's software. A customer may have experience one or more of the following: Not able to change state of heated seats and/or steering wheel during stop event on Stop/Start vehicles. Touchscreen confirmation beep may be too loud (Grand Cherokee only). U0208-00 - Loss Communication With Heated Seat Control Module (Cherokee only).Improvements: Only allow vehicle settings to be changed in run mode. To help insure settings are properly saved. Always gray out text message soft keys for non-supporting devices. Voice Recognition (VR) improved accuracy.

  Associated Products (7)

  2015 Jeep Cherokee2015 Jeep Grand Cherokee2015 Ram 15002015 Ram 25002015 Ram 35002015 Ram 45002015 Ram 5500
  Associated Documents

  • DownloadMC-10229890-0001.pdf↗
• December 9, 2014•Document ID: 10229888

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM; EQUIPMENT

  Mfr Comm. #:

  0810914

  Date Added:

  January 17, 2023

  Manufacturer:

  RAM

  Summary

  RG2 Or RJ2 Radio Software Enhancements This bulletin involves updating the radio's software. A customer may have experience one or more of the following: Not able to change state of heated seats and/or steering wheel during stop event on Stop/Start vehicles. Touchscreen confirmation beep may be too loud. The radio does not allow selection of the Polish language. The radio fan continually runs at high speed. Customer perception may be the radio fan is too loud.Improvements: Only allow vehicle settings to be changed in run mode. To help insure settings are properly saved. Always gray out text message soft keys for non-supporting devices. Voice Recognition (VR) improved accuracy.

  Associated Products (7)

  2015 Jeep Cherokee2015 Jeep Grand Cherokee2015 Ram 15002015 Ram 25002015 Ram 35002015 Ram 45002015 Ram 5500
  Associated Documents

  • DownloadMC-10229888-0001.pdf↗